GE JGS750EEFES LP Conversion Kit

Brand: GE

Model: JGS750EEFES

Type: LP Conversion Kit

GE JGS750EEFES is a versatile range that can be converted from natural gas to propane with the included conversion kit. With a variety of burner sizes and BTU outputs, it's perfect for any cooking task. The bake burner delivers 17,000 BTUs for even baking, while the extra-large burner provides 13,500 BTUs for rapid boiling. The cooktop burners offer precise control with their adjustable air shutters and low flame settings, preventing accidental flameouts. Additionally, the oven features a separate broil burner for perfectly cooked meats and vegetables.

PROPANE CONVERSION INSTRUCTIONS

WARNING

7KLVFRQYHUVLRQPXVWEHSHUIRUPHGE\DTXDOL¿HGLQVWDOOHU

or gas supplier in accordance with the manufacturer’s

instructions and all codes and requirements of the authority

having jurisdiction. Failure to follow ALL instructions could result

LQVHULRXVLQMXU\RUSURSHUW\GDPDJH7KHTXDOL¿HGDJHQF\

performing this work assumes responsibility for the conversion.

7KHSUHVVXUHUHJXODWRUDQGWKHEXUQHURUL¿FHVDUHVHWIRUQDWXUDO

JDV7RXVHSURSDQHJDVWKHUHJXODWRUDQGEXUQHURUL¿FHVPXVW

be converted.

7KHSURSDQHRUL¿FHVIRUWKHFRRNWRSEXUQHUVDUHVKLSSHGRQWKH

back of the range in a small box.

WARNING

Do not operate the cooktop or oven burners of this range

when using propane (bottled) gas before converting the

SUHVVXUHUHJXODWRUDQGEXUQHURUL¿FHVIRUSURSDQHJDVXVH

)DLOXUHWRGRVRFRXOGFDXVHKLJKÀDPHVDQGWR[LFIXPHV

which can result in serious injury.

To adjust your range for use with propane gas, follow these

instructions:

1. Disconnect all electrical power, at the main circuit breaker or

fuse box.

6KXWRȺWKHJDVVXSSO\WRWKHUDQJHE\FORVLQJWKHPDQXDO

VKXWRȺYDOYH

CONVERTING THE PRESSURE REGULATOR

CONVERTING THE COOKTOP BURNERS

A. Remove the top grates, burner caps and burner heads.

Remove the storage drawer. The pressure regulator is located in the

lower, left hand rear corner of the range as viewed from the front.

III

Denotes 0.95mm Orifice size openin

Denotes LP (Propane) Gas

7RSUHYHQWOHDNDJHPDNHVXUHWKHRUL¿FHVDUHVHFXUHO\VFUHZHG

into the gas supply tubes.

A. If this is your regulator:

1. Use an adjustable wrench to unscrew the hex-nut cap

from the pressure regulator.

 &RPSOHWHO\UHPRYHWKHSURWHFWLYHSODVWLFFDSRȺWKH

threaded metal cap.

LF RF

Propane

Red/Yellow

Propane

Orange/Yellow

Propane

Orange/Lt. Blue

Propane

Red/Yellow

Propane

Blue/Brown

Burner

cap

Burner construction

Burner

head

Base

2UL¿FH

located

through

this

opening

Propane Conversion Kit

Pressure Regulator

Gas Valve

& 5HPRYHWKHSURSDQHRUL¿FHVIURPWKHEUDFNHWVSURYLGHG7KH

SURSDQHRUL¿FHVKDYHWKHOHWWHU´/µRQWKHWRS

 7RDLGLQLGHQWLI\LQJWKHSURSHUORFDWLRQIRUWKHSURSDQHRUL¿FHV

during conversion from Natural Gas to Propane Gas, color

FRGHVKDYHEHHQDGGHGWRWKHVLGHRUWRSRIWKHRUL¿FH6HHWKH

FKDUWEHORZ(DFKRUL¿FHPD\DOVRVKRZDVHULHVRIHQJUDYHG

marks (I, II, III . . .) located on the top.

' ,QVWDOOWKHSURSDQHRUL¿FHVLQWKHLUSUHFLVHORFDWLRQV

E. For the extra large burner, the choke and set screw will be

needed. Insert the choke into the burner head, then inset the

set screw into the burner head and tighten securely.

BURNER OUTPUT RATINGS: BTU/HR

3URSDQH*DVµ:&3

BURNER

BTU

RATE

ORIFICE SIZE

(mm)

COLOR MARKING

RF 10,000 µ Orange/Lt. Blue /

LF 15,000 µ Orange/Yellow 114L

RR  µ Blue/Brown /

LR 5,000 µ Red/Yellow 66L

C 5,000 µ Red/Yellow 66L

BAKE 16,000 µ Orange .047

BROIL 12,000 µ Red 041L

NOTICE:

6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV

% 8VLQJDPPRUµQXWGULYHUUHPRYHWKHWRSEXUQHU

RUL¿FHV7KHVHPD\EHDFFHVVHGWKURXJKWKHEXUQHURSHQLQJLQ

the base.

TOOLS REQUIRED:

• Adjustable wrench

• µ2SHQHQGZUHQFK

• Phillips head screwdriver

• Flat bladed screwdriver

EODGHDSSUR[LPDWHO\µ

across)

• 1XWGULYHUVµµRUPP

PROPANE

NAT

Rotate cap counter-

clockwise to loosen.

/HYHUVKRZQFORVHG2YHQ6KXW2ȺRQO\

FLIP LEVER UP TO OPEN

Cap assembly

Rotate cap counter-

clockwise to loosen.

PROPANE

NAT

/HYHUVKRZQRSHQ2YHQ6KXW2ȺRQO\

386+/(9(5'2:172&/26(

CONVERSION

KIT

3. Turn the metal cap so the type of gas being converted to

is displayed and replace the protective plastic cover.

4. Screw the hex-nut cap back into the regulator.

(Do not over tighten)

B. If this is your regulator:

1. Use an adjustable wrench to unscrew the hex-nut cap

from the pressure regulator.

2. Turn the plastic cap 1/4 turn to disassemble.

3. Turn the plastic cap over and hook it into the slots. Rotate

cap 1/4 turn to reassemble. The type of gas to be used

should now be visible on the top of the cap..

4. Screw the hex-nut cap back onto the pressure regulator.

) ,QVWDOOWKHROGRUL¿FHVLQWRWKHSURSDQHRUL¿FHER[DORQJZLWK

these instructions, and replace onto the back of the range for

possible future conversion back to natural gas.

Choke

Base

(on some models)

Set Screw

Extra-Large

Burner Head

2UL¿FHORFDWHG

through this

opening

7DOO2UL¿FH

PROPANE CONVERSION INSTRUCTIONS

31-11014 05-15 GE

JGS750

Low setting adjustments must be made with other burners in

operation on a medium setting. This procedure prevents the

ORZÀDPHIURPEHLQJVHWWRRORZUHVXOWLQJLQWKHÀDPHEHLQJ

extinguished when other burners are turned on.

A. Turn on all surface burners.

%7XUQWKHNQRERQWKHEXUQHUEHLQJDGMXVWHGWR´/2µ

&5HPRYHWKHNQREDQGLQVHUWDVPDOOÀDWEODGHVFUHZGULYHULQWR

the valve shaft as shown and turn clockwise to fully tighten

down the bypass screw. Repeat for all valves.

',IÀDPHDSSHDUVWRRORZRUXQVWDEOHVORZO\WXUQE\SDVVVFUHZ

FRXQWHUFORFNZLVHXQWLODVWDEOHÀDPHH[LVWVIRUHDFKEXUQHU

Remember, other burners must be turned on to medium.

E. Additionally, for each burner being adjusted, quickly open

DQGFORVHWKHRYHQGRRUZKLOHREVHUYLQJÀDPH,IÀDPHLV

extinguished, continue adjusting bypass screw for a larger

ÀDPH5HSHDWGRRURSHQLQJVXQWLOÀDPHLVVWDEOH

F. Replace the knob.

PROPANE CONVERSION INSTRUCTIONS

31-11014 05-15 GE

JGS750

ADDITIONAL INFORMATION

BURNER OUTPUT RATINGS: BTU/HR

1*1DWXUDO*DVµ:&3

BURNER

BTU

RATE

ORIFICE SIZE

(mm)

COLOR MARKINGS

RF 11,000 µ Orange 1

LF 17,000 µ Black 1

RR  µ Green 136N

LR 5,000 µ :KLWH3XUSOH 101N

C 5,000 µ :KLWH3XUSOH 101N

BAKE 16,000 µ None .070

BROIL 13,500 µ Red 066N

198

III

Denotes 1.98 mm Orifice size opening

Denotes Natural Gas

ADJUSTING LOW FLAME SETTING

ON COOKTOP BURNERS

ADJUSTING AIR SHUTTER SETTINGS

FOR OVEN BURNERS

NOTICE:

2QFHWKHFRQYHUVLRQLVFRPSOHWHDQGFRQ¿UPHG

¿OORXWWKHSURSDQHVWLFNHUDQGLQFOXGH\RXUQDPH

organization and date conversion was made. Apply the

sticker to the range near the regulator to alert others

in the future that this appliance has been converted

to propane. If converting back to natural gas from

propane, please remove the sticker so others know the

appliance is set to use natural gas.

 :LWKD3KLOOLSVKHDGVFUHZGULYHU

loosen the screw securing the air

shutter on the bake burner. Adjust

the bake burner air shutter to fully

open. Retighten screw.

2. Turn on the gas.

3. Turn on the electricity.

4. Reinstall the oven door.

5. Turn on the bake burner.

 $V\RXZDWFKWKHÀDPHZLWKWKHRYHQGRRUFORVHGFKHFNWKH

following through the oven door window.

D ,IWKHÀDPHVDUH\HOORZRSHQWKHDLUVKXWWHUPRUH8VHD

screwdriver to loosen the air shutter screw.

E ,IWKHÀDPHVEORZDZD\RUÀXWWHUIURPWKHEXUQHUFORVHWKH

DLUVKXWWHUVOLJKWO\EXWQRWE\PRUHWKDQµ

7. Retighten the air shutter screw.

2YHQEXUQHUÀDPHPXVWEHREVHUYHGZLWKWKHGRRUFORVHGWR

SURSHUO\FKHFNÀDPHFKDUDFWHULVWLFV

 &KHFNLQJWKHÀDPHVL]H

 ,WVKRXOGEHDSSUR[LPDWHO\µ

WRµORQJIRUWKHEDNHDQGEURLO

burners.

The combustion quality of the

EXUQHUÀDPHVQHHGVWREH

determined visually.

127(,IEXUQHUÀDPHVORRNOLNH$IXUWKHUDLUVKXWWHU

DGMXVWPHQWWRWKHEDNHEXQHULVUHTXLUHG1RUPDOEXUQHU

ÀDPHVVKRXOGORRNOLNH%RU&GHSHQGLQJRQWKHW\SHRI

JDV\RXXVH:LWKSURSDQHJDVVRPH\HOORZWLSSLQJRQWKH

RXWHUFRQHVLVQRUPDO

)RUHLJQSDUWLFOHVLQWKHJDVOLQHPD\FDXVHDQRUDQJHÀDPHDW

¿UVWEXWWKLVZLOOVRRQGLVDSSHDU



 :KHQDOODGMXVWPHQWVDUHPDGHDQGWKHUHVXOWVDUH

satisfactory:

a. Replace the oven bottom.

b. Replace the storage drawer.

Screw

Air shutter

(A) Yellow flames:

Further Adjustment

Required

(B) Yellow tips on

outer cones:

Normal for Propane Gas

Normal for Natural Gas

WARNING

,I\RXDWWHPSWWRPHDVXUHWKHLQQHUFRQHRIWKHÀDPHSOHDVHXVH

caution: burns could result.

Center adjustment screw for all burners.

CONVERTING THE OVEN BURNERS

BAKE BURNER ORIFICE

1. Remove oven racks, door, storage drawer and oven bottom.

5HPRYHWKHµKH[VFUHZVVHFXULQJWKHEDNHEXUQHUEXWGRQ·W

remove burner from its location.

7KHEDNHEXUQHURUL¿FHLVRQWKHJDVYDOYHORFDWHGEHKLQGWKH

VWRUDJHGUDZHU/LIWWKHEXUQHURȺWKHRUL¿FHDQGDSSO\Dµ

ZUHQFKWRWKHKH[EDVHRIWKHRUL¿FHRQWKHJDVYDOYH/RRVHQ

WKHRUL¿FHE\WXUQLQJFRXQWHUFORFNZLVHDQGUHPRYH

NOTICE:

This product cannot be converted to propane by adjusting

the oven orifices. The orifices must be replaced for propane

NOTICE:

Save this orifice for future conversion back to natural gas.

Lift burner

%DNHEXUQHURUL¿FH

6HOHFWWKHSURSDQHEDNHRUL¿FHIURPWKHNLWDQGLQVWDOOLWRQWKH

JDVYDOYH&RQWLQXHWRWLJKWHQRUL¿FHXQWLOLWLVIXOO\VHDWHGRQWKH

gas valve.

5HSODFHWKHEDNHEXUQHURYHUWKHRUL¿FHDQGUHSODFHDOOVFUHZV

securing the burner.

SPECIAL NOTE:

7RFRQYHUWWKHRYHQEDFNWRQDWXUDOJDVUHYHUVHWKH

LQVWUXFWLRQVJLYHQLQPDNLQJSURSDQHDGMXVWPHQWV

NOTICE:

The air shutters on the dual broil burner are not

adjustable. Do Not change the broil burner air shutters, when

converting from natural gas to propane gas.

BROIL BURNER ORIFICE

NOTICE:

Save this orifice for future conversion back to natural gas.

5HPRYHWKHµKH[VFUHZVHFXULQJWKHEURLOEXUQHUDQGDOORZ

LWWRKDQJGRZQIUHHRIWKHEURLORUL¿FH

$SSO\DµZUHQFKWRWKHKH[EDVHRIWKHRUL¿FH/RRVHQWKH

RUL¿FHE\WXUQLQJFRXQWHUFORFNZLVHDQGUHPRYH

3. Select the propane broil orifice from the kit and install it on the

broil elbow. Tighten until snug.

4. Replace the broil burner over the orifice and replace the screw

securing the burner.

Broil

RUL¿FH

Oven

light

GE JGS750EEFES LP Conversion Kit

GE JGS750EEFES LP Conversion Kit

GE JGS750EEFES LP Conversion Kit

Related papers

Other documents