GE ZGG24L20BSS Installation guide

Brand: GE

Model: ZGG24L20BSS

Type: Installation guide

GE ZGG24L20BSS is a 24-inch Outdoor Cooking Center designed for outdoor use, powered by either liquid propane or natural gas (conversion kit sold separately). It features precise burners that enable various cooking methods, including grilling, roasting, and baking. The cooking grates, warming rack, and rotisserie system provide ample space for preparing meals, while the built-in thermometer helps monitor temperatures accurately. The unit requires a 120-volt electrical outlet for the rotisserie motor and has a dedicated space for mounting it on the right side.

GE Monogram ®

24" Outdoor

Cooking Center

MOdal

Z(.(.24I,

Before you begin-- Read these instructions completely and carefully.

IMPORTANT: Save these instructions for local inspector's use.

IMPORTANT: OBSERVE ALL GOVERNING CODES AND ORDINANCES.

NOTE TO INSTALLER: Be sure to leave these instructions with the Consumer.

NOTE TO CONSUMER: Keep these instructions with your Use and Care Book for future reference.

If you received a damaged cooking center, you should

contact your dealer.

Insta!latian of this cooking center requires basic

mechanica! skills. Proper installation is the responsibility

of the installer.

ForMonegram local service in veur area,

1=800-444-!845,

ForMueagram service in Caeada,!-888-880-3030.

ForMonogram Partsand Accessories, call

1=800-626-2002.

Inthe gommonwealtl_ of Massachusetts:

This product must be installed by a licensed

plumber or gasfitter.

•When using bailtype gas shut off valves, they

shall be T-handletype.

oA flexible gas connector, when used, must not

exceed 3 feet.

FORYOURSAFETY:

Do not usecooking center in a space where gasoline or

other liquids havingflammable vapors are stored or

used=

[FYOU SMELL GAS:

Shut off gas to appliance.

Extinguish any open flame.

Open lid.

if odor continues, immediately call ,/our gas supplier.

CAUTION:

• For outdoor use only. Use this cooking center only in

the manner intended by the manufacturer.

• This outdoor cooking gas appliance is not intended to

be installed in or on recreational vehicles and/or

boats.

®Do not use the grill in an explosive atmosphere. Keep

the grill away from areas where gasoline or other

flammable liquids and vapors are stored or being used.

®Observe proper clearances to combustible materials at

all times.

Do not use a rusty or damaged LPtank.

• Never substitute gases (natural for LP or LP for

natural).

®This grill is factory set for liquid propane gas. A natural

gas conversion kit must be installed before using

natura! gas.

®When storing the grill indoors, disconnect the LP tank.

Store the tank outdoors in a well ventilated area.

• Do not store additional LP tanks in or near the gas grill.

• Follow the guidelines on the LP tank for proper storage,

transport and handling.

®Tested in accordance wkh ANSI Z21.58 latest edition

standard for outdoor cooking gas appliances. This grill

is for outdoor use only. Check local building codesfor

the proper methodof installation in the absence of local

codes,this unit should beinstalled in accordance with

the National Fue!GasCode No.Z223latest edition and

the National Electrical CodeANSI/NFPA No.70-19%

CALiFORNiA PROPOSiTiON 65 -WARNING

The burning of gas cooking fue! generates some by

products that are on the list of substances which are

known by the State of California to cause cancer or

reproductive harm. California law requires businesses to

warn custorners of potential exposure to such

substances. To minimize exposure to these substances,

always operate this unit according to the use and care

manual, ensuring you provide good ventilation when

cooking with gas.

INSECT WARM N6[

Spiders and insects can nest in the burners of this and

any other grill, and cause the gas to flow from the front of

the burner. This is a very dangerous condition which can

cause a fire to occur behind the valve panel, thereby

damaging the grill and making it unsafe to operate.

Inspect the grill twice a year or immediately if an,/

symptoms appear.

Desiga [efarmatiee

Model ................................................................................. 3

Product Dimensions & Clearances .............................. 3

Accessories ...................................................................... 3

Advance Planning ............................................................ 3

Choosing the Location .................................................... 4

Tools & Materials Required ........................................... 4

Step 1: Remove the Packaging ..................................... 4

Step 2: Provide Support,

Insta!lation on a Cart ......................................... 4

[estallatiee

Step 2: Provide Support,

Built-in installations .......................................... 5

Step 3: Provide Gas & E[ectrica! Supply ..................... 6

Step 4: Test for Leaks ...................................................... 7

Step 5: Lighting the Grill .................................................. 7

Step 6: Adiusting the Burners ....................................... 8

Finalize Installation .......................................................... 9

install Rotisserie .............................................................. 9

ZXADYSS, ZXSDBSS, Optional Access Doors ........... 9

ZX24NGB, Natural Gas Conversion Kit ...................... 10

Design In%rmathm

24" O_ddoo*' Cookh_g"(.'e,ter

Modal

Pro&tct

Di me'++sio'Y+,s

ZGG24120 SS

The Monogram 24" ()indoor" Cooking (_ente1"

is f_( to_'v set R)_"LP gas and can be convex'ted

to natm'a] gas. O_'de_"ZX24N (;B Natm'a] gas

conve_'si on k]t _hen n at m'a] gas is ava]]ab] e.

24-3/4"

24" (Cutout)

"12" Min. to Combustibles

4" Min. for Lid Clearance

Manifold

Pipe 34/2"

_4" ForLid Clearancewhen installed

into a non-combustibleenclosure,

Allow 12"rain clearance to

combustible vertical surfaces.

Advance

This g_il] may be h]stalled on a pox'table g_il]

cm't oi" bllih into an e]]ch)sm'e.

Endosmes ca]] be consti'ucted o{ non-combus-

tible (mnsom'y) mnte1"ia] oi" of combustible

material such as _oo(L Insulated jackets a_'e

_'e(pfi_'ed fo_" h_stallation into combustible

e_] c] osHI"es.

* ZX24CTBSS, grill can't

" ZX24JBSS_]nsl_lated jacket J_b_"a combustible

en closm'e.

o ZX24TKBSS is _wai]ab]e to conceal the gap

betwee]] the cook] m]_.{cen te_" m]d the

eli c] osm'e.

* ZX24CV'C_ tol_gh vinyl on the oms]de_ felt

]im]ed im]shie with elastic to hold the cove_" hi

place. Fits g_'ill i_stalled on a cm't o_" M_en

b_fi]t-in,

* ZXS])BSS - Stai_]]ess Steel Single Access Doo_"

ZXADYSS - Stahi]ese Steel Dol_b]e Access

Door's- Optional at cesso_'ies to cove_" the

access openh_g m_de_" the g_il] in a b_fih-in

in sta]]atiom

* ZXI J_Y;IJ _ gas ta_k.

* This Monog_'am Outdoor" C_ooking Center" is

desig_led to be h_stalled on a g_ill cm't o_" hm)

;m e_]closm'e.

* h_ a mm-comb_,st]b]e (mas(m_'y) e_]c]osm'e_

the g_'i]](h'ope into the opening. A ]edge on

each side is _'eqld_'ed ibm" s_qq_<>rt.

A]] h]su]atedjacket is available to a]]o_ the

g_']]] to be i_]sta]]ed in a combustible

eli c] osm'e. The hi s_]ated,ja( ket m _st be

suppo_'ted by a ]edge o]] each side.

* If _si n g a backsp]ash o_" _'ea_" _ a]], locate the

electrical se_'vice fb_" the _'otisse_ie on the

_'igh t s] de.

* T_'] m kit ZX24TKBSS is awfi]ab] e to con cea]

the gap bet_een cook]_]___ tel'item" mid the bark

a_] d s]des of m] eli c] osm'e.

C_ea!oances

* Allo_ 4" at the _'em" fkn" lh] cleam_]ce.

* Allo_ at least 12" cleam_]ce at the back of the

g_'ill whe_] exha_st is dh'ected to a wi_]dow o_"

a sin'{hoe that is diil]c_*h to c]eam

* A]]o_ at least 6" c]em'm]ce ()1] each side to

an]v non-combustible matelia] Mcated above

the cooking sm'ihce %_" com]te_'space. This 6"

cl era'an ce _ ill all o_ }b_" placem en t an d

h a_] d]h] g of the _'ot] see_'i e m o to_" a_] d sk,e_ e_'.

* A]]o_ at least 12" c]em'm]ce ()1] ea(h side and

] 2" m hi. c] era'an ce at _'em" to corn b_ st] b]e

ve_'ti ca] mate_'ia]s.

Desigl_ I1Kbrmatkm

24" Outdoor Cookin£ (/e_/ter

CTtoosir_,g

the Locatio'n

* This cooki_lg cem]ter is designed for ol_tdoor

use on]v. Do not locate the grill in a

building, garage or other endosed area.

* En slate th at {}'esh air ve_ ti]ati o_ is adeq Irate.

* ( onsider exposure to _qnd and proxh_ity to

* The clearances to combustib]es

m'N?llstbe maim]taimled at air times.

* Do m)t h]sta]] a gr]]] be]o_ overhead

m_protected combllstib]e co]/struction.

* The installatio_ midst conform to local codes

or h_ the abse_ce of local codes, with the

national fuel gas code, ANSI Z223 latest

edition.

7bets

* Phillips head scre_driver

* Pipe _ ten ch

* I _eve]

* Fiat blade screv, driver (3/32" blade)

*P]iers

St@ l

Remove the

Pa&(_#i'n,g

* Open the box and remove packaging.

* Opel] the gr'i]] rid and r'emo_,e ]_ardv, ar'e

accessor_ car'ton. CJ/eck c(mte]]ts.

Motor

2 Grill Grates

St@2

Provide

Spit Forks

2 CeramicBricluetteTrays

RotisserieRodandHandle

LPRegulator

The Ol_tdoor C(_okim_g (}enter can be h_sta]]ed

on a ZX24CTBSS cart M_ich is desig_ed

specifically fin" this mode]. Fo]]o_ the i_]sta]]a-

tio_] h]structio_s provided _ith the cart to

i_sta]L Proceed to Gas s_app]?, Step 3, to

complete the i_sta]]ation.

Type1Acme,

20 Lb LPTankwith Overfill

Protection Device.(not supplied)

OrderZXLPY

Requiredfor Grill Cart Installation

*A]]ow at ]east 12" c]ear'a_ce at the back of the

gri]] _]]el] exhm_st is directed to a _in(]o_ of

a sm'JB/ce that is difticll]t to dean.

Ot_,a,(,a,'_t

Installation

24" Ou&Ioor Coohh_£" Ce_Her

Built@n,

T_ H S g_'H _ _ _;r _)e ira]stalled into a combustible

(w e]/dosm'e.

• (_x)mbl_stible eudosm'es ]'eql_i]'e the i_se of am]

Cle_oances

• TT

Allo_ 4 at the rear [o]" lkt dea]'ance.

* Allo_ at least 6" clearaN]ce on each side to

_H/V mlo]l-co])lbllgtig)le l))_teYi;_l located _bove

the cookim]_ sm'li_ce fl)r com]terspace_ T1]e 6"

clearam]ce ;_lhals fl_" placin£ and h;u_dling

ill e _x)t] sse_'i e m oto_" ;_m] d ske_,l e_'.

* A]hm _t least 12" c]earm]ce om] ea(b side mid

rear to combustible vertic;d m;_te_'i;ds.

Btdlt:{n

Acorn Nut- ' Right Side

ZX24T_SS _[¥im Kit

Thi s kit is awfi]ab] e flw m]on-corn blastib] e

enc]osm'es. The t_im _li]] conceal tile gap at

t]] e rear a_] d both si des of t]] e ope_]in g_

* Secm'e t_'im to tile sides and ba_k with sc_'ews

* _]ace the _ri]] iC_to the e]ldosm'e.

ZX24JBSS Insulated Jacket

The i_]s_flated,iad<et is req_fired fl)r combus-

due eudosm'es.

* b]sta]] ]eR a]] d rigb t si de pieces wi tb bolts

* Secm'e bolts d_],'d(]e the _]1]] _t]/ acoH] m_ts.

* h]sta]] ba_k pa_]e] to side pm]e]s. Place tile

grill i_to tile endosm'e.

4"Min.forLid

35-1/2

Max."

24-1/2"

If Installing

an Electrical

Outlet for

the Rotisserie

Motor, Mount

)n Right Side

12"Min.to If Installingan

Combustibles ElectricalOutlet

4" Min. forLid 25-3/4" forthe Rotisserie

Motor, Mounton

RightSide

(6.5AMPMin.)

35-1/2

Max."

Openingfor

DoubleAccess

Doors

_nstallation in a non-combustible enclosure.

* 1]] a m_]]-combustib]e (masom'}) e]]c]osm'e_

the g]'i]] drops i_]to the ope]]b]_. A ]ed£e o_]

each side is required for support.

Openingfor

DoubleAccess

Doors

i[nstallatlon [n a combustible enclosure,

ZX24JBSS insulated jacket is required

* Cxm/tx_stibIe eucIosm'es req_fire ZX24JBSS

b]s_]atedjacket. The ]_]s_]ated,iad<et must

be supported by a ]ed£e o_] eac]] side_

(]o]]str_ct the e]]dosm'e ;_s sho_l]]. }{_]stall the

b]sul_ted j_cket o]]to the grill. Pl_(e the

cooki_]g center b]to the opening. No

h]sta]];_tio]] b;wdware is req_fire(].

h stallati<m

24" OuMoor <,'oo]_h_g<,'e_rte*'

Provide

(;as

NOTE: S/@ this st@ !/ )'o_ wish to c<mr_ed to

Hat?_'gd ,gzt,ssw'_/@'. ()rd_,r Z,X224NC!I kit. 1{_,/b'to

Nat_r(d (;as Omve_:sio_ h_sh'_ctio_s, /_ag_,10.

PRODiJCT STORAGE

LPHose

Pre-Attached

Coupler Sleeve

* ( omlect the regl_]ator to the ql_ick

di scol] n ect ]1ose assemb]v.

* Check to be sm'e the main valve on] the I,P

To connect the tank:

* ]{nsert t]_e coupler sleeve over t]_e tmlk hl]et,

tur]] clockl_ise to tighten.

To diseon_met the tm_k:

* Tm'n off the main tan k valve.

* Grasp the coupler sleeve and ttu']/ comlter-

clockwise. Remove the h/]et t&>m the

o]oei] Jm/g.

I_P operating pressure is ]0" W.C.

IMPORTANT: The I,P tan k m ust be a Type ]

Acme. Do not attempt to change or alter these

slq_p]ied parts Do m]ot attempt to _se the

regulator/h ose assemb]y/_ ith a start dard 5 ]i0

POI, tank/w_]ve assembly.

EI ,ECTRICAI _S[ IPPI 5

The rotisserie reqtfres ] 20V, 6(}Hz., and

com]ected to an individtm] properly

groin]deal brm/ch ch'c_ft protected by a ]i5

amp circuit breaker or time delay fuse.

The po/_ er cord (>nt]] e rot] sseri e ]s eq ui pped

t_ith a th r ee-prol]g (gro un di n g p]ug/_ hi ch

mates/_it]] a standard three-prong grotmdi_]g

t_a]] receptacle to minimize the possibility of

shock hazard {}'ore this appliance.

If the electrical service provided does mtt

meet the above specifications, it is recoi/l-

m e_] de d t h at a ]i ceil se d el ectri cian h/stall an

approved om]et.

D O N OT [IN DER ANY CIRC [ IM STA N CES,

(;IJT OR REMOVE THE THIRD ((;RO[ IND)

PRONG FROM THE POWER (ORD.

* For b_f]t-in grill i_]sta]]atio_]s, locate the

el ectri ca] o inlet on the righ t h m/d side.

I stallati(m

24" Outdoor Cooking Center

Ste/ 4

e,%jo

Leaks

St@ 5

Lz ¢/ttir ¢

#te

TEST FOR I _EAKS

A complete gas tightm]ess check midst be

perMrmed at the installation site.

* Do not lase the grill m]ti] a]] c(mnections

have been leak tested.

* Repeat leak test a{}er ea(h I_P taM_ change.

* C_heck to be sm'e the maim/ wt]ve o]] the IJ -_

tin/k or th e sh IB.t-of} valve ]s ]FI th e "O FF"

position.

* Make a soap so] miom] of one part ]iqlfid

detergent an d o]]e part _ ater.

The valve pm]e] must be removed to check the

valves and fittings.

* A]] control valves shol_]d be in the "OFF"

* Remove the knobs.

- Rein ore the 4 scre_ s h o] di_'_g the valve pa_'_e]

to the grill (2 behind bm'ner knobs and t*ao

TO TEST:

* Apply the soap solution aromid the

com]ections, _t]ve a_]d tubing.

* Tm'n the gas supply on.

* CJ_eck a]] com]ections t_'om the supply ]h_e

or I_P tam]k IB.p to am/(] im/c]lB.(iim/g the maFdfi)]d

pipe assemb]v.

o If a leak is detected, mrn gas supply to off

mid tighten fittings. Tm'n the gas on mid

* P u]] the pan e] olltwards an d m]p] ug the _ ires

}}'ore the back of the rotary igni ters.

Do not attempt to

light the grill if the odor of gas is present.

1] _]e Imat pas essayer

d'a]hm_er ]e gri] s'i] v a m]e odem" de gaz.

* Open the rid.

* Tm'n a]] knobs to "OFF" positiom

* Tm'n gas supply on at the I,P tank or shut-off

valve.

NOTE: When lighting the b_.r_/er ti)r the first

time or a{_er a I_P tank chm]ge, allow _p to 20

sec(mds to purge air fl'om the ]h_es.

* Pus]] and tm'n control km_b to "I,ITE"

im m ediate]v tm'_ th e rotary ign] ter

]<_1]ob nex t to th e b III'11er ]<_1]oh.

NOTE: The spark will prod uce asn appi n g

so m_d. Th] s is n orm aL

* If the b_rn er does _ ot ]]gh t withh_ 4

see(rods, mrn knobs to "OFF" and _ait 5

mimates J_br the gas to dissipate before trying

* If the bur_] er does _]ot ]]gh t after several

attempts, the bm'ner can be lit _Gth a match.

TO MAF(H I_IGHT:

* Strike a match and hold over the match light

hole at the top ]eft side_ See illustration.

* Push and t_rn the control knob to "I,ITE".

Match

Hole

WAlT 5 MIN []TES BEFORE REi _IGHTIN G A

HOT GR]I _I.

Installathm

24" Outdoor Coohh_ K Ce_ller

st@ 6

A4iustb ,g

the Bur_,e_:_

Adiustmems should m_t be required, re]less

qbration dmqm_g transit or _ariatiol]s im_h_cal

gas slq_pl) make m im_o_"adjl_stm en ts m_ecessm').

A({iustmems must be made by a qualified

tec hm_]cian at th e ti m e of ]m_stall ati om Ex trem e

care sh o u] d be used if a({j ustm en t s are made

aiter hi sta]]ation.

TO ADJUST:

* The l_dve pm]e] cover m_lst be l'emoved to

access the the air shmten Follo_ the

instnlctions in St_jt 4, 7)<st/br Lt'al_,s.

LockScrew

6rill Box

* i,ocate amid ]oosen the ]ock scl'e_l on the

fhce of the ah" s]m.ttel" _,;ith a scl'e_,; driver.

*Tm'n bm'nel" to the "I_ITE" positiom

* I_ th e I_]am e is yell o_l_ im]di cati m]g h] surf] ci en t

air_ ope_] the air sh utter to a]] o_l m ore air to

the bm'_] er.

* If the flame is nois/ mid tends to ]ift m_av

from the bm'ner_ thel'e is to<)much air. Tm'<]

the air shutter to reduce the ope<]hlg.

* ()]1 ce ac]j usted_ t m']] t h e burn er off m] d

reverse steps to l'e-install the valve panel

coveL

Low setting Adjustment:

Mhml" a(!iustments may be requh'ed due to

f] u ct tlati o_/s hi ]oca] gas pl'essm'e. A (!i_lstm e<]ts

to i_lcrease or decrease gas flow may be

_1ecessarw

* Tm'n bm'_ el" knob to "I _ITE" posi ti on.

* Tm'n tile contro] knob to tile ]o_lest setting_

a]] th e _,;a/' co m] ter-c] ock_a ise.

* Remove the knob bv p_fl]ing straight o_lt.

* In sert a thin-blade flat scre_l driver hi to the

l_dvesha{t and hold. (3/32" blade width

* (;rip the shaft xqth pliers and turn _ om]ter-

c]ock_qse to hmer tile flame, or c]ock_dse to

in crease the f]ame.

Always check tile hm

flame size for stabi]itv. A bm'_lel" flame

_hich is to<) small may go out of be extin-

guished easily. This can cause m]bm'ned

gas to escape a_]d cause a hazardo_ls

con dition.

h stallati<m

24" OuMoor Cool,'h_g <,'e_r*e*'

* Place the small ceramic br]qL(ette trnx at the

rear an d larger truly towards the fn'on t.

* Pla_e the grill grates over the open(rig.

Nete: Theceramicbriquettes may moveduring shippillg orwhen

repositioningfor rotisserie use. Forbest cooking performance,

slide briquettes onthetra:vso they are evenly spaced anddonot

block vent holes.

• Rein ove b {u'm]er grates.

• Rein ove t_'on t (large) ceram] c br] quette tray.

• Place small ceramic briquette tray ]n the rear

sl OrS as sh {)v, ]1.

• P]a_e drip pan o]] the grill floor mid agn]nst

the briquette tray.

• Slide the motor dow]l ]c_to the chain(el ore(

the r]ght s(de.

• To i(se, place pointed end of the skew1 er into

the motor, an](] the threaded end rest(rig o]]

the lelt side support.

• Screw h m( dl e on to the th readed el( d of the

skew1 er.

Nete: %move motorwhen not in use.Store motor in dry place,

ZXAD YSS

(¢/n.d

ZXSDBS5'

ZXADYSS - Double Doors

The open(rig should be 24-1/8" _Hde and

ZXSDBSS - Single Doors

The openh_g shol(ld be 22" wide and 20" high.

* Place the fi'am e]m]to the open(rig an]d secm'e

_]th scre_ls on all sides.

e Hang the doors on the hinges as sho_l n.

Nat_rag Gas ConversionK_t

Parts supplied:

* Natm'al gas regulator

* Natm'al gas orifices

*Adapter 1/2" to 3/8" flare fkting

*T/_ o, ]/2" NPT close nipple

MateriaLs Required:

(not supplied)

* ]2 fi. to ]5 ft. max. []exib]e hose/_ith 3/8"

flare end (corrugated stah/]ess steel

* Pipe t_rench

* Pipe threadh]g compomld

* Mamm] gas sh m-off valve

* Appropriate ]ellgth of gas line to reach the

permanent installation location /_ith a 3/8"

flare end.

* Fiat blade scre/_ driver

Note: Optional ZX144HKYquick disconnecthosefor natural gas is

availableto reacha I44" connection

The grill mid its individual slmt-offvalve must

be disconnected [}'ore the gas supply during

any pressure testing o{ the system at test

pressures in excess of ]/2 PSIG.

The grill must be isolated fi'om the gas supply

svste F_]bv cl osi m/g its hi divi dual sh u t-off valve

durh/g rely pressure testin g of the svstem at

test pressures equal to or less than 1/2 PSK;.

The in sta]]ati oil of th]s grill must col/form

_ ith ]l)ca] codes i)_; h] the absence of local

codes, with the Natitma] fuel gas code, ANSI

Z223 latest edition, hlsta]]ation h] Canada

must be in accordance t_ith the Standard (AN

l-b] 49-1 and/or .2 (h/stallatio_] code Jtiw gas

burning appliances and equipment) and local

codes.

Operating pressm'e is 4" W.C.

Supply pressm'e s]]lm]d be 5" to ] 4" W_(]. 1[

pressure is more than 14" W.C. a step dog, m/

regulator is required.

Step l

lnsta22

l_ittin,<7:_'

R<q'uZator

Check/_it]] local gas utility or l_ith local codes

tbr instructiims on h]sta]]im]g gas supply ]im]es.

Be sure to check im type amid size of mm mid

ho/_ deep to bm'v the ]h]e_ If tile gas ]hie is too

si'_ial], the grill /_il] not hmctiol] properly.

• In stall a mall ua] gas sh m-off valve in an easily

accessible ]ocatiom

• Iise threadh]g compom/d on m/ira-flare

fittim]gs only. DI)not use threadhlg compound

oil tile male end i)t the ]/2 NPT to 3/8 tlare

* Make coill]ecti ollsas sh ia_n.

* Rein ove q u]ck di scIm n ect h o se assemblv f]'om

manifl)ld pipe.

* I,em'e flare fitti ng h/ the man]ti)ld pipe (1/2"

to 3/8" flare).

*Atta(h installer supplied gas line to end oJt

flare fitting i)l/ the mamJti)ld.

* Install regulator to gas ]im/e.

* h/stall ]/2" NPT close nipple to supplier

im]stall ed sh m-off valve.

* (:beck to be sm'e the regulator arrow points

in the direction otgas flol_, to/_ards the grill

an d :may from the gas supply.

Installer.

Supplied

TUBING

(3/8"FLARE)

Adapter1/

to3/8" FlareFitting

1/2 NPTCloseNi

Gas4.g" Regulator

Nipple

_pplied

Shut-Off

-NaturalGasSupply

"qaturag Gas Conversion Kil

• ()pem_ the hd.

• Rein ove racks m]d briq I_ette trays.

• Remove bm']]er knobs mid 4 scre_s o]] the

_lve panel (2 scre_s behind knobs :rod

2 scre_ s be] o_ valve pm] el ).

• ]]{t the com]tro] pane] iq_ mid mid tilt bad<

mu4' fi'om the grill.

• Discom]ect 2 ignitor wires.

• Remove comro] panel

• PItH bm']]ers ba(k mid ;_'aav fi'om the orifices.

• Remove orighm] orifices, one on each side_

• Apply threadh]g compom]d to new orifices,

h]sta]] mid tightem

• R e-p os] ti o n burm] er in si de th e grill m]d w] t h

air sh utter en (is coverh]g the orifi ces.

• (beck air s]mtter, the s]mtter shol_]d be

open approximately 5/] 6".

GrillBox

st@3

/o "

Leaks

\"ERIFI(;ATION

DES FI J[TES

1[1fmlt v&rifier qlle ]'installation n'a mtclme

flfite de gaz.

• Do m/or o.se the grill m/ti] a]] c]nmecti]ms

have been leak tested.

* Check to be sm'e that the sitar-off \:_]ve is hi

the "OFF position.

e I]] a spray bottle, make a soap so]Ht]o]] of

o_1 e part ]i qlfi d detergent m] d on e part _ at er.

TO TEST:

* Spray the soap sol mion arom]d the

com]ectio]]s, _;_]ve and robing.

* Tm']] the gns slq0p]y (m.

* (2h eck a]] con m]ecti]m s J@om the gas supply

limle lip to and im]c]l_(iing the mam]ifi)]d.

* If a leak is detected, mrn gas supply off and

tigh ten i] tti rigs. Tm']] the gas on an d cbeck

st@ 4

Adjust the

_Zt YY_,e)%

LockScrew

Grill Box

] I

Note: While performing installations described in this book,

safety glasses or goggles should beworn,

t_n ,_,li_tzo£'r_nf lo_'M _n, _ _t_yol_r __, _'MI

1-,_00-444-1,245.

Not@: ])loduc[ b11_['(£_- 1]](11[ Js _1 (:OH[[HUiII_ CHd__41"_OF _1[

( (H_rd I{l_ctric. Th_r([;)r_, materials, al>p(manc_ md

sp(cificafions ire subj_c_ to ch;m_( will]out noti{:(.

PuL No.49-8966-2

Dwg.No.164D3333P193

PrintedinUSA

(ND 728) 3/03

10905-Rev2

Monogram:

½9bringgoodthingstolife.

GEConsumer Produc_s

General E/ecnic Company

Louisville, KY 4f1225

4 200,?General Electric Company

GE ZGG24L20BSS Installation guide

Brand: GE

Model: ZGG24L20BSS

Type: Installation guide

Download PDF

report

in other languages

español: GE ZGG24L20BSS Guía de instalación

GE ZGG24L20BSS Installation guide

GE ZGG24L20BSS Installation guide

in other languages

Related papers

Other documents