Enraf-Nonius ManuXelect is an examination and treatment couch specially designed for the demands of the physical and manual therapist. The anatomically segmented top part combined with the wide array of section positions enable you to position your patient virtually however you wish.
Its standard features include:
- Electric height adjustment
- Electric backrest adjustment
- Electric leg rest adjustment
- Retractable wheels
- Intuitive all-around control
- Motorised headrest adjustment (optional)
- Motorised lateral tilt adjustment (optional)
Enraf-Nonius ManuXelect is an examination and treatment couch specially designed for the demands of the physical and manual therapist. The anatomically segmented top part combined with the wide array of section positions enable you to position your patient virtually however you wish.
Its standard features include:
- Electric height adjustment
- Electric backrest adjustment
- Electric leg rest adjustment
- Retractable wheels
- Intuitive all-around control
- Motorised headrest adjustment (optional)
- Motorised lateral tilt adjustment (optional)
Page 1 of 16 EN109-1550750-45
ManuXelect
EN109-1550750-45
MAY 7, 2019
Instructions for use
Page 2 of 16 EN109-1550750-45
Table of contents
1 Introduction ...................................................................................................................................................... 3
2 Symbols .............................................................................................................................................................. 4
3 Package contents ............................................................................................................................................ 5
4 Installation ......................................................................................................................................................... 6
5 Intended use and intended user ............................................................................................................... 6
6 Precautionary instructions ........................................................................................................................... 7
7 Operation ........................................................................................................................................................... 9
8 Safety instructions ....................................................................................................................................... 11
9 Cleaning, maintenance and troubleshooting .................................................................................... 12
10 Specifications ................................................................................................................................................. 14
11 Contact ............................................................................................................................................................. 15
12 Product liability ............................................................................................................................................. 15
Page 3 of 16 EN109-1550750-45
1 Introduction
We are pleased that you have purchased a ManuXelect treatment couch.
This examination and treatment couch is specially designed for the demands of the physical and
manual therapist. The anatomically segmented top part combined with the wide array of section
positions enable you to position your patient virtually however you wish.
During development and production of this ManuXelect a great deal of care was put into the
reliability, safety, ease of use and durability.
It is important to read the following instructions carefully before using your ManuXelect
properly and safely. The manufacturer cannot be held responsible for the results of using
this device for any purposes other than described in these operating instructions.
If the use of this device may have caused or contributed to an undesirable event such as
death or serious injury to the user, the manufacturer AND the competent authority of the
Member State MUST be notified immediately!
This manual applies to:
• ManuXelect 2-section, head section
• ManuXelect 2-section, back section
• ManuXelect 3-section
• ManuXelect Traction
• ManuXelect accessories
Page 4 of 16 EN109-1550750-45
2 Symbols
Symbol used
Description
Follow the instructions in the Instructions for Use.
It is important that you read, understand and observe the precautionary and
operating instructions
Warning or Caution:
Indicates a hazardous situation which, if not avoided, could result in:
a. Death or serious injury to the patient (or)
b. Minor to moderate injury to the patient (or)
c. Damage to the equipment
Temperature Range.
Indicates acceptable temperature range
Humidity Limits.
Indicates acceptable relative humidity
Atmospheric Pressure.
Indicates the range of atmospheric pressure to which the medical device can
be safely exposed.
Waste electrical items that can be recycled.
Indicates the electrical and electronic components of the device can be
recycled and has to be disposed separately.
Manufacturer name, address and date of manufacture.
Reference Number or Part Number
Serial Number
Indicates the serial number so that a specific medical device can be
identified.
IP 55
Ingress Protection Marking, classifies and rates the degree of protection
provided against intrusion (body parts such as hands and fingers), dust,
accidental contact, and water by mechanical casings and electrical enclosures.
“55” indicates device protection against dust and water jets.
Double Insulation
Product is in conformity with European Council of Medical Device Directive
(93/42/EEC)
Page 5 of 16 EN109-1550750-45
Risk of crushing hands
3 Package contents
1x ManuXelect Couch
Standard accessories
1x 1550.750 Instructions for Use
1x 0167.283 Information sheet first use ManuXelect
1x 6759.060 Cable clip
1x 0167.329 Information sheet disinfection of upholstery
Ordering data
For the ordering data of the ManuXelect, standard accessories and optional accessories we refer to
www.enraf-nonius.com.
Page 6 of 16 EN109-1550750-45
4 Installation
Unpacking the device
Do not lift the couch by the table top parts or the all-around control.
The device is heavy, it must be unpacked by at least 2 persons.
Inspection
Immediately after unpacking the couch, check whether the package contains all the items
listed above, and check the couch for any damage.
In case of damage, contact your local representative. Do NOT use the equipment!
Installation
Read this Instructions for Use carefully before using the equipment.
Avoid exposure to direct sunlight, UV radiation, rain, excessive dust, moisture, mechanical
vibrations, and shocks.
The ManuXelect couches are not intended for use in so-called “wet rooms” (hydrotherapy
rooms).
The device may not be used in close proximity (i.e. less than 2 metres) to shortwave or device.
The ManuXelect should be placed on a flat surface.
Turn the adjustable foot until it touches the ground and the couch is standing stable.
For correct assembly and safe use of possible optional accessories one must consult the
separately provided documents included with the optional accessories.
Follow the instructions for connection of controls and connection to mains supply on the
information sheet First Use ManuXelect (article 0167.283) supplied with the treatment couch.
5 Intended use and intended user
Intended use
The ManuXelect examination and treatment couches are intended to support a patient in the
desired position for examination or treatment within the physiotherapy, rehabilitation and adjacent
disciplines.
Intended user
The ManuXelect treatment couches are intended to be used, and shall only be used, by or under
the supervision of professional users in physiotherapy, rehabilitation and adjacent areas.
Connection to mains supply
Mains supply connections must comply with the national requirements regarding medical
rooms.
Prior to connection of this device to the mains supply, check that the voltage and frequency
stated on the type plate correspond with the available mains supply.
Page 7 of 16 EN109-1550750-45
6 Precautionary instructions
Read this Instructions for Use carefully before using the equipment.
Do not lift the couch by the table top parts or the all-around control.
Immediately after unpacking the couch, check whether the package contains all the items
listed above, and check the couch for any damage.
In case of damage, contact your local representative. Do NOT use the equipment!
Avoid exposure to direct sunlight, UV radiation, rain, excessive dust, moisture, mechanical
vibrations, and shocks.
The ManuXelect couches are not intended for use in so-called “wet rooms” (hydrotherapy
rooms).
The device may not be used in close proximity (i.e. less than 2 metres) to shortwave or device.
The ManuXelect should be placed on a flat surface.
Turn the adjustable foot until it touches the ground and the couch is standing stable.
For correct assembly and safe use of possible optional accessories one must consult the
separately provided documents included with the optional accessories.
Mains supply connections must comply with the national requirements regarding medical
rooms.
Prior to connection of this device to the mains supply, check that the voltage and frequency
stated on the type plate correspond with the available mains supply.
The ManuXelect is only meant to be used by competent personnel in physiotherapy,
rehabilitation or adjacent areas. Avoid any use of the equipment by unauthorized personnel.
When used by children, supervision by a knowledgeable (para)medic is obligatory. At all times
keep children away from the equipment when no supervision is at hand or use a safety switch.
Use both hands to change the couch settings: one hand for unlocking and the other to adjust
the section.
Never adjust a section when it supports the full weight of the patient! Each section of
this ManuXelect is supported by gas springs. As well as easing operation, they offer full
support of the sections. However, these gas springs are not strong enough to lift a section
while it supports the full weight of the patient.
A maximum patient’s weight of 150 kg is allowed with the 6000N motor KL95 (standard
motor) when the height of the couch is being adjusted.
