SunTouch ProMelt Outdoor Sensor 070 Installation guide

Brand: SunTouch

Model: ProMelt Outdoor Sensor 070

Type: Installation guide

This manual is also suitable for

070
300070

Installation & Operation Manual

 of4 ©203WattsRadiant

Outdoor Sensor 070

ReadthisManualBEFOREusingthisequipment.

Failuretoreadandfollowallsafetyanduseinformationcanresultin

personalinjury,propertydamage,ordamagetotheequipment.

KeepthisManualforfuturereference.

Itisyourresponsibilitytoensurethatthissensorissafelyinstalledaccordingto

allapplicablecodesandstandards.WattsRadiantisnotresponsiblefordamages

resultingfromimproperinstallationand/ormaintenance.

TheOutdoorSensor070providesaccuratemeasurementoftheoutdoorair

temperature.Manycontrolsandthermostatscanconnecttothe070tomeasure

anddisplaytheoutdoortemperature.

Mounting the Outdoor Sensor

Thetemperaturesensor(thermistor)isbuiltintothe070enclosure.

Removethescrewandpullthefrontcoveroffthesensorenclosure.

The070caneitherbemounteddirectlyontoawallora2"x4"electricalbox.When

the070iswallmounted,thewiringshouldenterthroughthebackorbottomofthe

enclosure.Donotmountthe070withtheconduitknockoutfacingupwardsasrain

couldentertheenclosureanddamagethesensor.

Inordertopreventheattransmittedthroughthewallfromaffectingthesensorreading,

itmaybenecessarytoinstallaninsulatingbarrierbehindtheenclosure.

The070shouldbemountedonawallwhichbestrepresentstheheatloadonthe

building(anorthernwallformostbuildingsandasouthernfacingwallforbuildings

withlargesouthfacingglassareas).The070shouldnotbeexposedtoheatsources

suchasventilationorwindowopenings.

The070shouldbeinstalledatanelevationabovethegroundthatwillprevent

accidentaldamageortampering.

•

Sensorwithbottom

entrywiring

Sensorwithrear

entrywiring

Sensormounted

onto2"x4"

electricalbox

IOM-WR-Outdoor_Sensor-070323 2of4

Connect8AWGorsimilarwiretothetwoterminalsprovidedintheenclosure

andrunthewiresfromthe070tothecontrol.Donotrunthewiresparallelto

telephoneorpowercables.Ifthesensor

wiresarelocatedinanareawithstrong

sourcesofelectromagneticinterference

(EMI),shieldedcableortwistedpair

shouldbeusedorthewirescanberun

inagroundedmetalconduit.Ifusing

shieldedcable,theshieldwireshould

beconnectedtotheComterminalonthe

controlandnottoearthground.

Followthesensortestinginstructionin

thisbrochureandconnectthewiresto

thecontrol.

Replacethefrontcoverofthesensor

enclosure.

•

Wires from outdoor

sensor to control’s

outdoor sensor and

sensor common

terminals

Sensor is built into

the enclosure

Wiring & Testing the Sensor

Sensor Testing Instructions

Agoodqualitytestmetercapableofmeasuringupto5,000kΩ(kΩ=000Ω)is

requiredtomeasurethesensorresistance.Inadditiontothis,theactualtemperature

mustbemeasuredwitheitheragoodqualitydigitalthermometer,orifathermometer

isnotavailable,asecondsensorcanbeplacedalongsidetheonetobetestedand

thereadingscompared.

Firstmeasurethetemperatureusingthethermometerandthenmeasuretheresistance

ofthesensoratthecontrol.Thewiresfromthesensormustnotbeconnectedto

thecontrolwhilethetestisperformed.UsingtheTemperaturevs.ResistanceTable,

estimatethetemperaturemeasuredbythesensor.Thesensorandthermometer

readingsshouldbeclose.Ifthetestmeterreadsaveryhighresistance,theremay

beabrokenwire,apoorwiringconnectionoradefectivesensor.Iftheresistance

isverylow,thewiringmaybeshorted,theremaybemoistureinthesensororthe

sensormaybedefective.Totestforadefectivesensor,measuretheresistance

directlyatthesensorlocation.

Temperature vs. Resistance Table

Do not apply voltage to a sensor at any time as damage to the sensor may result.

Temperature Resistance

°F °C

-50 -46 490,83

-45 -43 405,70

-40 -40 336,606

-35 -37 280,279

-30 -34 234,96

Temperature Resistance

°F °C

-25 -32 96,358

-20 -29 65,80

-5 -26 39,402

-0 -23 8,08

-5 -2 00,22

 3of4 ©203WattsRadiant

Temperature Resistance

°F °C

0 -8 85,362

5 -5 72,98

0 -2 62,465

5 -9 53,658

20 -7 46,28

25 -4 39,93

30 - 34,558

35 2 29,996

40 4 26,099

45 7 22,763

50 0 9,900

55 3 7,436

60 6 5,3

65 8 3,474

70 2 ,883

75 24 0,50

80 27 9,299

85 29 8,250

90 32 7,334

95 35 6,532

00 38 5,828

05 4 5,20

0 43 4,665

Temperature Resistance

°F °C

5 46 4,84

20 49 3,760

25 52 3,383

30 54 3,050

35 57 2,754

40 60 2,490

45 63 2,255

50 66 2,045

55 68 ,857

60 7 ,689

65 74 ,538

70 77 ,403

75 79 ,28

80 82 ,72

85 85 ,073

90 88 983

95 9 903

200 93 829

205 96 763

20 99 703

25 02 648

220 04 598

225 07 553

WARNING:

This product contains chemicals

known to the State of California to cause cancer

and birth defects or other reproductive harm.

For more information: www.watts.com/prop65

Technical Data

Outdoor Sensor 070

Literature ES-WR-Outdoor_Sensor-070,IOM-WR-Outdoor_Sensor-070

Packagedweight 0.4lb.(80g)

Dimensions 4-/2"Hx2-7/8"Wx-/2"D(73x4x38mm)

Enclosure WhitePVCplastic,NEMAtype2

Approvals CSACUS

Operatingrange

-58to40°F(-50to60°C)

Sensor

NTCthermistor,0kΩ@77°F(25°C±0.2°C)ß=3892

Temperature vs. Resistance Table Continued

A Watts Water Technologies Company

USA:Springeld,MO•Tel.(800)276-249•Fax:(47)864-86•www.wattsradiant.com

Canada:Burlington,ONT.•Tel.(905)332-4090•Fax:(905)332-7068•www.watts.ca

Hydronic System Electronic Controls and Thermostats Limited Warranty

WattsRadiant(theCompany)warrantsitshydronicsystemelectroniccontrolsandthermostats(theProduct)tobe

freefromdefectsinmaterialsandworkmanshipundernormalusageforaperiodofoneyearfromthedocumented

dateofinstallationoftheProduct.Intheeventofdefectswithinthewarrantyperiod,theCompanywillreplace

theProductwithoutcharge.Thisremedyisthesoleandexclusiveremedyforbreachofwarranty.Thiswarranty

istransferabletosubsequentowners.

UnderthisLimitedWarranty,theCompanywillprovidethefollowing:

Inordertomakeaclaim,youmust:

(a)ProvidetheCompanywithsufficientdetailsrelatingtothenatureofthedefect,theinstallation,thehistoryof

operation,andanyrepairsthatmayhavebeenmade.

(b)AttheCompany’sdiscretionandattheowner’sexpense,shiptheProducttotheCompanyortheCompany’s

localrepresentativeordistributor.

(c) ProvideproofthattheProductwasinstalledinaccordancewiththeapplicableProductInstallationManualand

anyspecialwrittendesignorinstallationguidelinesbytheCompanyforthisproject.

(d)ProvideproofthattheProductwasinstalledinaccordancewiththeNationalElectricalCode(NEC)orthe

CanadianElectricalCode(CEC),andallapplicablelocalbuildingandelectricalcodes.

(e) Providearetailsalesreceiptorproofofpurchase.

ThefollowingarenotcoveredbythisLimitedWarranty:

(a)Anyincidentalorconsequentialdamage,includinginconvenience,lossoftimeorlossofincome.

(b)

AnylaborormaterialsrequiredtorepairorreplacetheProductthatarenotauthorizedinwritingbytheCompany.

(c) Anylaborormaterialsrequiredtoremove,repairorreplacematerialsotherthantheProducts.

(d)AnyfreightordeliverycostsrelatedtotheProductoranyrelatedelectricalproducts.

WattsRadiantassumesnoresponsibilityunderthisLimitedWarrantyforanydamagetotheProductcausedby

anytradespeople,visitorsonthejobsite,ordamagecausedasaresultofpost-installationwork.ThisLimited

Warrantyshallbeinvalidatedbyanyabuse,misuse,misapplicationorimproperinstallationoftheProducts.The

staffattheCompanyisavailabletoansweranyquestionsregardingtheproperinstallationorapplicationofthe

Productatthistoll-freephonenumber:800-276-249(USA/International)or888-208-8927(Canada).Ifyouare

everindoubtaboutthecorrectinstallationproceduretofollow,oriftheProductappearstobedamaged,youmust

callusbeforeproceedingwiththeinstallationorproposedrepair.

WATTSRADIANTDISCLAIMSANYWARRANTYNOTPROVIDEDHEREIN,INCLUDINGANYIMPLIEDWARRANTY

OFMERCHANTABILITYORIMPLIEDWARRANTYOFFITNESSFORAPARTICULARPURPOSE.WATTS

RADIANTFURTHERDISCLAIMSANYRESPONSIBILITYFORSPECIAL,INDIRECT,SECONDARY,INCIDENTAL,

ORCONSEQUENTIALDAMAGESARISINGFROMOWNERSHIPORUSEOFTHISPRODUCT,INCLUDING

INCONVENIENCEORLOSSOFUSE.THEREARENOWARRANTIESWHICHEXTENDBEYONDTHEFACEOF

THISDOCUMENT.NOAGENTORREPRESENTATIVEOFWATTSRADIANTHASANYAUTHORITYTOEXTEND

ORMODIFYTHISWARRANTYUNLESSSUCHEXTENSIONORMODIFICATIONISMADEINWRITINGBYA

CORPORATEOFFICER.

Somestates/provincesdonotallowtheexclusionorlimitationofincidentalorconsequentialdamagesandsome

states/provincesdonotallowlimitationsonhowlongimpliedwarrantiesmaylast.Therefore,theabovelimitations

orexclusionsmaynotapplytoyou.Thiswarrantygivesyouspecificlegalrightsandyoumayalsohaveother

rights,whichvaryfromstatetostateorprovincetoprovince.SOFARASISCONSISTENTWITHAPPLICABLE

STATE/PROVINCIALLAW,ANYIMPLIEDWARRANTIESTHATMAYNOTBEDISCLAIMED,INCLUDINGIMPLIED

WARRANTIESOFMERCHANTABILITYORFITNESSFORAPARTICULARPURPOSEARELIMITEDINDURATION

TOONEYEARFROMTHEDATEOFMANUFACTURE.

Effective: May,203.ThiswarrantyappliestoallProductspurchasedafterthisdate.

SunTouch ProMelt Outdoor Sensor 070 Installation guide

Brand: SunTouch

Model: ProMelt Outdoor Sensor 070

Type: Installation guide

This manual is also suitable for

070
300070

Download PDF

report

SunTouch ProMelt Outdoor Sensor 070 Installation guide

This manual is also suitable for

SunTouch ProMelt Outdoor Sensor 070 Installation guide

Related papers

Other documents