SECT. IIA PAGE 19
0108
Featuring the
"Advanced Closed
System
+
3"
Cleveland
™
P
roject ________________________________
Item __________________________________
Quantity _______________________________
F
CSI Section ____________________________
A
pproval _______________________________
D
ate __________________________________
1333 East 179 St.,
Cleveland, Ohio, U.S.A. 44110
Tel: 1-216-481-4900
Fax: 1-216-481-3782
Web Site: www.ClevelandRange.com
Email: Steam@ClevelandRange.com
COMBI OVEN-STEAMER
Short Form Specifications
Cooking Modes:
I
I
Hot Air
I
I
Retherm
I
I
"Delta T" slow cooking
I
I
Steam
I
I
"Cook & Hold"
I
I
"Crisp & Tasty"
I
I
Combi
Cleveland Standard Features:
I
I
"Advanced closed system" with "Crisp & Tasty" de-moisturizing feature
I
I
High efficiency, power burner heating system for hot air and steam
generator saves energy and provides fast heat up times
I
I
Fully insulated steam generator and cooking compartment for
maximum energy savings
I
I
Polished cooking compartment with coved corners for easy cleaning
I
I
Ten (10) 12" x 20" wire shelves
I
I
Hinged fan guard and hinged removable pan racks
I
I
Two (2) speed auto reversing convection fan for even heat distribution
I
I
Space saving, easy to close "Disappearing Door"
I
I
Door latch with safety vent position and wear-free door switch
I
I
Vented, double glass door with integrated door stop
I
I
Trolley with self draining condensate drip pan
I
I
Easy to change, press-fit door seal
I
I
Oven light with shock resistant safety glass
I
I
Multipoint core temperature probe
I
I
Easy to use electronic controls for all operational functions
I
I
Self diagnostic system with full text message display
I
I
Easy to understand menu icons with bright graphics display
I
I
User friendly selector dial
I
I
Exclusive "Smart Key" for selecting option settings
I
I
Digital controls for temperature, time and core probe settings
I
I
Eight (8) "Press & Go" one step, recipe start buttons
I
I
Cook book library for up to 250 stored recipe programs, each
recipe capable of 20 steps
I
I
RS 232 connection for controlling one unit with a PC (personal computer)
I
I
Memory module automatically saves unit settings and recipes
I
I
Manual program override feature for operational settings
I
I
Smooth action hand shower for compartment cleaning
Gas Fired Steam Generator
I
I
Quiet, high efficiency, power burner heating system
I
I
Built-in automatic rinse system
I
I
Automatic fill and water level control
I
I
Automatic generator drain
Shall be Cleveland Model: OGB-20.10 Combination Convection Oven /
Steamer with simple to operate electronic programmable controls for Hot Air,
Convection Steam, and Combination cooking modes, "Cook & Hold" and
"Delta T" slow-cooking capabilities, "Advanced Closed System" with "Crisp
& Tasty" de-moisturizing feature. Multiple cooking stage programs, stored
recipe library, multipoint core temperature probe, "Press & Go", one-step
recipe start buttons, "Smart Key" for selecting option settings, Two (2) speed
auto reversing convection fan. Quiet, high efficiency power burner heating
system; steam generator with automatic drain. "Disappearing Door".
Capacity for twenty (20) 12" x 20" x 2 1/2" pans.
M
ODEL: OGB-20.10
CAPACITY: Twenty (20) - 13” by 18” by 1” half size sheet pans or
Twenty (20) - 12” x by 20” by 2 1/2” steam table pans
Options and Accessories
Ë ConvoClean automatic compartment washing system
Ë PC-HACCP software for establishing "HACCP controls" and automatic
documentation of the cooking process
Ë Lockable cover over operating controls for prison installations
Ë USB or RS 485 connection for networking and controlling up to 32
units with a personal computer
Ë Propane gas option
Ë Pan rack with trolley
Ë Plate rack with trolley for banquet operations
Ë Thermal cover for plate or pan rack
Ë ConvoClean compartment cleaning solution
Ë ConvoCare concentrate for compartment rinse cycle
Ë "Dissolve" generator descaling solution
Ë Chicken Grill Rack
Ë 12" x 20" Wire Baskets for frying products
Ë Additional 12" x 20" Wire Shelves
Ë Pre-heat bridge
Ë Kleensteam II Water Filters
GAS Fired – with Steam Generator
NOTES:
Cleveland Range reserves right of design improvement or modification, as warranted.
Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes.
Cleveland Range equipment is built to comply with applicable standards for manufacturers.
SECT. IIA PAGE 20
0108
The "Advanced Closed System" offers the following advantages:
I
I
Saves energy
I
I
Automatic moisture level adjustment
I
I
Low heat and steam emission to the kitchen
I
I
Automatically regulated steam injection
I
I
Enables immediate change into the steam mode
I
I
"Crisp & Tasty" demoisturizing function
Model: OGB-20.10
Pan Capacity [
Unit has 7 slide rails at 2.64" (67mm) apart
]:
6 (12" x 20" x 2 1/2") steam table pans 7 (12" x 20" x 1") steam table pans
7
(13" x 20") half size wire racks 7 (13" x 18") half size sheet pans
6
(12" x 20") frying baskets - (no wire racks needed)
For Banquet Operations: Optional Plate Rack holds 61 plates
Unit Dimensions: Width - 42.61", Depth - 36.47", Height - 78.43"
Shipping Dimensions: Width - 49", Depth - 42", Height - 86"
(including packaging)
Shipping Weight: 750 Lbs (including trolley)
Required Clearances:
Rear - 2", Left Side - 4", Right Side - 2 1/2"
• Allow for sufficient distance if a "high heat source" (i.e. Broiler) is located
next to the unit.
• Allow for sufficient clearance on left side for service access (contact the
factory service department for recommendations).
• Installation must comply with all local fire and health codes.
Agency Approvals: UL - Gas, UL - Sanitation (NSF Standards)
Electrical Requirements: 120 volt, 21.7 amps, 60 Hz, single phase
Do not connect to a G.F.I. outlet
Gas Connection: 3/4" NPT
Gas Type: Natural Gas (Propane optional)
Gas Flow Pressure: Natural Gas - Min. 5.5" WC / Max. 14" WC
Propane Gas - Min. 11" WC / Max. 14" WC
Total Connected Load: 151,500 BTU (136,000 BTU Propane)
Steam Generator: 113,600 BTU (102,000 BTU Propane)
Hot Air: 151,500 BTU (136,000 BTU Propane)
Water Connections: Cold Water (drinking water quality)
Flow Pressure: 30 - 60 PSI
Water Inlets: 3/4" GHT-F (Female Garden Hose Connection)
Treated Water for Steam Generator
Untreated Water for Condenser and Hand Shower
Drain Connection: 2" Tube
Venting: Exhaust Hood required
Gas Exhaust for Hot Air Heating
Gas Exhaust for Steam Generator
Air Vent
*Connection for Cleaning Solution
*Connection for Rinse Cycle
Low Pressure Safety Valve
*Available as an option
A = Water hook up soft water G"
B = Water hook up cold water G"
C = drainage hook up DN50
D = power hook up
E = Potential equaliser
F = Final rinse hook up
G = Cleaner hook up
H = Air vent pipe
I = Low pressure safety
OEB 20.10
A = Water hook up soft water G"
B = Water hook up cold water G"
C = drainage hook up DN50
D = power hook up
E = Potential equaliser
F = Final rinse hook up
G = Cleaner hook up
H = Air vent pipe
I = Low pressure safety
OES 20.10
OGB 20.10
A Water hook up soft water G"
B Water hook up cold water G"
C Drainage hook up DN50
D Power hook up
E Potential equaliser
F Final rinse hook up
G Cleaner hook up
H Air vent piper
I Low pressure safety
J Gas hook up R"
K Exhaust pipe gas (Hot air heating)
L Exhaust pipe gas (Steam generator)
OGS 20.10
A = Water hook up soft water G"
B = Water hook up cold water G"
C = Drainage hook up DN50
D = Power hook up
E = Potential equaliser
F = Final rinse hook up
G = Cleaner hook up
H = Air vent pipe
I = Low pressure safety
J = Gas hook up R"
K = Exhaust pipe gas
37.29"
2
.52"
1.58"
67.80"
9.06"
2.80"
76.85"
33.67
2.80"
11.11"
2.80"
6.97"
3.39"
5.04"
2.60"
7.48"
11.66"
3.08"
10.32"
9.30"
31.03"
3.15"
6.50"
13.55"
2.96"
19.33"
1.19"
21.70"
5.48"
3.00"
4.97"
S
AV
E1
E2
RC
CS
W1
W2
D
G
FRONT VIEW
TOP VIEW
BOTTOM VIEW
23.63"
2.01"
37.29"
2
.52"
1.58"
67.80"
9.06"
2.80"
76.85"
33.67"
2.80"
11.11"
2.80"
6.97"
3.39"
5.04"
7.48"
11.66"
3.08"
10.32"
9.30"
31.03"
3.15"
6.50"
13.55"
2.96"
19.33"
1.19"
21.70"
5.48"
3.00"
4.97"
S
AV
E1
RC
CS
W1
W2
D
G
FRONT VIEW
TOP VIEW
BOTTOM VIEW
23.63"
2.01"
37.29"
2.52"
1.58"
67.80"
9.06"
2.80"
76.85"
33.67"
2.80"
11.11"
2.80"
3.39"
11.66"
3
.08"
10.32"
9.30"
3
1.03"
3
.15"
6.50"
13.55"
2.96"
19.33"
1.19"
2
1.70"
5
.48"
3.00"
4.97"
S
AV
RC
CS
W1
W
2
D
FRONT VIEW
TOP VIEW
BOTTOM VIEW
23.63"
W1
W2
D
RC
S
CS
AV
G
E1
E2
W
1
W2
D
RC
S
CS
AV
G
E1
E2
W1
W2
D
RC
S
CS
AV
G
E1
E2
W1
W2
D
RC
S
CS
AV
G
E1
E2
W1
W2
D
RC
S
CS
AV
G
E1
E2
W1
W2
D
RC
S
CS
AV
G
E1
E2
W1
W2
D
RC
S
CS
AV
G
E1
E2
W1
W2
D
RC
S
CS
AV
G
E1
E2
W1
W2
D
RC
S
CS
AV
G
E1
E2
W1
W2
D
RC
S
CS
AV
G
E1
E2
W1
W2
D
RC
S
CS
AV
G
E1
E2
-
1
-
2
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Cleveland OEB-20.10 User manual
-
Cleveland OGS-20.10 User manual
-
Cleveland Oven OES-20.10 User manual
-
Cleveland Oven OES-10.10 User manual
-
Cleveland OEB-12.20 User manual
-
Cleveland Electric Steamer OEB-20.20 User manual
-
Cleveland Electric Steamer OES-12.20 User manual
-
Cleveland OES-6.10 User manual
-
Cleveland Oven OEB-10.10 User manual
-
Cleveland Oven OES-10.20 User manual
Other documents
-
Chicco Teddy Count With Me Owner's manual
-
Cleveland Range CICBOARD Datasheet
-
-
-
-
-
Convotherm OGB 20.20 User manual
-
-
-
