saunalife E8G User manual

Ergo-Series E8G Barrel Sauna

Full Glass Front 87D" x 81H"

Note: Please read manual before construction Rev 4/2023

Front & Back Walls

Details list.

63"x8⅞"x3¾"

1

51³/₁₆"•63"•78ｾ"x1⅝"

A

2

(x1)

3

X

Z

W

Y

x2 drain set

6

6a

6b

E

C

F

G

L=~9⅞"

B

B1

L=~256"

D

10

11

18½"x1¾"x1¾"

10a

³/₁₆"x3½"

(x50)

H

⁵/₃₂" x 2¼"

I

³/₁₆"x2"

J

⅛" x 1½"

(x150)

(x45)

(x90)

K

⅛" x 1¼

(x15)

~2lbs.

L

M

5⅞"x1¾"x1¾"

10c

(x2)

15b

3¹⁵/₃₂"x1⅝"1⅛"

15a

15c

15d

20

20c

20d

20a

20b

22

32¹¹/₁₆x3¹⁵/₃₂"x1⅛"

O

N

(x38/50/62)

(x5/7/8)

L=~17³/₁₆

25

Torx bits

T10 T15

T20 T25

6c

6d

Bit PH2

59¹/₁₆"•70⅞"•86⅝"x4²³/₃₂"x1⅝"

(x2)

59¹/₁₆"•70⅞"•86⅝"x1⅝"

59¹/₁₆"•70⅞"•86⅝"x1¾"x1⅝"

59¹/₁₆"•70⅞"•86⅝"x1"x1⅝"

59¹/₁₆"•70⅞"•86⅝"x1³/₁₆"x1⅝"

59¹/₁₆"•70⅞"•86⅝"x3/4"x1⅝"

59¹/₁₆"•70⅞"•86⅝"x3/8"x1⅝"

51³/₁₆"•63"•78¾"x20¹¹/₁₆"x3¹⁵/₁₆"

50"•61¹³/₁₆"•77⁹/₁₆"x15³/₁₆"x3⁹/₁₆"

(x1)

(x2)

(x1)

(x2)

25¹⁹/₃₂x3¹⁵/₃₂"x1⅛"

27⁹/₁₆x1⅝"x1⅛"

(x2)

(x4)

(x1)

(x3)

(x1)

(x2)

(x16)

(x2)

(x1)

(x2)

(x4)

59¹/₁₆"•70⅞"•86⅝"x2"x2"

E8G Barrel Sauna 87D" x 81H"

Tools needed

Circular saw

Measuring tape

Marker pen

Water level

Drill

Cresent wrench

Utility knife

Rubber mallet

Extra hands

Ratchet strap

Hammer

Silicone gun

(Only glass-wall models)

Front glass wall installation

I

DET 1

DET 2

3x DET 3a

3x DET 3b

Top

Bottom

2x DET 4a

2x DET 4b

Use scrap piece of wood

to protect plywood

Apply waterproof

silicone to the groove

II

~5 ⁵/₁₆"

~3 ⁵/₁₆"

1

2

3a

3b

4b

4a

x1

x3

x2

Thickness 1 ¹/₁₆"

x2

1

Thickness ⅝"

2

x2

3

x2

4

x2

5

x2

Baseframe 1 ¹/₁₆"

1.

TL1

76" x 3¾" x 1⅛"

U

x1

Silicone

10a

10c

x2

18½"x1¾"x1¾"

5⅞"x1¾"x1¾"

Mount carefully

glasses.

~⁵/₆₄"

I

II

2x DET 1

2x DET 2

2x DET 3

2x DET 5

2x DET 4

Top

Bottom

Use scrap piece of wood to

protect plywood

III

Coverframe ¹⁹/₃₂"

2.

Front glass wall installation

I

~²⁹/₃₂"

II

40x J

min.²⁵/₃₂"

CAUTION!

Do not hit the glass

with the screw.

III

Apply waterproof

silicone to the groove

3.

IV

Install front glass-wall same way

as instructed in main manual.

Front glass wall installation

4.

I

2x I

DET U

Fix it diagonally to make wall

more rigid during the installation.

Proceed with main manual

until benches installation!

2x DET 10

Drill holes ⅛"

before screws.

4x DET 10a

4x H

II

III

10x I

Pre-drill holes ⅛"

Under the benches both sides.

4x H

4x DET 10c

8x H

Fasten screws under the

benches on both sides

2x I

CAUTION! Do not hit

the glass with the screw.

Front glass wall installation

WARNING: Do not

let screws touch glass!

Pre-drill holes ⅛"

Install front glass-wall same way

as instructed in main manual.

Wooden back wall assembly

4x I

DET U

2x H

Pre-drill holes 5/32"

before screws.

II

III

Brackets

inside.

U

x1

TL1

76" x 3¾" x 1⅛"

Details

DET 1

2xDET A

DET 1

4x M

63"

51³/₁₆"•63"•78¾"

Diagonal measurements should be equal

1.

E8G Barrel Sauna 87D" x 81H"

2.

2x M

X

Z

W

Y

mm=mm

3a

DET 2

Position

cradles inside

grooves of

stave 2

I

II

2

3

8x DET 3

Center stave 2 on

cradle 1

E8G Barrel Sauna 87D" x 81H"

3.

16x M

I

II

E8G Barrel Sauna 87D" x 81H"

4.

I

Drill 4 holes Ø1/2"

through DET 2

outside

90°

6x H

Use waterlevel

II

3xDET 3

Fix temporarily to

support walls.

~1/4"

4x H

IMPORTANT! Be sure to leave a

1/4”gap when tightening screws to

leave room for adjustment when

the outer bands (B) are installed.

Check walls installation

manual on extra pages!

Sauna wall configuration

depends on Your model!

Brackets inside

E8G Barrel Sauna 87D" x 81H"

5.

I

III

DET 3

H

~1/4

Important!

Leave space

H

Remove

temporary

bracing

DET 3

See the next page.

II

Use strap to support

boards during installation

Strap

IMPORTANT! Be sure to leave a 1/4”

gap when tightening screws to leave

room for adjustment when the outer

bands (B) are installed.

E8G Barrel Sauna 87D" x 81H"

6.

A

3

DET 6

4

If needed, trim the flat edge of the

board to create the desired width.

Fasten the two halves using screws

I

Raise slightly before installing

the combined board

II

III

Join two boards together (as shown in

diagram II) that will bridge the width of

the "A" gap. It is recommended that

the combined boards are approximately

1/4" wider than the gap.

6

6a

6b

6c

6d

E8G Barrel Sauna 87D" x 81H"

7.

I

Remove

strap

C

E

D

~9⁷/₁₆"

DET B1

~5⅞"

DET B

DET B1

DET B

2x DET B

Place the bands around

the barrel on the outer

side of the cradle.

II

III

E8G Barrel Sauna 87D" x 81H"

8.

I

Remove all

temporary braces

3x DET F

1x DET G

Upper vent

Lower vent

6x K

2x DET 10

2x DET 10a

II

2x H

Pre-drill holes Ø5/32"

before screws.

III

72" and 88" Saunas

with front-glass wall

have 4 pc. of DET 10a.

NB! If Your sauna equipped with front-glass

wall, see front-glass wall installation manual

for proper benches installation.

E8G Barrel Sauna 87D" x 81H"

9.

I

10x I

2x H

Pre-drill holes 1/8"

Use level for

installation of benches

2x DET 10c

II

Under the benches

4x H

2x DET 11

6x M

III

72" & 88" Saunas with

front-glass walls have

four pieces of 10c.

E8G Barrel Sauna 87D" x 81H"

10.

I

2x DET 15a

2x DET 15b

2x H

If needed - To accommodate

the size of your heater, trim

15A on the end that meets

the back wall, before adding

part H

2x DET 15c

2x J

6x I

II

1x DET 15d

Mount sauna heater before

installing safety rail, per

manufacturer's recommended

safety clearance

2x J

E7G Barrel Sauna 71D" x 81H"

X

11.

I

18x H

1x DET 20

2x DET 20c

2x DET 20d

2x M

X

Use waterlevel!

II

Fasten door from inside.

III

16x J

2x DET 20a

2x DET 20b

8x H

Ensure door frame is pressed

tightly against the wall and

fasten from inside

2x DET 22

8x H

~39⅜"

IV

E8G Barrel Sauna 87D" x 81H"

X= Front wall thickness

Wooden front wall 1⅛"

Glass front wall 1⅝"

Page is loading ...

saunalife E8G User manual

saunalife E8G User manual

Related papers

Other documents