Tree Frogs Rainforest Cottage Install Manual

Tools Needed for Assembly

Tape Measure 24” Level Angle Square

Phillips Screw Driver

3/8” Cordless Drill or Electric Drill

3/8” Drive Ratchet or Electric Impact Gun

Claw Hammer or Rubber Mallet

Pliers or Vise Grips 7/16” Deep Well Socket

9/16” Deep Well Socket 3/4” Deep Well Socket 1/8”, 1/4”, and 9/16” Drill Bits

Phillips Head Screw Bits An Adult with two Adult Helpers

Please familiarize yourself with the install manual, parts/components and general construction process of your new swing set before

getting started. Approximate assembly time: 6 to 8 hours. 6 foot unobstructed safety perimeter around swing set recommended.

Rainforest Cottage

Install Manual

Version 2.17

When choosing a location for your swing set, always keep your child or children’s safety in mind. Here

are some recommendations to help you locate and install a safe play area.

●

This play set is designed for the use of 4 occupants who have a combined weight not exceeding 800 pounds

ontheelevatedoor;3occupantswhohaveacombinedweightof525poundsontheswingarea;foratotalUnit

capacityof5occupantswhohaveacombinedweightof1325.(thisweightisnotincludingthepicnictablearea)

● On-siteadultsupervisionisrequired.

●

The swing set should be located on level ground. The stationary components such as ladders and slides

are required to be a minimum of six feet from any structure or obstruction such as a fence, garage, house,

tree, overhanging branches, electrical wires, clotheslines, etc. Any swinging equipment is also required to be a

minimum distance twice the height of the swing beam away from these obstructions or structures as well. The

swing set should be located a safe distance from any water hazards, such as a lake, river, bayou, swimming pool, etc.

● Donotinstallthisresidentialswingsetinacommercialsetting.Thisswingsetisnotmanufactured

for commercial usage and will void all warranties. Tree Frogs Wooden Swing Set Factory is not

responsible for any damages or injuries resulting from this swing set being used in a commercial setting.

● Neverinstallthisswingsetindoors;oroverconcrete,asphalt,packedearth,grass,carpetoranyother

hard surface. A fall onto a hard surface can result in serious or fatal injury.

●

TheU.S.ConsumerProductSafetyCommission(CPSC)recommendsthatyouinstallandmaintainaresilient

surface under your swing set. The CPSC’s Consumer Information Sheet for Playground Surfacing Materials is on

the next page. A resilient surface, should be installed after the swing set has been completely assembled according

to these instructions. The swing set must rest on solid ground. Please note that this swing set has a maximum fall height of 7’.

Here are some maintenance tips required to insure safe play on your swing set for years of fun.

●

At the beginning of each usage season and every two weeks during, check: nuts and bolts and tighten as needed,

swing seats, chains, ladders, slides, rope and wood components for sign of deterioration and replace if necessary.

●

On a yearly basis, we recommend that you coat your swing set with a sealant or preservative. You may also want

to spot sand any areas prior to sealing.

** Special note: Although we recommend that you reseal your swing set annually, you may have to touch up the high

tracareasand/orareasthathaveahighexposuretodirectsunlight.**

●

Besurethatthesealantyouselectisnon-toxicandchildsafe.YourlocalTreeFrogsWoodenSwingSetFactory

 dealermayoeracompletepowerwashandresealandmaintenanceprogram.

●

Do not use line trimmers or “weed eaters” around your swing set. The line will remove both paint and wood from

uprights and base pieces. Any damage resulting from this type of abuse is not covered under our limited warranty.

●

Remove plastic swing seats and take in doors or do not use when temperature drops below 0°F.

Please keep this install manual for future reference.

Weight Limits for Tree Frogs Swing Sets

FortPlatform:800Lbs.TotalWeight SwingBelts:175Lbs.  Trapeze:125Lbs.

FullBucketSwing:50Lbs.  ToddlerBucketSwing:50Lbs. TireSwing:125Lbs.TotalWeight

RopeLadder:75Lbs.   RockWall:150Lbs.  AllSlides:125Lbs.

Tree Frogs recommends that the weight limits for all components must not be exceeded. Failure to adhere to these and

other safety guidelines could result in damage to the swing set and/or injury to the users.

To insure SAFE PLAY adults must teach children:

● Nottowalkcloseto,infrontof,behind,orbetweenmovingitems.

● Nottoswingemptyswingseats.

● Nottoswingsidewaysintothepathofadjacentswings.

● Nottousetheswingsetinamannerotherthanthatforwhichitisintended.

● Nottogetotheequipmentwhileitisinmotion.

● Nottojumpothetower.

● Nottostandintheswingseats.

● Nottoswingsohighthatchainsbecomeslack,orabovetheheightoftheswingsupport.

● Nottojumponaslide.

● Nottoclimbontopoftheswingsupport.

● Nottoattachtotheswingsetanyitemthatisnotspecicallydesignedforusewiththeequipment,

 suchas(butnotlimitedto)jumpropes,clotheslines,petleashes,cables,andchains.Thesemay

become strangulation hazards.

● Toholdontoswingsandclimberswithbothhands.

● Toslidefeetrst,neverheadrst.

● Towatchforotherchildrenwhileswingingorplayingneartheswingset.

To also insure SAFE PLAY adults must:

● Limitclimbingandswingingheightstoeachchild’sability.

● Verifythatsuspendedclimbingropesaresecuredatbothends.

● Verifythatsuspendedclimbingropescannotbeloopedbackonthemselves.

● Dresschildrenappropriatelyforplay.Usewell-ttedshoesthatdonothaveslipperysoles.

● Avoidponchos,scarves,hoods,loosettingclothing,neckties,andanyclothingwithadrawstring.

Serious injury could result should any part of the children’s clothing become entangled in the swing set.

● Donotallowchildrentoplaywearinghelmets.

●

Remember that children are inventive. When they develop games that are unsafe, be alert and change the rules.

IMPORTANT-PLEASEREAD

As fresh lumber acclimates to its new environment, the natural tendencies of the tree can show itself in the form of

checks,or“cracks”inthelumber.Inalmostallcasesthisisnormalanditwillnotaectthestructuralintegrityofyour

play set.

Cosmeticdefectsthatdonotaectthestructuralintegrityoftheproduct,ornaturaldefectsofwoodsuchaswarping,

checking or any other physical properties of wood that do not present a safety hazard, are not covered by this warranty.

Defects that develop because the product is exposed to extreme climate conditions are not covered by this warranty.

Defects that develop as a result of faulty or improper installation of the product are also not covered by this warranty.

Most cracks are not warrantable, however if you believe that the integrity of your play set is compromised by this

natural occurrence, please contact the Tree Frogs Swing Set Dealer that you purchased your swing set from.

We appreciate your purchase and know that you will enjoy your play system for many years to come.

●

Depending on your experience, assembly of our play sets can take as little as 6 hours up to 24 hours, depending on size, after

 inventoryofparts;therefore,werecommendyousetasideafulltwodaysforassembly.

● Identifyallofthepartsforyourplayset.Emptyeachboxandlayoutboardssoyoucanseeeachpart.Yourinstructionbookwill

have detailed drawings that will make it easy for you to recognize individual parts. Keep all hardware and metal parts separate

from wooden pieces.

● Aftereverythingislaidout,checkcarefullytoensureallpartsarepresent.Makesuretherearenobrokenboards.

● Findanareatosortyourhardware.Itisbesttoopenthehardwareonasolidsurfacesothatyoudonotloseanypiecesinthegrass.

 Thiswillsavetimeandfamiliarizeyouwithallthedierentpiecesinthehardwarebag.

**Important note: Wood has some natural defects such as knots, surface cracks, etc... We reject parts that are structurally defective. We use

ahighqualitylumberinourstructures;however,youshouldinspecteachpartforsplintersorroughspotsandsandthemsmoothtoprevent

injury.**

● Afterfamiliarizingyourselfwithallofthecomponents,readallinstructionsthoroughly.Readinginstructionsafteryouhave

studied the parts will help you understand more clearly the installation process, and help to eliminate unnecessary mistakes.

● Paycloseattentiontothediameterandlengthofeachboltandscrew.

● Nevertightenhardwarecompletelyatrst.Ithelpstohavesomeadjustmentforboltalignmentwhileyouareattachingparts

together. After everything is square, tighten each joint.

● Afterthemainunitisassembleditiscriticalthattheoorislevelandsquare.Ifthemainframeisnotlevel,thewallsandoor

will be out of square.

● Afteryoucompleteinstallation,makesureeverybolt,screw,andnutistight,andeveryboardissecure.Woodwillexpandand

contract with the seasons.

● Placethesetonlevelground,notlessthan6ftfromanystructureorobstructionsuchasafence,garage,house,overhanging

branches, laundry lines, or electrical wires.

● All1/4”and3/8”lagboltsmusthavepre-drilledholes1-1/2”to2”deep.Usea1/8”drillbitforthe1/4”lagboltsand1/4”drillbit

 for3/8”lagbolts.Usepre-drilledholesinfaciasasareferenceforplacinglagboltpilotholes.

● Ifaboardliftsorrisescausingagapbetweenboardswhenrunninginlagboltsorscrews,backoutthescreworlagboltandpress

 orapplypressure(butnotenoughtocrackorbreakboard)whilere¬runninginthelagboltorscrewinthesamehole.

● Donotovertightenbolts,lagboltsorscrews.Youcandamageboards,breakhardware,and/orstripoutthehardware.

● Whenusinghammerdonotbeatonthehardware,butgentlytapitin.Neverbeatonthewoodasitwillleavemarks.

● Completethestepswhichwillbethebasicframeofthefort{i.e.fourcornerpostswithbase(sandboxboards)anddecksupports}

●

Positioninthemostlevelareachosenfortheplayset,keepinginmindthelocationandsizeoftheswingbeam,ladder,slides,etc.thatextendothefort.

●

Oncetheframeisinthenalposition,checkforverticalandhorizontallevelnesstodeterminewhichside(s)willneedtobedugintothegroundtoleveltheplayset.

● Withashovel,scorethegroundaroundtheoutsideedgesofthesandboxboardsonthe‘high’sideofthefort.Thisistheareathat

 willbedugin.Makesuretoscoredeepenough;thescoredlineswillbeyourdiggingtemplate.

● Pushtheframeoandawayfromthescoredarea,farenoughtodigandremovedirttoreachtheappropriatedepth.

●

Digachannelalongthescoredline(s)forthebaseofthefort(cornerpostandsandboxboards)torestinto.Digthechannel(s)tothesamelevel

 depth.Thebottomofthechannel(s)shouldbeleveltoeachothersoyourframedoesn’tteeterorrockbecausethechannel(s)areuneven.

● Onceyouhaveremovedenoughgrassanddirt,slide/pushtheframeintothechannel(s).Placealevelontheverticalandhorizontal

boards of the frame to determine if enough soil, or too much, was removed.

● Repeatthisprocessuntilthebasicframeisplumbandlevelandinitsnalpositionbeforecompletingtherestoftheassembly.

● Measuretomakesurefortissquare.

** Important: if you require a channel depth of more than 6”,

then we recommend you have your play set area professionally graded before completing assembly. **

CONSUMER INFORMATION SHEET FOR PLAYGROUND SURFACING MATERIALS

TheU.S.ConsumerProductSafetyCommission(CPSC)estimatesthatabout100,000playgroundequipmentrelated

injuries resulting from falls to the ground surface are treated annually in U.S. hospital emergency rooms.

Injuries involving this hazard pattern tend to be among the most serious of all playground injuries, and have the

potential to be fatal, particularly when the injury is to the head. The surface under and around playground equipment

canbeamajorfactorindeterminingtheinjury-causingpotentialofafall.Itisself-evidentthatafallontoashock-

absorbing surface is less likely to cause a serious injury than a fall onto a hard surface. However, it should be

recognized that some injuries from falls will occur no matter what playground surfacing material is used.

Playground equipment should never be placed on hard surfaces such as concrete or asphalt. Grass may appear to be

acceptable,butcanturntohardpackedearthinareasofhightrac.Shreddedbarkmulch,woodchips,ornegravel

areconsideredtobeacceptableshockabsorbingsurfaceswheninstalledandmaintainedatasucientdepthunderand

around play equipment.

TABLE1-CRITICALHEIGHTS(infeet)OFTESTEDMATERIAL

MATERIAL UNCOMPRESSED DEPTH COMPRESSED DEPTH

6 Inch 9 Inch 12 Inch 9 inch

Wood Chips 7 10 11 10

Double Shredded Bark Mulch 6 10 11 7

Engineered Wood Fibers 6 7 >12 6

FineSand    5 5 9   5

CoarseSand    5 5 6   4

Fine Gravel 6 7 10 6

MediumGravel   5 5 6   5

ShreddedTires**   10-12N/A N/A   N/A

** This is data from tests conducted by independent testing laboratories on a 6 inch depth of uncompressed shredded

tire samples produced by four manufacturers. The test reported critical heights, which varied from 10 feet to greater

than 12 feet. It is recommended that persons seeking to install shredded tires as a protective surface request test data

from the supplier showing the critical height of the material when it was tested in accordance with ASTM F1292.

Table 1 should be read as follows: If, for example, uncompressed wood chips are used at a minimum of 6 inches, the

Critical Height is 7 feet. If 9 inches of uncompressed wood chips are used, the Critical Height is 10 feet. It should

be noted that, for some materials, the Critical Height decreases when the material is compressed. It is recommended

that a shock absorbing material should extend a minimum of 6 feet in all directions from the perimeter of stationary

equipment such as climbers and slides. However, because children may deliberately jump from a moving swing, the

shock absorbing material should extend in the front and rear of a swing a minimum distance of 2 times the height of the

pivot point measured from a point directly beneath the pivot on the supporting structure.

Thisinformationisintendedtoassistincomparingtherelativeshock-absorbingpropertiesofvariousmaterials.No

particularmaterialisrecommendedoveranother.However,eachmaterialisonlyeectivewhenproperlymaintained.

Materials should be checked periodically and replenished to maintain correct depth as determined necessary for your

equipment. The choice of a material depends on the type and height of the playground equipment, the availability in

your area, and its cost.

ThisinformationhasbeenextractedfromtheCPSCpublications“PlaygroundSurfacing-TechnicalInformationGuide”

and “Handbook for Public Playground Safety.” Copies of these reports can be obtained by sending a postcard to:

OceofPublicAairs

U.S. Consumer Product Safety Commission

Washington, D.C. 20207

Toll-freeHotline:1-800-638-2772orathttp://www.cpsc.gov

Item No. Part No. Part Description QTY.

4

2

1

31

4

3

2

1

4

1

6

3

2

16

4

3

4

1

3

1

2

1

2

1

2

14

2

5

1

2

6

7 5/8” WOOD ROOF FAN BOARD #1

13 1/16” WOOD ROOF FAN BOARD #2

5 3/4” CHIMNEY BLOCK #3

7” CHIMNEY BLOCK #4

25 13/16” WOOD ROOF FAN BOTTOM

48 1/16” WOOD ROOF TOPPER

52 3/16” WOOD ROOF TOPPER

25 1/2” RAIL PICKET

37 15/16” PICNIC SEAT BOARD

12” SHORT 2-HOLE FACIA

16” TIC TAC TOE BOARD

21” CENTER SUPPORT FACIA

33 3/4” WOOD ROOF CENTER SUPPORT

44” PICNIC SEAT BOARD

44” SLIM 4- HOLE FACIA

56 13/16” LADDER SIDE RAIL SUPPORT FACIA

92 5/8” ROPE HOLE FACIA

92 5/8” UPPER 6-HOLE FACIA

48 1/16” WOOD ROOF TOPPER #2

52 3/16” WOOD ROOF TOPPER #2

44” PICNIC TABLE BOARD

8 3/8” WOOD ROOF PEAK

25 1/2” TIC TAC TOE FILLER ARCH

44” DECK BOARD

28” 1-ROCK ROCKWALL BOARD

28” 2- ROCK ROCKWALL BOARD

28” BLANK ROCKWALL BOARD

28” ROCKWALL BOARD W/ ROPE HOLE

44” 4- HOLE FACIA

44” 6- HOLE FACIA

44” PICNIC SEAT BOARD

92 5/8” DECK SUPPORT

92 5/8” 10- HOLE FACIA

92 5/8” LADDER SIDE RUNNER

92 5/8” ROCKWALL SIDE RUNNER

8 13/16” WOOD ROOF FAN PLATE

15 3/8” PICNIC SEAT BENCH SUPPORT

17” GUSSET

18 3/16” OUTSIDE PICNIC BENCH SUPPORT

22” LADDER STEP

23 3/4” LADDER SUPPORT

32 5/8” PICNIC TABLE SUPPORT

35” WOOD ROOF SUPPORT

RFC-1

RFC-2

RFC-3

RFC-4

RFC-5

RFC-6

RFC-7

RFC-8

RFC-9

RFC-10

RFC-11

RFC-12

RFC-13

RFC-14

RFC-15

RFC-16

RFC-17

RFC-18

RFC-19

RFC-20

RFC-21

RFC-22

RFC-23

RFC-24

RFC-25

RFC-26

RFC-27

RFC-28

RFC-29

RFC-30

RFC-31

RFC-32

RFC-33

RFC-34

RFC-35

RFC-36

RFC-37

RFC-38

RFC-39

RFC-40

RFC-41

RFC-42

RFC-43

Rainforest Cottage- Base Lumber

Item No. Part No. Part Description QTY.

