VIAIR 300p User manual

VIAIR
Brand
VIAIR
Model
300p
Category
Air compressors
Type
User manual
IMPORTANT:
It is essential that you and any other operator of this
product read and understand the contents of this manual
before installing and using this product.
SAVE THIS MANUAL FOR FUTURE REFERENCE
USER MANUAL
300P PORTABLE COMPRESSOR
POWER SPORT SERIES
PART NO. 30033
IMPORTANT SAFETY INSTRUCTIONS:
CAUTION: To reduce risk of electrical shock or electrocution:
- Donotdisassemble.Donotattemptrepairsormodications.
Refertoqualiedserviceagenciesforallserviceandrepairs.
- Do not use this product in or area where it can fall or be pulled into water or other liquids.
- Do not reach for this product if it has fallen into liquid.
- Usethiscompressorwith12-voltDCsystemsonly.
- Thisproductshouldneverbeleftunattendedduringuse.
WARNING:Topreventinjury:
- Neverallowchildrentooperatethiscompressor.
Closesupervisionisnecessarywhenthiscompressorisbeingusednearchildren.
- ThiscompressorwillbecomeveryHOTduringandimmediatelyafteruse.
Donottouchanypartofthiscompressorwithbarehands,otherthantheON/OFFswitch
during and immediately after use.
- Donotusethisproductnearamesorexplosivematerialsorwhereaerosolproducts
are being used.
- Donotoperatethisproductwhereoxygenisbeingadministered.
- Do not pump anything other than atmospheric air.
- Neverusethisproductwhilesleepyordrowsy.
- Donotuseanytoolsorattachmentswithoutrstdeterminingmaximumairpressureforthat
tool or attachment.
- Neverpointanyairnozzleorairsprayertowardanotherpersonoranypartofthebody.
- This air compressor is equipped with an Automatic Reset Thermal Protector, and can
automatically restart after the thermal protector resets. Always cut off power source when
thermalprotectorbecomesactivated.
- Wear safety glasses or goggles when operating this product.
- Useonlyinwellventilatedareas.
OPERATING INSTRUCTIONS:
Pleasereadandfollowtheoperatinginstructionscarefullytoassurethatyouwillenjoythe
convenienceandbestuseoutofyouraircompressor.
1.AlwaysoperatethecompressorATORBELOWTHEMAXIMUMPRESSURERATINGofthe
compressor.RefertoSpecicationssectionofthismanual.
2.AlwaysOBSERVETHEMAXIMUMDUTYCYCLEoftheaircompressor.RefertoSpecications
sectionofthismanualfordetails.Operationsexceedingmaximumpressureratingsandorduty
cycle will result in damage to air compressor.
3.YouraircompressorisequippedwithanAUTOMATICTHERMALOVERLOADPROTECTOR.
Thisfeatureisdesignedtoprotecttheaircompressorfromoverheatingcausingpermanent
damagetoyouraircompressor.Thethermaloverloadprotectorwillautomaticallycutoffpower
toaircompressorshouldinternaloperatingtemperatureoftheaircompressorriseabovesafe
levelsduringexcessiveuse.
4.Shouldatanytimeduringuse,youraircompressorautomaticallyshutsoff,donotattemptto
restartaircompressor.TurnON/OFFswitchofaircompressortotheOFFposition.Theautomatic
thermaloverloadprotectorwillautomaticallyresetwheninternaltemperatureoftheair
compressordropsbelowsafelevel.Afterallowingaircompressortocooloffforabout30minutes,
you can safely resume use of the air compressor by turning on the air compressor.
5.Pleasenotethatyoumayexperienceaslightdelay(about½second)ofthecompressor’smotor
startingwhentheON/OFFSwitchisturnedonwhilecompressorispressurized(whenthereis
pressureinthelinethatthecompressorisconnectedto).Thisisanormaldelayedreaction,nota
CompressorON/OFFswitchmalfunction.
6.Itisstronglyrecommendedthatyoukeepthevehicle’senginerunningwhileusingtheair
compressortopreventdischargeofyourvehicle’sbattery.
7.ONLYOPERATETHEAIRCOMPRESSORINWELLVENTILATEDAREAS.
Compressorperformanceisenhancedwhenoperatingcompressorwithvehicleenginerunning.
USER MANUAL
300P PORTABLE COMPRESSOR
300P PORTABLE COMPRESSOR
OPERATING INSTRUCTIONS (cont’d):
IMPORTANT:Enginemustberunningwhileusingthiscompressor.
Beforeattachingaircompressor’spowercordtopowersource,checktomakesurethatthe
ON/OFFswitchofyourcompressorisintheOFFposition.AttachthePositivebatteryclamp(Red)
tothePositiveterminalofthebatteryandtheNegativebatteryclamp(Black)totheNegativeterminal
of the battery.
CAUTION:YourPortableAirCompressorisMoistureandDustResistant,butNOTWATERORDUST
PROOF.Neverplacecompressorinsoftsandwhilerunningthecompressor.Vibrationfromthe
compressor will cause the compressor to settle into soft sand, resulting in compressor drawing in
foreignparticles.Neverexposecompressortowaterwhilerunningthecompressor.
This air compressor comes with ¼” quick connect stud. Your Inline Deator comes with
extension coil hose with ¼” quick coupler. Simply attach this multifunction extension coil hose
to the ¼” quick connect stud and you are ready to inate tires. The Inline Inator/Deator
Hose can be used for both Airing Up and Airing Down. Please familiarize yourself with the
following different functions of this versatile air tool:
TIRE INFLATION:
1. Attach quick connect coupler to air compressor.
2.Pushthetirechuck,withtheleverintheuprightposition,downoverthetirevalvestemandthen
pushtheleverdowntothehorizontalpositiontolockinplace.
3.ChecktomakesuretheDeatorCollarLockisdisengaged.
4.Turncompressorswitchontobeginination.
When desired pressure is reached, turn compressor off.
CAUTION:Toavoidoverination,neverexceedrecommendedpressureonarticlestobeinated.
Burstingcancauseseriousinjury.
HANDS-FREE CONTINUOUS DEFLATION:
1.Pushthetirechuck,withtheleverintheuprightposition,downoverthetirevalvestemandthen
pushtheleverdowntothehorizontalpositiontolockinplace.
2.PushDeatorCollartowardtirevalvestemandturnDeatorCollarclockwisetoengagelock.
3.Whendesiredpressureisreached,turnDeatorCollarcounterclockwisetodisengagelock.
IMPORTANT:Makesurecompressorsitsuprightwhileoperatingcompressor.Donotoperate
compressorinanyotherposition.Avoidtuggingatcompressortomoveit.Instead,move
compressortothesamesideofvehicleastiresthatarebeingairedup.
AlwaysmakesurethePortableCompressor’s8ft.powercordisuncoiledandfullyextended
whenusingyouraircompressortoavoidoverheatingthepowercord.
INTERMITTENT DEFLATION:
1.Theintermittentdeationfunctionoffersfastdownwardpressureadjustments.
2.Withtirechuckattachedtotirevalvestem,pushDeatorCollartowardtirevalvestem
to decrease tire pressure.
3.ReleaseDeatorCollartohaltdeation.
INLINE PRESSURE GAUGE:
1.The2-inchInlinePressureGaugeprovidesconvenienttirepressuremonitoringwhenairingupor
down. This eliminates switching back and forth between a tire chuck and a tire pressure gauge.
2.Pleasenotethatduringinationanddeation,duetoairvelocity,pressuregaugecannot
provideaccuratepressurereadings.Momentarilyhaltinationordeationtoobtainaccurate
pressure readings.
USER MANUAL
SAFETY PRECAUTIONS:
1.Alwaysinatetirestomanufacturer’srecommendedtirepressures.Exerciseextremecaution
whendrivingwithaired-downtires.Reinatetiresbeforehigh-speedroadwaytravel.
2.Neverexceed20M.P.H.whendrivingwithpartiallyinatedtires.
3.Nevermakesharpturnswhiledrivingwithreducedtirepressure.
4.Re-inatetiresbeforehighspeedtravelingontoroadways.
5.Useheat-resistant,minimum200PSI-ratedworkingpressureextensionhose.
Donotuseaftermarkethoseswithlessthan200PSIworkingpressure.
Someaftermarkethosesmaynotbesuitableforusewiththisaircompressorduetoheatand
pressure typically generated by this type of air compressors.
6.Theuseofaclose-endedtirechuckwillcauseexcessivepressurebuildupiftirechuckisnot
attachedtotirevalvestemwhileaircompressorisinoperation.
IMPORTANT:AlwaysuseanOpen-Endedtirechucksuchasthetirechuckequippedonthe
Deator/InatorCoilHosefortireinationwhenusingacompressorwithoutanairtank.
CAUTION:TheextensionhoseandttingsconnectedextensionhosewillbecomeveryHOTduring
andafteruse.Ifnecessary,wearheatresistantglovestoremovehosefromthecompressorquick
connect stud.
MAINTENANCE & REPAIRS:
Youraircompressorisequippedwithpermanentlylubricated,maintenance-freemotor.Nevertry
tolubricatethecompressor.Regularlycleandustanddirtfromcompressorcoolingnsandmotor
housing. AllrepairsshouldbeperformedbyManufacturerorManufacturerauthorizedservice
agencies only.
MODEL 300P SPECIFICATIONS:
PartNumber: 30033/300P
MotorVoltage: 12-volt
MotorType: PermanentMagnetic
Max.IntermittentPressure: 150PSI
Max.DutyCycle(@72ºF): 33%@100PSI
ContinuousUse(@72ºF&30PSI): 30Minutes
Max.CurrentConsumption: 30Amps
Fuse: 40Amps
InlinePressureGauge: 100PSI
Auto.ResetThermalProtection: Yes
300P PORTABLE COMPRESSOR
LIMITED WARRANTY:
VIAIRCorporationwarrantsthisproduct,whenproperlyinstalled
and under normal conditions of use, to be free from defects in
workmanship and materials for a period of one year from its
originaldateofpurchase.Toreceivewarrantyserviceorrepair,
pleasecontactVIAIRCorporation.
Returns should be made within one year of the date of purchase,
afteraReturnGoodsAuthorization(RGA)numberhasbeen
assignedbyVIAIRCorporation.ToobtainRGA,faxacopyof
yourreceiptto(949)585-0188.Forcompletewarrantydetails,
pleasevisit:www.viaircorp.com/warranty
PLEASE NOTE:THISWARRANTYCOVERSPRODUCTDEFECTS
ONLY;ITDOESNOTCOVERINCIDENTALORCONSEQUENTIAL
DAMAGESASRESULTOFMISUSEORABUSE.
15EDELMAN•IRVINE,CA92618
TEL:(949)585-0011
FAX:(949)585-0188
www.viaircorp.com
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4

VIAIR 300p User manual

VIAIR
Brand
VIAIR
Model
300p
Category
Air compressors
Type
User manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents