Nexus 1000 Owner's Assembly And Operating Manual

Brand: Nexus

Model: 1000

Type: Owner's Assembly And Operating Manual

Owner’s Assembly And Operating Manual

Ultra Light Plus, Full Electric Low Bed

Nexus 1000

Item # 15235

1. Conrmthatallpartsarepresent.

 A.FootSpring

 B. HeadSpring

 C. HeadBoard

 D. FootBoard

 E. Hi/LowShaft

 F. LockingPins

 G. Motor

 H. HandCrank(attachedtofootboardforshipping)

 I. Casters(4)-2locking,2non-locking

 J. SpringClips(2)

 K. HandPendant

 L. FullElectricMotor

Assembly Instructions

Assembly Instructions Cont.

2. Connecttheheadspringbyaligningwithfootspringandswingingbothendsawayfromeachother.

3. Optional:Insertlockpinthroughconnected

 sleepsurfaceandsecurewithspringclip.

Assembly Instructions Cont.

6. Slidelockcollar1/4”fromthefoot

 sideofthehangerbracketasshown.

 Tightenthumbscrew.

5. InstallHi/LowshafttotheHi/Low

 motoratthefootsectionofthebed

 byinsertingthespringloadedside

 oftheshafttothebottomreceptacle

 asshown.

1/4”Gap

ThumbScrew

SpringLoadedShaft

4. Placethefootspringstandingupontheoor

 onitsside.SlideHi/Lowshaftthroughhanger

 bracket.

HangerBracket

Assembly Instructions Cont.

7. Hi/LowshaftconnectedtoHi/Lowmotor.

9. Installthecastersbyinsertingthe

 stemofthecasterintotheleg

 receptacle.Itisrecommendedto

 install1lockingcasterand1non-

 lockingcasteroneachbedend.

 Thelockingcastersshouldbe

 installeddiagonallyfromeachother.

8. Connectheadsectionandfootsection

 bysqueezingtogetherandattaching

 withspringlinks.Pullupthehead

 sectionandfootsectiontorelease

 tensionbetweenthesprings.

StemLegReceptacle

Assembly Instructions Cont.

10. Withbedonsideextendtheshaftuntilit

 reachesthefulllengthofbed.

a. NOTE:Theshaftadjustmentholesare

 markedtoindicatethestyle(semi/full)ofbed

 theshaftisbeinginstalledon.

11. Attachtheheadboardandfootboard

 asshown.

a. NOTE:Theheadsectionishigherthan

 thefootsection.However,theyare

 interchangeablewitheachother,withall

 otherDriveandothermanufacturers

 headandfootboards.

Assembly Instructions Cont.

12.Installtheheadendoftheshaftas

 shown.

13. Releasethespringloadedshafton

 thehi/lowmotorandinserttheshaft

 intothegearboxonthefootboard.

14. Makesuretheslotonthespring

 loadedshaftengagestherollpinon

 thegearbox.

NOTE:Beforeinstallingmotor,plughand

pendantandHi/Lowmotorcableintomotor

asshown

14.Connectthe9Vbattery(soldseparately)tothe

 batterycliponthemotor.Itisstoredintherecess

 underthemotorcover.Withthisbatteryinstalled,

 themotorcanbeoperatedintheeventofapower

 failure.

15. Toinstallmotor,removelockingcapsontopof

 themotor.

Motor Installation

HAND CONTROL

TheCompetitorbedcomeswithahandcontrolthatwill

illuminatewhenthebedispluggedintoagroundedor

polarizedwalloutlet,orwith9Vbattery(soldseparately)

installedinthehandcontrol.Thehandcontrolwill

illuminateaslongasthewallorbatteryhaspower.With

thisbatteryinstalled,themotorcanbeoperatedtoreturn

thesleepsurfacetothehorizontalpositionintheeventof

apowerfailure.

Motor Installation Cont.

16. Alignthemotorwiththeactuatorbar

 andlifttheheadspringtothehighest

 position.Themotorwillautomatically

 bepulledtowardsthebedandlock

 ontotheaccuator.Repeatforfoot

 section.

17.Afterthemotorisinstalled,slide

 lockingcoversbackonmotor.

ActuatorBar

Bed Rail Installation

18. AttachingBedRails

b. FullRails

• Thefootandheadsectionhavecolor

 codedsprings,labelsandnotchesinthe

 frame.

• Installthecrossbracebetweentheblack

 springsforproperrailplacement.

a. Halfrails

• Theheadsectionfeatureslabelsonthe

 framemarked,“AttachHalfRailsHere”

 andblackspringsforproperplacement.

Mattress Installation

20. Beforeamattressislaidonthebed,ip

 upthemattressguardtoreducethe

 movementofthemattress.

Driverecommendsthefollowingmaintenanceandcleaningproceduresbeconductedbetweenusers.

ELECTRONICS

• Checkallcontrolstomakesureallfunctionsworkproperly.

 • Footcontrol

 • Headcontrol

 • Hi/Lo

• Checkallcablesfordamagedorfrayedwires.

 • Powercord

 • Pendantcord

• Checktomakesureallplugsarefullyinsertedorattached.

• Check9Vbatteryonmotorandreplaceannually.

BED FRAME & SLEEPING SURFACE

• Visuallycheckallwelds.

 • Headsection

 • Footsection

 • MainFrame

• Checkjointsbetweensleepingsurfacesectionsforloosefasteners.

CLEANING

• Themetalpartsofthebedarecoveredwithapowdercoating.Cleanallcoatedpartswithmilddetergentandwarmwater.

 Periodicallyraiseheadandfeetsectionsofthebedandremovedustfromframe.Also,periodicallyremovemattressandclean

 mattressdeck.

LUBRICATION & MECHANICAL

• Lightlygreaseallactuatorscrewthreadswithwhitelithiumgrease.

• Lubricateallcasterrollerandswivelbearingswithlightmachineoil.

• Checkallboltsandtightenasneeded.

WARRANTY

• Lifetimewarrantyonwelds.

• 5yearwarrantyonframe.

• 5yearwarrantyonmotor.

• 1yearwarrantyonallotherpartsandcomponents.

Duringthewarrantyperiod,defectiveitemswillberepairedorreplacedatDrive’soptionatnocharge.

Maintenance & Safety Checks

99 Seaview Boulevard

Port Washington, NY 11050

Phone: 516-998-4600

Toll Free: 877.224.0946

Fax: 516.998.4601

www.drivemedical.com

Nexus 1000 Owner's Assembly And Operating Manual

Nexus 1000 Owner's Assembly And Operating Manual

Nexus 1000 Owner's Assembly And Operating Manual

Related papers

Other documents