Sealey WB952LEDR User manual

12V/24V LED WARNING BEACON

MODEL NO: WB951LEDG, WB951LEDR,

WB952LEDR, WB954LEDR, WB955LEDG

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these

instructions, and properly maintained, give you years of trouble free performance.

IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE

THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR

PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.

1. SAFETY

9 Familiariseyourselfwiththisproduct’sapplicationandlimitations,aswellasanyspecicpotentialhazardspeculiartothebeacon.

9 Replaceorrepairdamagedparts.Userecommendedpartsonly.Nonauthorisedpartsmaybedangerousandwillinvalidatethe 

 warranty.

8 DO NOTusethebeaconforanypurposeotherthanforwhichitisdesigned.

8 DO NOTallowchildrentooperatethebeacon.

8 DO NOToperatethebeaconifanypartsaremissingordamagedasthismaycausefailureorpossiblepersonalinjury.

9 Whennotinuseswitchthebeaconoandwhereappropriateremoveplugfrompowersupply.

9 Thisbeaconisintendedtobeusedonlyin12Vor24VDCsystems.

9 Thebeaconsaremeanttobeusedasawarningsignal.Applicationse.g.Trucks,excavators,agriculturalmachinesandtractorsetc.

8 DO NOTlookstraightintothelight.Thebrightlightmaycauseaseriouseyedamage.

9 Makesurethatthebeaconisproperlyinstalledbeforedrivingthevehicle.

9 Followthecountry-specicregulationswheninstallingthewarninglightsontheroofofthevehicle.

2. INTRODUCTION

WB951LEDG:Greencolourbeaconforuseonplantvehiclestoindicatethataseatbeltisbeingworn.Singlepoint-mountingbeaconsuitable

fordirectmountingtovehicleroofusing12mmbolt.Fittedwith361WhighpowerLEDs.120Flashperminutepattern.FullymeetsECER10

regulations.IPRatingofIP66.

WB951LEDR:Redcolourbeacontobeusedinrecoveriesonnormalandsmartmotorways.Singlepoint-mountingbeaconsuitablefordirect

mountingtovehicleroofusing12mmbolt.Fittedwith12highpowerLEDs.120Flashperminutepattern.FullymeetsECER65andECER10

regulations.IPRatingofIP66.

WB952LEDR:Redcolourbeacontobeusedinrecoveriesonnormalandsmartmotorways.Threepoint-mountingbeaconsuitablefordirect

mountingtovehicleroofusing3x6.5mmbolts.Fittedwith12highpowerLEDs.120Flashperminutepattern.FullymeetsECER65andECE

R10regulations.IPRatingofIP66.

WB954LEDR:Redcolourbeacontobeusedinrecoveriesonnormalandsmartmotorways.Fittedwithapowerfulmagnet,strongenoughto

copewithnormalroadspeedsandholesforoptionalmountingviascrews.Suppliedwith3mcoiledexanduniversalvehicleaccessorysocket

plug.Fittedwith12highpowerLEDs.120Flashperminutepattern.FullymeetsECER65andECER10regulations.IPRatingofIP66.

WB955LEDG:Greencolourbeaconforuseonplantvehiclestoindicatethataseatbeltisbeingworn.Flexiblespigotbeaconsuitablefor

mountingontopofapipe.Fittedwith361WhighpowerLEDs.120Flashperminutepattern.FullymeetsECER10regulations.IPRatingof

IP66.

3. SPECIFICATION

Model No:..........................................WB951LEDG......... WB951LEDR................... WB952LEDR........ WB954LEDR........WB955LEDG

LED Type:......................................... 36x1WSMD......... 12x3WSMD...................12x3WSMD........12x3WSMD....... 36x1WSMD

Wattage:...........................................................36W........................36W................................. 36W...................... 36W......................36W

Voltage:........................................................12/24V....................12/24V............................. 12/24V.................. 12/24V..................12/24V

IPRating:.........................................................IP66........................IP66................................. IP66...................... IP66......................IP66

Fixing:......................................... Single12mmBolt... Single12mmBolt.... Single3x6.5mmBolts............... Magnetic......FlexibleSpigot

WorkingTemperatureRange:......... -30°Cto+50°C.......-30°Cto+50°C.................-30°Cto+50°C..... -30°Cto+50°C..... -30°Cto+50°C

WB951LEDGWB951LEDRWB952LEDRWB954LEDRWB955LEDGIssue126/05/21

Original Language Version

©JackSealeyLimited

Refer to

instructions

4. FIXING INSTRUCTIONS

4.1. SINGLE BOLT FIXING

4.1.1. Drilla13mmmountingholeinasuitablepointonthevehicle.

4.1.2. Connecttocablesofatleast2mm²sectionandusean8Afuse;checkpolarities.

4.1.3. Fixthebeaconbyusingnutsandwashersaccordingtothetypeandshapeofthemountingsurface

4.2. THREE BOLT FIXING BASE

4.2.1. Drillmountingholesusingthebeaconbaseasatemplate.Alsomakeprovisiontoroutecablesintothevehicle.

4.2.2. Connecttocablesofatleast2mm²sectionandusean8Afuse;checkpolarities.

4.2.3. Fixthebeaconwith3xM6screws.

4.3. MAGNETIC BASE

4.3.1. Fittedwithhighpowermagnetstrongenoughtocopewithnormalroadspeeds.

4.3.2. Suppliedwith3mcoiledexanduniversalauxiliarypoweroutletplug.

4.3.3. Thebeaconmustbeplacedonasurfaceparalleltotheground.

4.3.4. Thesurfaceshouldbeatandcleantoensuregoodadherence.

4.4. FLEXIBLE BASE WITH DIN SPIGOT MOUNTING.

4.4.1. Fitasuitableadaptersocketontothevehicle.Makesureitisperfectlyvertical.

4.4.2. Usecablesofatleast2mm²sectionandusean8Afuse;checkpolarities.

4.4.3. Pushthebeaconspigotdownfullyontotheadaptersocketandsecurebytighteningthewingnut.

4.4.4. Whenthebeaconisremoved,alwaysclosetheadaptersocketoutletusingtherubbercap.

5. FLASH PATTERN SELECTION FIG.1

5.1.  SingleFlash120ashes/Min:Switch1on.

5.2.  DualFlash:Switch2on.

5.3.  Rotation:Switch3on.

5.4.  QuadFlash:Switch1and2on.

5.5.  MultipleFlash:Switch2and3on.

6. VOLTAGE SELECTION

6.1.  Thebeaconswillswitchbetween12Vand24Vautomatically.

g.1

Sealey Group, Kempson Way, Suffolk Business Park, Bury St Edmunds, Suffolk. IP32 7AR

01284 757500 01284 703534 sales@sealey.co.uk www.sealey.co.uk

ENVIRONMENT PROTECTION

Recycleunwantedmaterialsinsteadofdisposingofthemaswaste.Alltools,accessoriesandpackagingshouldbesorted,takento

arecyclingcentreanddisposedofinamannerwhichiscompatiblewiththeenvironment.Whentheproductbecomescompletely

unserviceableandrequiresdisposal,drainanyfluids(ifapplicable)intoapprovedcontainersanddisposeoftheproductandfluids

accordingtolocalregulations.

WEEE REGULATIONS

DisposeofthisproductattheendofitsworkinglifeincompliancewiththeEUDirectiveonWasteElectricalandElectronicEquipment

(WEEE).Whentheproductisnolongerrequired,itmustbedisposedofinanenvironmentallyprotectiveway.Contactyourlocalsolid

wasteauthorityforrecyclinginformation.

Note:Itisourpolicytocontinuallyimproveproductsandassuchwereservetherighttoalterdata,specificationsandcomponentpartswithoutprior

notice.

Important:NoLiabilityisacceptedforincorrectuseofthisproduct.

Warranty:Guaranteeis12monthsfrompurchasedate,proofofwhichisrequiredforanyclaim.

WB951LEDGWB951LEDRWB952LEDRWB954LEDRWB955LEDGIssue126/05/21

Original Language Version