A maximum patient’s weight of 250 kg is allowed with the 9000N motor SL80 (optional
motor) when the height of the couch is being adjusted.
Be aware of the duty cycle of the motor. The motor is not designed for continuous operation.
For every 25 seconds the motor is running, it needs 400 seconds to cool down. If you do use
the motor considerably longer without allowing it to cool down sufficiently, a thermal cut
shuts off the power and protects the motor against overheating. In that case, let the motor
cool down until it functions again.
The couch is not anti-static.
For safety reasons, the wheels of the unit should be retracted before the beginning of a
treatment.
Never let your full weight rest on the switch bar!
Ensure that you will never rest your feet on the all-around-operation.
Especially when seated next to the couch it can lead to a dangerous situation in which your
leg can be jammed between the section and the all-around-operation.
Do not sit on the head and leg section of the couch.
When adjusting this couch, keep hands and feet away from the couch for at least 20 cm,
especially on places that has been marked by these stickers.
Page 8 of 16 EN109-1550750-45
When adjusting the sections, squeezing-danger can arise at contact points of the section.
Keep enough distance between you or your clients and these points.
Head section: is not suited to sit upon and must be used to support the head only.
Always use the original Enraf-Nonius accessories that are meant for this product.
Use a clean couch cover / towel / terry cloth / paper cover for every individual. This is required
to guarantee a hygienic use.
Do not use cleaning agents that contain alcohol or other aggressive cleaners.
The ManuXelect should be checked once a year by authorized personnel of Enraf-Nonius or
by its authorized distributor.
The manufacturer will not be held responsible for the results of maintenance or repairs by
unauthorized persons!
Page 9 of 16 EN109-1550750-45
7 Operation
Use both hands to change the couch settings: one hand for unlocking and the other to adjust
the section.
Never adjust a section when it supports the full weight of the patient! Each section of
this ManuXelect is supported by gas springs. As well as easing operation, they offer full
support of the sections. However, these gas springs are not strong enough to lift a section
while it supports the full weight of the patient.
A maximum patient’s weight of 150 kg is allowed with the 6000N motor KL95 (standard
motor) when the height of the couch is being adjusted.
A maximum patient’s weight of 250 kg is allowed with the 9000N motor SL80 (optional
motor) when the height of the couch is being adjusted.
Be aware of the duty cycle of the motor. The motor is not designed for continuous operation.
For every 25 seconds the motor is running, it needs 400 seconds to cool down. If you do use
the motor considerably longer without allowing it to cool down sufficiently, a thermal cut
shuts off the power and protects the motor against overheating. In that case, let the motor
cool down until it functions again.
The couch is not anti-static.
The operation of your ManuXelect treatment couch is simple and safe.
The illustrations show how the various adjustments are done.
Moving the couch
The couch can be moved by using the foot pedal to
lower the wheels (optional).
NOTE: Never move the couch with a person or load on
it. Move the couch only on a smooth surface. The
couch is not designed to move across thresholds.
For safety reasons, the wheels of the unit should
be retracted before the beginning of a treatment.
Electric height adjustment
By pressing the foot switch continuously, the required
height can be reached.
Page 10 of 16 EN109-1550750-45
Height adjustment with the all-around operation
(optional)
By pressing or pulling the all-around operation - which
is located underneath the framework - with your foot,
the required height of the couch can be set. At the
head section of the couch, the height can be adjusted
by turning the handle to the left or to the right.
Never let your full weight rest on the switch bar!
Adjusting the back section
Use one hand to pull the handle underneath the back
section, while adjusting the section in the desired
position. Release the handle and the section will be
fixed.
Adjusting the head section
Use one hand to pull the handle underneath the head
section while adjusting the section in the desired
position. Release the handle and the section will be
fixed.
Releasing the rolling section (traction)
Release the rolling section by pulling out the stop pin.
Turn the pin slightly if you want to prevent it from
clicking back into the locking mechanism.
Locking the rolling section (traction)
To lock the rolling section again, turn the pin such that
it can click back into the start position.
Page 11 of 16 EN109-1550750-45
8 Safety instructions
Danger of squeezing the extremities
On this couch warning-stickers are placed.
When adjusting this couch, keep
hands and feet away from the couch
for at least 20 cm, especially on places
that has been marked by these
stickers.
Height adjustment (general)
Ensure that neither the patient nor the operator
can get any part of the body or clothes near or in
between the moving parts of the mechanism
when the couch is being raised or lowered.
Be particularly careful for those situations
indicated beside (the couch is set in flexion
position combined with the lowest possible
position):
Underneath the head section, between the head
section and floor.
Height adjustment
Ensure that you will never rest your
feet on the all-around-operation.
Especially when seated next to the
couch it can lead to a dangerous
situation in which your leg can be
jammed between the section and the
all-around-operation.
Page 12 of 16 EN109-1550750-45
Danger of tilting
Do not sit on the head and leg
section of the couch.
Adjustment of the sections
When adjusting the sections,
squeezing-danger can arise at contact
points of the section. Keep enough
distance between you or your clients
and these points.
Load
Head section: is not suited to sit upon and must be used to support the head only.
9 Cleaning, maintenance and troubleshooting
Cleaning
Use a clean couch cover / towel / terry cloth / paper cover for every individual. This is required
to guarantee a hygienic use.
Do not use agents that contain alcohol or other aggressive cleaners.
• The couch must be cleaned before it is first used and before it is disinfected.
• Clean the couch with a damp cloth.
• Use a mild detergent to clean the surface.
• Remove soap residue with a damp cloth and clean water.
Disinfection
• Clean the couch as described above before proceeding to disinfect the couch.
• Follow the disinfectant's instructions for use.
• Never use a mixture of disinfectants or a disinfectant and soap mixture.
• Preferably use a cloth to apply the agent to the imitation leather.
• Avoid water accumulation in the hinge points of the metal frame. (In the worst case, exposing
the hinges to water in the long-term can result in rust formation)
• The disinfectants listed on the information sheet (article 0167.329), are tested and safe for use
on the imitation leather of the treatment table.
For the most current version of the list see www.enraf-nonius.com/downloads
Page 13 of 16 EN109-1550750-45
Remark:
Since we have no control over the production and raw materials used for the disinfectants, we
are unable to give a general guarantee that these agents will not damage the upholstery.
Maintenance
If you encounter any problem with the ManuXelect, stop using the couch and contact your supplier.
• Check the operation of every section adjustment regularly (at least once every month). For correct
operation keep the bars of the mechanism clean and free of grease.
• Check at least once every 6 months the functioning of the height adjustment if this has not been
used for a long time.
• Disconnect the mains cable from the electricity supply if the couch is not being used for a long
period.
Troubleshooting
Disconnect the mains cable from the electricity supply if the all-around-operation is not working
appropriately.
Then check whether the three operation elements of the all-around-operation are in a neutral
position: the bar on the left and on the right plus the handle.
At the short-sided edge of the couch, where you
can find the small operation handle, there is a
cord that runs to the underside of the couch. Try
to follow this cord with your hand as far as
possible, till you can pull it loose carefully from
the small pin. – see the small illustration
alongside, illustration is a bottom view –.
Uncouple the cord for a moment and put it back
again. Afterwards you can connect the mains
cable with the electricity supply and bring the
all-around-operation back into use.
Expected service life
This device will remain suitable for its intended use as long as it is subjected to yearly maintenance
by a qualified service engineer as described in the service manual and the service engineer deems
the device fit for use according to specifications.
End of life
Your ManuXelect contains materials which can be recycled and/or are noxious for the environment.
The ManuXelect should be checked once a year by authorized personnel of Enraf-Nonius or by
its authorized distributor.
The manufacturer will not be held responsible for the results of maintenance or repairs by
unauthorized persons!
Please ensure that you are well informed of the local rules and regulations regarding the
removal of equipment and accessories.
Page 14 of 16 EN109-1550750-45
10 Specifications
Technical data
Height adjustment
ca. 48 - 105 cm
Length
ca. 207 cm (ca. 240 cm incl. traction frame)
Width
ca. 67 cm
Lifting capacity
150 kg with the standard motor KL95 of 6000N
250 kg with the optional motor SL80 of 8000N
Motor speed
6 mm/sec for both types
Mains voltage
230V~ 50/60 Hz or 115V~ 50/60 Hz
Current consumption
1.5A for the 6000N motor
2.0A for the 8000N motor
IP classification
IP 55
Upholstery
Type AKV Peri
Fire safety
DIN EN 1021 part 1/2
Free of phthalates
yes
Biological
DIN EN ISO 10993-5
DIN EN ISO 10993-10
Technical modifications reserved!
Safety and performance standards
Medical device classification
I
Safety class according to IEC 60601-1
II, double insulated
This equipment complies with all requirements of the Medical Device Directive (93/42/EEC).
Environmental conditions
Environmental conditions for transport and storage
Environmental temperature
-20° to +60° C
Relative humidity
30 to 70% (non-condensing)
Atmospheric pressure
700 to 1060 hPa
Environmental conditions normal use
Environmental temperature
-10° to 40° C
Relative humidity
30 to 70 % (non-condensing)
Atmospheric pressure
700 to 1060 hPa
Page 15 of 16 EN109-1550750-45
11 Contact
For assistance, please visit our website http://www.enraf-nonius.com
The latest version (in electronic or printed format) of this Instructions for Use can be obtained free
of charge from our website www.enraf-nonius.com or by contacting distributor or by calling the
telephone number: +31-(0)10-2030600. The Instructions for Use will be sent (free of charge) to you
within 7 (seven) calendar days.
12 Product liability
A law on Product Liability has become effective in many countries. This Product Liability law implies,
amongst other things, that once a period of 10 years has elapsed after a product has been brought
into circulation, the manufacturer can no longer be held responsible for possible shortcomings of
the product.
To the maximum extent permitted by applicable law, in no event will Enraf-Nonius or its suppliers
or resellers be liable for any indirect, special, incidental or consequential damages arising from the
use of or inability to use the product, including, without limitation, damages for loss of goodwill,
work and productivity, computer failure or malfunction, or any and all other commercial damages
or losses, even if advised of the possibility thereof, and regardless of the legal or equitable theory
(contract, tort or otherwise) upon which the claim is based. In any case, Enraf-Nonius entire liability
under any provision of this agreement shall not exceed in the aggregate the sum of the fees paid
for this product and fees for support of the product received by Enraf-Nonius under a separate
support agreement (if any), with the exception of death or personal injury caused by the negligence
of Enraf-Nonius to the extent applicable law prohibits the limitation of damages in such cases.
Enraf-Nonius cannot be held liable for any consequence resulting from incorrect information
provided by its personnel, or errors incorporated in this manual and / or other accompanying
documentation (including commercial documentation).
The opposing party (product’s user or its representative) shall disclaim Enraf-Nonius from all claims
arising from third parties, whatever nature or whatever relationship to the opposing party.
EN109-1550750-45
Copyright:
Enraf-Nonius B.V.
Vareseweg 127 | 3047 AT | Rotterdam | The Netherlands
Tel: +31 (0)10-20 30 600 | info@enraf-nonius.nl
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
Enraf-Nonius ManuXelect is an examination and treatment couch specially designed for the demands of the physical and manual therapist. The anatomically segmented top part combined with the wide array of section positions enable you to position your patient virtually however you wish.
Its standard features include:
- Electric height adjustment
- Electric backrest adjustment
- Electric leg rest adjustment
- Retractable wheels
- Intuitive all-around control
- Motorised headrest adjustment (optional)
- Motorised lateral tilt adjustment (optional)
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Enraf-Nonius ManuXelect User manual
-
-
-
-
-
-
-
-
-
