Cleveland Combi Oven-Steamer OGB-10.20 Datasheet

Brand: Cleveland

Model: Combi Oven-Steamer OGB-10.20

Type: Datasheet

This manual is also suitable for

OGB10.20

SECT. IIA PAGE 23

0810

Featuring the

"Advanced Closed

System

Short Form Specifications

Cooking Modes:

Hot Air

Retherm

"Delta T" slow cooking

Steam

"Cook & Hold"

"Crisp & Tasty"

Combi

Cleveland Standard Features:

"Advanced closed system" with "Crisp & Tasty" de-moisturizing feature

High efficiency, power burner heating system for hot air and steam

generator saves energy and provides fast heat up times

Fully insulated steam generator and cooking compartment for

maximum energy savings

Polished cooking compartment with coved corners for easy cleaning

Five (5) 26" x 20" wire shelves

Hinged fan guard and hinged removable pan racks

Two (2) speed auto reversing convection fan for even heat distribution

Space saving, easy to operate "Disappearing Door"

"Antibacterial Hygenic Door Handle" with embedded silver ion

protection

Door latch with safety vent position and wear-free door switch

Vented, double glass door with integrated door stop and self

draining condensate drip tray

Easy to change, press-fit door seal

Oven light with shock resistant safety glass

Multipoint core temperature probe

Digital controls for temperature, time and core probe settings

Self diagnostic system with full text message display

Easy to understand menu icons with bright graphics display

User friendly selector dial

Exclusive "Smart Key" for selecting option settings

Eight (8) "Press & Go" one step, recipe start buttons

Cook book library for up to 250 stored recipe programs, each

recipe capable of 20 steps

Memory module for saving unit settings and recipes

Smooth action hand shower for compartment cleaning

Gas Fired Steam Generator

Quiet, high efficiency, power burner heating system

Built-in automatic rinse system

Automatic fill and water level control

Automatic generator drain

Shall be Cleveland Model: OGB 10.20 Combination Convection Oven /

Steamer with simple to operate programmable controls for Hot Air,

Convection Steam, and Combination cooking modes, "Cook & Hold" and

"Delta T" slow-cooking capabilities, "Advanced Closed System" with "Crisp

& Tasty" de-moisturizing feature. Multiple cooking stage programs, stored

recipe library, multipoint core temperature probe, "Press & Go", one-step

recipe start buttons, "Smart Key" for selecting option settings, Two (2) speed

auto reversing convection fan. Quiet, high efficiency power burner heating

system; steam generator with automatic drain.

"Disappearing Door" with

"Antibacterial Hygenic Door Handle"

apacity for ten (10) 18" x 26" full size

sheet pans, or twenty (20) 12" x 20" x 2 1/2" pans.

ODEL:  OGB 10.20

CAPACITY:

Eleven (11) - 18” by 26” by 1” full size sheet pans* or

Twenty-two (22) - 13” by 18” by 1” half size sheet pans* or

Twenty (20)) - 12” x by 20” by 2 1/2” steam table pans

On wire racks. Additional wire racks required for maximum capacity.

Options and Accessories

Ë CONVOClean hands free automatic compartment washing system

Ë CONVOControl software for establishing "HACCP controls" and automatic

documentation of the cooking process

Ë Equipment stand(s)

Ë Equipment stand(s) with Casters

Ë Stacking kit for mounting one (1) OGB 6.20 model on top of

one (1) OGB 10.20

Ë Pan rack adapter to hold full size sheet pans without the use of wire shelves

Ë Lockable cover over operating controls for prison installations

Ë Ethernet connection for networking and controlling up to 100 units with a

personal computer

Ë Propane gas option

Ë Plate rack for banquet operations

Ë Plate rack cart

Ë Thermal cover for plate or pan rack

Ë CONVOClean compartment cleaning solution

Ë CONVORinse compartment rinse cycle solution

Ë "Dissolve" generator descaling solution

Ë Chicken Grill Rack

Ë CONVOGrill Grilling Rack

Ë 12" x 20" Wire Baskets for frying products

Ë Additional 26" x 20" Wire Shelves

Ë Kleensteam II Water Filters

Ë easyToUCH™ control panel

GAS Fired – with Steam Generator

Cleveland

™

roject ________________________________

Item __________________________________

Quantity _______________________________

CSI Section ____________________________

pproval _______________________________

ate __________________________________

1333 East 179 St.,

Cleveland, Ohio, U.S.A. 44110

Tel: 1-216-481-4900

Fax: 1-216-481-3782

Web Site: www.ClevelandRange.com

Email: Steam@ClevelandRange.com

COMBI OVEN-STEAMER

NOTES:

Cleveland Range reserves right of design improvement or modification, as warranted.

Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes.

Cleveland Range equipment is built to comply with applicable standards for manufacturers.

SECT. IIA PAGE 24

0810

Model: OGB

.20

Pan Capacity [

Unit has 11 slide rails at 2.64" (67mm) apart

1 (20" x 26") full size wire racks 11 (18" x 26") full size sheet pans - on wire racks

2 (13" x 18") half size sheet pans - on wire racks 20 (12" x 20" x 2 1/2") steam table pans

22 (12" x 20" x 1") steam table pans 20 (12" x 20") frying baskets - (no wire racks needed)

For Banquet Operations: Optional Plate Rack holds 63 plates

Unit Dimensions: Width - 52.26", Depth - 43.24", Height - 45.68"

Shipping Dimensions: Width - 58", Depth - 49", Height - 54"

(including packaging)

Shipping Weight: 540 Lbs

Required Clearances:

Rear - 2", Left Side - 4", Right Side - 2 1/2"

• Allow for sufficient distance if a "high heat source" (i.e. Broiler) is located

ext to the unit.

• Allow for sufficient clearance on left side for service access (contact the

factory service department for recommendations).

• Installation must comply with all local fire and health codes.

Agency Approvals: UL - Gas, UL - Sanitation (NSF Standards)

Electrical Requirements: 120 volt, 8.7 amps, 60 Hz, single phase

Do not connect to a G.F.I. outlet

Gas Connection: 3/4" NPT

Gas Type: Natural Gas (Propane optional)

Gas Flow Pressure: Natural Gas - Min. 5.5" WC / Max. 14" WC

Propane Gas - Min. 11" WC / Max. 14" WC

Total Connected Load: 132,700 BTU (119,000 BTU Propane)

Steam Generator: 113,600 BTU (102,000 BTU Propane)

Hot Air: 132,700 BTU (119,000 BTU Propane)

Water Connections: Cold Water (drinking water quality)

Dynamic Pressure: 35 - 60 PSI

Water Inlets: 3/4" GHT-F (Female Garden Hose Connection)

Treated Water for Steam Generator

Untreated Water for Condenser and Hand Shower

NOTE:

The owner / operator / purchaser must ensure that the Water Quality

Requirements are met. Not meeting the water quality requirements will void

the original equipment warranty.

Water Quality Requirements:

TDS . . . . . . . . . . . < 60 ppm pH Factor 7.0 – 8.5

Total Alkalinity . . . < 20 ppm Free Chlorine < 0.1 ppm

Silica . . . . . . . . . . < 13 ppm Conductivity min. 20 µS/cm (50 kOhms)

Chloride . . . . . . . . < 25 ppm

Drain Connection: 2" Tube

Venting: Exhaust Hood required

Gas Exhaust for Hot Air Heating

Gas Exhaust for Steam Generator

Air Vent

*Connection for Cleaning Solution

*Connection for Rinse Cycle

Low Pressure Safety Valve

*Available as an option

A = Water hook up soft water G"

B = Water hook up cold water G"

C = drainage hook up DN50

D = power hook up

E = Potential equaliser

F = Final rinse hook up

G = Cleaner hook up

H = Air vent pipe

I = Low pressure safety

OEB 10.20

A = Water hook up soft water G"

B = Water hook up cold water G"

C = drainage hook up DN50

D = power hook up

E = Potential equaliser

F = Final rinse hook up

G = Cleaner hook up

H = Air vent pipe

I = Low pressure safety

OES 10.20

OGB 10.20

AWater hook up soft water G"

BWater hook up cold water G"

CDrainage hook up DN50

DPower hook up

EPotential equaliser

FFinal rinse hook up

GCleaner hook up

HAir vent piper

I Low pressure safety

J Gas hook up R"

KExhaust pipe gas (Hot air heating)

LExhaust pipe gas (Steam generator)

OGS 10.20

A = Water hook up soft water G"

B = Water hook up cold water G"

C = Drainage hook up DN50

D = Power hook up

E = Potential equaliser

F = Final rinse hook up

G = Cleaner hook up

H = Air vent pipe

I = Low pressure safety

J = Gas hook up R"

K = Exhaust pipe gas

47.92"

2.52"

.58"

38.98"

6.00"

1.82"

44.98"

40.44"

2.80"

12.68"

2.80"

8.55"

3.39"

3.55"

7.49"

13.07"

3.23"

14.26"

10.87"

41.42"

3.27"

6.93"

10.40"

21.19"

2.96"

27.29"

1.19"

29.61"

3.90"

3.00"

4.97"

FRONT VIEW

TOP VIEW

40.44"

2.80"

12.68"

2.80"

8.55"

3.39"

7.49"

13.07"

TOP VIEW

BOTTOM VIEW

3.23"

14.26"

10.87"

41.42"

3.27"

6.93"

10.40"

21.19"

2.96"

27.29"

1.19"

29.61"

3.90"

3.00"

4.97"

BOTTOM VIEW

47.92"

2.52"

.58"

38.98"

6.00"

1.82"

44.98"

FRONT VIEW

47.92"

2.52"

1.58"

38.98"

6.00"

1.82"

44.98"

40.44"

2.80"

12.68"

2.80"

31.50"

3.39"

13.07"

3.23"

14.26"

0.87"

41.42"

3.27"

6.93"

21.19"

2.96"

27.29"

1.19"

29.61"

3.90"

3.00"

4.97"

FRONT VIEW

TOP VIEW

BOTTOM VIEW

31.50"

Cleveland Combi Oven-Steamer OGB-10.20 Datasheet

Brand: Cleveland

Model: Combi Oven-Steamer OGB-10.20

Type: Datasheet

This manual is also suitable for

OGB10.20

Download PDF

report

Cleveland Combi Oven-Steamer OGB-10.20 Datasheet

This manual is also suitable for

Cleveland Combi Oven-Steamer OGB-10.20 Datasheet

Related papers

Other documents