Sea Ray 2006 290 SUN SPORT Supplement Owner's manual

290 Sun Sport

Owner’s Manual Part Number: MRP 1803655

This owner’s manual is arranged into two parts. Following is a description of each.

General Information

This section contains general information you need to know to safely operate

and maintain your boat.

Specific Information

This section contains information that is specific to your boat such as dimensions, general

arrangement, specific safety information, special features and the electrical system.

If any of these sections are missing from this book contact your dealer.

Your dealer can find out when it will be available and order it for you.

Sea Ray

Owner’s

Manual

Sea Ray

®

• Owner’s Manual Supplement • 2001 290 Sun Sport • MRP #1803655

Printed in the U.S.A. February 2001, Revised May 2002, June 2004, July 2005

Sea Ray Boats, Inc. 2600 Sea Ray Blvd., Knoxville, TN 37914.

For information call 1-800-SRBOATS. or fax 1-314-213-7878 Domestic/International

Internet address: http://www.searay.com

Note: Not all accessories shown in pictures or described herein are standard equipment or even available as options.

Options and features are subject to change without notice.

Owner’s Manual

Supplement

290 Sun Sport

1-800-SRBOATS

www.searay.com

2

290 Sun Sport

3

290 Sun Sport

Engine Oil Change System ..................................29

Anchoring.............................................................. 30

Anchoring Arrangement .......................................30

Location Of Through-Hull Fittings ........................ 31

Canvas .................................................................. 32

Electrical Installation............................................. 33

Battery Switch (Option) ........................................33

Lighting Locations.................................................34

Ground Faunt Interrupter (GFI) Outlet

Loctions & Associated Loads ............................ 35

Electric Switch Pads & Electronic

Interface Modules (EIM) .................................... 36

Bilge Accessory Board .......................................... 38

Main DC Breaker Panel ......................................... 39

Main Distribution Panel .......................................... 40

Mercury

®

Diesel Engine Monitor (Option) .............. 41

Battery Cable Routing ..........................................41

Wiring Harness Installation .................................. 44

Wiring Schematics ................................................45

Safety Label Locations .........................................64

International Homologations ................................ 68

If this is your first craft, or you are changing to a type of

craft you are not familiar with, for your own comfort

and safety, please ensure that you obtain handling and

operating experience before “assuming command” of

the craft. Your dealer or yacht club will be pleased to

advise you of local sea schools, or competent instructors.

PLEASE KEEP THIS OWNER'S MANUAL PACKET IN A

SECURE PLACE, AND HAND IT OVER TO THE NEW

OWNER WHEN YOU SELL THE CRAFT.

This owner's manual supplement has been written to

provide additional specific information about your boat

and should be read carefully.

The owner's manual packet has been compiled to help

you to operate your craft with safety and pleasure. It

contains details of the craft, the equipment supplied or

fitted, its systems and information on its operation and

maintenance. Please read the information in it carefully,

and familiarize yourself with the craft before using it.

Life Saving Equipment (PFD) ................................. 4

Troubleshooting ....................................................... 4

Repair and Parts Facilities ...................................... 4

Docking / Lifting / Trailering ..................................... 5

Bow & Stern Eye / Cleat Location .......................... 5

General Arrrangements & Dimensions ....................

6

Accommodation Plan ............................................. 7

Deck Occupancy Plan ............................................ 9

Accessory Locations ............................................ 10

Dash Layout .......................................................... 12

Engine Compartment Layout ............................... 14

Optional Corsa Exhaust System Layout ..............16

Water System ....................................................... 17

Grey Water System (Option) ................................ 20

Head System ........................................................ 21

Macerator (Option) ...............................................22

Fuel System .......................................................... 22

Ventilation System / Bilge Blowers ....................... 24

Bilge Pumping System .........................................25

Steering System ................................................... 26

Fire Extinguishing System .................................... 27

Extinguisher Indicator Panel................................. 27

Air Conditioning / Heating System ....................... 28

Engine Cooling System ........................................29

Information in this publication is based upon the latest product specifications available at printing. Sea Ray

®

Boats, Inc. reserves the right to make changes at any time, without notice, in the colors, equipment, specifica-

tions, materials and prices of all models, or to discontinue models. Should changes in production models be

made, Sea Ray

®

is not obligated to make similar changes or modifications to models sold prior to the date of

such changes.

The following are registered trademarks of the Brunswick Corporation: Sea Ray

®

, The SR Wave Logo.

(This book contains 68 pages.)

INTRODUCTION & TABLE OF CONTENTS

4

290 Sun Sport

TROUBLESHOOTING

LIST OF REFERENCE MANUALS AND DRAWINGS

PERFORMANCE: Refer to “Power Capacity” in the own-

er's manual.

ENGINE: Refer to the owner's manual and/or the en-

gine manual.

ELECTRICAL: Refer to electrical section of the owner's

manual and electrical schematics in this owner's manual

supplement. Only a qualified marine electrical techni-

cian may service the boat's electrical system.

REPAIR AND PARTS FACILITIES

To find a Sea Ray

®

dealer in your area, call Sea Ray

®

Customer Service, or send a fax or look on the Sea

Ray

®

web site:

1-800-SRBOATS

FAX: 1-314-213-7878

Web Site: www.searay.com

To find repair and parts facilities for equipment installed

on your boat, refer to the original equipment manuals

(OEM's) found in the owner's manual packet.

SUPPLEMENTAL GENERAL INFORMATION

LIFE SAVING EQUIPMENT

(PERSONAL FLOTATION DEVICE (PFD) )

STORAGE: The 290 SS offers sutable storage for per-

sonal flotation devices (PFD’s) under the cockpit floor

storage and under the aft sun pad cushion.

OPERATION: Wear PFD according to manufacturer rec-

ommendations. See pamphlet Federal Requirements

And Safety Tips For Recreational Boats in the owner’s

packet or get one from your dealer.

MAINTENANCE: Rinse with fresh water and let dry

thoroughly. Do not store in a damp compartment. Avoid

the possibility of mildew.

STORAGE AREAS

(FIG. 4.1)

BELOW SEAT

CUSHIONS

COCKPIT

FLOOR

STORAGE

UNDER COCKPIT

ENTERTAINMENT

CENTER

COCKPIT SIDE

PANEL STORAGE

STORAGE BELOW

COCKPIT

SEATING

SUN PAD

STORAGE

COMPARTMENT

PLATFORM

STORAGE

COMPARTMENT

COOLER

STORAGE

TABLE STORAGE

BELOW CUSHION

ANCHOR

ROPE/CHAIN

STORAGE

5

290 Sun Sport

BOW & STERN EYES /

SLING TAG LOCATIONS

(FIG. 5.2)

BOW EYE

STERN EYE

(STARBOARD SHOWN)

(PORT SIDE IDENTICAL)

CLEAT LOCATIONS

(FIG. 5.1)

CLEAT

BOW/STERN

EYE

DOCKING/LIFTING/TRAILERING

CLEATS: Cleats must not be used for lift-

ing the boat, they are intended for moor-

ing use only.

BOW AND STERN EYES: The bow eye

should be used to haul the boat onto a

trailer. The stern eyes should be used as

tie down points for trailering the boat. The

bow and stern eyes may be used for short term lifting

of the boat such as for service. Long term lifting with

the bow and stern eyes may cause stress on the fiber-

glass and gel coat.

For long term storage use flat, wide

belt-type slings and spreaders long

enough to keep pressure from gun-

wales. Do not place slings where they may lift on un-

derwater fittings. When slings are used for lifting the

boat, they shoud be positioned at the “SLING” tag lo-

cations on the sides of the hull.

SLING

SLING TAG

SLING

6

290 Sun Sport

(C) 5’ 2” (1.57 m)

GENERAL ARRANGEMENTS & DIMENSIONS

KEEL

WATERLINE

INTERIOR SEATING PLAN

(A) 29’ 6” (8.99 m) Overall Length

PROFILE

(FIG. 6.1)

(D) 6’ 11” (2.11 m)

HEIGHT DIMENSIONS290 SS SPECIFICATIONS

(A) Overall Length ......................................29’ 6” (8.99 m)

(B) Beam ..................................................... 9’ 8” (2.95 m)

Draft (Stern Drive Down) ........................ 40” (101.6 cm)

Draft (Stern Drive Up) ................................ 25” (63.5 cm)

Draft (Twin Stern Drive Down) .................. 37” (94.0 cm)

Draft (Twin Stern Drive Up) ....................... 26” (66.0 cm)

Dry Weight (lbs.) ...................................... 8,000 (3.629 kg)

Fuel Capacity (gal.) ............................... 130 (492.1 liters)

Usable Fuel (gal.) .................................. 123.5 (467 liters)

Water Capacity (gal.) .................................. 24 (90.8 liters)

Holding Tank (gal.) .................................... 20 (75.7 liters)

Dead Rise ...................................................................... 21°

(FIG. 6.2)

Starboard Double Helm Seat w/Flip-Up Thigh-Rise Bolster, Port Back-to-Back Lounger - Adjustable

w/Flip-Up Thigh-Rise Bolster, Bow Rider Loungers, Aft Circular w/Sun Pad Filler Cushions

(FIG. 6.3)

(B)

9’ 8”

(2.95 m)

(C) Waterline To Top Of Windshield ......... 5’ 2” (1.57 m)

(D) Waterline To Top Of Arch .................. 6’ 11” (2.11 m)

(E) Keel To Top Of Windshield ................. 7’ 6” (2.28 m)

(F) Keel To Top Of Arch ............................ 9’ 3” (2.81 m)

(E) 7’ 6” (2.28 m)

(F) 9’ 3” (2.81 m)

(G) 1’ 2” (35 cm)

7

290 Sun Sport

ACCOMMODATION PLAN

COCKPIT & DECK

(FIG. 7.1)

PORT

STBD

FWD

COCKPIT

FLOOR

STORAGE

STARBOARD HELM SEAT

WITH SWIVEL, SLIDER, FLIP-UP

THIGH RISE BOLSTER

ENTERTAINMENT CENTER

WITH WET BAR

SWIM PLATFORM

WALK THROUGH

DOOR

CONCEALED LADDER

PLATFORM STORAGE

DECK

HATCH

PORT COMPANION SEAT

WITH SWIVEL & FLIP-UP THIGH

RISE BOLSTER

STORAGE BELOW

COCKPIT SEATING

SUN PAD STORAGE

COMPARTMENT

COOLER STORAGE

MAIN DC DISTRIBUTION

PANEL & BATTERY SWITCH

COMPARTMENT

WALK WAY

SLIDING CABIN DOOR

WITH BUILT IN STEPS

8

290 Sun Sport

ACCOMMODATION PLAN (CONTINUED)

COCKPIT & CABIN

(FIG. 8.1)

PORT

STBD

FWD

COCKPIT

ENCLOSED HEAD

FLOOR

STORAGE

HANGING LOCKER

V-BERTH SEATING WITH

STORAGE BELOW

CONVERTS TO BED

GALLEY

DINETTE TABLE STORAGE

UNDER CUSHION

9

290 Sun Sport

(FIG. 9.1)

DECK OCCUPANCY PLAN

TO AVOID RISK OF SERIOUS INJURY

OR DEATH SHUT OFF ENGINE WHEN

NEAR SWIMMERS OR PRIOR TO US-

ING SWIM PLATFORM AND BOARD-

ING LADDER.

! DANGER

PERSONAL INJURY HAZARD

When underway, keep occupants

clear of areas not designed for

riding. Especially hazardous areas

include seat backs, bow, gunwale,

transom platform and fore and aft

decks.

! WARNING

SLIPPING HAZARD - Wet decks

are slippery. Wear proper

footwear and use extreme

caution on wet surfaces.

! WARNING

PORT

STBD

FWD

WORKING DECK

(DECK AREA INTENDED FOR OCCUPATION

DURING ANCHORING, MOORING AND

EMERGENCY OPERATION ONLY)

ACCOMODATION DECK

(DECK AREA INTENDED FOR OCCUPATION

WHILE UNDERWAY.)

WORKING / RECREATION DECK

(USE EXTREEM CAUTION! THIS AREA IS

INTENDED FOR OCCUPATION DURING

MOORING OPERATION WITH ENGINE IDLING

AND FOR RECREATION USE WITH ENGINE

OFF. DO NOT WALK ON OR OCCUPY THIS

AREA WHEN BOAT IS MOVING ABOVE IDLE

SPEED.)

10

290 Sun Sport

ACCESSORY LOCATIONS

(FIG. 10.1)

TRANSOM

SHOWER

LIFTING/TIE

DOWN EYE

PORT

STBD

FWD

LIFTING/TIE

DOWN EYE

BILGE VENTS

BATTERY SWITCH(ES)

MAIN DC DISTRIBUTION

BREAKER PANEL

BILGE VENTS

FUEL TANK SENDING UNIT

ACCESS PLATE

(BELOW CUSHION)

OPTIONAL WINDLASS

OPTIONAL

SPOTLIGHT

ANCHOR CHUTE

(WITH OPTIONAL WINDLASS)

PORT BOW

NAVIGATION LIGHT

STARBOARD BOW

NAVIGATION LIGHT

CONTROL

STATION

ENGINE SHIFT AND

THROTTLE CONTROL

STANDARD: ANCHOR AND ROPE STORAGE

OPTION: ROPE STORAGE WITH WINDLASS

HORN

SKI TOW

WINDLASS

CONTROL SWITCHES

FRESH WATER TANK

FILL PLATE

SHORE POWER

CONNECTIONS

HEAD SYSTEM /GREY WATER

HOLDING TANK

PUMP-OUT PLATE

11

290 Sun Sport

ACCESSORY LOCATIONS (CONTINUED)

(FIG. 11.1)

PORT

STBD

FWD

STEREO SPEAKERS

BATTERY SWITCH(ES)

MAIN DC DISTRIBUTION

BREAKER PANEL

ENCLOSED HEAD

(WITH HEAD SYSTEM, SINK, PULLOUT

SPRAYER, STORAGE, MEDICINE CABINET,

MIRRORED DOOR & LIGHT)

BOW TABLE LEG INSERT

COCKPIT TABLE LEG INSERT

ENTERTAINMENT CENTER

COOLER

DINETTE TABLE

STORAGE

BELOW CUSHION

HANGING LOCKER

MAIN DISTRIBUTION

PANEL

STEREO SYSTEM

(ABOVE)

CARBON MONOXIDE MONITOR

(BELOW)

AIR CONDITIONER CONTROLS

ENTERTAINMENT

CENTER

TV/VCR COMBO

MICROWAVE OVEN

REFRIGERATOR

DUAL VOLTAGE 120V/12V

GALLEY SINK

TV ANTENNA TUNER /

CABLE SWITCH

BUILT-IN COOLER

ENTERTAINMENT CENTER

WET BAR

TRASH CAN

UNDER STEP

12

290 Sun Sport

MPH

100m/h

UP

SINGLE ENGINE GAUGE PANEL

(FIG. 12.2)

DASH LAYOUT

GAUGE PANEL

(FIG. 12.1)

PORT SWITCH

PANEL

STARBOARD

SWITCH PANEL

VHF MARINE RADIO

(OPTION)

INDICATOR LIGHT

AND INFORMATION TAG

FOR AUTOMATIC

FIRE EXTINGUISHING

SYSTEM

STEERING

WHEEL

KICK PANEL STORAGE AND

BEHIND DASH ACCESS

TWIN ENGINE

THROTTLES

STERN DRIVE TRIM &

SEARCH LIGHT PANEL

TWIN ENGINE

GEAR SHIFTS

IGNITION SHUT

DOWN SWITCH

(SEE ENGINE

MANUAL)

STORAGE

COMPARTMENT

STEREO REMOTE

DEPTH FINDER

12 VOLT

RECEPTACLE

TACHOMETER

FUEL GAUGE

SPEEDOMETER

OUTDRIVE

TRIM GAUGE

HOURMETER

WATER

TEMPERATURE

VOLTMETER OIL PRESSURE

13

290 Sun Sport

VOLUME

SEARCH

BAND

PROG

DISC

FUNC

PWR

MUTE

STEREO REMOTE DEPTH FINDER

CENTER PANEL

(FIG. 13.4)

MPH

100m/h

100

130

170

220

55

80

F/ C

0

80

40

0

420

280

140

PSI/kPa

10

12

14

18

UP

DN

100

130

170

220

55

80

F/ C

0

80

40

0

420

280

140

PSI/kPa

10

12

14

18

UP

DN

WATER TEMPERATURE

VOLTMETER

OIL PRESSURE

STARBOARD ENGINE

TACHOMETER

FUEL GAUGE

SPEEDOMETER

OUTDRIVE

TRIM GAUGE

HOURMETER

PORT ENGINE

TACHOMETER

HOURMETER

WATER

TEMPERATURE

VOLTMETER

OIL PRESSURE

OUTDRIVE

TRIM GAUGE

ENGINE RPM

SYNCHRONIZER

GAUGE

PORT ENGINE

MULTI-GAUGE

STBD ENGINE

MULTI-GAUGE

TWIN ENGINE GAUGE PANEL

(FIG. 13.1)

TRIM TAB

SWITCHES

ENGINE

IGNITION

SWITCH

(START)

HATCH

LIFT

TRIM TABS

FORWARD

ACCESSORY

(DOCKING LIGHTS OPTIONAL)

AFT

ACCESSORY

BILGE PUMP

(ON/OFF)

ENGINE HATCH

LIFT (UP)

ENGINE HATCH

LIFT (DOWN)

ENGINE

IGNITION

SWITCH

(STOP)

BILGE BLOWER

(ON/OFF)

NAV

ANCHOR

COMP

COCKPIT

BILGE

ARCH

VENT

OPEN

VENT

CLOSE

P

S

ACC

1

ACC

2

DIM

WINDSHIELD

WIPER

(PORT &

STARBOARD)

ACCESSORY

1 & 2

WINDSHIELD

VENT

(OPEN & CLOSE)

WINDLASS

(UP & DOWN)

WINDLASS

(ON/OFF)

DASH LIGHTS

DIMMER

CONTROL

ANCHOR LIGHT

(ON/OFF)

NAVIGATION LIGHT

(ON/OFF)

DEPTH

SOUNDER

STEREO

MUTE

LIGHTS:

COMP

BILGE

COCKPIT

ARCH

HORN

PORT SWITCH PANEL

(FIG. 13.2)

STARBOARD SWITCH PANEL

(FIG. 13.3)

STERN DRIVE TRIM &

SEARCH LIGHT PANEL (FIG. 13.5)

ENGINE TRIM

TRAILER

PORT STBD

DOWN

UP

SEARCHLIGHT

S

F

STERN

DRIVE

TRAILER

TRIM

PORT STERN

DRIVE TRIM

STBD STERN

DRIVE TRIM

SEARCH LIGHT

CONTROL PANEL

FWD

ACC

AFT

ACC

TWIN ENGINE

EMERGENCY START SWITCH

(SEE OWNER’S MANUAL

FOR DETAILED INFORMATION)

14

290 Sun Sport

I: BILGE PUMP FLOAT SWITCH

J: AUTOMATIC FIRE EXTINGUISHER

K: HIGH WATER BILGE PUMP

L: BILGE PUMP

M: TRIM TAB PUMP

N: HEAD SYSTEM OVERBOARD DISCHARGE

SEACOCK

O: ELECTRIC FUEL VALVE

P: FUEL TANK

Q: BATTERIES

A: TRANSDUCER

B: AIR CONDITIONER STRAINER

(OPTION)

C: AIR CONDITIONER SEACOCK

(OPTION)

D: AIR CONDITIONER WATER PUMP

(OPTION)

E: BILGE COMPONENT BOARD

F: STERN DRIVE POWER TRIM PUMP

G: BILGE BLOWER

H: HIGH WATER BILGE PUMP FLOAT

SWITCH

GASOLINE SINGLE ENGINE (FIG. 14.1)

ENGINE COMPARTMENT L AYOUT

E

F

G

A

H I J K L

M

N

P

Q

G

B

C

D

O

15

290 Sun Sport

GASOLINE TWIN ENGINE (FIG. 15.1)

E

F

G

A

H I J K L

N

O

Q

G

B

C

D

P

R

M

I: HIGH WATER BILGE PUMP

J: AUTOMATIC FIRE EXTINGUISHER

K: BILGE PUMP

L: BILGE PUMP FLOAT SWITCH

M: STARBOARD STERN DRIVE POWER TRIM PUMP

N: TRIM TAB PUMP

O: HEAD SYSTEM OVERBOARD DISCHARGE

SEACOCK

P: ELECTRIC FUEL VALVE

Q: FUEL TANK

R: BATTERIES

A: TRANSDUCER

B: AIR CONDITIONER WATER PUMP

(OPTION)

C: AIR CONDITIONER SEACOCK

(OPTION)

D: AIR CONDITIONER STRAINER

(OPTION)

E: BILGE COMPONENT BOARD

F: PORT STERN DRIVE POWER TRIM

PUMP

G: BILGE BLOWER

H: HIGH WATER BILGE PUMP FLOAT

SWITCH

16

290 Sun Sport

SINGLE ENGINE CORSA EXHAUST SYSTEM LAYOUT (FIG. 16.1)

OPTIONAL CORSA EXHAUST SYSTEM LAYOUT

TWIN ENGINE CORSA EXHAUST SYSTEM LAYOUT (FIG. 16.2)

(VIEW LOOKING AT STARBOARD ENGINE)

TRANSOM

STARBOARD

HULL

PORT

STBD

FWD

PORT

STBD

FWD

EXHAUST TIP

EXHAUST HOSE

4” DIAMETER

EXHAUST

ELBOW

EXHAUST

ELBOW

EXHAUST

DIVERTER

TRANSOM

STARBOARD

HULL

EXHAUST TIP

EXHAUST HOSE

4” DIAMETER

EXHAUST

ELBOW

EXHAUST

ELBOW

EXHAUST

DIVERTER

EXHAUST

TEE FITTING

17

290 Sun Sport

WATER SYSTEM

The water system on your Sea Ray® Sport Cruiser is

equipped with a cockpit entertainment cener wet bar,

transom shower pullout sprayer and freshwater

washdown spigot.

GREY WATER SUMP

(LOCATED BELOW AFT END OF COCKPIT HATCH)

(FIG. 17.4)

SUMP PUMP

FLOAT SWITCH

(FIG. 17.1)

ENTERTAINMENT CENTER WET BAR

(FIG. 17.3)

TRANSOM SHOWER

(FIG. 17.5)

TOILET

FAUCET

AND SINK

HEAD FAUCET AND TOILET

(FIG. 17.2)

FAUCET

ICE

BUCKET

SINK

18

290 Sun Sport

WATER TANK

WATER FILL HOSE

ROUTE TO DECK FILL

WATER TANK

VENT

WATER SYSTEM TANK LOCATION & HOSE ROUTING

(LOCATED BELOW COCKPIT HATCH & FORWARD)

(FIG. 18.2)

TO HEAD TOILET

(WITH VACUFLUSH

®

OPTION)

TO HEAD SINK

WATER SYSTEM

(FIG. 18.1)

TRANSOM

SHOWER

WATER FILL HOSE

ROUTE TO DECK FILL

WATER VENT HOSE

ROUTE TO DECK

FILL VENT

ROUTE TO

ENTERTAINMENT

CENTER

SEE PUMP

DETAIL B

WATER PUMP

& FILTER

HEAD PULLOUT

SPRAYER

COCKPIT WET

BAR FAUCET

TO TRANSOM

SHOWER

PORT

STBD

FWD

WATER PUMP

& FILTER

PORT

STBD

FWD

WATER HEATER

(OPTION)

WATER HEATER VENT

(WITH OPTION)

GALLEY FAUCET

WATER HEATER

VENT HOSE

(WITH OPTION)

WATER HEATER

(OPTION)

WATER TANK

TO GALLEY SINK

19

290 Sun Sport

SUMP HOSE ROUTING

(FIG. 19.1)

FROM

AIR CONDITIONER

CONDENSATION TO

SHOWER SUMP

FROM AFT

SUMP PUMP

TO OVERBOARD

THROUGH HULL

FITTING

AFT SUMP PUMP

& FLOAT SWITCH

SHOWER SUMP

WITH PUMP & FLOAT

SWITCH

FROM SHOWER

SUMP PUMP TO OVERBOARD

THROUGH HULL FITTING

FROM HEAD FLOOR PAN

TO FORWARD SUMP

PORT

STBD

FWD

FORWARD SUMP

& FLOAT SWITCH

FROM FORWARD

SUMP PUMP TO OVERBOARD

THROUGH HULL FITTING

Page is loading ...

Sea Ray 2006 290 SUN SPORT Supplement Owner's manual

This manual is also suitable for

Sea Ray 2006 290 SUN SPORT Supplement Owner's manual

Related papers

Other documents