Eaton 5S 1000 Installation and User Manual

Installation and

user manual

English - Français

Español - Português

EATON 5S

700/1000/1500

www.eaton.com

2

614-06818-01

2 3

1

4

EATON 5S

Packaging

Quick start

A

Caution!

•BeforeinstallingtheEaton 5S,readthebooklet

3

containingthesafetyinstructionsthatmustbefollowed.

Thenfollowtheinstructionsgiveninthismanual

2

.

•Avantl'installationdeEaton 5S,lirelelivret

3

quiprésentelesconsignesdesécuritéàrespecter.Suivre

ensuitelesinstructionsduprésentmanuel

2

.

•AntesdelainstalacióndelEaton 5S,leerelmanual

3

quepresentalasinstruccionesdeseguridadacumplir.A

continuación,seguirlasinstruccionesdelpresentemanual

2

.

•AntesdainstalaçãodoEaton 5S,lerocaderno

3

ondeconstamasinstruçõesdesegurançaarespeitar.

Depois,seguirasinstruçõesdopresentemanual

2

.

EN

FR

ES

PT

3

614-06818-01

4

B

C

1000 / 1500

700

E

D

Register warranty at: powerquality.eaton.com

Service cable

Modem

4

614-06818-01

Battery change

• Warning: take care not to inverse the polarity + (red) and - (black) when connecting the battery as this will destroy

the device.

b

c

a

Press and slide

a

b

c

Press and slide

700

1000 / 1500

Battery disposal and safety

•Caution. Batteryservicelifeisreducedby50%foreverytendegreesabove25°C(77°F).

•The battery must be replaced exclusively by qualied personnel (risk of shock),withnewbatteryapprovedby

EatontoensurecorrectoperationoftheUPS.

•Thebatterymustbedisposedofinaccordancewithapplicableregulations.Toremovethebattery,shutdownthe

UPS(button

6

OFF),removethepowercordandproceedasindicatedbelow"Batterychange".

5

614-06818-01

Technical characteristics

(*) Warning: Outputcablesshouldnotexceed10m(32.81ft)length.

Eaton 5S 700 1000 1500

•UPSpower 700VA/

420W

1000VA/

600W

1500VA/

900W

•Nominalinputvoltage 93V-138V

•Inputfrequency 50/60Hz(46-70Hzworkingrange)

•Voltage/frequencyofbatterybackup

outlets

19

inbatterymode

115V+15%-20%(60Hz±1Hz)

•Totaloutputcurrentforalloutlets 10Amax 15Amax

•Outputcurrentofbatterybackup

outlets

19

6.1Amax 8.7Amax 13.1Amax

•Leakagecurrent 0.4mA

•Inputprotection 10Aresettablecircuit

breaker

15Aresettablecircuitbreaker

•Transfertime 5mstypical

•Telephone/Datasurgeprotection Tel,ISDN,ADSL,Ethernet

•Sealedlead-acidbattery 12V,9Ah 2x12V,7Ah 2x12V,9Ah

•Automaticbatterytest Onceaweek

•Averagebatterylife 4yearstypical,dependingontemperatureandnumberofdischargecycles

•Operatingtemperature 0to35°C/32 to 95 °F

•Storagetemperature -25°Cto+55°C/-13 °F to 131 °F

•Operatingrelativehumidity 0to85%

•Operatingelevation 0to2000m/0 to 6562 ft

•Safetystandards UL1778

•Electromagneticcompatibility

standards

FCCPart15ClassB

•Dimensions(mm/inch) 260x87x250/

10.24 x 3.43 x 9.84

382x87x250/15.04 x 3.43 x 9.84

•Weigth(kg/lb) 5.9/13.0 9.7/21.4 11.6/25.6

6

614-06818-01

ENGLISH

1. Operating conditions

• ThisproductisanUninterruptiblePowerSupply(UPS)forcomputersandtheir

peripherals,televisionsets,stereosystemsandvideorecorders...Itmustnotbeused

tosupplyotherelectricalequipment(lighting,heating,householdappliances,etc.).

• UPScanbeinstalledinhorizontal,verticalposition.

2. Description

AVR

%

Min

Hz

kVA

kW

6

7

8

6

ON/OFFbuttonforthe

batterybackupoutlets

7

Scrolldown

8

Mutealarm

LCD

16

15

14

17

11

10

9

12

13

9

UPSON

10

AVRmode

11

Batterymode

12

Internalfault

13

Outputloadlevel

14

Batterylevel

15

Inputmeasurements

16

Outputmeasurements

17

Measuringunit

Outlets

20

21

19

18

20

21

19

18

Surgeprotectionoutlets

19

Batterybackupoutlets

20

Protection(circuitbreaker)

21

ACInputCord

7

614-06818-01

ENGLISH

3. UPS connections

• ConnecttheUPS

1

totheAC-powersystemviaawalloutletwithanearthconnector,

usingtheattachedcord

21

(seegureA).

• Plugcriticalequipment(computer,monitor,modem,etc.)intotheoutlets

19

providing

batterybackuppowerandsurgeprotection(seegureB),takingcarenottoexceed

theratedcurrentindicatedinamperes.

• Otherdevices(printer,scanner,fax,etc.)canbeconnecttothesurgeprotectionoutlets

18

(seegureB).Thesurgeprotectionoutletsarenotbackedupbybatterypowerin

theeventofapoweroutage.

Optional Internet modem / Network connection:

AmodemorEthernetdatalinecanbeprotectedagainstsurgesbyconnectingitviathe

UPS.ConnecttheexistingdevicecablebetweenthewalloutletandtheUPS,andusea

similarcablebetweentheUPSandthedevice,asindicatedinguresCandD(cablenot

supplied).

Optional USB connection:

TheUPSdevicecanbeconnectedtothecomputerusingtheUSBcable

4

supplied

(seegureC).

EatonUPSCompanionsoftwareisdownloadablefrompowerquality.eaton.com.

Registerforthewarrantyonpowerquality.eaton.com.

4. Master and EcoControl outlets operating procedure

Inordertolimitenergyconsumptionofperipherals(scanner,printer)instandbymode,

theEaton5SisequippedwithEcoControloutletsthataredependentontheMaster

outlet.WhenthemaindevicesuppliedbytheMasteroutlet(computer)isshutdown,the

EcoControloutletsareautomaticallydeactivatedandtheperipheralsshutdown.

Thisfunction(deactivatedbydefault)isvalidatedandconguredusingtheconguration

toolintegratedinthesoftware.

Note: when the function is activated, do not connect critical applications to EcoControl outlets.

Threshold setup

AdefaultsetupensuresthecorrectoperationoftheEcoControlfunction.However,

dependingontheconsumptionofthemainload,thetriggerthresholdoftheEcoControl

functionmayhavetobemodiedusingthecongurationsoftwaresuppliedwiththe

UPS:

• First,makesurethatthefunctionisactivatedinthe"EcoControlFunction"tabofthe

congurationtool.

• IftheperipheralsconnectedtotheEcoControloutletsdonotswitchoffwhenthemain

loadisnotinnormaloperation(ex:wheninstandbymode),thedetectionthreshold

valuemustbesettoHigh.

• IftheratedconsumptionlevelofthemainloadislowandtheEcoControloutletsshut

downwhenthemainloadisoperatingnormally,thedetectionthresholdvaluemust

besettoLow.

8

614-06818-01

ENGLISH

6. Operation

Battery charge

TheUPSchargesthebatteryassoonasitisconnectedtotheACoutlet,whetherbutton

6

ispressedornot.Whenusedforthersttime,thebatterywillonlyprovideits

maximumperformanceafterithasbeenchargedfor8hours.Itisrecommendedthat

theUPSbepermanentlyconnectedtotheACpowersupplytoensurethebestpossible

performance.

Switching-on the UPS

Pressbutton

6

forabout1second.

Surge protection outlets

18

without battery backup

EquipmentconnectedtotheseoutletsissuppliedassoonastheACcord

21

isplugged

in.Theyarenotaffectedbybutton

6

.

Battery backup outlets

19

Equipmentconnectedtotheseoutletsissuppliedassoonasbutton

6

turnsgreen

(seegureE).

TheseoutletscanbeturnedoneveniftheUPSisnotconnectedtoACpower

(button

6

ashes).

5. UPS setting through the LCD

l LCDshutoffifnoactivityfor3minutes.

5s 2s 2s

EcoControl Alarm

Release scroll down button to select menu

Save the new value

10s 5s 5s

Example of setting

9

614-06818-01

ENGLISH

(Forfurtherinformation,visitthewww.powerquality.eaton.comsiteorcontactpost-salessupport.)

Problem Diagnostic Solution

1

•Thebatterybackupoutlets

19



arenotsuppliedwithpower.

•Button



6



isnotliteon. •Pressbutton

6



andcheckthat

itturnsgreen.

2 •Theconnecteddevicesarenot

suppliedwhenACpowerfails.

•Thedevicesarenotconnected

tothebatterybackupoutlets

19

.

•Connectthedevicestothe

batterybackupoutlets

19

.

3 •ACpowerisavailable,butthe

UPSoperatesonbatterypower.

•Circuitbreaker

20

,locatedat

therearoftheUPS,hasbeen

trippedbyanoverloadonthe

UPSoutput.

•Disconnectexcessequipment

andresetthecircuitbreaker

20



bypressingthecorresponding

button.

4

•Greenbutton



6



ashesand

audiblealarmbeepsevery3

seconds.

•TheUPSbatterybackupoutlets

19

areoverloaded.

•Disconnectexcessequipment

connectedtothebatterybackup

outlets

19

.

5

•Faultsign

12

appearontheLCD

panelandaudiblealarmbeeps

continuously.

•AfaulthasoccurredontheUPS.

Thebatterybackupoutlets

19

are

nolongersupplied.

•Callpost-salessupport.

6 •EcoControloutletskeeppowered

whenmainapplication(Master

outlet)isstopped.

•EcoControlfunctionisnot

activatedornotproperlyset.

•Activateorsetproperly

EcoControlfunctionusingthe

softwareprovidedwiththe

product.

7. Troubleshooting

AC-power disturbance

• IfACpowerisdisturbedorfails,theUPScontinuestooperateonbatterypower.

Button

6

ashesgreen.Innormalmode,theaudiblealarmbeepseverytenseconds,

theneverythreesecondswhentheendofbatterybackuptimeisnear.Insilentmode,

theaudiblealarmsimplybeepsoncewhentheUPStransferstobatterypower.

• Ifthepoweroutagelastslongerthanthebatterybackuptime,theUPSshutsdown

andautomaticallyrestartswhenpowerisrestored.Followingacompletedischarge,a

fewhoursarerequiredtorechargethebatterybacktofullbackuptime.

Surge protection:

Alloutletsincludesurgeprotection.

Shutdown of the battery backup outlets

19

Pressbutton

6

formorethantwoseconds.

Page is loading ...

www.eaton.com

614-06818-01

Eaton 5S 1000 Installation and User Manual

This manual is also suitable for

Eaton 5S 1000 Installation and User Manual

in other languages

Related papers

Other documents