VIAIR 30034 User manual

VIAIR
Brand
VIAIR
Model
30034
Type
User manual

VIAIR 30034 is a portable air compressor designed for inflating tires and other inflatables. It features a powerful 12-volt motor with a maximum intermittent pressure of 150 PSI and a 33% duty cycle at 100 PSI. It also has an automatic reset thermal protector to prevent overheating and a 2-inch inline pressure gauge for accurate monitoring of tire pressure. Additionally, it comes with a ¼” quick connect stud and an extension coil hose with a ¼” quick coupler for easy attachment to tires.

VIAIR 30034 is a portable air compressor designed for inflating tires and other inflatables. It features a powerful 12-volt motor with a maximum intermittent pressure of 150 PSI and a 33% duty cycle at 100 PSI. It also has an automatic reset thermal protector to prevent overheating and a 2-inch inline pressure gauge for accurate monitoring of tire pressure. Additionally, it comes with a ¼” quick connect stud and an extension coil hose with a ¼” quick coupler for easy attachment to tires.


  
300P-RVS PORBLE COMPRESSOR
POWER SPORT SERIES
 






IMPORTANT SAFETY INSTRUCTIONS:
CAUTION: To reduce risk of electrical shock or electrocution:
- Donotdisassemble.Donotattemptrepairsormodications.
Refertoqualiedserviceagenciesforallserviceandrepairs.
- Do not use this product in an area where it can fall or be pulled into water or other liquids.
- Do not reach for this product if it has fallen into liquid.
- Usethiscompressorwith12-voltDCsystemsonly.
- Thisproductshouldneverbeleftunattendedduringuse.
WARNING:Topreventinjury:
- Neverallowchildrentooperatethiscompressor.
Closesupervisionisnecessarywhenthiscompressorisbeingusednearchildren.
- ThiscompressorwillbecomeveryHOTduringandimmediatelyafteruse.
Donottouchanypartofthiscompressorwithbarehands,otherthantheON/OFFswitch
duringandimmediatelyafteruse.
- Donotusethisproductnearamesorexplosivematerialsorwhereaerosolproducts
arebeingused.
- Donotoperatethisproductwhereoxygenisbeingadministered.
- Donotpumpanythingotherthanatmosphericair.
- Neverusethisproductwhilesleepyordrowsy.
- Donotuseanytoolsorattachmentswithoutrstdeterminingmaximumairpressureforthat
tool or attachment.
- Neverpointanyairnozzleorairsprayertowardanotherpersonoranypartofthebody.
- ThisaircompressorisequippedwithanAutomaticResetThermalProtector,andcan
automaticallyrestartafterthethermalprotectorresets.Alwayscutopowersourcewhen
thermalprotectorbecomesactivated.
- Wearsafetyglassesorgoggleswhenoperatingthisproduct.
- Useonlyinwellventilatedareas.
OPERATING INSTRUCTIONS:
Pleasereadandfollowtheoperatinginstructionscarefullytoassurethatyouwillenjoythe
convenienceandbestuseoutofyouraircompressor.
1. AlwaysoperatethecompressorATORBELOWTHEMAXIMUMPRESSURERATINGofthe
compressor.RefertoSpecicationssectionofthismanual.
2. AlwaysOBSERVETHEMAXIMUMDUTYCYCLEoftheaircompressor.RefertoSpecications
sectionofthismanualfordetails.Operationsexceedingmaximumpressureratingsandorduty
cyclewillresultindamagetoaircompressor.
3. YouraircompressorisequippedwithanAUTOMATICTHERMALOVERLOADPROTECTOR.
Thisfeatureisdesignedtoprotecttheaircompressorfromoverheatingcausingpermanent
damagetoyouraircompressor.Thethermaloverloadprotectorwillautomaticallycutopower
toaircompressorshouldinternaloperatingtemperatureoftheaircompressorriseabovesafe
levelsduringexcessiveuse.
4. Shouldatanytimeduringuse,youraircompressorautomaticallyshutso,donotattemptto
restartaircompressor.TurnON/OFFswitchofaircompressortotheOFFposition.Theautomatic
thermaloverloadprotectorwillautomaticallyresetwheninternaltemperatureoftheair
compressordropsbelowsafelevel.Afterallowingaircompressortocooloforabout30minutes,
youcansafelyresumeuseoftheaircompressorbyturningontheaircompressor.
5. Pleasenotethatyoumayexperienceaslightdelay(about½second)ofthecompressor’smotor
startingwhentheON/OFFSwitchisturnedonwhilecompressorispressurized(whenthereis
pressureinthelinethatthecompressorisconnectedto).Thisisanormaldelayedreaction,nota
CompressorON/OFFswitchmalfunction.
6. Itisstronglyrecommendedthatyoukeepthevehicle’senginerunningwhileusingtheair
compressortopreventdischargeofyourvehicle’sbattery.
7. ONLYOPERATETHEAIRCOMPRESSORINWELLVENTILATEDAREAS.
Compressorperformanceisenhancedwhenoperatingcompressorwithvehicleenginerunning.
USER MANUAL
300P-RVS PORTABLE COMPRESSOR
300P-RVS PORTABLE COMPRESSOR
OPERATING INSTRUCTIONS (cont’d):
IMPORTANT:Enginemustberunningwhileusingthiscompressor.
Beforeattachingaircompressor’spowercordtopowersource,checktomakesurethatthe
ON/OFFswitchofyourcompressorisintheOFFposition.AttachthePositivebatteryclamp(Red)
tothePositiveterminalofthebatteryandtheNegativebatteryclamp(Black)totheNegativeterminal
ofthebattery.
CAUTION:YourPortableAirCompressorisMoistureandDustResistant,butNOTWATERORDUST
PROOF.Neverplacecompressorinsoftsandwhilerunningthecompressor.Vibrationfromthe
compressorwillcausethecompressortosettleintosoftsand,resultingincompressordrawingin
foreignparticles.Neverexposecompressortowaterwhilerunningthecompressor.
This air compressor comes with ¼” quick connect stud. Your Inline Deator comes with
extension coil hose with ¼” quick coupler. Simply attach this multifunction extension coil hose
to the ¼” quick connect stud and you are ready to inate tires. The Inline Inator/Deator
Hose can be used for both Airing Up and Airing Down. Please familiarize yourself with the
following dierent functions of this versatile air tool:
TIRE INFLATION:
1. Attach quick connect coupler to air compressor.
2. Pushthetirechuck,withtheleverintheuprightposition,downoverthetirevalvestemandthen
pushtheleverdowntothehorizontalpositiontolockinplace.
3. ChecktomakesuretheDeatorCollarLockisdisengaged.
4. Turncompressorswitchontobeginination.
Whendesiredpressureisreached,turncompressoro.
CAUTION:Toavoidoverination,neverexceedrecommendedpressureonarticlestobeinated.
Burstingcancauseseriousinjury.
HANDS-FREE CONTINUOUS DEFLATION:
1. Pushthetirechuck,withtheleverintheuprightposition,downoverthetirevalvestemandthen
pushtheleverdowntothehorizontalpositiontolockinplace.
2. PushDeatorCollartowardtirevalvestemandturnDeatorCollarclockwisetoengagelock.
3. Whendesiredpressureisreached,turnDeatorCollarcounterclockwisetodisengagelock.
IMPORTANT:Makesurecompressorsitsuprightwhileoperatingcompressor.Donotoperate
compressorinanyotherposition.Avoidtuggingatcompressortomoveit.Instead,move
compressortothesamesideofvehicleastiresthatarebeingairedup.
AlwaysmakesurethePortableCompressor’s8ft.powercordisuncoiledandfullyextended
whenusingyouraircompressortoavoidoverheatingthepowercord.
INTERMITTENT DEFLATION:
1. Theintermittentdeationfunctionoersfastdownwardpressureadjustments.
2. Withtirechuckattachedtotirevalvestem,pushDeatorCollartowardtirevalvestem
to decrease tire pressure.
3. ReleaseDeatorCollartohaltdeation.
INLINE PRESSURE GAUGE:
1. The2-inchInlinePressureGaugeprovidesconvenienttirepressuremonitoringwhenairingupor
down.Thiseliminatesswitchingbackandforthbetweenatirechuckandatirepressuregauge.
2. Pleasenotethatduringinationanddeation,duetoairvelocity,pressuregaugecannot
provideaccuratepressurereadings.Momentarilyhaltinationordeationtoobtainaccurate
pressurereadings.
USER MANUAL
SAFETY PRECAUTIONS:
1. Alwaysinatetirestomanufacturer’srecommendedtirepressures.Exerciseextremecaution
whendrivingwithaired-downtires.Reinatetiresbeforehigh-speedroadwaytravel.
2. Neverexceed20M.P.H.whendrivingwithpartiallyinatedtires.
3. Nevermakesharpturnswhiledrivingwithreducedtirepressure.
4. Re-inatetiresbeforehighspeedtravelingontoroadways.
5. Useheat-resistant,minimum200PSI-ratedworkingpressureextensionhose.
Donotuseaftermarkethoseswithlessthan200PSIworkingpressure.
Someaftermarkethosesmaynotbesuitableforusewiththisaircompressorduetoheatand
pressuretypicallygeneratedbythistypeofaircompressors.
6. Theuseofaclose-endedtirechuckwillcauseexcessivepressurebuildupiftirechuckisnot
attachedtotirevalvestemwhileaircompressorisinoperation.
IMPORTANT:AlwaysuseanOpen-Endedtirechucksuchasthetirechuckequippedonthe
Deator/InatorCoilHosefortireinationwhenusingacompressorwithoutanairtank.
CAUTION:TheextensionhoseandttingsconnectedextensionhosewillbecomeveryHOTduring
andafteruse.Ifnecessary,wearheatresistantglovestoremovehosefromthecompressorquick
connect stud.
MAINTENANCE & REPAIRS:
Youraircompressorisequippedwithpermanentlylubricated,maintenance-freemotor.Nevertry
tolubricatethecompressor.Regularlycleandustanddirtfromcompressorcoolingnsandmotor
housing. AllrepairsshouldbeperformedbyManufacturerorManufacturerauthorizedservice
agenciesonly.
MODEL 300P-RVS SPECIFICATIONS:
PartNumber: 30034/300P-RVS
MotorVoltage: 12-volt
MotorType: PermanentMagnetic
Max.IntermittentPressure: 150PSI
Max.DutyCycle(@72ºF): 33%@100PSI
ContinuousUse(@72ºF&30PSI): 30Minutes
Max.CurrentConsumption: 30Amps
Fuse: 40Amps
InlinePressureGauge: 150PSI
Auto.ResetThermalProtection: Yes
300P-RVS PORTABLE COMPRESSOR
LIMITED WARRANTY:
VIAIRCorporationwarrantsthisproduct,whenproperlyinstalledandundernormalconditionsofuse,tobefreefromdefectsin
workmanshipandmaterialsforaperiodofoneyearfromitsoriginaldateofpurchase.Toreceivewarrantyserviceorrepair,please
contactVIAIRCorporation.
Returnsshouldbemadewithinoneyearofthedateofpurchase,afteraReturnGoodsAuthorization(RGA)numberhasbeen
assignedbyVIAIRCorporation.ToobtainRGA,faxacopyofyourreceiptto(949)585-0188.Forcompletewarrantydetails,please
visit:www.viaircorp.com/warranty
PLEASE NOTE:
THISWARRANTYCOVERSPRODUCTDEFECTSONLY;ITDOESNOTCOVERINCIDENTALORCONSEQUENTIALDAMAGES
ASRESULTOFMISUSEORABUSE.
ThisManualisproprietarytoVIAIRCorporationandnoownershiprightsareherebytransferred.NopartoftheManualshallbe
used,reproduced,translated,converted,adapted,storedinaretrievalsystem,communicatedortransmittedbyanymeans,forany
commercialpurpose,includingwithoutlimitation,sale,resale,license,rentalorlease,withoutthepriorexpresswrittenconsentofVIAIR.
VIAIRdoesnotmakeanyrepresentations,warrantiesorguarantees,expressorimplied,astotheaccuracyorcompletenessofthe
Manual.UsersmustbeawarethatupdatesandamendmentswillbemadefromtimetotimetotheManual.Itistheuser’sresponsibility
todeterminewhethertherehavebeenanysuchupdatesoramendments.NeitherVIAIRnoranyofitsdirectors,ocers,employees
oragentsshallbeliableincontract,tortorinanyothermannerwhatsoevertoanypersonforanyloss,damage,injury,liability,costor
expenseofanynature,includingwithoutlimitationincidental,special,directorconsequentialdamagesarisingoutoforinconnection
withtheuseoftheManual.
15EDELMAN•IRVINE,CA92618
TEL:(949)585-0011
FAX:(949)585-0188
www.viaircorp.com
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4

VIAIR 30034 User manual

VIAIR
Brand
VIAIR
Model
30034
Type
User manual

VIAIR 30034 is a portable air compressor designed for inflating tires and other inflatables. It features a powerful 12-volt motor with a maximum intermittent pressure of 150 PSI and a 33% duty cycle at 100 PSI. It also has an automatic reset thermal protector to prevent overheating and a 2-inch inline pressure gauge for accurate monitoring of tire pressure. Additionally, it comes with a ¼” quick connect stud and an extension coil hose with a ¼” quick coupler for easy attachment to tires.

Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents