Sealey WB952LEDR User manual

Type
User manual
12V/24V LED WARNING BEACON
MODEL NO: WB951LEDG, WB951LEDR,
WB952LEDR, WB954LEDR, WB955LEDG
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
9 Familiariseyourselfwiththisproduct’sapplicationandlimitations,aswellasanyspecicpotentialhazardspeculiartothebeacon.
9 Replaceorrepairdamagedparts.Userecommendedpartsonly.Nonauthorisedpartsmaybedangerousandwillinvalidatethe 
 warranty.
8 DO NOTusethebeaconforanypurposeotherthanforwhichitisdesigned.
8 DO NOTallowchildrentooperatethebeacon.
8 DO NOToperatethebeaconifanypartsaremissingordamagedasthismaycausefailureorpossiblepersonalinjury.
9 Whennotinuseswitchthebeaconoandwhereappropriateremoveplugfrompowersupply.
9 Thisbeaconisintendedtobeusedonlyin12Vor24VDCsystems.
9 Thebeaconsaremeanttobeusedasawarningsignal.Applicationse.g.Trucks,excavators,agriculturalmachinesandtractorsetc.
8 DO NOTlookstraightintothelight.Thebrightlightmaycauseaseriouseyedamage.
9 Makesurethatthebeaconisproperlyinstalledbeforedrivingthevehicle.
9 Followthecountry-specicregulationswheninstallingthewarninglightsontheroofofthevehicle.
2. INTRODUCTION
WB951LEDG:Greencolourbeaconforuseonplantvehiclestoindicatethataseatbeltisbeingworn.Singlepoint-mountingbeaconsuitable
fordirectmountingtovehicleroofusing12mmbolt.Fittedwith361WhighpowerLEDs.120Flashperminutepattern.FullymeetsECER10
regulations.IPRatingofIP66.
WB951LEDR:Redcolourbeacontobeusedinrecoveriesonnormalandsmartmotorways.Singlepoint-mountingbeaconsuitablefordirect
mountingtovehicleroofusing12mmbolt.Fittedwith12highpowerLEDs.120Flashperminutepattern.FullymeetsECER65andECER10
regulations.IPRatingofIP66.
WB952LEDR:Redcolourbeacontobeusedinrecoveriesonnormalandsmartmotorways.Threepoint-mountingbeaconsuitablefordirect
mountingtovehicleroofusing3x6.5mmbolts.Fittedwith12highpowerLEDs.120Flashperminutepattern.FullymeetsECER65andECE
R10regulations.IPRatingofIP66.
WB954LEDR:Redcolourbeacontobeusedinrecoveriesonnormalandsmartmotorways.Fittedwithapowerfulmagnet,strongenoughto
copewithnormalroadspeedsandholesforoptionalmountingviascrews.Suppliedwith3mcoiledexanduniversalvehicleaccessorysocket
plug.Fittedwith12highpowerLEDs.120Flashperminutepattern.FullymeetsECER65andECER10regulations.IPRatingofIP66.
WB955LEDG:Greencolourbeaconforuseonplantvehiclestoindicatethataseatbeltisbeingworn.Flexiblespigotbeaconsuitablefor
mountingontopofapipe.Fittedwith361WhighpowerLEDs.120Flashperminutepattern.FullymeetsECER10regulations.IPRatingof
IP66.
3. SPECIFICATION
Model No:..........................................WB951LEDG......... WB951LEDR................... WB952LEDR........ WB954LEDR........WB955LEDG
LED Type:......................................... 36x1WSMD......... 12x3WSMD...................12x3WSMD........12x3WSMD....... 36x1WSMD
Wattage:...........................................................36W........................36W................................. 36W...................... 36W......................36W
Voltage:........................................................12/24V....................12/24V............................. 12/24V.................. 12/24V..................12/24V
IPRating:.........................................................IP66........................IP66................................. IP66...................... IP66......................IP66
Fixing:......................................... Single12mmBolt... Single12mmBolt.... Single3x6.5mmBolts............... Magnetic......FlexibleSpigot
WorkingTemperatureRange:......... -30°Cto+50°C.......-30°Cto+50°C.................-30°Cto+50°C..... -30°Cto+50°C..... -30°Cto+50°C
WB951LEDGWB951LEDRWB952LEDRWB954LEDRWB955LEDGIssue126/05/21
Original Language Version
©JackSealeyLimited
Refer to
instructions
4. FIXING INSTRUCTIONS
4.1. SINGLE BOLT FIXING
4.1.1. Drilla13mmmountingholeinasuitablepointonthevehicle.
4.1.2. Connecttocablesofatleast2mm²sectionandusean8Afuse;checkpolarities.
4.1.3. Fixthebeaconbyusingnutsandwashersaccordingtothetypeandshapeofthemountingsurface
4.2. THREE BOLT FIXING BASE
4.2.1. Drillmountingholesusingthebeaconbaseasatemplate.Alsomakeprovisiontoroutecablesintothevehicle.
4.2.2. Connecttocablesofatleast2mm²sectionandusean8Afuse;checkpolarities.
4.2.3. Fixthebeaconwith3xM6screws.
4.3. MAGNETIC BASE
4.3.1. Fittedwithhighpowermagnetstrongenoughtocopewithnormalroadspeeds.
4.3.2. Suppliedwith3mcoiledexanduniversalauxiliarypoweroutletplug.
4.3.3. Thebeaconmustbeplacedonasurfaceparalleltotheground.
4.3.4. Thesurfaceshouldbeatandcleantoensuregoodadherence.
4.4. FLEXIBLE BASE WITH DIN SPIGOT MOUNTING.
4.4.1. Fitasuitableadaptersocketontothevehicle.Makesureitisperfectlyvertical.
4.4.2. Usecablesofatleast2mm²sectionandusean8Afuse;checkpolarities.
4.4.3. Pushthebeaconspigotdownfullyontotheadaptersocketandsecurebytighteningthewingnut.
4.4.4. Whenthebeaconisremoved,alwaysclosetheadaptersocketoutletusingtherubbercap.
5. FLASH PATTERN SELECTION FIG.1
5.1.  SingleFlash120ashes/Min:Switch1on.
5.2.  DualFlash:Switch2on.
5.3.  Rotation:Switch3on.
5.4.  QuadFlash:Switch1and2on.
5.5.  MultipleFlash:Switch2and3on.
6. VOLTAGE SELECTION
6.1.  Thebeaconswillswitchbetween12Vand24Vautomatically.
g.1
Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR
01284 757500 01284 703534 sales@sealey.co.uk www.sealey.co.uk
ENVIRONMENT PROTECTION
Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento
arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely
unserviceableandrequiresdisposal,drainanyfluids(ifapplicable)intoapprovedcontainersanddisposeoftheproductandfluids
accordingtolocalregulations.
WEEE REGULATIONS
DisposeofthisproductattheendofitsworkinglifeincompliancewiththeEUDirectiveonWasteElectricalandElectronicEquipment
(WEEE).Whentheproductisnolongerrequired,itmustbedisposedofinanenvironmentallyprotectiveway.Contactyourlocalsolid
wasteauthorityforrecyclinginformation.
Note:Itisourpolicytocontinuallyimproveproductsandassuchwereservetherighttoalterdata,specificationsandcomponentpartswithoutprior
notice.
Important:NoLiabilityisacceptedforincorrectuseofthisproduct.
Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.
WB951LEDGWB951LEDRWB952LEDRWB954LEDRWB955LEDGIssue126/05/21
Original Language Version
©JackSealeyLimited
  • Page 1 1
  • Page 2 2

Sealey WB952LEDR User manual

Type
User manual

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI