PGO G-MAX User manual

1

DEAR CUSTOMERS：

：：

：

Thank you for choosing G-MAX of PGO scooter. It is a fact that

the efficiency and sustaining life of each scooter depend heavily on

the operating method of each user. Thus this owner’s manual will

provide you a precise knowledge of easy adjusting, sustaining and

precaution for your scooter. We hope you will read and check it

carefully.

Please recognize your scooter model clearly in order to read the

following instruments.

If there is any question, please do not hesitate to ask

your dealer for assistance.

We hope you will enjoy it !

Manufactured by:

Motive Power Industry Co., Ltd.

2

ONTENT

ONTENTONTENT

ONTENT

Warranty Card ....................................................5

Scooter safety....................................................... 6

Part location......................................................... 8

Identification........................................................ 9

The function of switch & controller................... 1 1

Main switch ................................................... 1 1

Speedometer .................................................. 1 2

Handlebar Controls........................................ 2 2

Steering Lock................................................. 2 3

Seat Lock .......................................................2 3

Fuel Tank Cap................................................ 2 4

Passengers Pedal............................................ 2 4

Luggage Compartment ..................................25

Power Supply Outlet...................................... 2 5

Power Disconnection Switch......................... 2 6

Pre-riding inspection........................................... 2 7

Brake.............................................................. 28

Brake Fluid .................................................... 29

Engine Coolant .............................................. 30

Engine Oil...................................................... 31

Air Cleaner .................................................... 32

Tire................................................................. 33

Throttle Grip .................................................. 34

Lamp & Signal Light..................................... 34

Switches......................................................... 34

Fuel ................................................................ 35

Catalyst .......................................................... 36

Notation for operation and riding......................37

Starting the engine ......................................... 37

Warming up the engine.................................. 38

Brake operation.............................................. 39

Engine initial run-in....................................... 40

Parking vehicle .............................................. 41

Periodical maintenance..................................... ..42

Periodical maintenance table ....................... ..43

Exhaust control system................................ ..46

The air cleaner ............................................. ..47

The spark plug ............................................. ..48

Exchange of gear oil .................................... ..49

Brake adjustment......................................... ..49

Brake fluid check......................................... ..50

Front fork check........................................... ..51

Battery.......................................................... ..52

Fuse replacement ......................................... ..53

Reference Date ................................................... ..54

Periodical maintenance record......................... ..56

10

11

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

42

43

44

45

46

47

48

49

50

52

3

Check List before Delivery

Check List before DeliveryCheck List before Delivery

Check List before Delivery

Name： Tel： Age： Sex：

Address：

Model： Engine No： VIN No：

Delivery date： Year Month day Dealer：

NO

Check Item

Y

N

NO

Check Item

Y

N

1 Steering of Handle Bar 8 Tire Pressure

2 Gap of Brake Lever 9 Confirm Engine No & Document

3 Lights and Horn 10 Owner’s Manual

4 Fuel Tank and Fuel Kind 11

Operating Method Introduction

5 Engine Oil 12 Periodic Maintenance introduction

6 Disk Brake fluid 13 Warranty Introduction

7 Engine Coolant

Staff Signature：

Customer Signature：

Suggestion：

※ Please Sign both customer & service Staff.

※ Mail this chart to agent, and then the Warranty will be effective.

4

5

PGO Warranty Card

Name Telephone Registration date

Address

Model

Displacement

CC

Engine NO. Vin NO.

Customer Signature

Dealer Signature

6

SCOOTER SAFETY

▲WARNING

.Scooter riding requires special afford on your part to ensure your safety.

Know these requirements before you ride:

SAFE RIDING RULES

1. Always make a pre-ride inspection(page 27) and perform any needed adjustments or repairs before you ride

the scooter.

2. Many accidents involve inexperienced riders. Most countries require a special scooter riding test or license.

Make sure you are qualified before your ride.

NEVER lend your scooter to an inexperienced rider.

3. Many automobile/scooter accidents happen because the automobile driver does not "see" the motorcyclist.

Make yourself conspicuous to help avoid the accident that wasn't your fault:

- Wear bright or reflective clothing.

- Don't ride in another motorist's "blind spot"

4. Obey all national and local laws and regulations.

- Excessive speed is a factor in many accidents. Obey the speed limits, and NEVER travel faster than

conditions warrant.

- Signal before your make a turn or lane change. Your size and maneuverability can surprise other

motorists.

25

7

5. Don't let other motorists surprise you. Use extra caution at intersections , parking lot entrances and exits,

and driveways.

6. Keep both hands on the handlebars and both feet on the floorboards while riding. A passenger should hold

on to the scooter or the feet on then passenger foot pegs.

7. Never leave your scooter unattended with the engine running.

8. Moderate your speed when ridding over bumpy roads. Avoid hitting road hazards, such as sharp bumps and

holes, in the road surface. These hazards can cause loss of control or structural damage to the vehicle.

9. It’s not necessary to keep the vehicle idling for warm up. However, if you want to idle the vehicle, please

don’t go away the vehicle for safety!

8

Part location:

REAR LAMP

AIR CLEANER

MAIN STAND

SEAT

REAR RACK

FRT BRAKE DISK

THROTTLE GRIP

FRT BRAKE LEVER

REAR BRAKE LEVER

HEAD LAMP

FRT SIGNAL LAMP

FUEL CAP

9

IDENTIFICATION

2.Engine No. is located (stamped) on the rear side of the left crankcase.

NOTE:

The upper row is model type, the lower row is the production serial numbers.

Your dealer need this number for ordering the parts, please write down the

engine no. for their

reference.

IDENTIFICATION

3.Vehicle Identication Number (VIN) is located (stamped) inside the rear battery cover.

NOTE:

The first 9 digitals are model type, the last 8

digitals are production serial numbers.

Your dealer need this number for ordering the

parts, please write down the engine no. for their

reference.

10

THE FUNCTION OF SWITCHES

1. MAIN SWITCH

1. OFF: All the power is cut off, the key can be

pulled out at this position.

2. ON: The power is ON, engine can be started,

the key can not be pulled out at this position

3. LOCK: The handle bar is locked at this

position.

4. “Push + turn counterclockwise”:

to open the seat.

5. When at position #1, “Push + turn clockwise”

to open the fuel cap.

6. For anti-thief purpose, push to close the core

of key set.

7. Press the key to get anti-thief key out.

8. Push the anti-thief key into position #8, then

the core of key set will open again.

1 2

5

3

6

4

7

8

11

DASHBOARD

Engine check

Coolant temperature warning

Signal indicator

.High beam

Engine oil

Engine stop warning light

12

A、

、、

、Main items

#1.SEL SELECT button: refer to section B.

#2.ADJ ADJUST button: refer to section B.

#3.Engine check (red)

 Self-test whenever turn on the key for ~3 seconds.

 When lights on again during driving, please contact your PGO dealer to check the EMS units.

#4.Engine oil replacement warning light (red)

replace the 4T engine oil, then reset the counter. (refer to section B)

#5.Engine speed: * 1000 rpm：be careful when reaching the RED area！

#6.Signal indicator (green) : when acting the turn lights

#7.High beam (blue) : when (high beam) or (PASSING)

#8.Fuel meter: will twinkle when below 2 grids

when reaching to this point, it will twinkle to reminding you to add fuel ASAP.

#9.Coolant temperature warning lamb : (red)

 Self-test whenever turn on the key for ~2 seconds.

 When lights on again during driving, please contact your PGO dealer to check the cooling system.

#10.Speedometer : can switch the unit from km/h to mile/h

#11.Vehicle speed: can change unit by ( km/h) or (mile/h)

display mode: (ODO) or (TRIP)

#12. Engine stop warning light: remind you the Engine stop button working, you can’t start the engine now!

