AirScape SAF10R Installation guide

AirScape Solar Attic Fan

        InstallationManual

           SAF10R

           SAF25R

          

ThankyouforpurchasingtheAirScapeSolarAtticFan.Pleasetakethetimeto

readthroughtheentireinstructionspriortostartinganywork.

***View our Solar Attic Fan Installation Video on our website airscapefans.com

Tools Required

ReciprocatingSaw  MarkingPen  MeasuringTape String  

RazorKnife   ScrewGun  CaulkingGun  Ladders 

6,#61½PhillipsHeadScrews Prybar Nail & Hammer

Solar Attic Fan Components

Custom Solar Panel

Adjustable Panel Bracket

Aluminum Shroud

Precision Pitch Blade

Brushless DC Motor

Wire Mesh

Aluminum Flashing

Easy Steps

Step 1

ChoosealocationfortheSolarAtticFanon

thesouthsideoftheroof,consideringpotential

problemsliketrees,chimneyetc.Theymay

shadethesolarpanelduringcertaintimesof

theday,reducingruntime.

Ifasouthernexposureisnotpossible,thefan

canbeinstalledonanyotherexposureandthe

solarpanelcanbeadjustedtocapturemaxi-

mumsunlight.Note:TheSolarAtticFanmust

beinstalledbetweenroofrafters.

Step 2

Usingeitherastringortemplate,createa14½

inchcircleontotheroofshingles.

Step 3

The Solar Attic Fan must be installed

between roof rafters. Do not cut through

any framing member.

Withareciprocatingsaw,cutthecircumferenceof

thehole.

Step 4

Withrazorknife,cuta4inchslitthroughthe

shinglesandtarpaper,onoppositesidesof

theashing.Thisprovidesthefootprintforthe

ashingtobeinsertedundertheshingles.

Step 5

Removeanyroongnailsintheareawherethe

basewillbeslidundertheshingles.

Step 6

Layabeadofsiliconesealantaroundthebase

oftheashing.

Step 7

Slidetheashingunderneaththetarpaper

andshingles.Adjusttheashingupuntilthe

shinglescomeintocontactwiththeraised

portionoftheashing.Thebottomsideofthe

ashingwillbeontopoftheshingles.

Step 8

Positionthefourscrewsaroundtheashing.

Twoscrewsgooneitherside,andtheremain-

ingtwogoonthetopandbottom.Theside

screwsshouldgounderneaththeshingles.The

topandbottomscrewsshouldgoontopofthe

shingles.

Layabeadofsiliconesealantovereach

fastenerheadandalongtheedgestoseal

shinglestothebaseorroofdecking

Step 9

Layabeadofsiliconesealantalongtheedge

oftheshaftbasetoensureawaterproofseal.

Step 10

Adjustthepanel.

1.Choosethelocationcarefullytoensureop-

timalsunexposurethroughouttheday.Check

foranyshadeontheroofcreatedbytreesora

chimney.

2.Measureonceandcuttwice.Takea

minutetocreateatemplatethatwillcreatethe

correctdimensionsforyourcut.

3.CentertheAirScapeSolarAtticFanap-

proximately2feetawayfromtheroofridgeto

facilitategoodcirculation.

4.Beforeyoubegin,gentlycleananyoilresi-

duefromtheashing.

5.Useahighqualitysiliconesealanttoen-

sureagoodwaterproofseal.

Handy Tips

6.YourSolarAtticFanhasbeenfactory

equippedwithathermalon/offswitch,de-

signedtoturnthefan:

On: 80° F

Off: 80° F

(+/- 1°)

Astheattictemperaturerisesto80°thefan

willautomaticallyturnon.Oncetheatticcools

to80°thefanwillshutoff.

Youcanremovethesolaratticfanthermal

switch,thefanthenwilloperateonlywhen

thereissunshine,andshutoffatdusk.

625 Charles Way,

Medford, Oregon 97501

PST 9:00 am to 5:00 pm

[email protected]

www.airscapefans.com

Hardware

 AirScapewarrantstheoriginalenduser(“Customer”)thatnew

AirScapefanproducts,includingallmovingparts,motors,damp-

ers,anddamperactuatorswillbefreefromdefectsinworkman-

shipandmaterials,undernormaluse,forthree(3)yearsfromthe

originalpurchasedate.

 Exclusions

 Thiswarrantyexcludes(1)physicaldamagetothesurfaceof

theproduct,includingcracksorscratchesontheoutsidecasing;

(2)damagecausedbymisuse,neglect,improperinstallation,

unauthorizedattemptstoopen,repair,ormodifytheproduct,or

anyothercausebeyondtherangeofintendeduse;(3)damage,

causedbyaccident,re,powerchanges,otherhazard,orActsof

God;or(4)useoftheproductwithanyunauthorizeddeviceifsuch

devicecausestheproblem. 

Exclusive Remedies

 Shouldacovereddefectoccurduringthewarrantyperiodand

CustomernotiesAirScape,Customer’ssoleandexclusive

remedywillbe,atAirScape’ssoleoptionandexpense,torepairor

replacetheproduct.Replacementproductsorpartsmaybenew

orreconditionedoracomparableversionofthedefectiveitem.

AirScapewarrantsanyreplacedproductorpartforaperiodof

ninety(90)daysfromshipment,orthroughtheendoftheoriginal

warranty,whicheverislonger.

Obtaining Warranty Service

 CustomermustcontactandreturnproducttoAirScape,Product

dealerorInstallerwithintheapplicablewarrantyperiodtoobtain

warrantyservice.Datedproofoforiginalpurchasewillberequired.

AirScapewillnotberesponsibleforCustomer’smemorydata

containedin,storedon,orintegratedwithanyproductsreturnedto

AirScapeforrepair,whetherunderwarrantyornot.

Warranty Exclusive

 Theforgoingwarrantiesandremediesareexclusiveandinlieuof

allotherWarranties,expressorimplied,includingwarrantiesof

merchantability,Fitnessforaparticularpurpose,correspondence

withdescription,andNon-infringement,allofwhichareexpressly

disclaimedbyAirScapeanditssuppliers.

 Disclaimer

 NeitherAirScapenoritssuppliersshallbeliableforincidental,

consequential,indirect,special,orpunitivedamagesofanykind,

ornanciallossarisingoutoforinconnectionwiththesaleoruse

ofthisproduct,whetherbasedincontract,Tort(includingnegli-

gence)oranyothertheory,evenifAirScapehasbeenadvisedof

thepossibilityofsuchdamagesAirScape’sentireliabilityshallbe

limitedtoreplacementorrepairoftheproduct.

AirScape SAF10R, SAF25R Installation guide

Related papers

Other documents