DXV D23010S000.415 Installation guide

DXV
Brand
DXV
Model
D23010S000.415
Type
Installation guide
- 1 -
INSTALLATION INSTRUCTIONS
SAVE FOR FUTURE USE
Product names listed herein are trademarks of AS America, Inc.
© AS America, Inc. 2017
7302027-100 Rev. E (4/18)
RECOMMENDED TOOLS AND MATERIALS
Most of the procedures require the use of common tools and materials, which are available from hardware and plumbing
supply stores. It is tessential that the tools and materials be on hand before work is begun.
Thank you for selecting DXV. To ensure this product is installed properly, please read these instructions carefully before you begin.
(Certain installations may require professional help.) Also be sure your installation conforms to local codes.
CAUTION: PRODUCT IS FRAGILE. TO AVOID BREAKAGE AND POSSIBLE INJURY HANDLE WITH CARE!
NOTE: Pictures may not exactly define contour of china and components.
!
Cossu
™
(formerly SEAGRAM
®
)
Wall Hung Dual Flush
Toilet with Seat
Model D23010S000.415
GasketWax Ring
Regular Screwdriver
10'
Level Flexible Supply Tube
Closet Bolts
Putty Knife
Tape Measure
Hacksaw
SealantAdjustable Wrench
1
ROUGHING-IN DIMENSIONS:
ALL INSTALLATION PROCEDURES MUST COMPLY IN STRICT ACCORDANCE WITH APPLICABLE LOCAL
PLUMBING AND BUILDING CODES
SUPPLY
AS REQ’D
4"
(100 mm)
5-1/2"
MIN.
(140 mm)
1/2"
NPT
4" MIN.
(102 mm)
FINISHED
FLOOR
FINISHED
FLOOR
STUD FRONT
CENTER PIPE
4-1/4"
(108 mm)
7-1/16"
(180 mm)
0" - 7-7/8"
(0 - 200 mm)
12"-16"
(305-407 mm)
44-1/2"-48-7/16"
(1130-1230 mm)
X
19-3/4"
(500 mm)
21"
(533 mm)
14-1/2"
(366 mm)
6-1/8"
(155 mm)
10"
(254 mm)
FINISHED RIM
HEIGHT (FRM)
FRM =
X PLUS
3" (76 mm)
17-1/2"
(445 mm)
13-3/4"
(350 mm)
- 2 -
BOWL INSTALLATION:
Remove yellow protection plugs and seals from pipes.
Add dimension Y and 1/8" (3 mm). Using that dimension,
mark a line on the pipe measuring from the hub side.
Cut off the pipe at the line with a pipe cutter.
Place discharge pipe with gasket into waste outlet of bowl.
Also place ush pipe with n gasket into inlet of bowl. Then
mark a second line on both pipes.
Insert discharge pipe into the pipe hub in the wall. Place a
straight edge ush against the wall and mark a line on the
pipe. Fit nned rubber seal onto ush pipe. Repeat same
procedure for discharge pipe.
Bevel the sharp edges as shown to assure a smooth insertion
into the pipe hubs in the wall.
Add dimension X and 1/8" (3 mm). Using that dimension,
mark a line on the pipe measuring from the hub side. Cut off
the pipe at the line with a pipe cutter.
7302027-100 Rev. E (4/18)
6 7
2 3
5
4
1
1
2
2
2
2
1
1
2
2
1
1
1
2
X
X
+
1/8"
+
(
3
m
m
)
+
1/8"
+
(
3
m
m
)
Y
Y
1
2
- 3 -
Install both seals into the pipes in the wall. Lubricate seals
with appropriate rubber seal lubricant.
NOTE: DO NOT overtighten hex nuts!
Place bowl onto rods. Attach cap washer with nose up
and facing forwards onto rods. Install washer and hex nuts,
tighten loosely. Level bowl. Tighten hex nuts. Snap on the
bolt caps.
Remove protective sleeves from mounting rods. Determine
protruding rod length for bowl installation. Install both pipes
into the hubs in the wall.
Seal gap around bowl with waterproof sealant.
7302027-100 Rev. E (4/18)
8 9
11
10
2
2
1
+
13/16"
+
(
2
0
m
m
)
- 4 -
In the United States:
DXV
One Centennial Avenue
Piscataway, New Jersey 08855
Attention: Director of Customer Care
For residents of the United States, warranty
information may also be obtained by calling
the following toll free number: (800) 227-2734
www.DXV.com
In Canada:
DXV
5900 Avebury Road
Mississauga, Ontario
L5R 3M3
Canada
Toll Free: 1-800-387-0369
Local: 905-306-1093
Fax: 1-800-395-1498
www.DXV.ca
In Mexico:
DXV
Via Morelos 330
Col. Santa Clara Coatitla
Ecatepec, Estado de México 55540
Toll Free: 01-800-8391200
www.DXV.mx
7302027-100 Rev. E (4/18)
TOILET SEAT INSTALLATION:
Insert plugs into holes of toilet.
Place seat into position.
Install base.
Fix seat with screws.
12 13
15
14
PLUGS
BASE
PART NUMBER DESCRIPTION
D23010S000.415 WALL-HUNG BOWL
5035A.10G.XXX WALL-HUNG TOILET SEAT ELONGATED, SLOW-CLOSE, TOP MOUNT
D29054026.000 GROHE IN-WALL CARRIER
D28015000.XXX
SKATE COSMOPOLITAN ACTUATOR
FOR SINGLE, DUAL AND START AND STOP FUNCTIONS
(for carrier repair parts please check carrier installation instructions)
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4

DXV D23010S000.415 Installation guide

DXV
Brand
DXV
Model
D23010S000.415
Type
Installation guide
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents