Burkert 8316 Operating instructions

Brand: Burkert

Model: 8316

Type: Operating instructions

Bürkert - Type 8316 - Edition 02/2019 - 117260

8316

Relativ- und Absolutdrucktransmitter

Bedienungsanleitung (Seite 2-4)

Relative and absolute pressure transmitter

Operating instructions (page 5-7)

Transmetteur de pression relative et absolue

Mode d‘emploi (page 8-10)

Bürkert - Type 8316 - Edition 02/2019 - 117260

SteckerM12x1

 2-Leiter 3-Leiter

Litzenanschluss

Range of application for the pressure transmitter type 8316

Thepressuretransmitterisusedtomeasurerelativeandabsolutepressureofliquidandgases.

Thepressuretransmitterconsistsofapiezoresistivemeasuringcellwithadiaphragm,installedinastainless

steel housing. This transmitter is available with various connector types, IP protection standards as well as

current- and voltage outputs.

Installation

• Thelocationofthedevicehasnoinfluenceontheprecisionofthemeasurement.

• Beforeinstallation,comparetheprocessdatawiththedataofthenameplate.

• Themediumbeingmeasuredmustbesuitableforthepartsofthepressuretransmitterincontactwiththe

medium.

• Connectthedevicestoafixedcableinstallation.

• Thedevicesmayonlybeinstalled,connected,set-upandoperatedbyqualifiedstaffandincompliancewith

thetechnicalspecifications.

• TheeffectsofUVradiationcancausematerialstobecomebrittle.Protectthedevicefromdirectsunlight.

Safety instructions

Intermsofasafety-instrumentedsystem,thisdeviceleftthefactoryinperfectcondition.Tomaintainthisstatus

andtoensuresafeoperationofthedevice,observethefollowingnotes:

Thedevicemayonlybeusedforthepurposesspecifiedintheseinstructions.

• Whenconnectingup,installingandoperatingthedevice,thedirectivesandlawsofyourcountryapply.

• Thedeviceisnotusedproperly,seriousbodily injuryand/or considerabledamage topropertycannot be

 excluded.Thisshouldbekeptinmindparticularlywhenthedevicewasinuseandisreplaced.

• Thetransmitterispresettothespecificmeasuringrangeatthemanufacturer’splant.Anadditionalsetting

is not possible.

• Theoverloadlimitshouldbemonitoredandkepttoatalltimes.

• Thetransmitterismaintenance-free.

• Connectthedevicetoalowvoltagepowersupplywithsafeseparation(SELV).

• ForequipmentwithaULmark,theymustbesuppliedwithlimitedenergyaccordingtoUL61010-1Second

 Edition,Section 9.3 or LPS in conformance with UL60950-1 or class 2 in compliance with UL1310 or

 UL1585.

Tests / Admissions

Electromagneticcompatibility: CEconformityacc.EN61326-2-3

ULrecognizedcomponentmarks: acc.E312665

Shockacc.IEC60068-2-27:  25g,6mshalfsinewave,all3directions.

DroptestEN60068-2-23:  from1monconcrete

Vibrationacc.IEC60770-1:  5m/s,10...1000Hz,1Octave/min20constantloadperaxis

English

Bürkert - Type 8316 - Edition 02/2019 - 117260

Electrical Connection

B(IN)A(OUT) B(IN)C(OUT)A(GND)

 2wire 3wire

ConnectorDINEN175301-803-AorC

Swiftconnector

MetriPackSerie150

1)Notconnectedwithtransmitterhousing

1 (IN) 2 (OUT)

1 (IN) 2 (OUT) 1 (IN) 3 (OUT) 1 (IN) 4 (OUT) 1 (IN) 2 (OUT) B (IN) A (OUT)

1 (IN) 2 (OUT) 3 (GND) 1 (IN) 2 (OUT) 3 (GND) 1 (IN) 4 (OUT) 3 (GND) 1 (IN) 3 (OUT) 4 (GND) 1 (IN) 2 (OUT) 3 (GND) B (IN) C (OUT) A (GND)

1 (IN) 2 (OUT) 1 (IN) 2 (OUT) 1 (IN) 3 (OUT) 1 (IN) 4 (OUT) 1 (IN) 2 (OUT) B (IN) A (OUT)

1 (IN) 2 (OUT) 3 (GND) 1 (IN) 2 (OUT) 3 (GND) 1 (IN) 4 (OUT) 3 (GND) 1 (IN) 3 (OUT) 4 (GND) 1 (IN) 2 (OUT) 3 (GND) B (IN) C (OUT) A (GND)

1 (IN) 2 (OUT)

1 (IN) 3 (OUT) 1 (IN) 4 (OUT) 1 (IN) 2 (OUT) B (IN) A (OUT)

1 (IN) 2 (OUT) 3 (GND) 1 (IN) 2 (OUT) 3 (GND) 1 (IN) 4 (OUT) 3 (GND) 1 (IN) 3 (OUT) 4 (GND) 1 (IN) 2 (OUT) 3 (GND) B (IN) C (OUT) A (GND)

1 (IN) 2 (OUT) 1 (IN) 2 (OUT) 1 (IN) 3 (OUT) 1 (IN) 4 (OUT) 1 (IN) 2 (OUT) B (IN) A (OUT)

1 (IN) 2 (OUT) 3 (GND)

1 (IN) 4 (OUT) 3 (GND) 1 (IN) 3 (OUT) 4 (GND) 1 (IN) 2 (OUT) 3 (GND) B (IN) C (OUT) A (GND)

1 (IN) 2 (OUT) 1 (IN) 2 (OUT) 1 (IN) 3 (OUT) 1 (IN) 4 (OUT) 1 (IN) 2 (OUT) B (IN) A (OUT)

1 (IN) 2 (OUT) 3 (GND) 1 (IN) 2 (OUT) 3 (GND) 1 (IN) 4 (OUT) 3 (GND) 1 (IN) 3 (OUT) 4 (GND) 1 (IN) 2 (OUT) 3 (GND) B (IN) C (OUT) A (GND)

1 (IN) 2 (OUT) 1 (IN) 2 (OUT) 1 (IN) 3 (OUT) 1 (IN) 4 (OUT) 1 (IN) 2 (OUT) B (IN) A (OUT)

1 (IN) 2 (OUT) 3 (GND) 1 (IN) 2 (OUT) 3 (GND) 1 (IN) 4 (OUT) 3 (GND) 1 (IN) 3 (OUT) 4 (GND) 1 (IN) 2 (OUT) 3 (GND) B (IN) C (OUT) A (GND)

ConnectorRAST2.5

1 (IN) 2 (OUT) 1 (IN) 2 (OUT) 1 (IN) 3 (OUT) 1 (IN) 4 (OUT) 1 (IN) 2 (OUT) B (IN) A (OUT)

1 (IN) 2 (OUT) 3 (GND) 1 (IN) 2 (OUT) 3 (GND) 1 (IN) 4 (OUT) 3 (GND) 1 (IN) 3 (OUT) 4 (GND) 1 (IN) 2 (OUT) 3 (GND) B (IN) C (OUT) A (GND)

brown

green

brown

green

white

Bürkert - Type 8316 - Edition 02/2019 - 117260

Electrical Connection

 2wire 3wire

ConnectorDINEN175301-803-AorC

Swiftconnector

MetriPackSerie150

1(IN)3(OUT) 1(IN)4(OUT)3(GND)

1(IN)3(OUT)4(GND)1(IN)4(OUT)

ConnectorM12x1

 2wire 3wire

Braids