Macnaught C1BYB5025Y Operating instructions

Brand
Macnaught
Model
C1BYB5025Y
Type
Operating instructions

This manual is also suitable for

Macnaught C1BYB5025Y is a safety barrier reel designed to help cordon off hazardous areas, prevent accidents, and improve safety in various settings. It features a durable construction and a highly visible yellow and black barrier tape that can extend up to 25 meters (82 feet) in length. The reel's slow retraction system ensures safe and controlled tape deployment, preventing injuries caused by sudden recoiling. The C1BYB5025Y is easy to install and can be mounted on walls, ceilings, or other surfaces using the included hardware.

Macnaught C1BYB5025Y is a safety barrier reel designed to help cordon off hazardous areas, prevent accidents, and improve safety in various settings. It features a durable construction and a highly visible yellow and black barrier tape that can extend up to 25 meters (82 feet) in length. The reel's slow retraction system ensures safe and controlled tape deployment, preventing injuries caused by sudden recoiling. The C1BYB5025Y is easy to install and can be mounted on walls, ceilings, or other surfaces using the included hardware.

Instruction Manual
REV 07/27/23
Safety Barrier Reel
WARNING:
Read carefully and understand all INSTRUCTIONS before operating. Failure to follow the safety
rules and other basic safety precautions may result in serious personal injury.
Save these instructions in a safe place and on hand so that they can be read when required.
GENERAL SAFETY REGULATIONS
WARNING: The warnings, cautions, and instructions
discussed in this instruction manual cannot cover all
possible conditions or situations that could occur. It
must be understood by the operator that common
sense and caution are factors that cannot be built into
this product, but must be supplied by the operator.
The following general warnings should be observed when installing, operating
or maintaining barrier reel equipment.
1. Keep the work area clean and dry. Damp or wet work areas can result in
injury.
2. Keep children away from work area. Do not allow children to handle this
product.
3. The operator should wear appropriate protection equipment to protect against
personal injury.
4. Do not let go of the barrier tape when rewinding.
5. Use the right tool for the job. Do not attempt to force small equipment to do
the work of larger industrial equipment. There are certain applications for
which this equipment was designed. It will do the job better and more safely
at the capacity for which it was intended. Do not modify this equipment, and
do not use this equipment for a purpose for which it was not intended.
6. Check for damaged parts. Before using this product, carefully check that it
will operate properly and perform its intended function. Check for damaged
parts and any other conditions that may affect the operation of this product.
DO NOT use damaged equipment.
7. Do not overreach. Keep proper footing and balance at all times to prevent
tripping, falling, back injury, etc.
8. Do not use the equipment when tired or under the influence of drugs, alcohol,
or medication. A moment of inattention while operating this equipment may
result in serious personal injury.
TECHNICAL DETAILS
Page 1
TECHNICAL
DETAILS
SAFETY
PRECAUTIONS
INSTALLATIONOPERATIONMAINTENANCETRANSPORTATION LIMITED
WARRANTY
125mm / 4.92"
40mm / 1.57"
192mm / 7.55"
8.5mm / 2-Ø0.33"
15.5mm / 2-Ø0.61"
15mm / 0.6
"
C1BRW5025Y
C1BYB5025Y
SKU# Barrier Tape Capacity
Thickness
0.5mm
0.5mm
Width
48mm
48mm
Length
25m / 82ft
25m / 82ft
Colour
Red / White
Yellow / Black
438mm / 17.24" 84mm / 3.3"
396mm / 15.6"
205mm / 8.07"
SAFETY PRECAUTIONS
Use appropriate safety equipment when fitting and using this barrier tape reel.
1. Keep children away from the work area.
2. Make sure the tape is fully recoiled and spring tension is released before carrying out any
maintenance.
3. Personal injury and/or equipment damage may result if proper safety precautions are not
observed.
4. Make sure the spring force is fully released before maintenance.
5. Don't jerk the warning tape.
INSTALLATION
1. Unpack and inspect reel for damage. Turn by hand to check for smooth operation.
2. Check operation by pulling out the tape and then recoiling it back into the reel.
3. Secure the tape reel to the wall and the ceiling according to the installation diagrams. Using
screw anchors or suitable screws which must be fitted in the holes in the brackets. You will
need to purchase appropriate hardware for mounting your new reel.
a. The reel base has two 8.5mm drilled holes for mounting on a suitable flat surface.
b. Using the two holes in the base, mount the reel in the desired location. Be sure to use
appropriate hardware and tighten securely.
Page 2
TECHNICAL
DETAILS
SAFETY
PRECAUTIONS
INSTALLATIONOPERATIONMAINTENANCETRANSPORTATION LIMITED
WARRANTY
Wall
Page 3
TECHNICAL
DETAILS
SAFETY
PRECAUTIONS
INSTALLATIONOPERATIONMAINTENANCETRANSPORTATION LIMITED
WARRANTY
OPERATION
1. Check reel for correct operation by slowly pulling out warning tape.
2. To LOCK the tape, pull out the warning tape, turn the knob to
LOCK position.
3. To UNLOCK, hold the tape, turn the knob to UNLOCK position,
release the tape slowly till it is retracted into reel completely.
4. Equipped with slow retraction system to ensure safe use.
Anchorage Method
The reel contains accessory package (including magnet, eye screw and expansion
plug). The tape anchor method can vary, the anchors supplied will suit most applications.
1. The fixing pin on the reel can be directly hooked into the slot hole, or the belt can be
clamped with the pin after wrapping the object with a warning tape (see Figure 1).
2. The magnet is hung on the fixed pin. Through the magnet, the warning tape can be directly
connected with the metal surface (see Figure 2).
3. The eye screw can be fixed onto wood board or timber, and the fixing pin can be connected
with it (see Figure 3).
4. The expansion plug is used together with the eye screw, and the fixing pin is connected to
the wall (see Figure 4).
60°
180°FREEDOM OF ROTATION
60°
Locking Position
Locking Position
Locking Position
Metal Wood Wall
Figure 1 Figure 2 Figure 3 Figure 4
Page 4
TECHNICAL
DETAILS
SAFETY
PRECAUTIONS
INSTALLATIONOPERATIONMAINTENANCETRANSPORTATION LIMITED
WARRANTY
DO NOT OPEN COVER.
This reel is non-repairable and must not be opened as this can cause serious injury or
death. There are no spare parts available. See below picture.
MAINTENANCE
1. Make sure the tape is in proper working order.
2. Clean the tape with a cloth dipped in warm water to remove dirt or deposits and ensure
correct rewinding.
3. Do not use detergents or solvents which could be incompatible with reel materials.
4. Do not dissasemble the reel. This reel is not servicable.
LIMITED WARRANTY
For Warranty Terms and Conditions see macnaught.com.au / macnaughtusa.com.
For a list of Australian Service Centres see macnaught.com.au
8-PT4.0x12F
Don't Open
Macnaught
1800 185 102 | [email protected]
Macnaught Americas
(813) 628-5506 | [email protected]
* Read Manual Before Use!
Size: 145x210mm REV 07/27/23157
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8

Macnaught C1BYB5025Y Operating instructions

Brand
Macnaught
Model
C1BYB5025Y
Type
Operating instructions
This manual is also suitable for

Macnaught C1BYB5025Y is a safety barrier reel designed to help cordon off hazardous areas, prevent accidents, and improve safety in various settings. It features a durable construction and a highly visible yellow and black barrier tape that can extend up to 25 meters (82 feet) in length. The reel's slow retraction system ensures safe and controlled tape deployment, preventing injuries caused by sudden recoiling. The C1BYB5025Y is easy to install and can be mounted on walls, ceilings, or other surfaces using the included hardware.

Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents