Honda P/N 08A53-S5A-100 User manual

Brand: Honda

Model: P/N 08A53-S5A-100

Category: Toys & accessories

Type: User manual

Honda P/N 08A53-S5A-100 is a cassette player designed for use in Honda Civic vehicles. It features a range of capabilities that enhance the audio experience, including:

Cassette playback: The player supports playback of cassette tapes, providing access to a wide range of music and audio content.
Audio output: The cassette player connects to the vehicle's audio system, enabling users to enjoy their favorite cassettes through the car's speakers.
Easy installation: The included installation instructions guide users through the process of seamlessly integrating the cassette player into their vehicle's dashboard.

Honda P/N 08A53-S5A-100 is a cassette player designed for use in Honda Civic vehicles. It features a range of capabilities that enhance the audio experience, including:

Cassette playback: The player supports playback of cassette tapes, providing access to a wide range of music and audio content.
Audio output: The cassette player connects to the vehicle's audio system, enabling users to enjoy their favorite cassettes through the car's speakers.
Easy installation: The included installation instructions guide users through the process of seamlessly integrating the cassette player into their vehicle's dashboard.

INSTALLATION

INSTRUCTIONS

Accessory Application Publications No.

Issue Date

AUG 2004

08A53-S5A-1000-91

CIVIC

2- AND 4-DOOR

CD/CASSETTE PLAYER

PARTS LIST

Cassette Player:

P/N 08A53-S5A-100

Cassette player

Owner’s Manual

5 Washer-screws, 5 x 8 mm

Harness clip

TOOLS AND SUPPLIES REQUIRED

Phillips screwdriver

8 mm and 10 mm Sockets

Ratchet

Shop towel

Utility knife

Isopropyl alcohol

Tape measure

Adhesive pad

CD Player:

P/N 08A53-S5D-100

CD player

Owner’s Manual

4 Washer-screws, 5 x 8 mm

Washer-screw, 4 x 8 mm

Harness clip

Rubber pad

AII 27857

INSTALLATION

Customer Information: The information in this

installation instruction is intended for use only by

skilled technicians who have the proper tools,

equipment, and training to correctly and safely add

equipment to your vehicle. These procedures should

not be attempted by “do-it-yourselfers.”

1. Make sure you have the anti-theft code for the

radio, then write down the radio station presets.

2. Disconnect the negative cable from the battery.

HandA-Accessories.com

If the vehicle is equipped with a center console

armrest, go to step 6, otherwise; continue with step 3.

3. Pull up on the parking brake lever, then remove the

console box (nine clips).

4. Remove the center console.

A/T Model:

• Place the shift lever in the Neutral position.

• Remove the two self-tapping screws, two

screws, and two clips that fasten the center

console and remove the console

• If equipped with an optional seat armrest,

remove the console after reclining the seat-

back.

PARKING BRAKE

LEVER

Pull up

completely.

CONSOLE BOX

CLIPS (9)

3620020K

SELF-TAPPING

SCREW

CENTER

CONSOLE

SCREW

SHIFT LEVER

Place in the

Neutral position.

CLIP

M/T Model:

• Remove the shift knob from the lever by holding

the plastic section above the boot down firmly

with one hand and turning the knob in a

counterclockwise with the other hand.

• Remove the two self-tapping screws, two

screws, and two clips that fasten the center

console and remove the console.

3620030K

SELF-TAPPING

SCREW

CENTER

CONSOLE

SCREW

BOOT

PLASTIC

SECTION

SHIFT

KNOB

SHIFT LEVER

Place in the

Neutral position.

CLIP

5. Remove the dashboard center lower cover.

Without a Cigarette Lighter and Ashtray:

• With the parking brake applied, place the gear

shift lever in the Neutral position.

• Gently pry out on the lower cover to release the

six retaining clips.

• Unplug the accessory power socket connector

(if equipped, unplug the fog light harness), and

remove the lower cover.

If the vehicle is not equipped with a center console

armrest, go to step 10, otherwise; continue with step 6.

6. Remove the escutcheon, and the center console

trim:

A/T Model:

• With the parking brake applied, place the shift

lever in the Neutral position.

• Pry up on the four retaining tabs and remove

the escutcheon.

• Pry up on the three clips and six retaining tabs

and remove the center console trim.

DASHBOARD CENTER

LOWER COVER

FOG LIGHT

SWITCH

(if equipped)

FOG LIGHT SWITCH

CONNECTOR

(if equipped)

ACCESSORY

POWER

SOCKET

CONNECTOR

CLIPS (6)

With a Cigarette Lighter and Ashtray:

• With the parking brake applied, place the gear

shift lever in the Neutral position.

• Remove the ashtray.

• Inside the ashtray opening, remove the one

self-tapping screw securing the dashboard

center lower cover.

• Gently pry out on the lower cover to release the

six retaining clips.

3304120W

CIGARETTE

LIGHTER

CONNECTOR

RETAINING

CLIPS (6)

SELF-

TAPPING

SCREW

ILLUMINATION

BULB

DASHBOARD CENTER

LOWER COVER

ASHTRAY

CENTER CONSOLE

TRIM

ESCUTCHEON

RETAINING

TABS (4)

RETAINING

TABS (6)

CLIPS (3)

CENTER PANEL

SELF-TAPPING

SCREW

HEATER

CONTROL

PANEL

KNOB

M/T Model:

• Apply the parking brake.

• Remove the shift knob from the lever by

holding the plastic section above the boot down

firmly with one hand and turning the knob

counterclockwise with the other hand.

• Pry up on the three clips and six retaining tabs

and remove the center console trim.

3624030K

CENTER

CONSOLE TRIM

RETAINING

TABS (6)

CLIPS (3)

SHIFT KNOB

PLASTIC

SECTION

BOOT

7. Remove the dashboard center lower cover.

Without a Cigarette Lighter and Ashtray:

• Remove the two self-tapping screws that fasten

the dashboard center lower cover.

• Gently pry out on the dashboard center lower

cover to release the rear four clips, then pull the

cover rearward to release five clips and one

retaining tab.

• Unplug the accessory power socket connector

(If equipped, unplug the fog light harness), and

remove the dashboard center lower cover.

RETAINING TAB

SELF-TAPPING

SCREW

DASHBOARD

CENTER

LOWER

COVER

FOG LIGHT

SWITCH

CONNECTOR

(if equipped)

CLIPS (9)

FOG LIGHT SWITCH

(if equipped)

ACCESSORY

SOCKET

CONNECTOR

8. Open the center console lid, and remove the mat.

3804020K

RETAINING TAB

DASHBOARD

CENTER

LOWER COVER

ASHTRAY

SELF-

TAPPING

SCREW

CLIPS (9)

CIGARETTE

LIGHTER

CONNECTOR

ILLUMINATION

BULB

With a Cigarette Lighter and Ashtray:

• Remove the ashtray. Inside the ashtray

opening, remove the one self-tapping screw.

• Remove the two self-tapping screws that fasten

the dashboard center lower cover.

• Gently pry out on the dashboard center lower

cover to release the rear four clips, then pull the

cover rearward to release five clips and one

retaining tab.

• Unplug the cigarette lighter connector, the

accessory power socket connector, and the

illumination bulb, then remove the lower cover.

3624040K

CENTER

CONSOLE

CLIPS (2)

CENTER

CONSOLE LID

SELF-

TAPPING

SCREW

MAT

SCREW

SHIFT LEVER

Move to the

Neutral position.

9. Remove the two clips, two self-tapping screws and

three screws that fasten the center console. Move

the shift lever to the Neutral position, and remove

the center console.

CENTER

PANEL

SELF-TAPPING

SCREW

(Discard.)

POCKET

SELF-TAPPING SCREW

(Discard.)

40 mm

RUBBER

PAD

ADHESIVE BACKING

CENTER PANEL

RUBBER PAD

(Cut.)

END OF CURVE

RIB

Thoroughly clean

with isopropyl

alcohol.

10. Remove the center panel:

• Remove the two bolts from the bottom of the

center panel.

• Reach through the bottom opening, and push

out on the center panel bracket to release the

nine clips.

• Unplug the five connectors and the antenna

lead, then remove the center panel.

CENTER

PANEL

RETAINING

CLIPS (9)

ANTENNA

LEAD

BOLT

CENTER

PANEL

BRACKET

VEHICLE HARNESS

CONNECTORS (5)

Push.

11. Gently pull out on each knob to remove them from

the heater control panel.

12. Remove the three self-tapping screws that fasten

the heater control panel to the center panel, and

remove the heater control panel.

CENTER PANEL

SELF-TAPPING

SCREW

HEATER

CONTROL

PANEL

KNOB

13. Remove the pocket (four self-tapping screws).

14. Use a tape measure to measure and mark the

rubber pad as shown. Using scissors, cut the

rubber pad into three pieces. Remove the adhesive

backing from each of the rubber pads, and attach

them to the center panel in the areas shown.

ADHESIVE PAD

BOTTOM OF

CASSETTE PLAYER

ADHESIVE

BACKING

CENTER PANEL

Cut off the

bottom

rib.

Sectional

View

If you’re installing a cassette player, continue with

step 15; otherwise, go to step 17.

15. Using a utility knife, cut off the bottom rib from the

center panel at the lower edge of the audio

opening. Remove all burrs. Before attaching the

rubber pads, thoroughly clean the areas where the

rubber pads will attach with isopropyl alcohol.

16. Remove the adhesive backing from the adhesive

pad, and attach it to the bottom of the cassette

player in the area shown.

17. Slide the CD or cassette player into the opening of

the center panel, then install the four screws

provided with the CD or cassette player.

AUDIO UNIT

CONNECTOR

CD OR

CASSETTE

PLAYER

HARNESS

CLIP

WASHER-SCREW

CD player:

4 x 8 mm washer-

screw

Cassette player:

5 x 8 mm washer-

screw

CENTER PANEL

SCREWS (4)

(Provided with the

CD or cassette

player.)

Install in

the lower

hole.

CD OR

CASSETTE

PLAYER

18. Attach the harness clip to the rear of the CD or

cassette player with the washer-screw provided.

19. Plug the connector from the CD or cassette player

into the rear of the audio unit, and secure the harness

with the harness clip.

CENTER PANEL

SELF-TAPPING

SCREWS

HEATER

CONTROL

PANEL

KNOB

To reinstall the

knobs, align the flat

surface on the rod

with the flat surface

on the knob.

CENTER

PANEL

VEHICLE HARNESS

CONNECTORS (5)

BOLT

(reused)

ANTENNA

LEAD

20. Reinstall the heater control panel and knobs on the

center panel.

21. Plug in the five vehicle harness connectors, then

plug the antenna lead into the rear of the audio

unit.

22. Reinstall the center panel with the two bolts.

23. Reconnect the negative cable to the battery.

24. Enter the anti-theft code, and reset the customer’s

radio station presets.

25. Reset the clock.

26. Check operation of the CD or cassette player

according to the Owner’s Manual.

27. Reinstall all removed parts. Check that all clips

and fasteners are installed securely.

28. Place the Owner’s Manual for the CD player or the

cassette player in the glove box.

29. Test the operation of the accessory socket/

cigarette lighter.

NOTE: Whenever the battery is disconnected, the

driver's window AUTO function is disabled.

30. Start the engine. Push down on the driver's window

switch until the window is fully open.

31. Pull up on the driver's window switch to close the

window completely, then hold the switch for 2

seconds or more.

32. Lower and raise the driver's window to check

operation of the driver's window AUTO function.

33. Do the ECM/PCM idle learn procedure.

Make sure all electrical items are turned off.

Start the engine. Hold the engine speed at

3,000 rpm with no load (in Park or Neutral) until

the radiator fan comes on.

Let the engine idle for about 5 minutes with

the throttle fully closed and with all electrical

items off.

NOTE: If the radiator fan comes on during this

step, the time it operates must not be included

in the 5 minutes.

Honda P/N 08A53-S5A-100 User manual

Brand: Honda

Model: P/N 08A53-S5A-100

Category: Toys & accessories

Type: User manual

Honda P/N 08A53-S5A-100 is a cassette player designed for use in Honda Civic vehicles. It features a range of capabilities that enhance the audio experience, including:

Cassette playback: The player supports playback of cassette tapes, providing access to a wide range of music and audio content.
Audio output: The cassette player connects to the vehicle's audio system, enabling users to enjoy their favorite cassettes through the car's speakers.
Easy installation: The included installation instructions guide users through the process of seamlessly integrating the cassette player into their vehicle's dashboard.

Download PDF

report

Honda P/N 08A53-S5A-100 User manual

Honda P/N 08A53-S5A-100 User manual

Related papers

Other documents