Drive Medical Design 15560 User manual

Drive Medical Design
Brand
Drive Medical Design
Model
15560
Type
User manual
1
Owner’s Assembly And Operating Manual
Ultra Light Plus, Semi Electric Bed
Competitor
Item # 15560
2
REV3.1.23.14
1. Remove contents from carton.
Assembly Instructions
2. Placebothendsofthesleepsurfaceontheirsideandaligntheangewiththereceptacleasshown.
3. Toattachtheheadandfootspring,pulltheblackknobawayfortheframeandslidethetwosides
together.Thelockknobisspringloadedandwilllockintopositionwhenreleasedandthetwosections
ofthebedareushtogether.
To disassemble the head and foot section, pull the black lock knob out and rotate the knob a quarter turn.
Thelockknobwillremainopentoallowtheheadsectiontoberemovedfromthefootsection.
3
Assembly Instructions Cont.
4. Securethesleepsurfacewiththecotterpinasshown.
5. Lockthecotterpinwiththeattachedclasp.Repeatontheoppositeside.
4
REV3.1.23.14
Assembly Instructions Cont.
6. NOTE:Beforeinstallingmotor,plughandpendantcableintomotorasshown
7. To install motor, remove locking caps on top of the motor.
HAND CONTROL
TheCompetitorbedcomeswithahandcontrolthatwill
illuminatewhenthebedispluggedintoagroundedor
polarizedwalloutlet,orwith9Vbattery(notincluded)
installedinthehandcontrol.Thehandcontrolwill
illuminateaslongasthewallorbatteryhaspower.With
thisbatteryinstalled,themotorcanbeoperatedtoreturn
the sleep surface to the horizontal position in the event of
apowerfailure.
5
Assembly Instructions Cont.
There are two methods for the installation of
the motor
Method A
Themotorisinstalledonthebedframewhentheframeisstanding
on its side.
Installation instructions can be found on pages 7-8.
Method B
The motor is installed from underneath the bed frame
(horizontaltotheground)
Installation instructions can be found on pages 10-11.
6
REV3.1.23.14
Assembly Instructions Cont.
A2. Align the opening on the head end of the
motorwiththeangeontheheadsectionof
thebedandinserttheangeintothemotor
compartment.
Actuator Bar
Flange
A3. Withthepalmofyourhand,snapthemotor
ushtotheactuatorbar.
A4. Align the opening on the foot end of the
motorwiththeangeonthefootsectionof
thebedandinserttheangeintothemotor
compartment.
Method A
Installation of the motor when bed frame is on its side
A1. Priortoinstallation,makesurethatthe2whitemotorblocksareintheretractedposition.
CORRECT INCORRECT
A5. Withthepalmofyourhand,snapthemotor
ushtotheactuatorbar.
7
A6. Once in place, replace the motor covers to secure the motor.
A6.Oncethemotorisattached,laybedatandinstallheadandfootboards.Thereare2height
adjustments on the head and foot board. Select the desired positions and hook the frame onto the foot
board.Slidelocktowardslegoffootboardtosecurepositionasshown.Repeatforoppositeside.
Assembly Instructions Cont.
Slide Lock
HEIGHT ADJUSTMENT
9. TheCompetitorbeddeckhastwoheightadjustments.
10. Adjustmentoneislocatedontheframeasindicatedbelow.Thereisahighpositionandalowposition.
11. Adjustmenttwoisonthelegoftheheadandfootboard.Toadjust,loosenthethumbscrewontheleg
andpullonthespringloadedknobwithonehandandslidethelegtothedesiredheightwiththeotherhand.
Oncethedesiredpositionisfound,turnthethumbscrewuntiltight.Adjustotherlegstothesameposition.
8
REV3.1.23.14
Assembly Instructions Cont.
End Method A
Thechartbelowindicatestheheightadjustmentsastheyrelatetothetwoadjustmentoptions.
*Rails cannot be used at this height.
Deck Height Pins
Leg Holes
Upper
Lower
1- High
1- Medium
1-Low
Deck Height (inches) Deck Height Pins Leg Hole Wheels
11* Lower Low No
13.125 Upper Low No
14 Lower Low Yes
14.152 Lower Middle No
16.125 Upper Low Yes
16.25 Upper Middle No
17.152 Lower Middle Yes
17.875 Lower High No
19.25 Upper Middle Yes
20 Upper High No
20.875 Lower High Yes
23 Upper High Yes
9
End Method A
Method B
Installation of the motor from underneath the frame
B2. Repeat for the other side.
Assembly Instructions Cont.
Deck Height Pins
Leg Holes
Upper
Lower
1- High
1- Medium
1-Low
B1. Attached head a foot board to frame.
10
REV3.1.23.14
Assembly Instructions Cont.
B4.Removethecoversfromthemotorandplaceunderthebedandalignedwiththeactuatorunderthehead
section. There are labels on the motor that provide direction and placement in relation to the head section.
B5.Withbothhands,liftthemotorandinsertintotheactuatorandframeasshown.Withthepalmofyour
handsnapthemotorushtoactuatorbar.
B3. Priortoinstallation,makesurethatthe2whitemotorblocksareintheretractedposition.
CORRECT INCORRECT
11
Assembly Instructions Cont.
B6. Once in place, replace the motor covers to secure the motor.
End Method B
12
REV3.1.23.14
Assembly Instructions Cont.
Oncethedesiredpositionisfound,turnthethumbscrewuntiltight.Adjustotherlegstothesameposition.
12. Adjustmenttwoisonthelegoftheheadandfootboard.Toadjust,loosenthethumbscrewontheleg
andpullonthespringloadedknobwithonehandandslidethelegtothedesiredheightwiththeother
hand.
13
Assembly Instructions Cont.
Thechartbelowindicatestheheightadjustmentsastheyrelatetothetwoadjustmentoptions.
*Rails cannot be used at this height.
Deck Height (inches) Deck Height Pins Leg Hole Wheels
11* Lower Low No
13.125 Upper Low No
14 Lower Low Yes
14.152 Lower Middle No
16.125 Upper Low Yes
16.25 Upper Middle No
17.152 Lower Middle Yes
17.875 Lower High No
19.25 Upper Middle Yes
20 Upper High No
20.875 Lower High Yes
23 Upper High Yes
HEIGHT ADJUSTMENT
13. TheCompetitorbeddeckhastwoheightadjustments.
13A. Adjustmentoneislocatedontheframeasindicatedbelow.Thereisahighpositionandalowposition.
14
REV3.1.23.14
Assembly Instructions Cont.
14.TheCompetitorbedcomeswithacasteraccessory(soldseparately,model#15044SET).Toinstallthe
casters,insertthestemofthecasterintothelegreceptacleasshown.Itisrecommendedtoinstall1
non-lockingcasteroneachbedend.Thelockingcastersshouldbeinstalleddiagonallyfromeachother.
15
15. Toinstallbedrails,lifttheheadsectionandndtherailreceptaclelocatedontheframeofthebedasshown.
Assembly Instructions Cont.
16. Pullreceptacleoutwardandreturnheadsectiontotheatposition.
17. Turn the receptacle in order to receive the rail. Repeat for all four rail receptacles.
16
REV3.1.23.14
Assembly Instructions Cont.
18. Insert the bed rail into the receptacle. Repeat for the other rail.
NOTE: The competitor bed can be used with a free standing trapeze or a Drive Medical frame
mounted trapeze (Item # 15560TRAPEZE). A trapeze cannot be mounted on the Competitor head
board.
17
Driverecommendsthefollowingmaintenanceandcleaningproceduresbeconductedbetweenusers.
ELECTRONICS
• Checkallcontrolstomakesureallfunctionsworkproperly.
• Foot control
• Head control
• Checkallcablesfordamagedorfrayedwires.
• Powercord
• Pendant cord
• Checktomakesureallplugsarefullyinsertedorattached.
• Check9Vbatteryonmotorandhandcontrolandreplaceannually.
BED FRAME & SLEEPING SURFACE
• Visuallycheckallwelds.
• Head section
• Foot section
• Main Frame
• Checkjointsbetweensleepingsurfacesectionsforloosefasteners.
CLEANING
• Themetalpartsofthebedarecoveredwithapowdercoating.Thebedcanbepowerwashed.
Cleanallcoatedpartswithmilddetergentandwarmwater.Periodicallyraiseheadandfeet
sectionsofthebedandremovedustfromframe.Also,periodicallyremovemattressandclean
mattress deck.
WARRANTY
• Lifetimewarrantyonwelds.
• 5yearwarrantyonframe.
• 5yearwarrantyonmotor.
• 5yearonhandcontrol.
• 1yearwarrantyonallotherpartsandcomponents.
Duringthewarrantyperiod,defectiveitemswillbereplacedatDrive’soptionatnocharge.
Maintenance & Safety Checks
18
REV3.1.23.14
99 Seaview Boulevard
Port Washington, NY 11050
Phone: 516-998-4600
Toll Free: 877.224.0946
Fax: 516.998.4601
www.drivemedical.com
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18

Drive Medical Design 15560 User manual

Drive Medical Design
Brand
Drive Medical Design
Model
15560
Type
User manual
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents