Euro-Line AWR518/522HL Technical Data & Service Manual

Brand: Euro-Line

Model: AWR518/522HL

Category: Split-system air conditioners

Type: Technical Data & Service Manual

This manual is also suitable for

TECHNICAL DATA & SERVICE MANUAL

Indoor Unit Outdoor Unit

AWR518/522HL AER518SH3

FCR518/522HL AER522SH3

SPLIT SYSTEM AIR CONDITIONER

AER518SH3

AER522SH3

AWR518/522HL

FCR518/522HL

0.8180.144.0 02/2001

Important!

Please Read Before Starting

This air conditioning system meets strict safety and

operating standards. As the installer or service person,

it is an important part of your job to install or service the

system so it operates safely and efficiently.

For safe installation and trouble-free operation, you

must:

●Carefully read this instruction booklet before

beginning.

●Follow each installation or repair step exactly as

shown.

●Observe all local, state, and national electrical codes.

●Pay close attention to all warning and caution notices

given in this manual.

This symbol refers to a hazard or

unsafe practice which can result

in severe personal injury or

death.

This symbol refers to a hazard or

unsafe practice which can result

in personal injury or product or

property damage.

If Necessary, Get Help

These instructions are all you need for most installation

sites and maintenance conditions. If you require help

for a special problem, contact our sales/service outlet

or your certified dealer for additional instructions.

In Case of Improper Installation

The manufacturer shall in no way be responsible for

improper installation or maintenance service, including

failure to follow the instructions in this document.

Special Precautions

When Wiring

ELECTRICAL SHOCK CAN CAUSE

SEVERE PERSONAL INJURY OR

DEATH. ONLY A QUALIFIED,

EXPERIENCED ELECTRICIAN SHOULD

ATTEMPT TO WIRE THIS SYSTEM.

• Do not supply power to the unit until all wiring and

tubing are completed or reconnected and checked.

• Highly dangerous electrical voltages are used in this

system. Carefully refer to the wiring diagram and

these instructions when wiring. Improper connections

and inadequate grounding can cause accidental

injury or death.

• Ground the unit following local electrical codes.

• Connect all wiring tightly. Loose wiring may cause

overheating at connection points and a possible fire

hazard.

WARNING

CAUTION

WARNING

When Transporting

Be careful when picking up and moving the indoor and

outdoor units. Get a partner to help, and bend your

knees when lifting to reduce strain on your back. Sharp

edges or thin aluminum fins on the air conditioner can

cut your fingers.

When Installing…

…In a Ceiling or Wall

Make sure the ceiling/wall is strong enough to hold the

unit’s weight. It may be necessary to construct a strong

wood or metal frame to provide added support.

…In a Room

Properly insulate any tubing run inside a room to

prevent “sweating” that can cause dripping and water

damage to walls and floors.

…In Moist or Uneven Locations

Use a raised concrete pad or concrete blocks to

provide a solid, level foundation for the outdoor unit.

This prevents water damage and abnormal vibration.

…In an Area with High Winds

Securely anchor the outdoor unit down with bolts and a

metal frame. Provide a suitable air baffle.

…In a Snowy Area (for Heat Pump-type Systems)

Install the outdoor unit on a raised platform that is

higher than drifting snow. Provide snow vents.

When Connecting Refrigerant Tubing

• Use the flare method for connecting tubing.

• Apply refrigerant lubricant to the matching surfaces

of the flare and union tubes before connecting them,

then tighten the nut with a torque wrench for a leak-

free connection.

• Check carefully for leaks before starting the test run.

When Servicing

• Turn the power off at the main power box (mains)

before opening the unit to check or repair electrical

parts and wiring.

• Keep your fingers and clothing away from any

moving parts.

• Clean up the site after you finish, remembering to

check that no metal scraps or bits of wiring have

been left inside the unit being serviced.

Others

• Ventilate any enclosed areas when installing or

testing the refrigeration system. Escaped refrigerant

gas, on contact with fire or heat, can produce

dangerously toxic gas.

• Confirm upon completing installation that no

refrigerant gas is leaking. If escaped gas comes in

contact with a stove, gas water heater, electric room

heater or other heat source, it can produce

dangerously toxic gas.

CAUTION

Table of Contents

Page

1 OPERATING RANGE 1

2 SPECIFICATIONS

2-1 Unit Specification 2

2-2 Major Component Specifications 6

2-3 Other Component Specifications 12

3 DIMENSIONAL DATA 16

4 REFRIGERANT FLOW DIAGRAM 20

5 PERFORMANCE DATA

5-1 Air Throw Distance Chart 23

5-2 Performance Charts 29

5-3 Cooling Capacity 31

5-4 Heating Capacity 35

6 ELECTRICAL DATA

6-1 Electrical Characteristic 36 6-2 Electric Wiring Diagrams 40

7 FUNCTION

7-1 Room Temperature Control 44

7-2 Dry Operation 46

7-3 Automatic Switching between Cooling and Heating 47

7-4 Freeze prevention 47

7-5 Overload prevention 48

7-6 Cold draft prevention 49

7-7 Defrosting operation 50

7-8 Outdoor Fan Speed Control 51

8 REFRIGERANT R407C:SPECIAL PRECAUTION WHEN SERVICING UNIT

8-1 Characteristics of new refrigerant R407c 52

8-2 Checklist before servicing 52

8-3 Tools specifically for R407c 53

8-4 For tubing installation procedures 53

8-5 In case of compressor malfunction 54

8-6 In case refrigerant is leaking 56

8-7 Charging additional refrigerant 58

8-8 Retro-fitting existing systems 58

9 TROUBLESHOOTING

9-1 Check before and after troubleshooting 59

9-2 Air Conditioner Does not operate 61

9-3 Some Parts of Air Conditioner does not operate 66

1. OPERATING RANGE

Temperature Indoor Air Intake Temp. Outdoor Air Intake Temp.

Cooling Maximum 32°C D.B. / 23°C W.B. 43°C D.B.

Minimum 19°C D.B. / 14°C W.B. 19°C D.B.

Heating Maximum 27°C D.B. 24°C D.B. / 18°C W.B.

Minimum 16°C D.B. – 8°C D.B. / – 9°C W.B.

DATA SUBJECT TO CHANGE WITHOUT NOTICE.

Remarks: Rating conditions are:

Cooling: Indoor air temperature 27°C DB / 19°C WB

Outdoor air temperature 35°C DB / 24°C WB

Heating: Indoor air temperature 20°C DB

Outdoor air temperature 7°C DB / 6°C WB

Power Source 380 – 400 V – 3N ~ 50 Hz

Voltage rating V 400

Control circuit 230 V ~ 50 Hz

Cooling Heating

Capacity kW 4.80 6.40

BTU/h 16,400 21800

Air circulation (High) m3/h 800

Moisture removal (High) Liters/h 2.7 —

Available voltage range V 342 to 418

Running amperes A 4.0 4.2

Power input W 2150 2250

Power factor % — —

C.O.P. W/ W 2.30 2.85

Compressor locked rotor amperes A 22

Controls / Temperature control Microprocessor / I.C. thermostat

Control unit Wireless remote control unit

Timer ON / OFF 24-hours & Daily Program

Fan speeds Indoor / Outdoor 3 and Auto / Auto (Hi, Lo)

Airflow direction (Indoor) Horizontal Manual

Vertical Auto

Air filter Washable, Anti-Mold

Compressor Rotary (Hermetic)

Refrigerant / Amount charged at shipment g R407c / 1600

Refrigerant control Capillary tube

Operation sound Indoor – Hi / Me / Lo dB-A 48 / 44 / 39

Outdoor – Hi dB-A 51

Refrigerant tubing connections Flare type

Max. allowable tubing length at shipment m 10

Refrigerant tube Narrow tube mm (in.) 6.35 (1/4)

diameter Wide tube mm (in.) 12.7 (1/2)

Refrigerant tube kit Optional

Indoor Unit Outdoor Unit

Unit dimensions Height mm 680 630

Width mm 900 830

Depth mm 190 305

Package dimensions Height mm 813 713

Width mm 1,011 994

Depth mm 296 413

Weight Net kg 23.5 59.0

Shipping kg 30.0 64.0

Shipping volume m30.24 0.29

Dimensions & Weight Features Electrical Rating Performance

Indoor Unit FCR518HL

Outdoor Unit AER518SH3

2. SPECIFICATIONS

2-1. Unit Specifications

DATA SUBJECT TO CHANGE WITHOUT NOTICE.

Remarks: Rating conditions are:

Cooling: Indoor air temperature 27°C DB / 19°C WB

Outdoor air temperature 35°C DB / 24°C WB

Heating: Indoor air temperature 20°C DB

Outdoor air temperature 7°C DB / 6°C WB

Power Source 380 – 400 V – 3N ~ 50 Hz

Voltage rating V 400

Control circuit 230 V ~ 50 Hz

Cooling Heating

Capacity kW

BTU/h

Air circulation (High) m3/h 900

Moisture removal (High) Li/h —

Available voltage range V 342 to 418

Running amperes A 4.8 5.0

Power input W 2750 3000

Power factor % — —

C.O.P. W/W 2.1 2.46

Compressor locked rotor amperes A 28

Controls / Temperature control Microprocessor / I.C. thermostat

Control unit Wireless remote control unit

Timer ON / OFF 24-hours & Daily Program

Fan speeds Indoor / Outdoor 3 and Auto / Auto (Hi, Lo)

Airflow direction (Indoor) Horizontal Manual

Vertical Auto

Air filter Washable, Anti-Mold

Compressor Rotary (Hermetic)

Refrigerant / Amount charged at shipment g R407c / 2400

Refrigerant control Capillary tube

Operation sound Indoor – Hi / Me / Lo dB-A 50 / 47 / 44

Outdoor – Hi dB-A 55

Refrigerant tubing connections Flare type

Max. allowable tubing length at shipment m 10

Refrigerant tube Narrow tube mm (in.) 6.35 (1/4)

diameter Wide tube mm (in.) 15.88 (5/8)

Refrigerant tube kit Optional

Indoor Unit Outdoor Unit

Unit dimensions Height mm 680 835

Width mm 900 850

Depth mm 190 305

Package dimensions Height mm 813 913

Width mm 1,011 1,000

Depth mm 296 400

Weight Net kg 23.5 70.0

Shipping kg 30.0 79.0

Shipping volume m30.24 0.37

Dimensions & Weight Features Electrical Rating Performance

Indoor Unit FCR522HL

Outdoor Unit AER522SH3

5.70 7.40

3.0

19.500 25.200

DATA SUBJECT TO CHANGE WITHOUT NOTICE.

Remarks: Rating conditions are:

Cooling: Indoor air temperature 27°C D.B. / 19°C W.B.

Outdoor air temperature 35°C D.B. / 24°C W.B.

Heating: Indoor air temperature 20°C D.B.

Outdoor air temperature 7°C D.B. / 6°C W.B.

Power Source.......Voltage Rating 380-400V-3N-50Hz.....400V

Control Circuit 230 V - 50Hz

Cooling Heating

Capacity kW 4.80 6.40

BTU/h 16400 21800

Air circulation (High) m3/h 760

Moisture removal (High) Liters/h 2.2 —

Available voltage range V 342 to 418

Running amperes A 4.0 4.2

Power input W 2150 2250

Power factor % 77 77

C.O.P. W/W 2.30 2.85

Compressor locked rotor amperes A 22

Controls / Temperature control Microprocessor / I.C. thermostat

Control unit Wireless remote control unit

Timer ON/OFF 24 hours & Daily program, 1-hour OFF

Fan speeds Indoor / Outdoor 3 and Auto / Auto(Hi, Lo)

Airflow direction (Indoor) Horizontal Manual

Vertical Auto

Air filter Washable

Compressor Rotary (Hermetic)

Refrigerant / Amount charged at shipment g R407c / 1600

Refrigerant control Capillary tube

Noise power level Indoor – Hi / Me / Lo dB-A 55 / 51 / 49

Outdoor – Hi dB-A 65

Refrigerant tubing connections Flare type

Max. allowable tubing length at shipment m 7.5

Refrigerant tube Narrow tube mm (in.) 6.35 (1/4)

diameter Wide tube mm (in.) 12.7 (1/2)

Indoor Unit Outdoor Unit

Unit dimensions Height mm 285 630

Width mm 995 830

Depth mm 206 305

Package dimensions Height mm 276 713

Width mm 1,070 994

Depth mm 363 413

Weight Net

kg 12.0 55

Shipping kg 15.0 60

Shipping volume m3

0.11 0.29

Dimensions & Weight Features Electrical Rating Performance

Indoor Unit AWR518HL

Outdoor Unit AER522SH3

DATA SUBJECT TO CHANGE WITHOUT NOTICE.

Remarks: Rating conditions are:

Cooling: Indoor air temperature 27°C D.B. / 19°C W.B.

Outdoor air temperature 35°C D.B. / 24°C W.B.

Heating: Indoor air temperature 20°C D.B.

Outdoor air temperature 7°C D.B. / 6°C W.B.

Power Source ........... Voltage Rating 380 – 400 V -3N - 50Hz........400V

Control Circuit 230 V 50 Hz

Cooling Heating

Capacity kW 5.70 7.40

BTU/h 19.500 25.300

Air circulation (High) m3/h 830

Moisture removal (High) Liters/h 2.7 —

Available voltage range V 342 to 418

Running amperes A 4.8 5.0

Power input W 2750 3000

Power factor % - -

C.O.P. W/W 2.1 2.46

Compressor locked rotor amperes A 28

Controls / Temperature control Microprocessor / I.C. thermostat

Control unit Wireless remote control unit

Timer ON/OFF 24 hours & Daily program, 1-hour OFF

Fan speeds Indoor / Outdoor 3 and Auto / Auto(Hi, Lo)

Airflow direction (Indoor) Horizontal Manual

Vertical Auto

Air filter Washable

Compressor Rotary (Hermetic)

Refrigerant / Amount charged at shipment g R407c /

Refrigerant control Capillary tube

Noise power level Indoor – Hi / Me / Lo dB-A 58 / 55 / 52

Outdoor – Hi dB-A 68

Refrigerant tubing connections Flare type

Max. allowable tubing length at shipment m 7.5

Refrigerant tube Narrow tube mm (in.) 6.35 (1/4)

diameter Wide tube mm (in.) 15.88 (5/8)

Indoor Unit Outdoor Unit

Unit dimensions Height mm 285 835

Width mm 995 850

Depth mm 206 305

Package dimensions Height mm 276 913

Width mm 1,070 1,000

Depth mm 363 400

Weight Net kg 12.0 70.0

Shipping kg 15.0 79.0

Shipping volume m30.11 0.37

Dimensions & Weight Features Electrical Rating Performance

Indoor Unit AWR522HL

Outdoor Unit AER522SH3

DATA SUBJECT TO CHANGE WITHOUT NOTICE.

Part No. POW–K186GHS–(C)

Controls Microprocessor

Control circuit fuse 250 V – 3 A

Remote Control Unit RCS–6HPS3E

Type Centrifugal

Number ... Dia. and length mm 2 ... ø 130 / L 180

Fan motor model ... Number K48410–M01597 ... 1

No. of poles ... rpm (230 V, High) 4 ... 1,140

Nominal output W 27

Coil resistance (Ambient temp. 20°C) Ω GRY – WHT : 194 - 223

WHT – VLT : 80.1 - 92.2

VLT – ORG : 80.1 - 92.2

ORG – YEL : 200 - 230

WHT – PNK : 238 - 274

Safety Type Internal protector

devices Operating temp. Open °C 145 ± 5

Close Automatic reclosing

Run capacitor µF 2.0

VAC 440

Model M2LJ24ZE31

Rating AC 208 / 230 V, 50 / 60 Hz

No. of poles ... rpm 8 ... 2.5 / 3.0

Nominal output W 3 / 2.5

Coil resistance (Ambient temp. 20°C) kΩ16.45 ± 15%

Coil Aluminum plate fin / Copper tube

Rows 2

Fin pitch mm 1.8

Face area m20.192

Heat

Exch. Coil Flap Motor Fan & Fan Motor

Controller

PCB

Indoor Unit FCR518HL

2-2. Major Component Specifications

2-2-1. Indoor Unit

DATA SUBJECT TO CHANGE WITHOUT NOTICE.

Part No. POW–K186GHS–(C)

Controls Microprocessor

Control circuit fuse 250 V – 3 A

Remote Control Unit RCS–6HPS3E

Type Centrifugal

Number ... Dia. and length mm 2 ... ø 130 / L 180

Fan motor model ... Number K48410–M01598 ... 1

No. of poles ... rpm (230 V, High) 4 ... 1,280

Nominal output W 41

Coil resistance (Ambient temp. 20°C) Ω GRY – WHT : 124 - 144

WHT – VLT : 69.3 - 79.8

VLT – ORG : 69.3 - 79.8

ORG – YEL : 200 - 233

WHT – PNK : 255 - 294

Safety Type Internal protector

devices Operating temp. Open °C 145 ± 5

Close Automatic reclosing

Run capacitor µF 2.0

VAC 440

Model M2LJ24ZE31

Rating AC 208 / 230 V, 50 / 60 Hz

No. of poles ... rpm 8 ... 2.5 / 3.0

Nominal output W 3 / 2.5

Coil resistance (Ambient temp. 20°C) kΩ16.45 ± 15%

Coil Aluminum plate fin / Copper tube

Rows 2

Fin pitch mm 1.8

Face area m20.192

Heat

Exch. Coil Flap Motor Fan & Fan Motor

Controller

PCB

Indoor Unit FCR522HL

DATA SUBJECT TO CHANGE WITHOUT NOTICE.

Part No. POW–K181GJH

Controls Microprocessor

Control circuit fuse 250 V – 3.15 A

Remote Control Unit RCS–8HPS3E

Type Cross-flow

Q´ty ... Dia. and length mm 1 ... ø88 / L746

Fan motor model ... Q´ty UF2– 31A5PA–S ... 1

No. of poles ...Cool / Heat rpm (High) 2 ... 1,305 / 1,335

Nominal output W 30

Coil resistance (Ambient temp. 20°C) ΩWHT – BRN : 130.4

WHT – PNK : 169.8

– : –

Safety Type Thermal protector

devices Operating temp. Open °C 130 ± 8

Close Automatic reclosing

Run capacitor µF 2.0

VAC 440

Type Stepping motor

Model MP24GA2

Rating DC 12 V

Coil resistance (Ambient temp. 20°C) ΩEach terminals (1–2, 1–3, 1–4, 1–5) 400 : ± 7%

Coil Aluminum plate fin / Copper tube

Rows 2

Fin pitch mm 1.3

Face area m2 0.250

Heat

Exch. Coil Flap Motor Fan & Fan Motor

Controller

PCB

Indoor Unit AWR518HL

DATA SUBJECT TO CHANGE WITHOUT NOTICE.

Part No. POW–K241GJH

Controls Microprocessor

Control circuit fuse 250 V – 3.15 A

Remote Control Unit RCS–8HPS3E

Type Cross-flow

Q´ty ... Dia. and length mm 1 ... ø88 / L746

Fan motor model ... Q´ty UF2– 31A5PA–S ... 1

No. of poles ...Cool / Heat rpm (High) 2 ... 1,410 / 1,425

Nominal output W 30

Coil resistance (Ambient temp. 20°C) ΩWHT – BRN : 130.4

WHT – PNK : 169.8

– : –

Safety Type Thermal protector

devices Operating temp. Open °C 130 ± 8

Close Automatic reclosing

Run capacitor µF 2.0

VAC 440

Type Stepping motor

Model MP24GA2

Rating DC 12 V

Coil resistance (Ambient temp. 20°C) ΩEach terminals (1–2, 1–3, 1–4, 1–5) 400 : ± 7%

Coil Aluminum plate fin / Copper tube

Rows 2

Fin pitch mm 1.3

Face area m2 0.250

Heat

Exch. Coil Flap Motor Fan & Fan Motor

Circuit

Board

Ass´y

Indoor Unit AWR522HL

Power source

Control circuit

CONTROLLER PCB

COMPRESSOR

Com

ressor model

Source

Nominal out

ut W

Com

ressor oil ... Amount cc

C - R Ω

C - S Ω

R - S Ω

Safet

devices: T

ype

Internal

rotecto

External

rotecto

Overload rela

HOE-10TB TH-7A

en °C 120 ± 5

Close °C

utomatic reclosin

eratin

(

Ambient tem

. 25°C) // 5 A

VAC

Crank case heater

FAN AND FAN MOTO

Number ... Dia. mm

Fan motor model ... Number

Source

No. of

oles ... r

(

220 V

)

Nominal out

ut W

WHT - BRN Ω

WHT - YEL Ω

Safet

devices: T

ype

en °C

VAC

HEAT EXCH. COIL

Coil

Rows

Fin

itch mm

Face area m2

EXTERNAL FINISH

C-2RN173H8A 80242088

5,62

5,51

5,62

Data subject to change without notice.

utomatic reclosing

440

Acrylic baked-on enamel finish

380 - 400 V - 3N ~ 50 H

220 - 240 V ~ 50 H

POW-C186GH

Rotary (Hermetic)

380 - 400 V - 3N ~ 50 H

Propelle

Run capacitor /

Coil resistance (Ambient temp. 25°C)

Operating temp.

1 ... Ø400

Smen 19TFB6055 ... 1

220 - 240 V ~ 50 H

6 ... 900

240 V - 30 W

Run capacitor

Coil resistance (Ambient temp. 20°C)

Operating temp. 130 ± 8

Internal protecto

77,7

366,0

211,0

0,453

Aluminum plate fin / Copper tube

1,6

FV68S ... 800

1700

WHT - PNK

Ω

Outdoor Unit AER518SH3

Power source

Control circuit

CONTROLLER PCB

COMPRESSOR

Com

ressor model

Source

Nominal out

ut W

Com

ressor oil ... Amount cc

C - R

Ω

C - S

Ω

R - S

Ω

Safet

devices: T

ype

Internal

rotecto

External

rotecto

Overload rela

HOE-10TB TH-7A

en °C

utomatic o

enin

Close °C

utomatic reclosin

eratin

(

Ambient tem

. 25°C

)

VAC

Crank case heater

FAN AND FAN MOTO

Number ... Dia. mm

Fan motor model ... Number

Source

No. of

oles ... r

(

220 V

)

Nominal out

ut W

WHT - BRN

Ω

WHT - YEL

Ω

Safet

devices: T

ype

en °C

VAC

HEAT EXCH. COIL

Coil

Rows

Fin

itch mm

Face area m2

EXTERNAL FINISH

crylic baked-on enamel finish

Data subject to change without notice.

380 - 400 V - 3N ~ 50 H

220 - 240 V ~ 50 H

POW-C226GH

Rotar

(

Hermetic

)

380 - 400 V - 3N ~ 50 H

Run capacitor /

240 V - 30 W

Propelle

Internal protecto

130 ± 8

Operating temp.

utomatic reclosin

1 ... Ø460

Smen 19TFB6064 ... 1

220 - 240 V ~ 50 H

6 ... 840

Run capacitor 5

440

99,5

252,0

63,2

Coil resistance (Ambient temp. 20°C)

Operating temp.

Coil resistance (Ambient temp. 25°C) 4,64

4,88

C-RN223H8A 80244088

2200

FV68S ... 1350

4,97

luminum plate fin / Copper tube

0,61

WHT - PNK

Ω

Outdoor Unit AER522SH3

2-3. Other Component Specifications

Indoor Unit FCR518HL FCR522HL

Thermistor (Room sensor TH2) KTEC-35-S6

Resistance kΩ10°C 10.0 ± 4% 30°C 4.0 ± 4%

15°C 7.9 ± 4% 35°C 3.3 ± 4%

20°C 6.3 ± 4% 40°C 2.7 ± 4%

25°C 5.0 ± 4% 50°C 1.8 ± 4%

Thermistor (Coil sensor TH1) PBC-41E-S14

Resistance kΩ–20°C 40.1 ± 5% 20°C 6.5 ± 5%

–10°C 24.4 ± 5% 30°C 4.4 ± 5%

0°C 15.3 ± 5% 40°C 3.0 ± 5%

10°C 9.9 ± 5% 50°C 2.1 ± 5%

Transformer (TR) ATR-J105

Rating Primary AC 230V, 50Hz

Secondary 19V, 0.526A

Capacity 10VA

Coil resistance Ω(at 21°C) Primary (WHT – WHT): 205 ± 10%

Secondary (BRN – BRN): 2.0 ± 10%

Thermal cut-off temp. 150°C

Thermistor (Room sensor) DTN-TKS142B

Resistance kΩ25°C 5.0 ± 3%

Thermistor (Coil sensor) DTN-TKS131B

Resistance kΩ0°C 15.0 ± 2%

Transformer (TR) ATR-J105

RatingPrimary AC 230V, 50Hz

Secondary 19V, 0.526A

Capacity 10VA

Coil resistance Ω(at 21°C) Primary (WHT – WHT): 205 ± 10%

Secondary (BRN – BRN): 2.0 ± 10%

Thermal cut-off temp. 150°C

Indoor Unit AWR518HL

AWR522HL

Outdoor Unit AER518SH3

Negative Phase Relay (47C) RDR-S400

Rating AC 415V, 3-phase 50Hz

Contact rating AC 400V, 1A

Operation Positive phase: ON

Negative phase: OFF

Relay (PR) MY2-TSDF

Coil rating DC 24V

Coil resistance Ω(at 20°C) 650 ± 10%

Contact rating AC 200V, 5A

4-way Valve (SC) LB64012 (Coil), V26-110B (Valve)

Coil rating AC 220/240V, 50Hz, 6W

Coil resistance Ω(at 20°C) 1,740 ± 7%

Electro Magnetic Contactor (MG) HOE-10TB TH-5A

Magnetic contactor

Coil rating AC 220–240V, 50Hz / AC 240–260V, 60Hz

Coil resistance Ω(at 25°C) 1,260 ± 10%

Contact rating (Main) AC 440V, 8A

Thermal relay (Overcurrent relay)

Operating amperes 5A

Thermostat (Defrost thermo. 23D) TRS02-12MSR

Operating temp. °C ON 12 ± 2

Diff. 8 deg. below

Thermostat (Fan Speed Control 23S) MQT5S-27YZJ

Switching temp. °C high LOW 23.5°C ± 1.5

low HIGH 27.0°C+0

–3

Contact rating AC 220V, 3A

Outdoor Unit AER522SH3

Electro Magnetic Contactor (MG) HOE-10TB TH-7A

Magnetic Contactor

Coil rating AC 220–240V, 50Hz / AC 240–260V, 60Hz

Coil resistance Ω(at 25°C) 1,260 ±10%

Contact rating (Main) AC 440V, 8A

Thermal relay (Overcurrent relay)

Operating amperes 7A

Negative Phase Relay (47C) RDR-S400

Rating AC 415V, 3-phase 50Hz

Contact rating AC 400V, 1A

Operation Positive phase: ON

Negative phase: OFF

4-way Valve (20S) LB64012 (Coil), V26-110D (Valve)

Coil rating AC 220/240V, 50Hz, 6W

Coil resistance Ω(at 20°C) 1,740 ± 7%

Thermostat (Defrost thermo. 23D)

TRS02-12MSR316

Operating temp. °C ON 12 ± 2

Diff. 8 deg. below

Thermostat (Fan Speed Control 23S) YTB-S383

Switching temp. °C

high LOW 28.5°C ± 1

low HIGH 31°C ± 1

Operating press. setting

OFF 25 ± 1

ON 20 ± 1.5

ACB - IB29

High pressure switch (HPS)

3. DIMENSIONAL DATA

Indoor Unit FCR518HL FCR522HL

Remote control unit

74 74

Center of tubing hole

ø75 (4 places)

Wide tube ø12.7 (1/2")

Narrow tube ø6.35 (1/4")

Drain hose ø26

74 74

61 18.5

900

190

680

Wide tube ø15.88 (5/8") FCR518

FCR522

172.5

Dimensions : mm

Indoor Unit AWR518HL

28545

995

147.5 147.5

206 (3)

Remote control unit

Center of tubing

hole (2 places)

Narrow tube ø6.35 (1/4")

Drain hose ø18

Wide tube ø12.7 (1/2") AWR518

Wide tube ø15.88 (5/8") AWR522

61 18.5

172.5

Unit : mm

AWR522HL

Page is loading ...

Euro-Line AWR518/522HL Technical Data & Service Manual

Brand: Euro-Line

Model: AWR518/522HL

Category: Split-system air conditioners

Type: Technical Data & Service Manual

This manual is also suitable for

Download PDF

report

Euro-Line AWR518/522HL Technical Data & Service Manual

This manual is also suitable for

Euro-Line AWR518/522HL Technical Data & Service Manual

Related papers

Other documents