2

1

2

1

2

1

2

1

16

8

65 1/8” ROCKWALL SUPPORT LEG

69 7/16” LEFT LADDER LEG

69 7/16” RIGHT LADDER LEG

35” WOOD ROOF EXTENSION

92 5/8” MAINBEAM

11 1/8” PICNIC SEAT LEG

18 3/16” TRAPEZE GUSSET

24 1/8” PICNIC TABLE LEG

44” SWINGBEAM TOP JOIST

76 3/8” TRAPEZE ARM

103” CENTER POST

103” CORNER POST

108 1/2” CORNER POST

9 9/16” CHIMNEY BLOCK #2

13” CHIMNEY BLOCK #1

48 1/16” SB SIDE WOOD ROOF BOARD

52 3/16” (L) WOOD ROOF BOARD- TRAPEZE

52 3/16” (R) WOOD ROOF BOARD-TRAPEZE

RFC-44

RFC-45

RFC-46

RFC-47

RFC-48

RFC-49

RFC-50

RFC-51

RFC-52

RFC-53

RFC-54

RFC-55

RFC-56

RFC-57

RFC-58

RFC-59

RFC-60

RFC-61

Rainforest Cottage- Base Lumber

Rainforest Cottage- Treehouse Panel Lumber

1

12

2

13

4

2

4

1

2

11

2

6

8

1

26 1/2” LOWER SB SIDE PANEL BOARD

10 1/16” UNDER FAN BOARD

26 1/2” PANEL BOARD

6 1/4” UPPER LEMONADE BOARD

10 1/2” UNDER FAN ANGLE CUT

11 1/4” (L) SHUTTER FOR TRAPEZE SIDE

11 1/4” (R) SHUTTER FOR TRAPEZE SIDE

12” (L) WINDOW SHUTTER FOR SIDE

12” (R) WINDOW SHUTTER FOR SIDE

14 1/4” LOWER LEFT SHUTTER

14 1/4” LOWER RIGHT SHUTTER

16 3/4” (L) SB SHUTTER

16 3/4” (L) SB SIDE SHUTTER

16 3/4” (R) SB SHUTTER

16 3/4” (R) SIDE SHUTTER

23 1/16” CORNER ANGLE BOARD

26 1/2” LOWER PANEL BOARD

28 13/16” CORNER ANGLE BOARD SB SIDE

44 1/2” LOWER PANEL BOARD

17 1/4” UPPER PANEL BOARD

17 1/4” UPPER PANEL BOARD FOR SHUTTERS

24 9/16” SB SIDE UNDER FAN CENTER BOARD

RFTP-1

RFTP-2

RFTP-3

RFTP-4

RFTP-5

RFTP-6

RFTP-7

RFTP-8

RFTP-9

RFTP-10

RFTP-11

RFTP-12

RFTP-13

RFTP-14

RFTP-15

RFTP-16

RFTP-17

RFTP-18

RFTP-19

RFTP-20

RFTP-21

RFTP-22

Item No. Part No. Part Description QTY.

2

1

15

2

1

2

1

2

1

2

1

2

26 1/16” UPPER PANEL BOARD FOR SHUTTER

26 1/16” UPPER PANEL BOARD FOR END

26 1/2” RAIL PICKET FOR TREEHOUSE

31 9/16” SB SIDE UPPER CENTER BOARD

8 1/4” CENTER WOOD ROOF SUPPORT

12 3/4” LEMONADE WOOF ROOF SUPPORT

28 11/16” PANEL SUPPORT

44” SLIM 4- HOLE FACIA

47 13/16” WINDOW ARCHES

32 1/4” LEMONADE STAND COUNTER

44” WINDOW TOP

44” LEMONADE FACIA

44” LEMONADE 4 HOLE FACIA

45 3/4” LEMONADE WOOD ROOF BOARD

RFTP-23

RFTP-24

RFTP-25

RFTP-26

RFTP-27

RFTP-28

RFTP-29

RFTP-30

RFTP-31

RFTP-32

RFTP-33

RFTP-34

RFTP-35

RFTP-36

Rainforest Cottage- Treehouse Panel Lumber

Rainforest Cottage- Swingbeam Lumber

1

2

1

7 5/8” CENTER A-FRAME BLOCK

12 7/8” A-FRAME BLOCK

12 7/8” A-FRAME BLOCK SINKED

68” A-FRAME CROSSMEMBER

113” A-FRAME LEG

122 3- POSITION SWINGBEAM

SBL-1

SBL-2

SBL-3

SBL-4

SBL-5

SBL-6

Item No. Part No. Part Description QTY.

Rainforest Cottage- Base Hardware

14

151

76

4

6

10

4

10

96

2

8

132

20

4

26

8

3/8” ACORN NUT PLATED

1 5/8” COATED DECK SCREW

2 1/2” COATED DECK SCREW

3/8” HEX NUT

3/8” 4-PRONG T-NUT

3/8” X 4 1/2” HEX BOLT

3/8” X 6” HEX BOLT

1/4” X 1 1/2” HEX LAG SCREW

1/4” X 3” HEX LAG SCREW

3/8” X 3 1/2” HEX LAG SCREW

3/8” SPLIT LOCKWASHER

1/4” USS FLATWASHER

3/8” USS FLATWASHER

3/8” NYLON INSERT LOCKNUT

#14 X 1” PAN PHILLIPS T/S

3/8” BOLT CUP

40-1-00001

40-1-00020

40-1-00022

40-1-00026

40-1-00080

40-1-00042

40-1-00117

40-1-00053

40-1-00055

40-1-00059

40-1-00073

40-1-00081

40-1-00082

40-1-00064

40-1-00122

41-1-00025

RFH-1

RFH-2

RFH-3

RFH-4

RFH-5

RFH-6

RFH-7

RFH-8

RFH-9

RFH-10

RFH-11

RFH-12

RFH-13

RFH-14

RFH-15

RFH-16

Rainforest Cottage- Picnic Table Hardware

48

24

28

4

2 1/2” COATED DECK SCREW

1/4” X 3” HEX LAG SCREW

1/4” USS FLATWASHER

1/4” X 2” HEX LAG SCREW

40-1-00022

40-1-00055

40-1-00081

40-1-00054

PTH-1

PTH-2

PTH-3

PTH-4

Rainforest Cottage- Wood Roof Hardware

6

8

24

32

8

188

3/8” 4-PRONG T-NUT

3/8” BOLT CUP

3/8” X 4 1/2” HEX BOLT

2 1/2” COATED DECK SCREW

2” COATED DECK SCREW

1 1/2” COATED DECK SCREW

1/4” USS FLATWASHER

1/4” X 2” HEX LAG SCREW

1 5/8” COATED DECK SCREW

40-1-00080

41-1-00025

40-1-00042

40-1-00022

40-1-00104

40-1-00123

40-1-00081

40-1-00054

40-1-00020

WRH-1

WRH-2

WRH-3

WRH-4

WRH-5

WRH-6

WRH-7

WRH-8

WRH-9

Item No. Part No. Part Description QTY.

Rainforest Cottage- Rockwall Hardware

48

22

28

6

2

2” COATED DECK SCREW

1/4” X 1 1/4” PAN PHILLIPS M/S

1/4” 4-PRONG T-NUT

1/4” USS FLATWASHER

#14 X 1” PAN PHILLIPS T/S

3/8” 4-PRONG T-NUT

3/8” X 1 1/2” HEX BOLT

3/8” USS FLATWASHER

40-1-00104

40-1-00066

40-1-00077

40-1-00081

40-1-00122

40-1-00080

40-1-00041

40-1-00028

RWH-1

RWH-2

RWH-3

RWH-4

RWH-5

RWH-6

RWH-7

RWH-8

Rainforest Cottage- Step Ladder Hardware

24

2

14

2

2 1/2” COATED DECK SCREW

3/8” 4-PRONG T-NUT

#14 X 1” PAN PHILLIPS T/S

1/4” USS FLATWASHER

3/8” X 1 1/2” HEX BOLT

3/8” USS FLATWASHER

40-1-00022

40-1-00080

40-1-00122

40-1-00081

40-1-00041

40-1-00082

SLH-1

SLH-2

SLH-3

SLH-4

SLH-5

SLH-6

Rainforest Cottage- Slide Hardware

3

1/4” USS FLATWASHER

1/4” X 1” PAN PHILLIPS M/S

1/4” 4-PRONG T-NUT

40-1-00081

40-1-00065

40-1-00077

SH-1

SH-2

SH-3

Rainforest Cottage- Tic Tac Toe Hardware

81 5/8” COATED DECK SCREW40-1-00020TH-1

Item No. Part No. Part Description QTY.

10

8

2

4

1

2

8

2

8

10

8

14

9

7

2

1

10

3/8” ACORN NUT PLATED

1/2” ACORN NUTPLATED

1/2” X 3 1/2” CARRIAGE BOLT

1/2” X 7” CARRIAGE BOLT

1/2” X 9” CARRIAGE BOLT

3/8” HEX NUT

1/2” HEX NUT

3/8” X 7” HEX BOLT

3/8” X 3 1/2” HEX LAG SCREW

3/8” X 5” HEX LAG SCREW

3/8” NYLON INSERT LOCKNUT

3/8” SPLIT LOCKWASHER

1/2” SPLIT LOCKWASHER

3/8” USS FLATWASHER

1/2” USS FLATWASHER

3/4” USS FLATWASHER

3/8” X 10” HEX BOLT

#14 X 1’ PAN PHILLIPS T/S

1/2” X 12” HEX BOLT

3/8” BOLT CUP

40-1-00001

40-1-00002

40-1-00011

40-1-00013

40-1-00014

40-1-00026

40-1-00028

40-1-00045

40-1-00059

40-1-00061

40-1-00064

40-1-00073

40-1-00074

40-1-00082

40-1-00083

40-1-00084

40-1-00097

40-1-00122

40-1-00124

41-1-00025

SBH-1

SBH-2

SBH-3

SBH-4

SBH-5

SBH-6

SBH-7

SBH-8

SBH-9

SBH-10

SBH-11

SBH-12

SBH-13

SBH-14

SBH-15

SBH-16

SBH-17

SBH-18

SBH-19

SBH-20

Rainforest Cottage- Swingbeam Hardware

Rainforest Cottage- Treehouse Hardware

357

28

1 5/8” COATED DECK SCREW

1/4” X 3” HEX LAG SCREW

1/4” USS FLATWASHER

40-1-00020

40-1-00055

40-1-00081

TPH-1

TPH-2

TPH-3

Item No. Part No. Part Description QTY.

6

2

1

2

6

1

9

2

1

4

1

DUCTILE IRON SWING HANGER

1” PLAYGRIP U-MOUNT LADDER HANDLE

1 1/4” PLAYGRIP SAFETY HANDLE

SWINGBEAM TRI-PLATE

16” TRAPEZE BAR W/ RINGS

SWINGBEAM 45 DEGREE BRACKET

SPRING CLIPS 10 X 100MM

DISC SWING

TELESCOPE

90 DEGREE BRACKET

14’ YELLOW ROPE

12” SHIP’S WHEEL

SPIRAL GROUND ANCHOR

90 DEGREE LADDER/ ROCKWALL BRACKET

TIC TAC TOE SET

22” X 22” CHALKBOARD PANEL

56-1-00012

57-2-00003

57-2-00004

58-1-00010

60-1-00005

58-1-00014

59-1-00011

33-1-00036

37-1-00021

58-1-00004

65-7-00017

37-1-00017

59-1-00012

58-1-00006

39-1-00010

39-1-00013

RFA-1

RFA-2

RFA-3

RFA-4

RFA-5

RFA-6

RFA-7

RFA-8

RFA-9

RFA-10

RFA-11

RFA-12

RFA-13

RFA-14

RFA-15

RFA-16

Rainforest Cottage- Base Accessories

Rainforest Cottage- Box A. & B. Accessories (Color Depends on Package)

11

2

ROCKWALL ROCKS

66” CHAINED BELT SWING

36-1-000XX

60-1-000XX

BAB-1

BAB-2

Rainforest Cottage- Base Lumber

RFC-12

21” Center Support Facia

QTY. 1

RFC-11

16” Tic Tac Toe Board

QTY. 2

RFC-10

12” Short 2- Hole Facia

QTY. 3

RFC-9

37 15/16” Picnic Seat Board

QTY. 4

RFC-5

25 13/16” Wood Roof Fan Bottom

QTY. 2

RFC-6

48 1/16” Wood Roof Topper

QTY. 1

RFC-7

52 3/16” Wood Roof Topper

QTY. 1

RFC-8

25 1/2” Rail Picket

QTY. 31

RFC-4

7” Chimney Block #4

QTY. 2

RFC-3

5 3/4” Chimney Block #3

QTY. 2

RFC-2

13 1/16” Wood Roof Fan Board #2

QTY. 2

RFC-1

7 5/8” Wood Roof Fan Board #1

QTY. 4

RFC-24

44” Deck Board

QTY. 16

RFC-23

25 1/2” Tic Tac Toe Filler Arch

QTY. 2

RFC-22

8 3/8” Wood Roof Peak

QTY. 3

RFC-21

44” Picnic Table Board

QTY. 6

RFC-17

92 5/8” Rope Hole Facia

QTY. 1

RFC-18

92 5/8” Upper 6- Hole Facia

QTY. 1

RFC-19

48 1/16” Wood Roof Topper #2

QTY. 1

RFC-20

52 3/16” Wood Roof Topper #2

QTY. 1

RFC-16

56 13/16” Ladder Side Rail Support Facia

QTY. 1

RFC-15

44” Slim 4- Hole Facia

QTY. 4

RFC-14

44” Picnic Seat Board

QTY. 4

RFC-13

33 3/4” Wood Roof Center Support

QTY. 4

Rainforest Cottage- Base Lumber

RFC-36

8 13/16” Wood Roof Fan Plate

QTY. 2

RFC-35

92 5/8” Rockwall Side Runner

QTY. 1

RFC-34

92 5/8” Ladder Side Runner

QTY. 1

RFC-33

92 5/8” 10 Hole Facia

QTY. 2

RFC-29

44” 4- Hole Facia

QTY. 3

RFC-30

44” 6- Hole Facia

QTY. 1

RFC-31

44” Picnic Seat Board

QTY. 2

RFC-32

92 5/8” Deck Support

QTY. 1

RFC-28

28” Rockwall Board w/ Rope Hole

QTY. 1

RFC-27

28” Blank Rockwall Board

QTY. 4

RFC-26

28” 2- Rock Rockwall Board

QTY. 3

RFC-25

28” 1- Rock Rockwall Board

QTY. 4

Rainforest Cottage- Base Lumber

RFC-48

92 5/8” Mainbeam

QTY. 2

RFC-47

35” Wood Roof Extension

QTY. 2

RFC-46

69 7/16” Right Ladder Leg

QTY. 1

RFC-45

69 7/16” Left Ladder Leg

QTY. 1

RFC-41

23 3/4” Ladder Support

QTY. 1

RFC-42

32 5/8” Picnic Table Support

QTY. 2

RFC-43

35” Wood Roof Support

QTY. 6

RFC-44

65 1/8” Rockwall Support Leg

QTY. 2

RFC-40

22” Ladder Step

QTY. 5

RFC-39

18 3/16” Outside Picnic Bench Support

QTY. 2

RFC-38

17” Gusset

QTY. 14

RFC-37

15 3/8” Picnic Seat Bench Support

QTY. 2

RFC-60

52 3/16” (L) Wood Roof Board- Trapeze

QTY. 8

RFC-59

48 1/16” SB Side Wood Roof Board

QTY. 16

RFC-58

13” Chimney BLock #1

QTY. 1

RFC-57

9 9/16” Chimney Block #2

QTY. 1

RFC-53

76 3/8” Trapeze Arm

QTY. 1

RFC-54

103” Center Post

QTY. 2

RFC-55

103” Corner Post

QTY. 2

RFC-56

108 1/2” Corner Post

QTY. 2

RFC-52

44” Swingbeam Top Joist

QTY. 1

RFC-51

24 1/8” Picnic Table Leg

QTY. 2

RFC-50

18 3/16” Trapeze Gusset

QTY. 1

RFC-49

11 1/8” Picnic Seat Leg

QTY. 2

Rainforest Cottage- Base Lumber

RFC-61

52 3/16” (R) Wood Roof Board- Trapeze

QTY. 8

Rainforest Cottage- Base Lumber

RFTP-12

16 3/4” (L) SB Shutter

QTY. 1

RFTP-11

14 1/4” Lower Right Shutter

QTY. 1

RFTP-10

14 1/4” Lower Left Shutter

QTY. 1

RFTP-9

(R) Window Shutter For Side

QTY. 4

RFTP-5

10 1/2” Under Fan Angle Cut

QTY. 4

RFTP-6

11 1/4” (L) Shutter For Trapeze Side

QTY. 2

RFTP-7

11 1/4” (R) Shutter For Trapeze Side

QTY. 2

RFTP-8

12” (L) Window Shutter For Side

QTY. 4

RFTP-4

6 1/4” Upper Lemonade Board

QTY. 13

RFTP-3

26 1/2” Panel Board

QTY. 2

RFTP-2

10 1/16” Under Fan Board

QTY. 12

RFTP-1

26 1/2” Lower SB Side Panel Board

QTY. 1

Rainforest Cottage- Treehouse Panel Lumber

RFTP-24

26 1/16” Upper Panel For End

QTY. 1

RFTP-23

26 1/16” Upper Panel Board For Shutter

QTY. 2

RFTP-22

24 9/16” SB Side Under Fan Center Board

QTY. 1

RFTP-21

17 1/4” Upper Panel Board For Shutters

QTY. 8

RFTP-17

26 1/2” Lower Panel Board

QTY. 11

RFTP-18

28 13/16” Corner Angle Board SB Side

QTY. 2

RFTP-19

44 1/2” Lower Panel Board

QTY. 2

RFTP-20

17 1/4” Upper Panel Board

QTY. 6

RFTP-16

23 1/16” Corner Angle Board

QTY. 2

RFTP-15

16 3/4” (R) SB Side Shutter

QTY. 1

RFTP-14

16 3/4” (R) SB Shutter

QTY. 1

RFTP-13

16 3/4” (L) SB Side Shutter

QTY. 1

Rainforest Cottage- Treehouse Panel Lumber

Page is loading ...

Tree Frogs Rainforest Cottage Install Manual

Tree Frogs Rainforest Cottage Install Manual

Related papers

Other documents