Stenner Chlorinator 45MHP2 Installation guide

Brand: Stenner

Model: Chlorinator 45MHP2

Type: Installation guide

This manual is also suitable for





CleanWaterMadeEasy

www.cleanwaterstore.com



StennerPumpChlorinator

Installation&Start‐UpGuide



ThankyouforpurchasingaCleanWaterSystem!Withproperinstallationandalittleroutinemaintenanceyour

systemwillbeprovidingtreatedwaterformanyyears.

YournewsystemcomeswithaprintedStennerinstallationmanual,whichalongwiththisstart‐upguidewill

helpguideyouintheinstallationandstart‐upofyournewsystem.Pleasereviewthisstart‐upguideandthe

Stennerinstallationmanualentirelybeforebeginningtoinstallyoursystemandfollowthestepsoutlinedfor

bestresults.



CHLORINEBLEACHCANDAMAGECLOTHINGANDIRRITATESKINANDEYES.

USERUBBERGLOVESANDEYEPROTECTIONWHENHANDLING.



WARNING:Riskofelectricalshock.ReadStennerInstallationManualbeforeinstalling.Thepumpissuppliedwithagroundingconductor

andgroundingtypeofattachedplug.Toreduceriskofelectricalshock,becertainthatitisconnectedtoaproperlygroundedgrounding‐

typeelectricalreceptacle.

Thispumpisintendedforindooruse.SuitableforoutdoorusewheninstalledwithaStennerrainroof.



Questions?

Callustoll‐free:1‐888‐600‐5426or1‐831‐462‐8500

Emailus:[email protected]

Seemoreinformationonourwebsite:www.cleanwaterstore.com/resources







CleanWaterMadeEasy

www.cleanwaterstore.com



TableofContents



Pre‐Installation......................................................................................................................................................3

BestPracticesforInstallation................................................................................................................................3

HowYourChlorinatorWorks................................................................................................................................3

Fig1...............................................................................................................................................................4

Figure2..........................................................................................................................................................5

InstallationInstructions.........................................................................................................................................6

RECOMMENDEDINSTALLATIONSETUP...............................................................................................................7

HowToSelecttheChlorineSolutionStrengthandPumpSetting........................................................................8

StepThree.........................................................................................................................................................9

NOTE............................................................................................................................................................10

Maintenance...............................................................................................................................................10

Winterizing..................................................................................................................................................10



StennerPumpChlorinatorInstallation&StartupGuide

Page3www.cleanwaterstore.comRev082912

PreInstallation

1. Reviewyourpackinglistandmakesureyouhavereceivedallthepartsbeforebeginninginstallation.

2. Ifyouaregoingtobeturningoffthewatertothehouseandyouhaveanelectricwaterheater,shutoff

thepowertothewaterheaterbeforebeginninginstallationincasewaterheaterisaccidentially

drained.

3. Pickasuitablelocationforyourchlorinationsystemonadrylevelspotwhereitwon’tbeexposedto

freezingtemperatures.Maximumlinepressureis100PSI.

4. Getallofyourplumbingpartstogetherbeforebeginninginstallation.Installationtypicallytakes1to5

hours.

5. Afterthesystemisinstalledandrunning,yourwatermaybediscolored,orfullofsedimentorrust,

particularlyifyouhaveolderorcorrodedpiping.



BestPracticesforInstallation

1. Seetypicalinstallationforwellwater.(seeFig1).

2. MakesurethattheStennerpumpturnsonandoffwiththewellpump,orifyouareusingaflowswitch,

plugintotheflowswitchsotheStennerpumpisactivatedbasedonwaterflow.

3. DonotcutthecordontheStennerpumpfordirectwiringtothepressureswitch.Itisbettertoinstalla

dedicatedwallreceptablethatiswiredtopoweronandoffwiththewellpump,unlessyouareusinga

flowswitch.



HowYourChlorinatorWorks

SeeFig2.Thewellpumpiscontrolledbythepressureswitch.AdedicatedoutletfortheStennerpumpis

installedandwiredsoitisenergizedwhenthewellpumpisenergized.Whenthewaterpressureinthepressure

tankdropsbelowthecut‐inpointonthepressureswitch,thewellpumpandmeteringpumpturnon.Aswater

ispumpedthroughthesystem,asmallamountofchlorineispumpedintothewaterbythechlorinemetering

pump.



StennerPumpChlorinatorInstallation&StartupGuide

Page4www.cleanwaterstore.comRev082912

Fig1:Typicalinstallationwithcontacttankandcarbonbackwashorironfilter.NOTE–Stennerpumpmustbewiredsoit

isswithesonandoffwithwellpumpbywiringtosamecircuitaswellpressureswitch.AlternativelyaFlowSwitchcanbe

used.TheStennerpumpcannotjustbepluggedintoawallandlefttorunfor24hoursaday.







StennerPumpChlorinatorInstallation&StartupGuide

Page5www.cleanwaterstore.comRev082912

Figure2:Typicalwiring220vStennerpumponsamecircuitaswellpump.RunwiresfromT1andT2(load

sideofpressureswitch)todedicatedwalloutlet,andplugStennerpumpintooutletsoStennerpumponly

runswhenwellpumpisenergized.



StennerPumpChlorinatorInstallation&StartupGuide

Page6www.cleanwaterstore.comRev082912

InstallationInstructions‐

TypicallytheStennerpumpiswallmounted,facingdown.AsoutlinedintheStennerinstallationmanual,the

OptionalSpillRecoveryisrecommended,whereyoupunchoutoneoftheindentedholesattheendofpump

assemblyandinsertalengthof¼”tubing(includedwithpump)sothatiftheStennerpumptubefails,the

chlorinesolutionwilldrainbackintothesolutiontankinsteadofleakingontothefloor.

Asthewaterflowsintothecontacttank,thechlorineisthoroughlymixedinthewater,allowingcontacttimeto

killanybacteriaandoxidizeiron,manganeseorhydrogensulfidegas.Precipitatedoxidizedparticlesofiron,

sulfidesandmanganesearefilteredoutofthewaterbythegreensandplusfiltersystem.

AdjusttheStennerpumpandthesolutionstrengthsothereisafree‐chlorineresidualof0.2to1.0ppmafter

thecontacttankbeforefiltration.

Regardingoptionalvacuumbreaker:thecontacttankcanwithstandalinepressureof75PSI,butcannottake

anyvacuum.Ifthecontacttankisdrainedorifthewellsystemlosespressure,andwateraccidentallydrains

backdownthewell,orisdrainedaftercontacttankandahosebiborfaucetisnotopenedtoallowairintothe

tank,avacuummayoccurinsidethetank.Thiswillcausecontacttankfailure,soasmall1/2"or3/4"vacuum

breakerisrecommendedtopreventthisrareoccurence.

Followalllocalplumbingandelectricalcodes.

FollowinstructionsintheStennerClassicSeriesInstallationandMaintenanceManualIfyouneedacopyofthe

manualyoucandownloaditfromtheStennersite:

http://www.stenner.com/support.htm



StennerPumpChlorinatorInstallation&StartupGuide

Page7www.cleanwaterstore.comRev082912

RECOMMENDEDINSTALLATIONSETUP



AccessoryKitincludedwitheachStennerpump:

3connectingnuts¼”or3/8”;3ferrules;1injectioncheckvalve100PSI;1weightedsuctionlinestrainer;120”rollof

suction/dischargetubing;1sparepumptube;1mountingbracket;1Stennermanual



NOTE–donotplugStennerpumpintoa

standardwalloutlet.Theoutletmustbe

wiredsoitswitchesonandoffwiththe

wellpump,ORaflowswitchcanbeused

sotheStennerpumpswitchesonandoff

basedonflowofwater.

StennerPumpChlorinatorInstallation&StartupGuide

Page8www.cleanwaterstore.comRev082912

HowToSelecttheChlorineSolutionStrengthandPumpSetting

Thegoalofaproperlyfunctioningchlorineinjectionsystemistohaveafree‐chlorineresidualof0.2to1.0

ppmaftersufficientcontacttime,beforeanycarbonfiltersystem.Orifnocarbonfilterorotherde‐

chlorinationisused,tohaveafree‐chlorineresidualof0.2to1.0ppmattheendofthedistributionsystem

orfurthestpointintheplumbing.

ThiscanbeaccomplishedbyadjustingthechlorinebleachsolutionstrengthandsettingtheStennerFeed

RateControlDialuntilyouachievethedesiredresidual.



Indeterminingyourmeteringpumpssettingsandsolutionstrength,keepinmindthatitsbesttomakeup

freshsolutiononceevery1to3months.Thechlorinesolutionlosesstrengthasitages,andissensitiveto

heatandlight.Generally,keepsolutiontankoutofthesunandusefreshsolutionregularlyforbestresults.



StepOne:Determineflowrateofthewaterstreamyouareinjectinginto,inGallonsPerMinute(GPM)

1.Openanyhosebiborfaucetuntilpumpturnson.

2.Closehosebiborfaucetandletpumpfilluppressuretankuntilitturnsoff.

3.Usinga1or5gal.bucket,openfaucet,collectandmeasureallwaterdischargeduntilpumpturnson.

4.Whenpumpturnson,immediatelyclosefaucetandstarttimingpumpcycle.

5.Whenpumpturnsoff,recordpumpcycletimetorefillpressuretankinseconds.

6.DividethenumberofgallonscollectedinStep3bythenumberofsecondsinStep5.

7.MultiplytheanswerfromStep6by60.

8.TheanswerinStep7istheaveragepumpingcapacityofthepumpingallonsperminute(GPM).



StepTwo:HowMuchChlorineShouldBeInjected?Determinethepartspermillionofchlorineyouare

tryingtoachieveinpartspermillion(PPM).



Chlorineisinjectedinpartspermillion('ppm')whichisthesameassayingmilligramsperliter('mg/L').The

amountofchlorinetoadddependsonthe“chlorinedemand”ofthewater.Chlorinedemandistheamount

ofvariouscontaminantsinthewaterthatcombinewiththechlorineafterthechlorinehasbeeninjectedand

sufficientcontacttimehasoccurred.Afterthechlorinehascombinedwiththevarioussubstancessuchas

bacteria,iron,manganeseandodor,somelevelofuncombinedor“free”chlorinewillexist.Thegoalisto

havesomesmallamountoffree‐chlorine,usuallyaround0.2to0.4ppmoffree‐chlorine,uptoamaximumof

1.0ppmoffree‐chlorine.

Forbacteriayouwanttoinject1–2ppmofchlorinewithapproximately10minutesofcontacttime.Ifthe

wateriscolderthan50F(10C)and/orthepHishigherthan7.5youmayneedlongercontacttimeorahigher

residual.

StennerPumpChlorinatorInstallation&StartupGuide

Page9www.cleanwaterstore.comRev082912

Foreachpartpermillionofironormanganesegenerallyyouwanttoinject1ppmofchlorine.Foreach1.0

ppmofhydrogensulfidegas(whichcausestherotteneggsmellinwater)youwanttoinject2to3ppmof

chlorine.Sosayyouhavebacteriaand2.0ppmofiron.Forourexamplehere,wewillassumeyouwantto

inject3ppmofchlorine.

StepThree:Determinewhatsolutionstrengthofbleachtouse



Householdbleachisapproximately5%chlorine;poolchlorineis10to12%.5%isthesameassaying50,000

partspermillion(PPM)and10%isthesameassaying100,000PPM.

Regardingthesolutionstrength:Ifyoudilutethebleachbyusing1gallonsofpurewaterto1gallonof

householdbleach,youendupwithsolutionstrengthofapproximately2.5%or25,000ppm.Inotherwords,

householdbleachhasasolutionstrengthof50,000ppm,andifyoudiluteitwith1gallonofwater,youend

upwithsolutionstrengthof25,000ppm.

Regardingsettingtheoutputofthemeteringpump:Youcanvarytheapplieddosageofchlorinebyadjusting

thechlorinebleachsolutionstrengthandsettingtheStennerFeedRateControlDialuntilyouachievethe

desiredresidual.

Afteryouusetheformulabelowtocomputethegallonsperdayadjustthepumptoendupwiththedesired

applieddosage.Theformulaissimple,youonlyhaveto:

MultiplytheFlowRate(ingallonsperminute)timestheAppliedDosageinPartsPerMillionDesiredtimes

1440.ThendividebytheSolutionStrengthinPPMthatisbeingused.



Example:Assumethatyouhaveawellpumpthathasaflowrateof12gallonsperminute(12GPM)and

thatyouwanttoinject3.0ppmofchlorineintothewater.Youhavedecidedtouseasolutionstrengthof

25,000ppmor1gallonof5%bleachtoonegallonofpurifiedoratleastsoftenedwater.Thereare1440

minutesin24hourperiod,andtheformulawilltellyouhowmanygallonsofchlorineyouwilluseforevery

24hoursthewellpumpruns.

Theformulais:12GPMx3.0PPMx1440andthendividedby25,000=2.07GallonsPerDay

Thismeansthatyouneedameteringpumpthathasanoutputof2.0gallonsperday.Youcanusethe

Stenner45MHP2,whichhasamaximumoutputof3gallonsperday,andsetthepumpatthe66%level,since

2is66%of3,themaximumoutputofthepump.Theoreticallythiswillgiveyouanappliedchlorinedoseof

3.0ppm,andyoucanadjustitlateronceyoudetermineyouractualfree‐chlorineresidual.TheStennerpump

hasaFeedRateControlDialwithnumbersfrom1to10.Ifyousetthepumpat6orbetween6and7,youwill

havethedesiredadjustmentof66%.



Yourwellpumpmightrunfor1houraday,soatthisrateyouwoulduse2.0gallonsofyourchlorinebleach

solutionevery24hoursthepumpruns.Itisbettertoaddmoresolutioneveryonetotwomonthsasthe

solutioncanloseitspotencyovertime.



Whateveryourinitialsettingbesuretotestfortotalandfree‐chlorineandthenadjustthepumpand/orthe

solutionstrengthtoachieveyourdesiredfree‐chlorineresidualinyourpiping.

StennerPumpChlorinatorInstallation&StartupGuide

Page10www.cleanwaterstore.comRev082912

NOTE:ifyoufindyoudoneedtodilutethebleach,useonlydistilledwater,

waterfromareverseosmosissystem,oratleastsoftenedwater.Donotuse

untreatedwellwater.



Maintenance:Checkfree‐chlorineresidualatleastoncepermonthandadjust

Stennerpumpand/orsolutionstrengthifneeded.SeetheStennermanual

forroutinemaintenance.Changethepumptubeevery1–3years.



Winterizing:donotlettheStennerpumportubingfreeze.Ifyouneedto

winterize,drainthechlorinesolutiontankanddiscardchlorinesolution.

Placethesuctionofthepumpintoabucketofcleanwaterandallowthe

pumptorununtiltheStennerpumpisfreeofanychlorinesolution.

Removethesuctionfromthewater,andallowthepumptopumpdry.

Pumpisreadytostore.



Stenner Chlorinator 45MHP2 Installation guide

Brand: Stenner

Model: Chlorinator 45MHP2

Type: Installation guide

This manual is also suitable for

Download PDF

report

Stenner Chlorinator 45MHP2 Installation guide

This manual is also suitable for

Stenner Chlorinator 45MHP2 Installation guide

Related papers

Other documents