13

LCD Operating instruments:

function

mode

key display SEL. ADJ. Result

ON main menu Click Altitude

ON Altitude Click voltage

ON voltage Click Engine check

ON EMS OK! Click Setup

Basic mode

ON Setup

Click Mileage menu

km Click 3 sec. mph

Vehicle speed

ON

mph

Click 3 sec. km

ODO Click TRIP

TRIP Click Oil

Oil Click ∮

∮∮

∮(Km/l)

(ODO)

(TRIP) /

OIL /

(fuel consumption)

ON

∮

∮∮

∮(Km/l)

Click ODO

Reset (TRIP) ON TRIP Click 3 sec.

Reset TRIP to

0do

Altitude ON altitude

Only shows

when engine

stopped

Forever ON Click 3 sec. twinkle Reset oil indicator

(under OIL menu)

ON

twinkle

Click 3 sec. OFF

Cancel

Reset (4T oil indicator)

ON twinkle

Click Forever ON

14

function

mode

key display SEL. ADJ. Result

Setup ON Setup Click 3 sec. Clock

ON

hour twinkle

Click

0~23

increasing

ON

hour twinkle

Click

Switch to

minute

ON

minute twinkle

Click

0~59

increasing

Setting

Clock setting

ON

minute twinkle

Click

Switch to

display contrast

ON

display twinkle

Click

0~16

increasing

Setting

Display contrast

ON

display twinkle

Click

Switch to

Alti. meter

ON

Click

Reset Elevation

to 0do

ON

pressure

twinkle

Click

Switch to

Elevation

ON

Click Ref. Elevation

Setting

Alti. meter setting

ON

Ref. Elevation

twinkle

Click

Switch to

Speed alarm

15

function

mode

key display

SEL. ADJ. Result

ON Click

50~130 km/h

increasing

Setting

Speed alarm

ON

Speed twinkle

Click

escape to

main menu

Power Test main menu Click Click

Power Test

0~100km/h

ON

Click Reset

Power Test

0~100km/h

ON

Time

(0~100km/h)

Click3 sec.

escape to

main menu

ON

Click Reset

Power Test

0~400 m

ON

Time

(0~400 m)

Click3 sec.

escape to

main menu

ON

general Click3 sec. animation

main menu

ON

animation

Click3 sec. general

ON

standard

Speed ≧ Speed alarm

Speed

simplified

main menu (animation)

ON

Speed simplified

Speed ≦ 40 km/h standard

16

menu switching:

Click

sel

3 seconds

main menu

(general)

main menu

(animation)

Speed / fuel

/ water temperature

Speed ≧

≧≧

≧

Speed alarm

Speed ≦

≦≦

≦ 40

40 40

40

km/h

km/hkm/h

km/h

Click

ADJ.

Click

ADJ.

Click

ADJ.

Click

ADJ.

speed TRIP ODO : click ADJ to switch

Mileage under TRIP , press ADJ to reset TRIP

under ODO ,press ADJ to switch MPH&KMH

17

Basic mode:

Click

SEL.

Click

SEL.

Click

SEL.

Click

SEL.

Click

SEL.

Altitude (only shows

when engine stopped)

battery

voltage

press SEL(3 SECOND) to

switch sub menu of EMS

information

Press SEL at the same

time for 3 seconds

18

Click

SEL.

3 second

Click

SEL

Click

SEL

Click

SEL

3 second

Click

ADJ

5 second

19

Setting:

Click

SEL

3 second

Time setting mode:

Click SEL to switch hour & minute

Click ADJ to change digitals

Click

SEL

Display mode:

Press ADJ to adjust

Click SEL to switch

Click ADJ to change digitals

Click SEL to switch

Click ADJ to change digitals

Click

SEL

20

Click ADJ & SEL within 3 seconds,

Into POWER TEST mode:

Click SEL to start test.

0~100 KM/h test:

Start test whenever vehicle move

Click ADJ to reset

0~400m test:

Start test whenever vehicle move

Click ADJ to reset

Click

SEL

Click

SEL

Page is loading ...

PGO G-MAX User manual

PGO G-MAX User manual

Other documents