Summers Heat 50-SHSSW01LC User manual

Brand: Summers Heat

Model: 50-SHSSW01LC

Category: Stoves

Type: User manual

THE

MADISON



15‐SSW01,50‐SHSSW01,

50‐TRSSW01



INSTALLATION&OPERATION

MANUAL



Manufactured

By:



England’sStoveWorks,

Inc.



POBox

206



Monroe,VA

24574



www.heatredefined.com

(800)245‐6489



Rev.2/2017



CAUTION



Pleasereadthisentiremanualbeforeinstallationanduseofthiswood

fuel‐

burningappliance. Keepchildren,furniture,fixturesandallcombustibles

away

fromanyheating

appliance.



SAVETHESEINSTRUCTIO NS

SAFETY

NOTICE



Failuretofollowtheseinstructionscanresultinpropertydamage,bodily 

injury



orevendeath. Foryoursafetyandprotection,followthe

installation 

instructionsoutlinedinthismanual. Contactyourlocalbuildingorfire

officials

aboutrestrictio ns andinstallationinspectionrequirements(including

permit s)

inyour

area .

Page | 2

IMPORTANT:IFYOUHAVEAPROBLEMWITHTHISUNIT,DO

NOTRETURNITTOTHEDEALER. CONTACTTECHNICAL

SUPPORT@1‐800‐245‐6489



MobileHomeUse(ApprovedforUSAonly):



Thisfreestandingwoodunitisapprovedformobilehomeor



doublewideinstallationwiththeoutsidecombustionairhook‐

up. Seethe“Installation”sectionofthismanualfordetails

pertainingtomobilehomeinstallations. Mobilehome

installationmustbeinaccordancewiththeManufactured

HomeandSafetyStandard(HUD),CFR3280,Part24.



Retainforyour

files



Model

Number

Date

of

Purchase

Date

ofManufacture

Serial

Number

*Thisinformationcanbefoundonthesafetytagattachedtotherearoftheunit.

Havethisinformationonhandifyouphonethefactoryoryourdealerregardingthis

product.



•

Keepchildrenaway.

CAUTION



•

Supervisechildreninthesameroomasthisappliance.

•

Alertchildrenandadultstothehazardsofhightemperatures.

•

DoNOToperatewithprotectivebarriersopenorremoved.

•

Hotwhileinoperation!Keepclothing,furniture,draperiesandother

combustiblesaway. Contactmaycauseskinburns!

•

InstallationMUSTcomplywithlocal,regional,stateandnationalcodesand

regulations.

•

Consultlocalbuilding,fireofficialsorauthoritieshavingjurisdictionabout

restrictions,installationinspection,andpermits.

Page | 3

WELCOME!



Introduction

•

ThankYou!…...............................4



Specifications

•

HeatingSpecifications..................5

•

Dimensions...................................5

•

EPACompliance...........................5



Installation

•

Installation

Overview

...................6

•

ClearancestoCombustibles.........7

•

VentingIntroduction....................8

•

VentingGuidelines.......................8

•

AdditionalVenting

Information

...9

•

Wall

Pass

‐Throughs....................10

•

ApprovedVentingMethods

o ThroughtheWall...........11

o ThroughtheCeiling........12

o MasonryChimney...........13

o MasonryFireplace..........14

•

MobileHomeInstallation...........15

•

OutsideAir

Hook‐Up

...................15

•

FloorProtection.........................16



Operation

•

Break‐InFires.............................17

•

ContinuousOperation...........17‐18

•

Safety

Notes

...............................19



Maintenance

•

StoveMaintenance....................20

•

Inspecting

Gaskets

......................21

•

Finish..........................................21



Replacing Components

•

Glass...........................................22

•

BurnerTubes..............................23

•

CeramicFiberboards...................23

•

DoorHinges................................23

•

HeatShield&BackPanel...........23

•

OtherComponents.....................24



Optional Accessories

•

AC‐16/AC‐30

Blower

..................24

•

SideHeatShield



……...................24



Troubleshooting Guide

•

Troubleshooting.........................25



Illustrated Parts Detail

•

PartsList.....................................26

•

ExplodedPartsDiagram.............27

•

BrickLayout................................28



Warranty

•

SampleTag..................................29

•

Warranty

Details

........................30

•

ImportantNo

tice

........................31

•

WarrantyregistrationForm.......32

*EPAAddendumfollowsWarrantySection



NOTE:CLEARANCESMAYONLYBEREDUCEDBYMEANSAPPROVEDBYTHEREGULATORYAUTHORITY

HAVINGJURISDICTION

DONOTCONNECTTOANYAIRDISTRIBUTIONDUCTORSYSTEM.



DONOTBURNGARBAGEORFLAMMABLEFLUIDSSUCHASGASOLINE,NAPHTHAOR

ENGINEOIL.



DONOTUSECHEMICALSORFLUIDSTOSTARTTHEFIRE.

Page | 4

Thank you for purchasing this fine product from England’s Stove

Works!

England's Stove Works was started, and is still owned by, a family that

believes strongly in a "Do It Yourself" spirit – that’s one reason you

found this product at your favorite “Do It Yourself” store.

We intentionally design and build our stoves so that any homeowner

can maintain his or her unit with basic tools, and we're always more

than happy to show you how to do the job as easily and as

inexpensively as possible.

From our free, downloadable service sheets to our "wizard-style," click-

through Troubleshooting guide on our web site, we have always tried to

help our customers stay "heat-ready," especially when oil and

electricity prices continue to skyrocket.

Please look at our vast Help section on our web site and call our

Technical Support department at (800) 245-6489 if you need any help

with your unit. We are nearly always able to help “walk you through”

any repairs, problems or questions you may have.

PLEASE NOTE: While information obtained on our web site and

through our 800 number is always free of charge, there will be a service

charge incurred with any “on-site” repairs or maintenance that we may

arrange.

Wishing you years of efficient, quality and “comfy” heating,

England’s Stove Works

Technical Support Department

www.HeatRedefined.com

(800) 245-6489

This manual is available for free download on the manufacturer’s web site. It is a copyrighted document and resale

is strictly prohibited. The manufacturer may update this manual occasionally and cannot be responsible for

problems including injuries or damages resulting from the use of information found in any manual from

unauthorized sources.

PLEASE NOTE: If you purchased this model from certain stores, their model number may end in “L” “LC” “H”

“CT”

etc. This manual does a

to those models as well.

CAUTION:Stoveisheavy.

Inaddition,whenhandlinganysheetmetalproducts,beawarethattheremaybesharpedgesorburrs.

Althoughwemakeeveryefforttoeliminateanysharpedges,pleaseusecautionwhenhandlinganymetalparts.

Remembertodisconnect(unplug)thestovefromthepowersourceand

allowittocompletelycooldown

before

erformin

an

maintenance.

Page | 5

SPECIFICATIONS



Heating Specifications



•

MaximumBurnTime**

.................................................................................

6‐8hours

•

ApproximateSquareFootageHeated***

....................................................

2000sq.ft.

•

Firebox

Capacity............................................................................................ 35

pounds

•

FlueCollar

..................................................................................................

6.0in.round



Dimensions(Inches)

EPA and Safety Compliance Specifications

•

EPA

Compliance

...........................................................................................Certified

•

Particulate

Emissions.................................................................................2.49

grams/hr

•

Efficiency*

..............................................................................................72%HHV(78%LHV)

•

Tested

To...............................................................................

UL‐1482,ULC‐S627‐00



**‐Maximumburntimesareheavilydependentonthetypeofwoodburnedinthestove;assuch,thesenumbers

mayvary.

***‐Themaximumheatingcapacityofthisunitcanvarygreatlybasedonclimate,constructionstyle,insulation

andamyriadofotherfactors.Usethisinformationinconjunctionwith

aBTUlosscalculationforyourhometo

determineifthisunitwillbesufficientforyourneeds.

Page | 6

INSTALLATION



Installation Overview



Whenchoosingalocationforyournewstove,thereareamultitudeoffactorsthat

shouldbetakenintoaccountbeforebeginningtheinstallation.



1.TrafficPatterns–Tohelppreventaccidents,thestoveshouldbeplacedinalocation

whereitisoutofthewayofnormaltravelthroughthe home.



2.HeatFlow–Whendecidingonalocationforthestove,considerthewayheatmoves

throughoutyourhome.Installthestovewhereyouneedtheheat;basement

installationsoftendonotallowsufficientheattoflowtotheupperfloorsandatop

floorinstallationwillnotallow any heattoreachthefloorsbelow. Alwaysconsider

thatheatrisesandwilltakethepathofleastresistancewhileitisstillhot.



3.ExhaustLocation–Theenginewhichdrivesawoodstoveisthechimneysystem,so

itisimportanttoconsiderpreciselyhowthechimneysystemwillbeintegratedinto

thestoveinstallation. Ideally,awoodstovechimney willruncompletelyvertical

fromthefluecollaroftheunitallthewaytotheterminationpointabovetheroof

line. Keepingtheentirechimneysysteminsidetheheatedenvelopeofthehome

willensureastrong,easytoinitiatedraftinthechimney. Althoughexteriorchimney

systemsoftenfunctionproperly,theyaremorelikelytosufferfromcolddowndrafts

atstartuporprovideweakdrafttotheunit. Also,considerthecross‐sectionalarea

ofthechimney;althoughexistingmasonrychimneyscanoftenbeused,alarge

externalmasonrychimneywillresultinaunitthatisdifficultorimpossibleto

operateproperly. Inthatcase,aninsulatedchimneylinerwilloftenberequiredto

supplythenecessarydraft.



4.WallConstruction–Locatingthestovesothattheexhaustsystemcanpassbetween

studswillsimplifytheinstallationandeliminatetheneedtoreframeanysectionsof

thewallorceilingtoaccommodatethewallthimbleorceilingbox.



WARNING



•

Donotstoreorusegasolineorotherflammablevaporsandliquidsinthe

vicinityofthisoranyotherappliance.

•

DoNotOver‐fire–Ifanyexternalpartstartstoglow,youareover‐firing.

Reduceintakeairsupply. Over‐firingwillvoidyourwarranty.



•

Complywithallminimumclearancestocombustiblesasspecified.

Failuretocomplymayresultinahousefire.



•

Testedandapprovedforcordwoodonly. Burninganyotherfuelwill

voidyourwarranty.

Page | 7

INSTALLATION



Clearances to Combustibles



Parallel



Wall

Installation



CornerInstallation



WARNING‐INSTALLVENTATCLEARANCESSPECIFIEDBYTHEVENTMANUFACTURER



Unitto

Side



Wall

Chimney

Connector

to

Side

Wall

Chimney

Connector

to

Rear

Wall

Unit



Rear

Wall

Unitto

Corner

Chimney

Connector

to

Corner

in.(mm.) in.(mm.) in.(mm.) in.(mm.) in.(mm.) in.(mm.)

SingleWall

Chimney

Connector

Unprotected

Surface



21.5

(546.1)



29

(736.6)



12

(304.8)



7.5

(190.5)



9.5

(241.3)



19

(482.6)

DoubleWall

Chimney

Connector

Unprotected

Surface



N/A



N/A



N/A



N/A



N/A



N/A

SingleWall

Chimney

Connector

Unprotected

Surfacewithside

shields.

17.5

(445.5)

25

(635)

12

(304.8)

7.5

(190.5)

5.5

(139.7)

15

(381)

DoubleWall

Chimney

Connector

Unprotected

Surfacewithside

shields.



N/A



N/A



N/A



N/A



N/A



N/A

Page | 8

Venting Introduction

INSTALLATION

Venting Guidelines



Thiswoodstoveoperatesona

naturaldraftsystem,inwhichthechimney

systempullsairthroughthestove. Thisunit

mustbeinstalledinaccordancewiththe

followingdetaileddescriptionsofventing

techniques;notinstallingthestovein

accordancewiththedetailslistedherecan

resultinpoorstoveperformance,property

damage,bodilyinjuryordeath. Avoid

make‐shiftcompromiseswheninstallingthe

ventingsystem. England’sStoveWorksis

notresponsibleforanydamageincurred

duetoapoororunsafeinstallation.

Becertainthatallaspectsofthe

ventingsystemareinstalledtotheventing

manufacturer’sinstructions,particularlythe

requiredclearancestocombustibles. Also,

becertaintouseanatticradiationshieldto

preventinsulationfromcontactinga

chimneywhichpassesthroughanattic.

Thechimneysystemisthe“engine”

whichdrivesawoodstove,soitis

imperativeforproperunitfunctionthatthe

ventingsystembeinstalledexactlyas

describedinthefollowingsection.

Ifquestionsarisepertainingtothe

safeinstallationofthestove,ourTechnical

Supportline(800‐245‐6489)isavailable.

Contactyourlocalcodeofficialtobecertain

yourinstallationmeetslocalandnational

firecodes,andifyou’reuncertainabout

howto safelyinstallthestove,westrongly

recommendcontactingalocalNFIcertified

installertoperformtheinstallation.



•

ALWAYSinstallventpipeinstrict

adherencetotheinstructionsand

clearancesincludedwithyour

ventingsystem.

•

DONOTconnectthiswoodstoveto

achimneyfluewhichalsoserves

anotherappliance.

•

DONOTinstallafluepipedamper

oranyotherrestrictivedeviceinthe

exhaustventingsystemofthisunit.

•

USEanapprovedwallthimblewhen

passingthroughawallandaceiling

support/firestopwhenpassing

throughaceiling.

•

INSTALLthreesheetmetalscrewsat

everychimneyconnectorjoint.

•

AVOIDexcessivehorizontalruns and

elbows,asbothwillreducethedraft

of theventing systemand will result

inpoorstoveperformance.

•

INSPECTyourventingsystemoften,

tobecertainitisclearofcreosote,

fly‐ashandotherrestrictions.

•

CLEANtheventingsystemas

detailedinthemaintenancesection

ofthismanual.

•

ADHEREtothe10‐3‐2rule regarding

chimneyterminations.

•

INSTALLsinglewallchimney

connectorwiththemaleenddown

topreventcreosoteleakage. Follow

doublewallchimneyconnector

manufacturer’sinstructions

regardingproperpipeinstallation.



WARNING:VentingsystemsurfacesgetHOT,andcancauseburnsif

touched. Noncombustibleshieldingorguardsmayberequired.

Page | 9

FlueGasDirection



Additional Venting Information

INSTALLATION

•

Donotmixandmatchcomponentsfromdifferentpipemanufacturerswhenassembling

yourventingsystem(i.e.DoNOTuseventingpipefromonemanufacturerandathimble

fromanother).



•

Werequireaminimumchimneyheightof15.0ft. Chimneysystemsshorterthanthis

maynotcreatethe amountofdraftwhichisrequiredtooperatethiswoodburningunit. 



•

Donotusemakeshiftcompromiseswheninstallingtheventingsystem;haveexisting

chimneysystemsinspectedbeforeuseandbecertainallnewchimneysystemsare

installedtothemanufacturer’sspecificationsandwithonlyULlistedcomponents(ULCif

Canada).



•

PrefabricatedventingsystemsusedforthisstovemustbelistedtoULCS629(Canada)

andUL103HT(US).



•

Neverinstalladraftinduceroranyothersystemwhichincreasesthenaturaldraftofthe

chimney;similarly,donotinstallabarometricorstovepipedamperwiththisunit.



•

Neverusesinglewallordoublechimneyconnectorasachimneysystem;neverpass

eithertypeofchimneyconnectorthroughacombustiblewallwithoutcarefullyfollowing

themanufacturer’sinstructions andthoselistedinthefollowingpageonWallPass‐

Throughs.NEVERpasschimneyconnectorthroughanattic,floor,closetorroof.

•

Onlyuse24gaugeMSGblacksinglewallchimneyconnectororULListed(ULCifCanada)

doublewallchimneyconnector.



Single Wall Chimney Connector Installation



Themaleendofsinglewall

chimneyconnectoris

installedfacingdownsothat

anyliquidcreosoteinthe

fluewillrunintotheunit

insteadofontotheoutside

ofthepipe(thenaturaldraft

inthechimneysystemwill

preventsmokeleakageat

thejoints).



Crimpedormaleendof

singlewallchimney

connectormustfacedown.



Fasteneachsinglewall

chimneyconnectorjoint

withthreesheetmetal

screws.



WARNING



•

INSTALLVENTATCLEARANCESSPECIFIEDBYTHEVENTMANUFACTURER.

•

HOT!Donottouch! Severeburnsorclothingignitionmayresult.

•

Glassandothersurfacesarehotduringoperation.

INSTALLATION

Wall

Pass-Throughs

Canada

, the

installation

must

conform

to CAN/CSA-8365 when passing through

combustible

construction.

Page



Page | 11

18.0in.



2.0ft.



3.0ft.



INSTALLATION



Approved Venting Method 1:ThroughtheWallFactoryBuiltChimney



10

ft.



TerminationCap



StormCollar



RoofFlashing

The 10‐3‐2 Rule:Thechimneysystem

mustterminate3.0ft.abovethepoint

whereitscenterlinepassesthroughthe

roofANDthechimneymustterminate

2.0ft.aboveanypartofthedwelling



withina10ft.radiusofthechimney.



WallThimble

ClassAChimneySystem



ChimneyConnector

(SingleorDoubleWall)

TeeandTeeSupport



•

PrefabricatedchimneysystemsmustconformtoUL‐103HT(2100°F)fortheU.S.andULC‐S629(650°C)for

Canada.

•

Thiswoodburningunitisonlylistedforinstallationwith6.0”diameterchimneyconnectorandchimneysystems.

Installingthisunitonprefabricatedchimneyslargerthan6.0”diameterwillresultindecreaseddraftandthe



potentialforpoorunitperformance.

•

Followallventingsystemmanufacturer’sinstallationrequirementsandrequiredclearances .

•

Usethreesheetmetalscrewsateachsinglewallchimneyconnectorjoint(checkmanufacturer’s

recommendationswhendoublewallchimneyconnectorisused).

•

Drillthreeholesinthefluecollaroftheunitandattachthechimneyconnectortotheunitusingsheetmetal

screws(holesshouldbepre‐drilledinfluecollarfromfactory).

•

Properlyattachtheprefabricatedchimneysystemtothehomeinstrictaccordancewiththeprefabricated

chimneysystemmanufacturer’sinstructions.

•

Avoidnumerouselbowsandexcessive horizontalrunsasbothwillleadtopoordraftandincreasedcreosote

accumulation. Horizontalrunsofchimneyconnectormustneverexceed4.0ft.andtheoveralllengthofthe

chimneyconnectormustnotexceed8.0ft.

•

Specialadaptersandslipconnectorsareavailabletoeliminatetheneedtocutsinglewallchimneyconnector.

Doublewallchimneyconnectormustbeusedwiththeseslipconnectors,asitcannotbetrimmedtolength.



Please Note:Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplans

foreachindividualinstallation. Pleasefollowallventingsystemrequirements,maintaintherequiredclearancesto

combustibles,andfollowalllocalcodes.

Page | 12

2.0ft.



3.0ft.



INSTALLATION



Approved Venting Method 2:ThroughtheCeiling



10

ft.



TerminationCap



StormCollar

The 10‐3‐2 Rule:Thechimneysystem

mustterminate3.0ft.abovethepoint

whereitscenterlinepassesthroughthe

roofANDthechimneymustterminate

2.0ft.aboveanypartofthedwelling



withina10ft.radiusofthechimney.



RoofFlashing

ClassAChimneySystem



CeilingSupportBox



ChimneyConnector

(SingleorDoubleWall)



•

PrefabricatedchimneysystemsmustconformtoUL‐103HT(2100°F)fortheU.S.andULC‐S629(650°C)for

Canada.

•

Thiswoodburningunitisonlylistedforinstallationwith6.0”diameterchimneyconnectorandchimneysystems.

Installingthisunitonprefabricatedchimneyslargerthan6.0”diameterwillresultindecreaseddraftandthe

potentialforpoorunitperformance.

•

Followallventingsystemmanufacturer’sinstallationrequirementsandrequiredclearances.

•

Usethreesheetmetalscrewsateachsinglewallchimneyconnectorjoint(checkmanufacturer’s

recommendationswhendoublewallchimneyconnectorisused).

•

Drillthreeholesinthefluecollaroftheunitandattachthechimneyconnectortotheunitusingsheetmetal

screws(holesshouldbepre‐drilledinfluecollarfromfactory).

•

Properlyattachtheprefabricatedchimneysystemtothehomeinstrictaccordancewiththeprefabricated

chimneysystemmanufacturer’sinstructions.

•

Theoveralllengthofthechimneyconnectormustnotexceed8.0ft. Inthecaseofcathedralceilings,the

prefabricatedchimneysystemshouldextendto8.0ft.fromthetopoftheunit.

•

Specialadaptersandslipconnectorsareavailabletoeliminatetheneedtocutsinglewallchimneyconnector.

Doublewallchimneyconnectormustbeusedwiththeseslipconnectors,asitcannotbetrimmedtolength.



Please Note:Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplans

foreachindividualinstallation. Pleasefollowallventingsystemrequirements,maintaintherequiredclearancesto

combustibles,andfollowalllocalcodes

Page | 13

2.0ft.



18.0in.



3.0ft.



INSTALLATION



Approved Venting Method 3:InternalorExternalMasonryChimneySystem



10

ft.



Chimneylinercross‐sectional

area(LengthxWidth)must

be

nolargerthantwicethecross‐

sectionalareaofthefluecollar

(2x28.27in

2

=56.55in

). If

chimneylinerislargerthan

56.55in

,reliningwitha5.5”

or6.0”linerisrequired

The10‐3‐2Rule:Thechimneysystem

mustterminate3.0ft.abovethepoint

whereitscenterlinepassesthroughthe

roofANDthechimneymustterminate

2.0ft.aboveanypartofthedwelling

withina10ft.radiusofthechimney.



ChimneyConnector

(SingleorDoubleWall)



MasonryThimblewith

properclearanceto

combustibles



AshCleanoutsmust

haveanairtightsealto

preventweakdraft.



•

Followtheruleslistedaboveconcerningmaximumpermissiblefluelinersize;installingthisunitonmasonry

chimneysexceeding56.55

2

incross‐sectionalareawillresultindecreaseddraftandthepotentialforpoorunit

performance.

•

Usethreesheetmetalscrewsateachsinglewallchimneyconnectorjoint(checkmanufacturer’s

recommendationswhendoublewallchimneyconnectorisused).

•

Drillthreeholesinthefluecollaroftheunitandattachthechimneyconnectortotheunitusingsheetmetal

screws(holesshouldbepre‐drilledinfluecollarfromfactory).

•

Avoidnumerouselbowsandexcessive horizontalrunsasbothwillleadtopoordraftandincreasedcreosote

accumulation. Horizontalrunsofchimneyconnectormustneverexceed4.0ft.andtheoveralllengthofthe

chimneyconnectormustnotexceed8.0ft.

•

Atightsealatthethimbleiscrucialforproperunitperformanceandtocreateasafeinstallation. Usetheproper

adapterdesignedforconnectingsingle ordoublewallchimneyconnectortoamasonrythimble.

•

Haveexistingmasonrychimneysinspectedforsafetyandproperclearancestocombustiblesbeforeputtingthem

intoservice;aqualifiedchimneysweepcanperformthisinspection.

•

Externalmasonrychimney s oftensuffercolddowndraftsandpoordraftperformanceevenwhentheymeetthe

cross‐sectionalarearules. Inthiscase,a6.0”insulatedlinermaybenecessary.



Please Note:Installationdiagramsareforreferencepurposesonlyandarenotdrawntoscale,normeanttobeusedasplans

foreachindividualinstallation. Pleasefollowallventingsystemrequirements,maintaintherequiredclearancesto

combustibles,andfollowalllocalcodes.

Page | 14

INSTALLATION



INSTALLATION INTO A MASONRY FIREPLACE

Preparation

Measure your hearth to ensure it is large enough to accept the unit.

Unit must have a 36” clearance from the top of the stove to a mantel in accordance with NFPA 211

For the USA: Hearth must extend at least 16 in. from the front of the fuel opening.

For Canada: Hearth must extend at least 18 in (450.0 mm) from the front of the fuel opening.

Keep in mind that this type of a installation will make it difficult to change speeds on the

blower frequently. We recommend picking a blower speed and sticking with it, since

adjusting the blower will be difficult because of the tight installation.

WARNING: DO NOT ATTEMPT TO ADJUST BLOWER DURING OPERATION. SKIN BURNS

MAY OCCUR WHEN MAKING CONTACT WITH THE UNIT. WAIT FOR UNIT TO COMPLETELY

COOL BEFORE ATTEMPTING TO ADJUST BLOWER.

Inspect your hearth to be sure it is constructed of a noncombustible material such as brick or

stone. Do not install this stove on a hearth that is constructed of wood framework that is covered

by brick or stone and do not install this unit in a zero (0) clearance fireplace. The manufacturer will

not be held responsible for an accident resulting from this stove being installed on a hearth

constructed of a combustible material.

Inspect your fireplace to ensure it is in proper working order and free of any obstructions.

Prior to installation, remove the existing damper or wire it to fasten it open.

Venting Your Stove - Direct Connect

When this unit is direct connected it will require six inch (6”) diameter 24 gauge pipe from the stove

through the damper opening. (NOTE: The chimney connector must be attached to the appliance

with a minimum of three (3) screws, and 3 screws should be used to attach each adjoining

section.)

We highly recommend having the chimney fully lined with a 6 inch liner to ensure proper draft. This

will make it necessary to block off the open area on both sides of the pipe that passes through the

damper opening, which can be done with sheet metal or by packing flame retardant fiberglass

insulation in the open areas (no paper or combustibles). You must be sure the draft from the

chimney is being pulled through the stove, and not around the connector pipe. .

We highly recommend you have this done by a professional. You should also contact your local

authorities to be sure you are following all codes.

Page | 15

INSTALLATION



WARNING



DONOTINSTALLINASLEEPINGROOM.

CAUTION



THESTRUCTURALINTEGRITYOFTHE

MANUFACTUREDHOMEFLOOR,WALL

AND

CEILING/ROOFMUSTBE

MAINTAINE

Caution



NEVERdrawoutsidecombustionair

from:

Wall,floororceilingcavity



enclosedspacesuchasanattic,garageor

crawl

space.

Mobile Home Installation(USAONLY,NOTAPPROVEDFORCANADIANMOBILEHOMEINSTALLATION)



•

ThewoodstoveMUSTbesecuredtothefloorofthemobilehomeusinglagboltsandtheholes

providedinthebottomoftheunitforthis

purpose.Usea#8copperwiretogroun d

stovetoframeofmobilehome.



•

Thewoodstovemustbeconnectedtothe

chimneysystemwithdoublewallchimney

connectorwhichisULlistedforusein

mobileandmanufacturedhomes.



•

Carefullyfollowallclearanceslistedinthe

appropriatesectionofthismanualANDfollow

theventingmanufacturer’s

minimum

clearance

requirements. Similarly,becertain

theventingsystemusedisapproved

formobile



homeuse.



•

Installationmustbeinaccordancewith 

ManufacturersHome&SafetyStandard



ChimneyCap/SparkArrestor



ClassAChimneySystem



RoofFlashingandStormCollar



JoistShield/Firestop



MobileHomeApprovedDouble

WallChimney

Connector



Usesiliconetocreateavapor

barrierwherethechimneypasses

throughtoexterior.

(HUD)CFR3280,Part24aswellasanyapplicablelocalcodes.

Outside Combustion Air

•

Theuseofoutsidecombustionairismandatorywheninstallingthiswoodstoveinamobileor

manufacturedhome.



•

Theoutsideairconnectionpipeprotrudesfromthebottomcenterofthestove;akitisavailable

fromEngland’ sStoveWorks,Inc.designedforconnectingthisunittooutsidecombustionair.[Part

No.AC‐OAK3]



•

IfitisnotfeasibletousetheAC‐OAK3outsideairhookupkitinyourstoveinstallation,other

materialsmaybeused,providedthefollowingrulesarefollowed:



o Thepipeusedforoutsideairhookupmustbemetal,withaminimumthicknessof.0209in.

(25gaugemildsteel)orgreaterandaninsidediameterofapproximately2.75in.



o Keeppiperunsshortanduseamechanicalfastenerateachpipejoint.



o Ascreenorotherprotectiondevicemustbefittedovertheoutsideairterminationpointto

preventrain,debrisandnuisanceanimals fromenteringthepipingsystem. Inspectthe

outsidecombustionairinletforblockanddebrismonthly.

Page | 16

FLOORPROTECTION



•

ThiswoodstoverequiresaULlistedtype1sparkandemberfloorprotectorifthestoveistobe

installedonacombustiblefloor. Ifthefloorthestoveistobeinstalledonisalready

non‐combustible(i.e.aconcretefloorinabasement),nofloorprotectionis

needed(althougha

decorativefloorprotectorcanstillbeusedforaestheticreasons).



•

WhenusinganyULlistedtype1spark andemberfloorprotector,considerthatthisstoveisnotonly

heavybutwillinduceheatingandcoolingcyclesonthefloorprotectorwhichcandamagetileand

loosenmortarand groutjointslocatednearthestove.



•

Thespar kandem berfloorprotectorshouldbeULapprovedorequivalent(ULCifCanada)andmust

benoncombustible. Sincethemajorityoftheheatfromthisunitisradiant,thefloorprotectoronly 

servestokeepashesandsparksfromlanding oncombustibleflooringneartheunit. Ahearth

rugis

NOTanapprovedsubstituteforaproperhearthpad.NoRValueisnecessary.



•

FortheUS:Thefloorprotectormustextendatleast16in.fromthefrontofthefuelopening,8in.

fromthesidesofthedooropeningand8in.fromtherearoftheunit.



•

ForCanada:Thefloorprotectormustextendatleast450.0mmfromthefrontofthefuel

opening,



200.0mmfromthesidesofthedooropeningand200.0mmfromtherearoftheunit.



•

Thesparkandemberfloorprotectormustextend2in.(50.8mm.)oneithersideofanyhorizontal

ventingrunsandextenddirectlyunderneathanyverticalventingpipe.



CAUTION



NEVERUSEGASOLINE,GASOLINE‐TYPELANTERNFUEL,KEROSENE,CHARCOALLIGHTER

FLUID,

ORSIMILARLIQUIDSTOSTARTOR“FRESHENUP”AFIREINTHISHEATER. KEEPALL

SUCH

LIQUIDSWELLAWAYFROMTHEHEATERWHILEINUSE. ADDITIONALLY,NEVERAPPLY

FIRE‐

STARTERTOANYHOTSURFACEOREMBERSINTHE

STOVE.



38½in

47in

Page | 17

OPERATION



Break‐In Fires



•

Thiswoodburningunitisconstructedofheavygaugesteelandcastironandisbuilttolastalong

time. However,inordertoensurenoexcessivethermalstressesareinducedonthe

metal

during

thefirstfire,threebreak‐infiresshouldbeburned,eachoneslightlyhotterthanthelast.

Thesebreak‐infireswillnotonlyhelpthestovebodyacclimatetothehightemperaturesofthe

fire,butwillalsoslowlycurethehightemperaturestovepaint,whichwillensurethe

high

qualityfinishlastsforyears.



•

Thisstovehasasingleaircontrolrodwhichregulatesthewoodburnrate;whentheprimaryair

controlslideispulledallthewayoutoftheunit,thestovewillburnmoreslowlyandputout

heatoveralongertimeperiod. Conversely,whentheaircontrolslide

ispushedallthewayin,

theunitwillburnmorequicklyandputoutalargeramountofheatoverarelativelyshorter

time



period. Donotattempttomodifytherangeofaircontroladjustmentforanyreason.



•

Thefirstbreak‐infireshouldbejustalargekindlingfire,gettingthestovetoabout300°Fas

measuredbyamagneticthermometerontherightorleftsideofthestove,abovethe

door.

Once

thistemperatur ehasbeenreached,allowthefiretodieoutwiththeaircontrolopen.The

secondandthirdbreak‐infiresshouldbeabitlarger,withsomesmalldrysplitsaddedtothe

kindlingload. Thetemperaturegoal duringthesefiresisabout350°F–450°

F;don’tletthefire

gethotterthanthat.



Continuous Operation



•

Afterthebreak‐infiresarecomplete,thisunitisreadyforcontinuousoperation. Whenburning

thestovecon tinuously, donotallowashandcoalstoaccumulatehigherthantheairholeinthe

dogbox. Excessivecoalingisoftenaresultofburningwoodattoohighaburn

rate,andthecoal

bedshouldbeallowedtoburndownbeforereloadingthestovewithfreshwood.



•

Combustionairisdeliveredtothestoveattwolocations:Themajorityoftheprimarycombus tion

airentersthefireboxviatheair‐washsystemwhichkeepstheglasscleanandfeedstheprimary

combustionflamesonthetopsurfacesofthewood;someprimarycombustionairisfeedinto

the

coalbedviathedogboxholeinthebottom,frontboxofthestove. (Thisairissuppliedfrom 

undertheunit.)Everyeffortmustbetakentomaintaintheareainfrontofthisholefreeofash.



•

Whenloadingthestoveforalongtermburn,itismostusefultorakea“v”inthecenterofthe

coalbed,toallowtheprimaryairbleedholetopushairallthewaytotherearoftheunit.



•

Afterloadingthestovewithafullfireboxoffreshwood,itisimportanttooperatetheunitwith

theaircontrolinthefullopenpositiontoproperlycharthewoodloadanddriveofftheinitial

moistureinthefreshwood. Oncethewoodhasbeenproperlycharred

andiscompletely

ignited,theaircontrolcanthenbesettothedesiredheatoutputlevel.



•

Thisunitalsooffersanewfeature. Whenloadingthestoveforalonglowburn,youcansetthe

aircontroldampertoallowtheunittoheatupandgetagoodburngoingbeforetheairis

closed



offtothelowposition. Simplypulltherodouttolowandturnitcounter‐clockwiseuntil

youhearaslight “click”(aboutaquarterofaturn). Whenitisreadythedamperwillshutitself.

Thiswillworkforlowandmediumlowsettings.

age | 18

OPERATION



•

England’sStoveWorks,Inc.alwaysrecommendstheuseofamagneticstovethermometer,so

thatthetemperatureoftheunitcanbemonitored. Whenusingamagneticstovethermometer,

locatethethermometerabovethedooroneithertheleftorrightsideofthestoveandusethe

followingtemperatures

asroughguidelinestodeterminetheburnrateandheatoutputlevelof

thestove:

o Normalwoodstoveoperationshouldoccurbetween350°F(177°C)and550°F(288°C),

with350°F(177°C) to450°F(232°C)bei ngalowtomediumheatoutputleveland450°F

(232°C)to550°F(288°C)beingamedium

tohighheatoutputlevel. Operatingthestove

at600°F(316°C)wouldbeconsideredthemaximumcontinuousoperatingtemperature

permissibleandunitdamagemayresultfromoperatingatthathighofaburnratefor

extendedtimeperiods. Allowingtheunittoreach650°F(343°C)orhigherisdefinedas

over

‐firingandwillresultinunitdamage.



•

Theoptionalroomairconvectionblowerwasdesignedtoextractthemaximumamountofheat

fromthestove,forthehighestpossibleheattransferintotheroom. Sincetheblowerisso

efficientatremovingheatfromtheunit,itisveryimportanttoonlyoperatetheroomairblower

afterafreshwoodloadhasbeenallowedtoburnforatleastthirty(30)minutes. Allowingafresh

loadofwoodtoburnwithoutthebloweronensuresthattheentireunitreachesproper

operationtemperaturesandthatthesecondarycombustionsystemisfunctioningproperly.

Additionally,followtheguidelinesbelow

foracceptableblowerspeeds.



•

Whenusingtheoptionalroomairconvectionblower(PartNo.AC‐16,oryoucanupgradetothe

AC‐30),theblowershouldbeoperatedasfollowsdependingonheatoutputlevel:



Burn

Rate

High MediumHigh Medium MediumLow Low

BlowerSpeedAC‐16 High

High

Low

BlowerSpeedAC‐30 High MediumHigh Medium MediumLow Low

Creosote – Formation and Need for

Removal



Whenwoodisburnedslowly,itproducestarandotherorganicvapors,

which



combinewithexpelledmoisture toformcreosote. Thecreosote

vapors

condenseintherelativelycoolchimneyflueofaslow‐burningfire. Asa

result,

creosoteresidueaccumulatesonthefluelining. Whenignited,this

creosote

makesanextremelyhotfire. Thechimneyandchimneyconnectorshould

be

inspectedatleastonceeverytwomonthsduringtheheatingseason

to

determineifacreosotebuilduphasoccurred. Ifcreosotehasaccumulated,

it

shouldberemovedtoreducetheriskofchimney

fire.

DONOTUSEGRATEORELEVATEFIRE–BUILDWOODFIREDIRECTLYON

HEARTH



DONOTOPERATEWITHTHEMAINDOOROPEN–OPERATINGTHESTOVEWITHTHE

MAIN

DOOROPENWILLCREATEANOVER‐

FIRE

Intheeventofacreosoteorsootfire(chimneyfire),closetheaircontrolonthe

stove,

contactthelocalfiredepartmentandgetout! Donotthrowwateronthefire!

Contact

yourlocalfireauthorityformoreinformationonhowtohandleachimneyfire

and



developasafeevacuationplanforyouandyourfamilyintheeventofachimneyfire.

Page | 19

OPERATION



Additional Safety Guidelines



CAUTION:Whenaddingfueltothestove,theblowermustbeturnedOFF.



•

Theinstallationofsmokedetectorsishighlyrecommendedwheninstallingthisoranyother

solidfuelburningappliance. Smokedetectorsshouldbelocatednearorineveryroomofthe

home,particularlysleepingrooms.



•

Asmokedetectorcanbeinstalledinthesameroomasthiscordwoodburningunit;installingthe

smokedetectortooclosetotheunitcanleadtonuisancealarmsduetoslightwispsofsmoke

emittedduringthefirestartingorreloadingprocess. Duetothis,thesmokedetectorin

the

sameroomastheunitwillbemostusefulifitislocatedasfarfromtheunitastheroomwill

permit.



•

Thisstoveismeantforburningcordwoodonly;neverburnpressuretreatedwood,kilndried

wood,creosotetreatedwood(railroadti es),icecoveredorwetwood,greenwood,driftwood,

charcoal,coal,cokeorANYotherfuel.



•

Burningfuelsotherthancordwood,particularlycoalandcharcoal,canresultinhazardous

concentrationsofcarbonmonoxidebeingemittedintothedwelling. Forthesereasons,NEVER

burncoalorcharcoalinthiscordwoodstove.Installingacarbonmonoxidedetectorandbeing

awareofthesymptomsofcarbonmonoxidepoisoningcan

helpreducetheriskofcarbon

monoxiderelatedissues. 



•

Thisunitwasdesignedforoperationonlywiththeloadingdoorclosedandtightlylatched.

Operatingthisunitwiththeloadingdoorlatchedlooselyoropenwillallowexcessivecombustion

airtoreachthefireandwillresultindangerouslyhighunittemperatures. Highunit

temperaturescan damagetheunit,

voidthewarrantyorignitecreosotedepositedinthe

chimneysystembyprevious,slowburningfires.



•

Thenaturaldraftthatpullsairthroughthisunitandallowsthefiretoburnusestheindoorairof

thedwellingforcombustion,unless theunitisconnectedtoanoutsidecombustionairsource.

Kitchenrangeventhoods,furnacesandotherairmovementappliancesinthehomeareoften

alsoremovingairfromthedwelling;iftheamountofairfiltrationorleakagebackintothehome

isexceededbytheairbeingremoved,negativepressuremaybecreatedinthehome.



•

Sincethisisanaturaldraftappliance,itwilloftenbethefirstappliancetohaveproblemsrelated

tonegativepressure. Ifsmokeisforcedoutthechimneyconnectorjointsoroutoftheair

inductionsystemoftheunit,theunitislikelyfightingnegativepressureinthedwelling.

Crackingawindowordoorneartheappliancecanhelpequalizethenegativepressure;

ultimately,anunrestrictedsourceofoutsidecombustionmaybenecessaryforproperunit

function.



•

Iftheunitisconnectedtooutsideair,becertaintomonitortheexteriorinlettothecombustion

systemforicingorsnowaccumulation. Allowingtheoutsideairconnectionto

becomerestricted



willresultinairstarvationtotheunit.



DONOTSTOREFUELCLOSERTHANSPECIFIEDCLEARANCESTOCOMBUSTIBLESOR

WITHINTHESPACENEEDEDFORLOADINGTHESTOVEANDFORASHREMOVAL.

Page | 20



Daily Maintenance

MAINTENANCE

•

Inspectthefireboxforashaccumulation;removeexcessashandfollowinstructions

belowregardingdisposa l. Ashshouldnotbeallowedtoaccumulateinthestovetothe

pointthatitcoversthedogboxhole.



Monthly Maintenance

•

Checktheblowerfordustaccumulation(ifinstalled);checkthedoorhandleforproper

operationandtobecertainanairtightsealisstillbeingmadebythedoor.

•

Inspectthechimneysystemandchimneyconnectorandsweepifnecessary. Although

cleaningmayberequiredlessthanmonthly,ALWAYSinspecttheventingsystem

monthlytodecreasethechanceofachimneyfire.

•

Visuallyinspecttheceramicfiberinsulatingboardsinthefireboxforcracksand/or

breakage. Slightsurfacecrackswillnotaffecttheperformanceoftheboards,but

crackedorcrumblingboardsshouldbereplacedimmediately.

•

Visuallyinspectthesecondarycombustiontubesforcracks,warpingandcorrosion.

Althoughthesetubesareconstructedfromstainlesssteel,theyoperateatveryhigh

temperaturesandcaneventuallywearoutfromnormaluse.



Yearly Maintenance

•

Checkallgaskets(windowanddoor)forwearandtobecertaintheystillmaintainan

airtightseal. Seethefollowingpageforinstructions.

•

Thoroughlycleanthechimneysystemandthechimneyconnectorsystem. Sincethe

chimneyconnectorisgenerallyexposedtohighexhausttemperatures,inspectit

carefull

forleaksandweakspots;replaceanyquestionablepieces.[Inthecaseof

straightthroughtheroofchimneysystem,becertaintoremovetheceramicfiberbaffles

beforepushingthechimneysweepingbrushdownintothefirebox. Forcefullyhitting

thetopofthebafflewithacleaningbrushorrodcandamageordestroythebaffle.]

•

Removeallashfromthestove,including the ashwhichaccumulatesonthetopofthe

fireboxbaffles. Leavetheaircontrolopenduringthenon‐heatingmonthstoallow

someairtoflowthroughthestovetohelppreventcorrosion.Asmallopencontainerof



catlitterinthestovecanhelppreventcorrosionduringthehumidsummermonths;be

certaintoremoveitbeforebuildingafireinthefall.



IMPROPERGASKETMAINTENANCE,INCLUDINGFAILURETOREPLACEGASKETS,CAN

CAUSEAIRLEAKSRESULTINGINANUNCONTROLLABLEFIREINTHEUNIT.



DisposalofAshes–Ashesshouldbeplacedinametalcontainerwithatightfittinglid. The

closedcontainerofashesshouldbeplacedonanoncombustiblefloororontheground,well

awayfromallcombustiblematerials,pendingfinaldisposal. Iftheashesaredisposedofby

burialinsoilorotherwiselocallydispersed,theyshouldberetainedintheclosedcontainer

untilallcindershavebeenthoroughlycooled.

Page is loading ...

Summers Heat 50-SHSSW01LC User manual

Brand: Summers Heat

Model: 50-SHSSW01LC

Category: Stoves

Type: User manual

Download PDF

report

in other languages

français: Summers Heat 50-SHSSW01LC Manuel utilisateur

Summers Heat 50-SHSSW01LC User manual

Summers Heat 50-SHSSW01LC User manual

in other languages

Related papers

Other documents