Alcatel-Lucent 1643 AMS Installation guide

1643 Access Multiplexer AM / 1643

Access Multiplexer Small AMS

(Formerly Metropolis® AM /

Metropolis® AMS)

Release 1.0 through 7.2

Installation Guide

365-312-802R7.2

CC109635797

Issue 4

June 2007

Alcatel-Lucent - Proprietary

This document contains proprietary information of Alcatel-Lucent and

is not to be disclosed or used except in accordance with applicable agreements.

Unpublished and Not for Publication

See notice on first age

Alcatel, Lucent, Alcatel-Lucent and the Alcatel-Lucent logo are trademarks of Alcatel-Lucent. All other trademarks are the property of their

respective owners.

The information presented is subject to change without notice. Alcatel-Lucent assumes no responsibility for inaccuracies contained herein.

Notice

Every effort has been made to ensure that the information in this document was complete and accurate at the time of printing. However,

information is subject to change.

Release notification

This document describes AM and AMS release 7.2 and covers previous releases.

Compared to provided descriptions some of the legacy releases may vary due to the feature upgrades.

Safety

Always observe the Safety Instructions given in Chapter 1 when operating the system.

Please note that Alcatel-Lucent warranty is contingent upon the use of Alcatel-Lucent specified SFPs for AMS. Use of other SFPs is not

approved by Alcatel-Lucent and is fully at the customer’s own risk. Any warranty obligation of Alcatel-Lucent is extinguished when

non-Alcatel-Lucent specified SFPs are used.

Ordering information

The order number of this document is 365-312-802R7.2 (Issue 4).

Technical support

Please contact your Alcatel-Lucent Local Customer Support Team (LCS) for technical questions about the information in this document.

Information product support

To comment on this information product online, go to http://www.alcatel-lucent-info.com/comments or email your comments to

[email protected].

See notice on first age

Alcatel-Lucent - Proprietary

See notice on first page

Contents

About this information product

Purpose

........................................................................................................................................................................................ xviixvii

Reason for reissue

................................................................................................................................................................... xviixvii

Safety information

..................................................................................................................................................................... xxxx

Intended audience

...................................................................................................................................................................... xxxx

How to use this information product

................................................................................................................................. xxxx

Conventions used

...................................................................................................................................................................... xxixxi

Related documentation

.......................................................................................................................................................... xxiixxii

Technical support

................................................................................................................................................................... xxiiixxiii

How to order

........................................................................................................................................................................... xxiiixxiii

How to comment

................................................................................................................................................................... xxiiixxiii

Part I: Physical and power installation

1 Safety

Overview

...................................................................................................................................................................................... 1-11-1

General notes on safety

Overview

...................................................................................................................................................................................... 1-31-3

Structure of hazard statements

............................................................................................................................................ 1-41-4

Basic safety aspects

................................................................................................................................................................. 1-81-8

Specific safety areas

Overview

...................................................................................................................................................................................... 1-91-9

Laser safety

.............................................................................................................................................................................. 1-101-10

Optical circuit pack specifications

.................................................................................................................................. 1-131-13

...................................................................................................................................................................................................................................

365-312-802R7.2

Issue 4, June 2007

Alcatel-Lucent - Proprietary

See notice on first page

iii

Power supply safety instructions ..................................................................................................................................... 1-141-14

Electrostatic discharge

......................................................................................................................................................... 1-151-15

Conformity statements

......................................................................................................................................................... 1-161-16

2 General information

Overview

...................................................................................................................................................................................... 2-12-1

Hardware description

.............................................................................................................................................................. 2-22-2

Environmental considerations

........................................................................................................................................... 2-102-10

EMC/ESD information

........................................................................................................................................................ 2-122-12

ITM-CIT requirements

......................................................................................................................................................... 2-142-14

Required tools and test equipment

................................................................................................................................. 2-152-15

Sequence of steps

.................................................................................................................................................................. 2-162-16

3 Mechanical installation

Overview

...................................................................................................................................................................................... 3-13-1

1643 AM installation

Overview

...................................................................................................................................................................................... 3-23-2

Technical data for AM unit

.................................................................................................................................................. 3-33-3

Installation of an option card

.............................................................................................................................................. 3-73-7

Mounting the EMC bracket

................................................................................................................................................. 3-93-9

Technical data for fan unit

................................................................................................................................................. 3-103-10

AM unit installation

.............................................................................................................................................................. 3-123-12

1643 AMS installation

Overview

................................................................................................................................................................................... 3-193-19

Technical data for AMS unit

............................................................................................................................................. 3-203-20

Installation of an option card

............................................................................................................................................ 3-213-21

Mounting the EMC bracket

............................................................................................................................................... 3-233-23

Technical data for fan unit

................................................................................................................................................. 3-243-24

AMS unit installation

........................................................................................................................................................... 3-263-26

Contents

...................................................................................................................................................................................................................................

iv

Alcatel-Lucent - Proprietary

See notice on first page

365-312-802R7.2

Issue 4, June 2007

4 System cabling

Overview

...................................................................................................................................................................................... 4-14-1

Power and ground cable installation

Overview

...................................................................................................................................................................................... 4-34-3

Power interfaces (AM unit)

................................................................................................................................................. 4-44-4

Power interfaces (AMS unit)

............................................................................................................................................... 4-64-6

Cabling with AC/DC converter

.......................................................................................................................................... 4-84-8

Ground wiring

......................................................................................................................................................................... 4-114-11

External cable installation

Overview

................................................................................................................................................................................... 4-124-12

Fan power interface

.............................................................................................................................................................. 4-134-13

Fan alarm and LED interface

........................................................................................................................................... 4-154-15

MDI/MDO interface

............................................................................................................................................................. 4-174-17

Timing interface

..................................................................................................................................................................... 4-234-23

Q-LAN interface (OMS)

..................................................................................................................................................... 4-254-25

ITM-CIT interface

................................................................................................................................................................. 4-274-27

EOW interfaces

....................................................................................................................................................................... 4-304-30

Option card cable installation

Overview

................................................................................................................................................................................... 4-324-32

E1 interfaces (Main board/X16E1-V3 card)

............................................................................................................... 4-334-33

DS1 interfaces (Main board/X16DS1 card)

................................................................................................................ 4-354-35

SHDSL interfaces (X12SHDSL-V2 card)

................................................................................................................... 4-374-37

E3 interfaces (X2E3 card)

.................................................................................................................................................. 4-404-40

DS3 interfaces (X2DS3 card)

........................................................................................................................................... 4-414-41

LAN interfaces (X4IP, X8PL and X5IP card)

........................................................................................................... 4-424-42

X.21 interfaces (X4X.21 card)

......................................................................................................................................... 4-454-45

STM-1e interfaces (X2STM1ETRIB card)

................................................................................................................. 4-474-47

Fiber cabling

Overview

................................................................................................................................................................................... 4-494-49

Contents

...................................................................................................................................................................................................................................

365-312-802R7.2

Issue 4, June 2007

Alcatel-Lucent - Proprietary

See notice on first page

v

Optical interfaces (AM unit) ............................................................................................................................................. 4-504-50

Optical interfaces (AMS unit/X5IP card)

.................................................................................................................... 4-524-52

Aggregate interfaces (Main board)

................................................................................................................................. 4-554-55

Tributary interfaces (X2S11TRIB card)

....................................................................................................................... 4-574-57

5 Powering

Overview

...................................................................................................................................................................................... 5-15-1

Power initialisation

Overview

...................................................................................................................................................................................... 5-25-2

Switching on and testing supply voltage

........................................................................................................................ 5-35-3

Fan unit test

................................................................................................................................................................................ 5-45-4

Physical installation check

Overview

...................................................................................................................................................................................... 5-55-5

AM/AMS unit installation

.................................................................................................................................................... 5-65-6

Cable connections

.................................................................................................................................................................... 5-75-7

Physical and power installation exit checklist

............................................................................................................. 5-85-8

Part II: NE provisioning and stand-alone installation test

6 ITM-CIT installation and NE provisioning

Overview

...................................................................................................................................................................................... 6-16-1

Software installation

Overview

...................................................................................................................................................................................... 6-26-2

Installing ITM-CIT

.................................................................................................................................................................. 6-36-3

Installing the fast download application

......................................................................................................................... 6-66-6

Fast NE software download

................................................................................................................................................. 6-76-7

Connecting the ITM-CIT to the NE

.............................................................................................................................. 6-106-10

NE login procedure

............................................................................................................................................................... 6-126-12

Provisioning system parameters

Overview

................................................................................................................................................................................... 6-146-14

NE date and time

................................................................................................................................................................... 6-156-15

Contents

...................................................................................................................................................................................................................................

vi

Alcatel-Lucent - Proprietary

See notice on first page

365-312-802R7.2

Issue 4, June 2007

Node creation .......................................................................................................................................................................... 6-176-17

Slot provisioning

.................................................................................................................................................................... 6-206-20

Confirm/Update the MIB

................................................................................................................................................... 6-226-22

7 Stand-alone test procedures

Overview

...................................................................................................................................................................................... 7-17-1

Test equipment and accessories

.......................................................................................................................................... 7-37-3

Preparation and test of the main unit

............................................................................................................................... 7-67-6

E1 tributary ports distribution wiring test

...................................................................................................................... 7-77-7

Line port connection to optical distribution frame test

............................................................................................ 7-97-9

PDH option card test

............................................................................................................................................................ 7-137-13

Optical STM-1 option card test

....................................................................................................................................... 7-167-16

X.21 option card test

............................................................................................................................................................ 7-197-19

X4IP, X8PL, and X5IP option card test

....................................................................................................................... 7-227-22

X12SHDSL-V2 option card test

...................................................................................................................................... 7-257-25

NE provisioning and stand alone installation test exit checklist

....................................................................... 7-287-28

Part III: Link testing

8 Link testing

Overview

...................................................................................................................................................................................... 8-18-1

Connecting the fiber cables

.................................................................................................................................................. 8-28-2

Remote login test

..................................................................................................................................................................... 8-48-4

BER test

....................................................................................................................................................................................... 8-68-6

Link testing exit checklist

..................................................................................................................................................... 8-88-8

9 Conclusion

Overview

...................................................................................................................................................................................... 9-19-1

Power supply measurements

................................................................................................................................................ 9-29-2

Optical output power measurements

................................................................................................................................ 9-39-3

Final checklist

............................................................................................................................................................................ 9-49-4

Completion form

....................................................................................................................................................................... 9-59-5

Contents

...................................................................................................................................................................................................................................

365-312-802R7.2

Issue 4, June 2007

Alcatel-Lucent - Proprietary

See notice on first page

vii

A Mounting rules

Overview

..................................................................................................................................................................................... A-1A-1

AM/AMS units (DC powered)

.......................................................................................................................................... A-2A-2

AM/AMS units (AC powered)

.......................................................................................................................................... A-4A-4

B Installation trouble shooting

Overview

..................................................................................................................................................................................... B-1B-1

Power failure

............................................................................................................................................................................. B-2B-2

Installing the NE software

................................................................................................................................................... B-4B-4

Parameters for NE software installation

........................................................................................................................ B-7B-7

Software check (correct ISD)

............................................................................................................................................. B-9B-9

Fiber cleaning

......................................................................................................................................................................... B-10B-10

Removing the SFP modules

............................................................................................................................................. B-12B-12

C Cable assembly instructions

Overview

..................................................................................................................................................................................... C-1C-1

SUB-D connector

.................................................................................................................................................................... C-2C-2

Coax connector (1.6/5.6)

...................................................................................................................................................... C-5C-5

Mounting 4x2.5mm coax (75 Ω) to RJ45 connector

............................................................................................... C-8C-8

Glossary

Index

Contents

...................................................................................................................................................................................................................................

viii

Alcatel-Lucent - Proprietary

See notice on first page

365-312-802R7.2

Issue 4, June 2007

List of tables

Part I: Physical and power installation

2 General information

2-1 Technical specifications (AC/DC converter)

................................................................................................ 2-22-2

2-2 Technical specifications (FSP12AMS)

............................................................................................................ 2-32-3

2-3 Available option cards

............................................................................................................................................ 2-72-7

2-4 Environmental conditions

................................................................................................................................... 2-102-10

2-5 Required tools

......................................................................................................................................................... 2-152-15

2-6 Required test equipment

..................................................................................................................................... 2-152-15

3 Mechanical installation

3-1 Technical specifications (AM unit)

.................................................................................................................. 3-33-3

3-2 Technical specifications (fan unit)

.................................................................................................................. 3-103-10

3-3 Technical specifications (AMS unit)

............................................................................................................. 3-203-20

3-4 Technical specifications (fan unit)

.................................................................................................................. 3-243-24

4 System cabling

4-1 Pin assignment (power cables, AM unit)

....................................................................................................... 4-44-4

4-2 Pin assignment (power cables, AMS unit)

.................................................................................................... 4-64-6

4-3 Parts (DIN rail)

......................................................................................................................................................... 4-94-9

4-4 Pin assignment (fan power cable)

.................................................................................................................. 4-134-13

4-5 Pin assignment (fan alarm cable)

................................................................................................................... 4-154-15

4-6 Pin assignment (MDI/MDO cable)

................................................................................................................ 4-194-19

4-7 Pin assignment (timing cable)

.......................................................................................................................... 4-234-23

4-8 Pin assignment (Q-LAN cable)

....................................................................................................................... 4-254-25

...................................................................................................................................................................................................................................

365-312-802R7.2

Issue 4, June 2007

Alcatel-Lucent - Proprietary

See notice on first page

ix

4-9 Pin assignment (ITM-CIT cable) .................................................................................................................... 4-274-27

4-10 Pin assignment (EOW cables, valid for both connectors)

.................................................................... 4-304-30

4-11 Pin assignment (E1 cables)

............................................................................................................................... 4-334-33

4-12 Pin assignment (DS1 cables)

............................................................................................................................ 4-354-35

4-13 Pin assignment (SHDSL cables)

..................................................................................................................... 4-374-37

4-14 Pin assignment (LAN cables - E/FE)

........................................................................................................... 4-424-42

4-15 Pin assignment (LAN cable - GE)

................................................................................................................. 4-434-43

4-16 Pin assignment (X.21 cables)

........................................................................................................................... 4-454-45

4-17 Components (STM-1e cable)

............................................................................................................................ 4-474-47

4-18 Optical specifications

........................................................................................................................................... 4-504-50

4-19 Optical SFP specifications

................................................................................................................................. 4-534-53

List of tables

...................................................................................................................................................................................................................................

x

Alcatel-Lucent - Proprietary

See notice on first page

365-312-802R7.2

Issue 4, June 2007

List of figures

Part I: Physical and power installation

2 General information

2-1 AC/DC converter

..................................................................................................................................................... 2-22-2

2-2 Remote Power Supply box

.................................................................................................................................. 2-32-3

2-3 Optical SFP module

................................................................................................................................................ 2-62-6

2-4 SFP155E module

...................................................................................................................................................... 2-62-6

2-5 Dust plug

..................................................................................................................................................................... 2-72-7

2-6 Example of an option card

................................................................................................................................... 2-92-9

3 Mechanical installation

3-1 Front view (AM unit)

............................................................................................................................................. 3-43-4

3-2 AM rear view with different option cards mounted

.................................................................................. 3-53-5

3-3 Location of an AM option card

......................................................................................................................... 3-83-8

3-4 Installed AM option card

...................................................................................................................................... 3-83-8

3-5 Mounting the EMC bracket (AM unit)

........................................................................................................... 3-93-9

3-6 Fan unit

...................................................................................................................................................................... 3-113-11

3-7 Fixing wall mounting brackets (AM unit)

.................................................................................................. 3-133-13

3-8 Vertical wall mounting (AM unit)

.................................................................................................................. 3-133-13

3-9 Horizontal wall mounting (AM unit)

............................................................................................................ 3-143-14

3-10 Fixing horizontal rack brackets (AM unit)

................................................................................................. 3-153-15

3-11 Bracket mounting (AM unit)

............................................................................................................................ 3-163-16

3-12 Vertical mounting (AM unit)

............................................................................................................................ 3-163-16

3-13 Mounted fan unit

................................................................................................................................................... 3-183-18

....................................................................................................................................................................................................................................

365-312-802R7.2

Issue 4, June 2007

Alcatel-Lucent - Proprietary

See notice on first page

xi

3-14 Front view (AMS unit) ....................................................................................................................................... 3-203-20

3-15 Installation of an AMS option card

............................................................................................................... 3-223-22

3-16 Mounting the EMC bracket (AMS unit)

..................................................................................................... 3-233-23

3-17 Fan unit

...................................................................................................................................................................... 3-253-25

3-18 Fixing wall mounting brackets (AMS unit)

............................................................................................... 3-273-27

3-19 Vertical wall mounting (AMS unit)

............................................................................................................... 3-283-28

3-20 Horizontal wall mounting (AMS unit)

......................................................................................................... 3-293-29

3-21 Fixing additional brackets to the AMS unit (if required)

..................................................................... 3-303-30

3-22 Mounting position for MADM compact racks, Wavestar ADM 16/1 racks and DACS racks

............................................................................................................................................................................ 3-303-303-30

3-23 Mounting position for MADM universal racks and ETSI racks (depth 300 mm)

..................... 3-313-31

3-24 Mounting position for ADM 16/1 racks and ETSI racks (600 mm x 600 mm)

......................... 3-323-32

3-25 Mounting position for 19-inch racks

............................................................................................................. 3-333-33

3-26 Mounting position for ETSI-2 (LambdaUnite) racks (back-to-back, depth 600 mm)

.............. 3-343-34

3-27 Mounted AMS brackets

...................................................................................................................................... 3-353-35

3-28 Vertical AMS mounting (with bars)

............................................................................................................... 3-363-36

3-29 Fixing fan unit and brackets (AMS unit)

.................................................................................................... 3-373-37

3-30 Street cabinet mounting (AMS unit)

............................................................................................................. 3-373-37

4 System cabling

4-1 DC connector (AM unit)

....................................................................................................................................... 4-44-4

4-2 DC connection (AM unit)

.................................................................................................................................... 4-54-5

4-3 AC connection (AM unit)

.................................................................................................................................... 4-54-5

4-4 DC connector (AMS unit)

.................................................................................................................................... 4-64-6

4-5 DC connection (AMS unit)

.................................................................................................................................. 4-74-7

4-6 AC connection (AMS unit)

.................................................................................................................................. 4-74-7

4-7 Cabling with AC/DC converter

.......................................................................................................................... 4-84-8

4-8 DIN rail with one power supply

........................................................................................................................ 4-84-8

4-9 DIN rail with two power supplies

.................................................................................................................... 4-94-9

4-10 DIN rail without power supply (direct feed)

................................................................................................ 4-94-9

List of figures

...................................................................................................................................................................................................................................

xii

Alcatel-Lucent - Proprietary

See notice on first page

365-312-802R7.2

Issue 4, June 2007

4-11 Fan power connector ............................................................................................................................................ 4-134-13

4-12 Fan power cable

..................................................................................................................................................... 4-144-14

4-13 Fan alarm and LED connector

......................................................................................................................... 4-154-15

4-14 Fan alarm cable

...................................................................................................................................................... 4-164-16

4-15 MDI circuit

............................................................................................................................................................... 4-174-17

4-16 MDI implementation

............................................................................................................................................ 4-184-18

4-17 MDO circuit

............................................................................................................................................................. 4-194-19

4-18 MDI/MDO connector

........................................................................................................................................... 4-194-19

4-19 MDI/MDO cable (AM unit)

............................................................................................................................. 4-214-21

4-20 MDI/MDO cable (AMS unit)

........................................................................................................................... 4-214-21

4-21 MDI/MDO cable (AMS unit to Remote Power Supply (FSP) unit)

............................................... 4-224-22

4-22 Timing connector

................................................................................................................................................... 4-234-23

4-23 Timing cable (AM unit)

...................................................................................................................................... 4-244-24

4-24 Timing cable (AMS unit)

................................................................................................................................... 4-244-24

4-25 Q-LAN connector

.................................................................................................................................................. 4-254-25

4-26 Q-LAN cable (AM unit)

..................................................................................................................................... 4-264-26

4-27 Q-LAN cable (AMS unit)

.................................................................................................................................. 4-264-26

4-28 ITM-CIT connector

............................................................................................................................................... 4-274-27

4-29 ITM-CIT cable (AM unit)

................................................................................................................................. 4-284-28

4-30 ITM-CIT cable (AMS unit)

............................................................................................................................... 4-284-28

4-31 ITM-CIT cable connection

................................................................................................................................ 4-294-29

4-32 EOW connector

...................................................................................................................................................... 4-304-30

4-33 EOW cables

............................................................................................................................................................. 4-314-31

4-34 E1 connector

............................................................................................................................................................ 4-334-33

4-35 E1 cables

................................................................................................................................................................... 4-344-34

4-36 DS1 connector

........................................................................................................................................................ 4-354-35

4-37 DS1 cables

................................................................................................................................................................ 4-364-36

4-38 SHDSL connector

.................................................................................................................................................. 4-374-37

4-39 SHDSL cables

......................................................................................................................................................... 4-394-39

List of figures

...................................................................................................................................................................................................................................

365-312-802R7.2

Issue 4, June 2007

Alcatel-Lucent - Proprietary

See notice on first page

xiii

4-40 E3 cables ................................................................................................................................................................... 4-404-40

4-41 DS3 cables

................................................................................................................................................................ 4-414-41

4-42 LAN connector

....................................................................................................................................................... 4-424-42

4-43 Cable design (LAN cable - GE)

..................................................................................................................... 4-434-43

4-44 LAN cables (X4IP card)

..................................................................................................................................... 4-444-44

4-45 LAN cables (X8PL card)

................................................................................................................................... 4-444-44

4-46 X.21 connector

....................................................................................................................................................... 4-454-45

4-47 X.21 cables

............................................................................................................................................................... 4-464-46

4-48 Cable design (STM-1e cable)

........................................................................................................................... 4-474-47

4-49 STM-1e cables

........................................................................................................................................................ 4-484-48

4-50 Optical connectors

................................................................................................................................................. 4-504-50

4-51 Optical SFP module

.............................................................................................................................................. 4-524-52

4-52 Dust plug

................................................................................................................................................................... 4-534-53

4-53 Aggregate fiber cables (AM unit)

.................................................................................................................. 4-554-55

4-54 Aggregate fiber cables (AMS unit)

................................................................................................................ 4-564-56

4-55 Tributary fiber cables

........................................................................................................................................... 4-574-57

Part II: NE provisioning and stand-alone installation test

6 ITM-CIT installation and NE provisioning

6-1 Connection with crossed Ethernet cable (AM unit)

.................................................................................. 6-76-7

6-2 Connection with crossed Ethernet cable (AMS unit)

............................................................................... 6-86-8

6-3 ITM-CIT cable connection (AM unit)

.......................................................................................................... 6-106-10

6-4 ITM-CIT cable connection (AMS unit)

....................................................................................................... 6-116-11

7 Stand-alone test procedures

7-1 E1 tributary ports distribution wiring test

..................................................................................................... 7-77-7

7-2 Line port connection to optical distribution frame test

............................................................................ 7-97-9

7-3 PDH option card test

........................................................................................................................................... 7-137-13

7-4 Optical STM-1 option card test

....................................................................................................................... 7-167-16

7-5 X.21 option card test

............................................................................................................................................ 7-197-19

List of figures

...................................................................................................................................................................................................................................

xiv

Alcatel-Lucent - Proprietary

See notice on first page

365-312-802R7.2

Issue 4, June 2007

7-6 X12SHDSL-V2 option card test ..................................................................................................................... 7-257-25

Part III: Link testing

8 Link testing

8-1 Remote login test

..................................................................................................................................................... 8-48-4

8-2 BER test

....................................................................................................................................................................... 8-68-6

A Mounting rules

A-1 Horizontal mounting (AM/AMS, DC)

........................................................................................................... A-2A-2

A-2 Vertical mounting (AM/AMS, DC)

................................................................................................................. A-3A-3

A-3 Vertical mounting (AM/AMS, AC)

................................................................................................................. A-4A-4

B Installation trouble shooting

B-1 Unlocking a MSA latch (type 1) SFP

.......................................................................................................... B-13B-13

B-2 Unlocking a MSA latch (type 2) SFP

.......................................................................................................... B-14B-14

B-3 Unlocking a bail latch (type 1) SFP

............................................................................................................. B-15B-15

B-4 Unlocking a bail latch (type 2) SFP

............................................................................................................. B-16B-16

C Cable assembly instructions

C-1 SUB-D assembly steps

.......................................................................................................................................... C-3C-3

C-2 Low frequency cable

............................................................................................................................................. C-4C-4

C-3 IMS assembly procedure

...................................................................................................................................... C-6C-6

C-4 Crimp tool and die

.................................................................................................................................................. C-7C-7

C-5 RJ45 connector

...................................................................................................................................................... C-11C-11

List of figures

...................................................................................................................................................................................................................................

365-312-802R7.2

Issue 4, June 2007

Alcatel-Lucent - Proprietary

See notice on first page

xv

About this information productAbout this information product

Purpose

This manual provides information on the installation and configuration of 1643 AM

and 1643 AMS units. Furthermore, all steps for putting the system into operation are

also described.

Reason for reissue

This is the fourth issue of this guide for 1643 AM and 1643 AMS, Release 1.0 through

7.2.

Note

The 1643 AM / 1643 AMS Installation Guide contains images with old logos and will

be replaced in forthcoming releases.

Previous versions and features are listed below:

Release GA Features added

....................................................................................................................................................................................................................................

365-312-802R7.2

Issue 4, June 2007

,

Alcatel-Lucent - Proprietary

See notice on first page

xvii

Ruby 1.0 December 2000

• One or Two STM-1 or two STM-4 optical line interface

pairs (transmit/receive)

• Upto sixteen 2 Mbit/s interface ports - G.703 interface -

G.704/G.706 interface

• Remote and local software downloading

• General VC-11/VC-12 SNC/N protection or VC-3

SNC/N protection

• 1+1 MSP protection (STM-1 aggregate only) in terminal

applications

• Performance Monitoring

• E1 or DS1 or E3 or DS3 or X.21 loopbacks

• Cross-connect loopbacks

• Four Miscellaneous Discrete Inputs (MDI)

• Four Miscellaneous Discrete Outputs (MDO)

• Dual fiber pair working

• IP Tunneling in the DCC channels for the management

of elements (TCP/IP protocol)

• Space-efficient for simple and rapid installation within

street cabinets or in customer premises

• Supported by the user-friendly Integrated Transmission

Management (ITM) network management and element

management systems

• AC/DC or DC/DC converter

• Working in large temperature range

• Optional additional sixteen 1.5 Mbit/s ports

• Optional additional sixteen 2 Mbit/s ports

• Optional additional two 34 Mbit/s ports

• Optional additional two 45 Mbit/s ports

• Optional additional four 2 Mbit/s X.21 ports

• Optional additional four 10/100Base-T LAN interfaces

Topaz 2.0 July 2001

• Optional additional two optical STM-1 tributary signals

Pearl 2.2 July 2002

• Optional additional two electrical STM-1 tributary

signals

• Spanning tree protocol

Garnet 3.1 May 2003

• Rapid spanning tree protocol

Garnet 3.2 July 2003

• introduction of 1643 AMS

• introduction of Network Termination Unit (NTU)

• Optional additional twelve SHDSL interfaces

About this information product

...................................................................................................................................................................................................................................

xviii

Alcatel-Lucent - Proprietary

See notice on first page

365-312-802R7.2

Issue 4, June 2007

,

Venus 4.0 September 2003

• X8PL option card

• LCAS functionality for VC-12 and VC-3

• AITS operation (DCC

m

)

• Transparent DCC

r

Earth 5.0 April 2004

• Support of SNMP management

• Advanced SFP data retrieve capability

• Enhanced VLAN tagging

• Enhanced Ethernet port provisioning

• Provisionable LSP size

Mars 6.1 March 2005

• Enhanced flow classification (Port, VID, UP) on E/FE

units

• QoS in IEEE 802.1Q & IEEE 802.1ad mode on E/FE

units, i.e. flow classification, rate control and traffic

class handling

• Oversubscription in IEEE mode

• SHDSL Performance Monitoring

• SHDSL enhancements

• Port Loopback alarming

• J0 support on STM-n lines

• E1 non-intrusive performance monitoring

• E1 PDH AIS

• 1643 AMS with integrated AC power supply

Uranus 7.1 November 2006

• Optional TransLAN card - X5IP, Remote Power Supply

support

• Ethernet PM counter enhancements

• PM counter for Congestion monitoring

• Round trip time/delay measurement

• Provisionable CBS

• Flow classification based on DA-MAC and

IP-TOS/DSCP

• SHDSL enhancements

Miranda 7.2 February 2007 The following features are implemented in this release:

• Alarm Severity Assignment Profile (ASAP)

• X5IP option card enhancements

• Outloops on Ethernet ports in repeater mode

• Performance Monitoring

• VC-4-4c cross connection

• Supported by the Lucent OMS Release 5.0.2 and

Wavestar

®

ITM-CIT - Release 18.0

About this information product

...................................................................................................................................................................................................................................

365-312-802R7.2

Issue 4, June 2007

,

Alcatel-Lucent - Proprietary

See notice on first page

xix

Safety information

This information product contains hazard statements for your safety. Hazard statements

are given at points where safety consequences to personnel, equipment, and operation

may exist. Failure to follow these statements may result in serious consequences.

Intended audience

This manual is intended for users who wish to install, configure and cable 1643 AM

and 1643 AMS units including all accessories.

This requires that the installation staff has a basic knowledge of SDH and Ethernet

technology. Working on the equipment described in this manual requires also special

training of the personnel.

How to use this information product

This manual is divided into the following sections with a brief description of the

contents of each major part/chapter/appendix:

About this document describes the purpose, intended audience, reason for reissue,

and organisation of this document. This section references related documentation and

explains how to order, make comments or recommend changes to this document.

Part I – Physical and power installation

• Chapter 1, Safety

This chapter provides all relevant information and safety guidelines to safeguard

against personal injury. Furthermore, this chapter may be useful to prevent material

damage to the equipment.

• Chapter 2, General information

This chapter provides all facts which must be known before the system can be

installed, such as environmental requirements, ITM-CIT requirements, EMC/ESD

information, etc.

• Chapter 3, Mechanical installation

This chapter provides all information needed to install 1643 AM and 1643 AMS

units.

• Chapter 4, System cabling

This chapter provides all tasks for a complete system cabling.

• Chapter 5, Powering

This chapter describes the system powering and some final tests which should be

performed to end the physical installation part.

Part II – NE provisioning and stand alone installation test

• Chapter 6, ITM-CIT installation and NE provisioning

This chapter describes the ITM-CIT and NE software installation and the initial NE

provisioning via ITM-CIT.

• Chapter 7, Stand alone test procedures

This chapter provides all tests which must be performed to verify the proper

working of the units/NEs.

About this information product

...................................................................................................................................................................................................................................

xx

Alcatel-Lucent - Proprietary

See notice on first page

365-312-802R7.2

Issue 4, June 2007

,

Page is loading ...