Astria Fireplaces Vega Instruction Sheet

Astria Fireplaces
Brand
Astria Fireplaces
Model
Vega
Type
Instruction Sheet

This manual is also suitable for

INSTALLATION INSTRUCTIONS
BRICK LINER KIT
Models
BLZ32SVF
BLZ36SVF
BLZ42SVF
IMPORTANT: Read entire instruction sheet before installing brick
liner
This brick liner accessory is approved for use in (V)FB(F,L)(32,36,42)
series vent-free fireboxes. Do not use brick liner accessory in any
other fireplace models.
The Brick Liner Kit contains the following:
32" Fiber Panel Kit BLZ32SVF
Description Part No. Qty.
Rear Panel 126242-01 1
Right Side Panel 126241-01 1
Left Side Panel 126240-01 1
Retainer Brackets 116531-01 2
Screws, HWH AB 8-18 X .38 M11084-38 4
36" Fiber Panel Kit BLZ36SVF
Description Part No. Qty.
Rear Panel 126245-01 1
Right Side Panel 126244-01 1
Left Side Panel 126243-01 1
Retainer Brackets 116531-01 2
Screws, HWH AB 8-18 X .38 M11084-38 4
42" Fiber Panel Kit BLZ42SVF
Description Part No. Qty.
Rear Panel 126248-01 1
Right Side Panel 126247-01 1
Left Side Panel 126246-01 1
Retainer Brackets 116531-01 2
Screws, HWH AB 8-18 X .38 M11084-38 4
Tools required:
• Phillips Screwdriver
• 5/16'' Hex Socket Wrench or Nut Driver
If any of these parts are missing or damaged, contact the dealer
where you purchase this kit. Normally, all parts should be ordered
through your IHP distributor or dealer. Parts will be shipped at pre-
vailing prices at time of order.
Note: Some installations may require the gas supply line to be
disconnected before removing log assembly. If so, call a qualified
service person to disconnect gas supply from fireplace.
Figure 1 - Brick Liner Kit
IMPORTANT: Always handle firebrick panels with two hands.
WARNING: Turn off, unplug, and let fireplace cool
before installing brick liner. Only a qualified service
person should service and repair fireplace.
NOTICE: If already installed, you must remove log base
assembly before installing brick liner. Refer to log base
assembly owner's manual.
WARNING: A qualified service person must connect
and disconnect fireplace to gas supply. Follow all local
codes.
Screws
Screws
Retaining
Bracket
Retaining
Bracket
Left Side
Panel
Right Side
Panel
Rear Panel
Gas Line
Knockout
P126389-01
P/N 126389-01 Rev. B 05/2015
For more information, visit IHP.US.com
Figure 2 - Firebrick Panels with Retaining Brackets and Gas Knockout
1. Install rear firebrick panel on back wall. Rest bottom edge of
firebrick panel on firebox floor. Lean firebrick against back wall
of firebox while installing side panels.
Note: The rear panel is held in place by two side panels.
2. Gently slide left side brick into place while holding rear brick
panel upright against firebox back.
3. Use supplied retainer bracket and screw to secure side brick
panel to firebox (see Figure 2).
4. Repeat steps 2 and 3 for right side brick panel.
CAUTION: Always handle fiber panels with two
hands. Do not force fiber panels into place. Excessive
force will break fiber panels.
5. There is a gas knockout in each side panel for the gas line to
feed through (see Figure 2). Determine on which side the gas
connection will be located. Using a utility knife or cutting blade,
remove the identified gas knockout.
6. Replace log base if removed for firebrick installation (see log base
owner's manual for proper installation).
WARNING: Test all gas piping and connections for
leaks after installing or servicing. Correct all leaks at
once.
WARNING: Never use an open flame to check for a
leak. Apply a noncorrosive leak detection fluid to all joints.
Bubbles forming show a leak. Correct all leaks at once.
Screws
Retaining
Bracket Retaining
Bracket
Gas
Knockout
Innovative Hearth Products reserves the right to make changes at any time, without notice, in
design, materials, specifications, prices and also to discontinue colors, styles and products. Consult
your local distributor for fireplace code information.
Printed in U.S.A. © 2014 IHP LLC
P/N 126389-01 Rev. B 05/2015. 1508 Elm Hill Pike, Suite 108 • Nashville, TN 37210
P126389-01
  • Page 1 1
  • Page 2 2

Astria Fireplaces Vega Instruction Sheet

Astria Fireplaces
Brand
Astria Fireplaces
Model
Vega
Type
Instruction Sheet
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents