Leisure NHL2 User manual

1970-02

2. Fitthexingclipstothe

sink using the screws

provided,asshownin

g. 2 and hinge them

back away from the

sinkedge.

3. Atthispointtrythesink

in the cut-out, some

localised enlargement

of the hole may be

necessaryaroundthe

clips.

4. Fit the tap to the

sink.

5. Fit the wastes to the sink following the instructions

packedwiththem.

6. Fitthefoamsealtotheedgeofthesink.Peeloffthepaper

backingstripandstickthesealtotherecessinthesink

asshowning.3.Ensurethataneatbuttjointisachieved

wheretheendsofthesealmeet.

FITTINGTHESINK

1. Positionthesinkinthecut

out.

2. Tensionthexingclipsas

showning.4.

 Ensurethatthefoamseal

is carefully compressed

butdonotovertightenthe

clips.

3. Completetheplumbingof

thehotandcoldsupplyto

thetap.

ALTERNATIVEMETHODOFSEALING

1. Applysiliconesealant(notsupplied)totheundersideof

thesinkrim,asshowning.5.

2. Removesurplussealantfromaroundthesinkusingadamp

cloth.

NOTE: During installation care should be taken to ensure

the sinkisprotectedfromscuffsandscratches.Strainingand

overtighteningofallplumbingxturesconnectedtothesink

shouldbeavoided.Installersshouldcarefullycheckthatthe

mouldingandtheedgesof thesinkaredeadlevel sothat

waterwillowoffthedrainer.

PLEASEREADTHOROUGHLYBEFOREATTEMPTINGTO

INSTALLSINK.

PREPARINGTHEWORKTOP

1. Itisrecommendedthattheinsetsinkisttedtotheworktop

beforebeingpermanentlyxedtothecabinet.

2. Placethesinkupsidedownonworktop.Positionthesink

relativetotheworktopasrequired,ensuringthatthecabinet

frameworkwillbeclearofallpartsofthesink.

 Withasharpsoftpencildrawroundsinkasaccuratelyas

possible.Seeg.1.

3. Remove the sink and draw another line 10mm inside

theout-lineofthesinktop.Thisisthecuttinglineforthe

aperture.

4. Drillaslargeaholeaspossibleinsidethecuttingline.Using

apadsaw,jigsaworsimilar,cutouttheaperture.Atthis

pointwewouldrecommendthattheworktopapertureis

sealed.Todothispaintoverwithap.v.a.adhesive,paint,

varnishorsmearwithsiliconesealant.

PREPARINGTHESINK

1. Ifatapholeisrequired,buthasnotbeensuppliedinthe

sink,proceedasfollows.

 Decidewhetherthebowlistobeontheleftorrighthand

whenthesink istted.Cut theappropriatetapholeinto

thesink.Todothisyouwillneedaholesawortankcutter

settocutouta35mmdiameterholeandapilotdrill.On

thereversesideofthesinkyouwillndalocationpoint

forthepilotdrillinthecentreofthetapcut-out.Drillout

thepilothole.TurnthesinkoverandcarefullydrilLcOt4he

tap-hole.

WARNING: Velstra&Neostoneproductsincludeasilicaller.

Anymachiningoperationwillproduceneparticlesofdust.

Drillingorcuttingmustbecarriedoutinawell-ventilated

area.

INSTALLATIONDETAILSVELSTRA

&NEOSTONESINKS

1970-02

VELSTRAANDNEOSTONECAREINSTRUCTIONS

Congratulationsonpurchasingyournewsink.Vel-

straandNeostonearerevolutionarysinkmaterials

thatareextremelyrobustandhardwearing.How-

ever both materials will benet from a little care

andattentiontoensurelastinggoodlooksandper-

formance. Please read the following care advice

carefully.

Cleaning

Foreverydaycleaningadampclothwithordinary

washingupliquidwillsufce.Heavierstainingcan

beremovedwithacreamcleanere.g.Cifonadamp

cloth.Reallystubbornstainsshouldbetreatedto

anovernightsoakingindilutedbleach.Pleasedo

notuseabrasivepowdersorsteelscouringpads

as they may affect the surface gloss. Do not at-

tempttoremovelimescalebyscrapingit off,anap-

plicationofcitricacid(lemonjuice)should,withthe

helpofastiffbrush,removeanydeposits.Silver

streaksonthesurfaceofthesinkarecausedby

aluminiumutensilsandarenotscratches,theycan

beeasilyremovedwithacreamcleaner.

HeatResistance

Velstra and Neostone are highly resistant to ex-

tremesoftemperatureandwillwithstandhotpans

upto230°Cbutavoidpanscontainingveryhotoil

abovethistemperature.

ChemicalResistance

Velstra and Neostone are resistant to just about

any chemical found in the home, but be careful,

thesedayswastesystemsaremadefromplastic

materialswhichmaynotbe.Thecolouredwastes

suppliedasstandardwiththesink,aremadefrom

atoughplasticmaterialbutthesearenotresistant

tosomesolvents,especially nailvarnishremover,

acetoneandnitrothinners.

FurtherAdvice

Donotusethedrainerasachoppingboard.Ahard

woodchoppingboardorpolyethylenefoodboard

isavailableasanoptionalextra.

Avoidplasticwashingupbowls,theypickupne

particlesofgritwhichtransformsthemintoveryef-

cientgrindingsurfacescausingwearonyoursink.

Werecommendarubbermatinthiscase.

20YearGuarantee

WeguaranteetoreplaceanyVelstraorNeostone

sinkthatbreaksduetomaterialormanufacturing

defectswithin20yearsfromthedateofpurchase.

The guarantee does not cover normal wear and

tearoccurringthroughuseoftheproduct.

Fortheguaranteetoapplytheownermustfollow

theuse,careandcleaninginstructionsprovided.

Accessoriesandwastettingsarenotincludedin

thisguarantee.

Meadow Lane, Long Eaton,

Nottingham, NG10 2GD, England

Tel: +44 (0) 115 946 4000 Fax: +44 (0) 115 973 6602

E-mail: consumers@rangemaster.co.uk

www.leisuresinks.co.uk

EN 13310 : 2003

Kitchen sink made of:

Cleanability:

Load resistance:

Durability:

Pass

NPD / N/A

Pass

Composite / Velstra / Neostone

Leisure NHL2, VHL1, VHL2 User manual

Related papers

Other documents