VIAIR 45053 User manual

Brand: VIAIR

Model: 45053

Category: Air compressors

Type: User manual

This manual is also suitable for

IMPORTANT SAFETY INSTRUCTIONS:

CAUTION: To reduce risk of electrical shock or electrocution:

- Donotdisassemble.Donotattemptrepairsormodications.

 Refertoqualiedserviceagenciesforallserviceandrepairs.

- Do not use this product in or area where it can fall or be pulled into water or other liquids.

- Do not reach for this product if it has fallen into liquid.

- Usethiscompressorwith12-voltDCsystemsonly.

- Thisproductshouldneverbeleftunattendedduringuse.

WARNING:Topreventinjury:

- Neverallowchildrentooperatethiscompressor.

 Closesupervisionisnecessarywhenthiscompressorisbeingusednearchildren.

- ThiscompressorwillbecomeveryHOTduringandimmediatelyafteruse.

 Donottouchanypartofthiscompressorwithbarehands,otherthantheON/OFFswitch

 duringandimmediatelyafteruse.

- Donotusethisproductnearamesorexplosivematerialsorwhereaerosolproducts

 arebeingused.

- Donotoperatethisproductwhereoxygenisbeingadministered.

- Donotpumpanythingotherthanatmosphericair.

- Neverusethisproductwhilesleepyordrowsy.

- Donotuseanytoolsorattachmentswithoutrstdeterminingmaximumairpressureforthat

tool or attachment.

- Neverpointanyairnozzleorairsprayertowardanotherpersonoranypartofthebody.

- ThisaircompressorisequippedwithanAutomaticResetThermalProtector,andcan 

 automaticallyrestartafterthethermalprotectorresets.Alwayscutopowersourcewhen

 thermalprotectorbecomesactivated.

- Wearsafetyglassesorgoggleswhenoperatingthisproduct.

- Useonlyinwellventilatedareas.

- Afterusage,alwaysreleaseexcesspressurefromthecoilhosebyturningOn/OswitchtotheO

 position,disconnecthosefromcompressor,withthetireinationgunstillconnectedtotheother

 endofthecoilhose,pulltriggeronthetireinationguntoreleaseexcesspressure.

USER MANUAL

450P-RV AUTOMATIC PORTABLE COMPRESSOR

OPERATING INSTRUCTIONS:

Pleasereadandfollowtheoperatinginstructionscarefullytoassurethatyouwillenjoythe

convenienceandbestuseoutofyouraircompressor.

1.AlwaysoperatethecompressorATORBELOWTHEMAXIMUMPRESSURERATINGofthe

 compressor.RefertoSpecicationssectionofthismanual.

2.AlwaysOBSERVETHEMAXIMUMDUTYCYCLEoftheaircompressor.RefertoSpecications

 sectionofthismanualfordetails.Operationsexceedingmaximumpressureratingsandorduty

 cyclewillresultindamagetoaircompressor.

3.YouraircompressorisequippedwithanAUTOMATICTHERMALOVERLOADPROTECTOR.

 Thisfeatureisdesignedtoprotecttheaircompressorfromover-heatingandcausingpermanent

 damagetoyouraircompressor.Thethermaloverloadprotectorwillautomaticallycutopower

 toaircompressorshouldinternaloperatingtemperatureoftheaircompressorriseabovesafe

 levelsduringexcessiveuse.

4.Shouldyourcompressorshutosuddenlyafterextendeduse,donotattempttorestartair

 compressor.TurnON/OFFswitchofaircompressortotheOFFposition.Theautomaticthermal

 overloadprotectorwillautomaticallyresetwheninternaltemperatureoftheaircompressordrops

 belowsafelevel.Afterallowingaircompressortocooloforabout30minutes,youcansafely

 resumeuseoftheaircompressorbyturningontheaircompressor.

5.Foryourconvenience,andtoprotecttheaircompressorfromover-pressureoperationthatcan

 causepermanentdamagetotheunit-thiscompressorisequippedwithbuilt-inpressureswitch

 withafactorysetcut-onpressureof130PSI(±5%)andafactorysetcut-opressureof

 155PSI(±5%).Duringinationoftirepressuresbetween130PSIto155PSI,ifyoustopination,

 thecompressormaynotrestart.Thisiscompletelynormal,sinceinlinepressureisgreaterthan

 cut-onpressureofthepressureswitchandlessthancut-opressureofthepressureswitch.

 Torestartcompressor,deatetirepressuretobelow130PSI,reconnecttirechucktotirevalve

 stemandresumetireination.

6.Pleasenotethatyoumayexperienceaslightdelayofthecompressor’smotorstartingwhenthe

 ON/OFFswitchisturnedonwhilecompressorispressurized(whenthereispressureintheline

 thatthecompressorisconnectedto).Thisisanormaldelayedreaction,notaCompressor

 ON/OFFswitchmalfunction.

7.Itisstronglyrecommendedthatyoukeepthevehicle’senginerunningwhileusingtheair

 compressortopreventdischargeofyourvehicle’sbattery.

8.ONLYOPERATETHEAIRCOMPRESSORINWELLVENTILATEDAREAS.

 Compressorperformanceisenhancedwhenoperatingcompressorwithvehicleenginerunning.

IMPORTANT:Enginemustberunningwhileusingthiscompressor.

Beforeattachingaircompressorpowerclampstoyourvehicle’sbatteryterminals,checktomake

surethattheON\/OFFswitchofyourcompressorisintheOFFposition.AttachthePositive(+)

batteryclamp(Red)tothePositiveterminalofthebatteryandtheNegative(-)batteryclamp(Black)

totheNegativeterminalofthebattery.Alwayskeepyourvehicle’senginerunningwhileoperating

compressortoavoiddrainingyourvehicle’sbattery.

CAUTION:YourPortableAirCompressorisMoistureandDustResistant,butNOTWATERORDUST

PROOF.Neverplacecompressorinsoftsandwhilerunningthecompressor.Vibrationfromthe

compressorwillcausethecompressortosettleintosoftsand,resultingincompressordrawingin

foreignparticles.Neverexposecompressortowaterwhilerunningthecompressor.

USER MANUAL

OPERATING INSTRUCTIONS (cont’d):

This air compressor comes with 1/4” quick connect stud. An extension coil hose and a tire

ination gun are also included with your compressor. Each end of the extension coil hose is

equipped with a 1/4” quick connect coupler. The tire ination gun comes with a 1/4” quick

connect stud, pressure gauge, rubber hose, bleeder valve and tire chuck. Attach one end of

the extension coil hose to the stud on your compressor and the other end to the stud on the

tire gun kit. The tire gun kit can be used for both airing up and airing down. Please familiarize

yourself with the following functions of this versatile air tool:

TIRE INFLATION:

1.Attachoneendoftheextensioncoilhosetothecompressorandtheotherendtothetiregunkit,

 45-degreeangledchuckor90-degreetwist-onchuck–dependingonneed.

2.Turncompressorswitchonandholddownthetriggeronthetiregunkittobeginination.

3.Whendesiredpressureisreached,releasethetrigger.Ifnishedwithuse,turnpowerswitchon

 compressoroposition.

NOTE:Toreleaseexcesspressure,turnocompressoranddisconnecthosefromcompressor.

Withthetireinationgunstillconnectedtotheotherendofthecoilhose,pulltriggeronthetire

inationguntoreleaseexcesspressure.

CAUTION:Toavoidoverination,neverexceedrecommendedpressureonarticlestobeinated.

Burstingcancauseseriousinjury.

NOTE:Youraircompressorisequippedwithapressureswitch(cutonat130PSI,cutoat

155PSI).Thisfeatureisdesignedtoprotecttheaircompressorfromover-pressurecausing

permanentdamagetoyouraircompressor.Thepressureswitchautomaticallyturnsothemotor

whentheinternalpressureoftheaircompressorreachesthefactoryset“cut-o”pressureof

155PSIandrestartswhentheinternalpressuredropsbelow130PSI.

TIRE DEFLATION:

1.Withtheinationoptionofyourchoicestillconnectedtothetireinationgun,pressthebleeder

valvebuttononthetiregunkittodecreasetirepressure,pressthebleedervalvebuttononthetire

gunkittodecreasetirepressure.

2.Pressthebleedervalvebuttononthetiregunkittodecreasetirepressure.

3.Whendesiredpressureisreached,releasethebleedervalvebuttontohaltdeation.

IMPORTANT:Makesurecompressorsitsuprightwhileoperatingcompressor.Donotoperate

compressorinanyotherposition.Avoidtuggingatcompressortomoveit.Instead,move

compressortothesamesideofvehicleastiresthatarebeingairedup.

AlwaysmakesurethePortableCompressor’spowercordisuncoiledandfullyextended

whenusingyouraircompressortoavoidoverheatingthepowercord.

INLINE PRESSURE GAUGE:

1.Thepressuregaugeontheinationgunprovidesconvenienttirepressuremonitoringwhenairing

 upordown(notairowofthecompressor).Thiseliminatesswitchingbackandforthbetweena

 tirechuckandatirepressuregauge.

2.Pleasenotethatduringinationanddeation,duetoairvelocity,pressuregaugecannotprovide

 accuratepressurereadings.Releaseleveronthetireinationgunduringinationtocheck

tire air pressure.

NOTE:Toreleaseexcesspressure,turnocompressoranddisconnecthosefromcompressor.

Withthetireinationgunstillconnectedtotheotherendofthecoilhose,pulltriggeronthetire

inationguntoreleaseexcesspressure.

450P-RV AUTOMATIC PORTABLE COMPRESSOR

USER MANUAL

SAFETY PRECAUTIONS:

1.Alwaysinatetirestomanufacturer’srecommendedtirepressures.Exerciseextremecaution

 whendrivingwithaired-downtires.Reinatetiresbeforehigh-speedroadwaytravel.

2.Neverexceed20M.P.H.whendrivingwithpartiallyinatedtires.

3.Nevermakesharpturnswhiledrivingwithreducedtirepressure.

4.Re-inatetiresbeforehighspeedtravelingontoroadways.

5.Useheat-resistant,minimum200PSI-ratedworkingpressureextensionhose.

 Donotuseaftermarkethoseswithlessthan200PSIworkingpressure.Someaftermarkethoses

 maynotbesuitableforusewiththisaircompressorduetoheatandpressuretypicallygenerated

 bythistypeofaircompressors.

CAUTION:Nevertouchtheaircompressororttingsconnectedtotheaircompressorotherthan

theON/OFFswitchwithbarehandsduringorimmediatelyafteruse.Theextensionhoseandttings

connectedextensionhosewillbecomeveryHOTduringandafteruse.Ifnecessary,wearheat

resistantglovestoremovehosefromthecompressorquickconnectstud.

MAINTENANCE & REPAIRS:

Youraircompressorisequippedwithpermanentlylubricated,maintenance-freemotor.

Nevertrytolubricatethecompressor.Regularlycleandustanddirtfromcompressorcoolingns

andmotorhousing.AllrepairsshouldbeperformedbyManufacturerorManufacturerauthorized

serviceagenciesonly.

450P-RV AUTOMATIC PORTABLE COMPRESSOR

USER MANUAL

450P-RV-AUTOMATIC ACCESSORIES:

45-Degree Extended Reach, Angled Chuck:

Open-endedairchuckallowsreachintoareasdiculttoreachbyhand.

ConnectstoTireInationGun.

90-Degree Twist-on Chuck:

Thisopen-endedairchuckcanbeattachedtoanyinationvalvewherethereislimitedclearance.

Primary Hose & Extension Hoses:

Dualhoses,withquickconnectcouplings.

Tire Ination Gun:

Normallyclosed-endedchuck,(untilleverisengaged)allairchucksattachtotheTireInationGun

withquickconnectcouplings.

INLET AIR FILTER INSTALLATION INSTRUCTION:

1.ChecktomakesureairlterelementisproperlyinstalledinyourInletAirFilterAssembly

2.Removethetemporaryprotectiveredplugfromcompressor’sairinletport.

3.Installinletairlterontocompressor’sairinletport.(ThreadtapeNotRecommended).

4.Handtighteninletairlter.

IMPORTANT:Foroptimalcompressorperformance,replacelterelementperiodically.

Cloggedlterwilldrasticallyreducecompressorowrateandperformance.

450P-RV AUTOMATIC PORTABLE COMPRESSOR

USER MANUAL

TROUBLESHOOTING GUIDE:

Compressorwillnotrun 1.Nopower,orpowerswitch

inOFFposition

2.Blownfuse

3.Motoroverheats

1.Makesurecompressor

switchisON

2. Disconnect compressor

frompowersource,replace

fuse.(RefertoSpecications

section for correct

fuseamperage)

3.Letcompressorcoolofor

about30minutestoallow

thermaloverloadswitchtoreset.

Thermaloverload

protector cuts out

repeatedly

1.Lackofproperventilationor

ambienttemperatureistoohigh

2.Compressorvalvesfailed

1.Movecompressortowell

ventilatedarea,orareawith

lower ambient temperature

2.Serviceorreplacecompressor

Excessiveknocking

orrattling

1.Wornbearingoneccentricor

motor shaft

2.Cylinderorpistonringisworn

1.Serviceorreplacecompressor

Compressorairowlower

thannormal,orcannot

pumptohigherpressures

1.Wornpistonringorinletvalve 1.Serviceorreplacecompressor

PROBLEM: POSSIBLECAUSE(S) CORRECTIVEACTION

450P-RV AUTOMATIC PORTABLE COMPRESSOR

USER MANUAL

15EDELMAN•IRVINE,CA92618

TEL:(949)585-0011•FAX:(949)585-0188

www.viaircorp.com

MODEL 450P-RV AUTOMATIC SPECIFICATIONS:

PartNumber: 45053/450P-RVAutomatic

MotorVoltage: 12-volt

MotorType: PermanentMagnetic

Max.IntermittentPressure: 150PSI

Max.DutyCycle: 100%(Continuous)

(Min.On/O@72ºF&100PSI)

ContinuousUse@72ºF&30PSI: Continuous

Max.CurrentConsumption: 23Amps

Fuse: 30Amps

InlinePressureGauge: 160PSI

Built-inPressureSwitch: 130PSIOn,155PSIO

Auto.ResetThermalProtection: Yes

450P-RV AUTOMATIC PORTABLE COMPRESSOR

*Tolerance:

3%

LIMITED WARRANTY:

VIAIRCorporationwarrantsthisproduct,whenproperlyinstalledandundernormalconditionsofuse,tobefreefromdefectsin

workmanshipandmaterialsforaperiodofoneyearfromitsoriginaldateofpurchase.Toreceivewarrantyserviceorrepair,please

contactVIAIRCorporation.

Returnsshouldbemadewithinoneyearofthedateofpurchase,afteraReturnGoodsAuthorization(RGA)numberhasbeen

assignedbyVIAIRCorporation.ToobtainRGA,faxacopyofyourreceiptto(949)585-0188.Forcompletewarrantydetails,please

visit:www.viaircorp.com/warranty

PLEASE NOTE:

THISWARRANTYCOVERSPRODUCTDEFECTSONLY;ITDOESNOTCOVERINCIDENTALORCONSEQUENTIALDAMAGES

ASRESULTOFMISUSEORABUSE.

ThisManualisproprietarytoVIAIRCorporationandnoownershiprightsareherebytransferred.NopartoftheManualshallbe

used,reproduced,translated,converted,adapted,storedinaretrievalsystem,communicatedortransmittedbyanymeans,forany

commercialpurpose,includingwithoutlimitation,sale,resale,license,rentalorlease,withoutthepriorexpresswrittenconsentofVIAIR.

VIAIRdoesnotmakeanyrepresentations,warrantiesorguarantees,expressorimplied,astotheaccuracyorcompletenessofthe

Manual.UsersmustbeawarethatupdatesandamendmentswillbemadefromtimetotimetotheManual.Itistheuser’sresponsibility

todeterminewhethertherehavebeenanysuchupdatesoramendments.NeitherVIAIRnoranyofitsdirectors,ocers,employees

oragentsshallbeliableincontract,tortorinanyothermannerwhatsoevertoanypersonforanyloss,damage,injury,liability,costor

expenseofanynature,includingwithoutlimitationincidental,special,directorconsequentialdamagesarisingoutoforinconnection

withtheuseoftheManual.

VIAIR 45053 User manual

Brand: VIAIR

Model: 45053

Category: Air compressors

Type: User manual

This manual is also suitable for

Download PDF

report

VIAIR 45053 User manual

This manual is also suitable for

VIAIR 45053 User manual

Related papers

Other documents