Bobrick B-4063 Installation guide

In the U.S.A.: BOBRICK WASHROOM EQUIPMENT, INC.

#OMMERCE$RIVE#LIFTON0ARK.EW9ORKs4ELs&!8

(ART3TREET.ORTH(OLLYWOOD#ALIFORNIAs4ELs&!8

In Canada: BOBRICK WASHROOM EQUIPMENT COMPANY

2OLARK$RIVE3CARBOROUGH/NTARIO-2"s/NTARIO%AST4ELs&!8

s-ANITOBA7EST4ELs&!8

©"OBRICK7ASHROOM%QUIPMENT)NC

&ORM.OR0RINTEDIN53!

INSTRUCTIONS FOR INSTALLATION AND MAINTENANCE

Bobrick ConturaSeries

Model B-4063 Recessed Soap Dispenser

INSTALLATION:

5NITISTOBEMOUNTEDINROUGHWALLOPENINGggWIDEXggHIGHXMM-INIMUMRECESSEDDEPTHTOlNISHFACEOFWALLISgg

MM2ECESSEDMOUNTINGBOXISSECUREDWITHFOURXMMSHEETMETALSCREWSNOTFURNISHEDAND"OB+EY

 5NLATCHUNITWITH"OB+EYPROVIDEDBYINSERTINGENDOFKEYINTOSLOTINDOORFACE4ILT"OB+EYUPSOTHATLATCHINGMECHANISMDISENGAGESSOAP

DRAWERANDTILTTOPOFDRAWERFORWARD,IFTDRAWERSLIGHTLYANDPULLDRAWERWHILE"OB+EYISTILTEDUP3LIDEDRAWEROUTUNTILANGLEBRACKETSAT

REAROFSOAPVESSELSTOPAGAINSTDRAWERSTOPS

 4ILTDRAWERUPTOREMOVEFROMMOUNTINGBOX

 0LACEMOUNTINGBOXINWALLOPENINGANDSECURETOFRAMINGWITHMOUNTINGSCREWS

 ./4%5NITISTOBEMOUNTEDWITHTHESOAPVALVEOVERASINKORLAVATORY3PACERSHIMSSHOULDBEUSEDBETWEENMOUNTINGBOXANDFRAMED

WALLOPENINGTOPREVENTDISTORTIONORDAMAGETOCABINETWHENMOUNTINGSCREWSARETIGHTENED

 2EPLACESOAPDRAWERINMOUNTINGBOXANDPUSHBOTTOMOFDRAWERCLOSEDlRSTTHENPUSHTOPOFDRAWERFULLYCLOSEDTOLATCH9OUMAYNEEDTO

MOVEDRAWERSIDETOSIDESLIGHTLYASYOUARECLOSINGTHETOPOFTHEDRAWERTOENABLEITTOENGAGEPROPERLY

MAINTENANCE:

 5NLATCHUNITANDOPENDRAWERUNTILITISSTOPPEDAGAINSTDRAWERSTOPSASDESCRIBEDABOVE

 ./4%)TISNOTNECESSARYTOREMOVEDRAWERFROMMOUNTINGBOXFORRElLLING&ORMAINTENANCEANDCLEANINGPURPOSESTILTDRAWERUPWARDTO

REMOVEITFROMMOUNTINGBOX

 2EMOVEREDPLASTICLIDFROMSOAPVESSELANDlLLWITHSOAPCorrosion-resistant valve dispenses commercially marketed all-purpose

hand soaps.2EPLACEPLASTICLIDONSOAPVESSEL#LOSEDOORFULLYTOLATCH

 #LEANEQUIPMENTOPERATESBETTERLASTSLONGERANDREQUIRESLESSMAINTENANCE7IPETHEUNITDAILYINCLUDINGTHESPOUTUSINGADAMPCLOTH

Never use abrasive cleaners.

 0ERIODICALLYCLEANTHEDISPENSERBYPUMPINGWARMWATERMIXEDWITHSOAPFROMTHEDISPENSERTHROUGHTHEVESSELANDVALVETOmUSHOUT

CONTAMINANTSORDRIEDSOAPRESIDUENever use abrasive cleaners.

 )FTHESOAPVALVEFAILSTOOPERATESATISFACTORILYTHEPROBLEMMAYBECAUSEDBYDRIEDSOAPORDIRTCLOGGINGTHESPOUTORTHESOAPVALVE

4/2%-%$9#LEANSPOUTWITHENDOF"OB+EYANDORmUSHTHEDISPENSERASDESCRIBEDABOVE

 $O NOT DISASSEMBLE THE SOAP VALVE ./4% )F FOR ANY REASON THE VALVE BECOMES NONFUNCTIONAL A NEW SOAP VALVE REPLACEMENT KIT

0ART.OMUSTBEORDERED

7-1/4''

185mm

1/4''

6mm

Ty p.

Window

Stainless Steel

Faceplate

Push Button

Valve

6-3/8''

160mm

5-3/4''

145mm

Recessed Cabinet

Finish Face of Wall

7/8''

22mm

3-7/8''

100mm

3-1/2''

90mm

Ty p.

5-3/8''

135mm

1-7/8''

50mm

Ty p.

1-1/2''

40mm

1/8''

3mm

Latch Release

Recommended Mounting Height Off Floor

For Universal / Barrier-Free Design

49" 1245mm

Rough Wall Opening

MMWIDE

MMHIGH

MMMINIMUM

RECESSEDDEPTH

QA033011

VALVE REPLACEMENT INSTRUCTIONS

TO REMOVE VALVE:

 5NLATCHUNITANDOPENDRAWERFROMMOUNTINGBRACKETASDESCRIBEDININSTALLATIONINSTRUCTIONS

 2EMOVEREDPLASTICLIDANDEMPTYSOAPVESSEL

 0LACEMMCLOSEDENDWRENCHPROVIDEDINSIDESOAPCONTAINERANDOVERTHELARGECOLLARNUTATREAROFSOAPVALVEANDLOOSENUNTILFACE

OFVALVECANROTATE

 7HILEHOLDINGTHECOLLARNUTINPLACEWITHTHEWRENCHUNSCREWSOAPVALVEFROMTHEFRONTOFTHEUNITBYROTATINGCOUNTERCLOCKWISE

TO INSTALL VALVE:

! /.5.)437)4(2/5.$(/,%).3/!0#/.4!).%2

 0ULLBACKmATRUBBERWASHERATREAROFSOAPVALVEFACETOEXPOSE

THETWOPLASTICTABS

 #UTPLASTICTABSOFFREAROFSOAPVALVEFACEmUSHWITHINDICATED

SURFACESEE&IGURE

 -OVEmATRUBBERWASHERBACKTOITSINITIALPOSITION-AKESUREmAT

EDGEOFWASHERISEVENWITHTOPOFVALVEFACE

 (OLDTHECOLLARNUTWITHTHEMMCLOSEDENDWRENCH-AKE

SURETHENOTCHINTHECOLLARNUTISFACINGTOWARDTHEFRONTOFTHE

DISPENSERANDPOSITIONNUTBEHINDSOAPVALVEHOLEINSIDEDISPENSER

 3CREWNEWSOAPVALVEINTOCOLLARNUTCLOCKWISEUNTILREAROFVALVE

FACEHITSTHEFRONTOFTHESOAPCONTAINER

 0USHTHESOAPVALVEINTOTHERECTANGULARRECESSINTHEFACEOFTHESOAPCONTAINERWITHSPOUTFACINGDOWNWARD

 4IGHTENCOLLARNUTWITHWRENCHUNTILTIGHTENOUGHSOTHATVALVEWILLNOTLEAKAROUNDSEALATFRONTOFUNIT

" /.5.)437)4(315!2%4/06!,6%(/,%).3/!0#/.4!).%2

 (OLDTHECOLLARNUTWITHTHEMMCLOSEDENDWRENCH-AKESURETHENOTCHINTHECOLLARNUTISFACINGTOWARDTHEFRONTOFTHEDISPENSER

ANDPOSITIONNUTBEHINDSOAPVALVEHOLEINSIDEDISPENSER

 3CREWNEWSOAPVALVEINTOCOLLARNUTCLOCKWISEUNTILREAROFVALVEFACEHITSTHEFRONTOFTHESOAPCONTAINER

 0USHTHESOAPVALVEINTOTHERECTANGULARRECESSINTHEFACEOFTHESOAPCONTAINERWITHSPOUTFACINGDOWNWARD

 4IGHTENCOLLARNUTWITHWRENCHUNTILTIGHTENOUGHSOTHATVALVEWILLNOTLEAKAROUNDSEALATFRONTOFUNIT

REFILL-INDICATOR WINDOW REPLACEMENT INSTRUCTIONS SEE&IGURE:

 5NLATCHUNITANDREMOVEDRAWERFROMMOUNTINGBOXASDESCRIBEDININSTALLATIONINSTRUCTIONS

 2EMOVEREDPLASTICLIDANDEMPTYSOAPVESSEL

 2EMOVECOLLARNUTFROMBACKOFRElLLINDICATORWINDOWINSIDEOFVESSELUSINGPLIERSORMMCLOSEDENDWRENCH

 2EMOVERElLLINDICATORWINDOWANDSEALFROMFACEOFDRAWER

 !SSEMBLENEWRElLLINDICATORWINDOWANDSEALTOFACEOFDRAWERBYREVERSINGABOVEPROCEDURE#OLLARNUTISTOBETIGHTENEDSO 

THATWINDOWWILLNOTLEAKAROUNDSEALATFRONTOFUNIT

INSTRUCTIONS FOR INSTALLATION AND MAINTENANCE

Bobrick ConturaSeries

Model B-4063 Recessed Soap Dispenser

PART NAME PART NO.

6ALVE2EPLACEMENT+IT 

#OLLAR.UTFOR6ALVE 

2ElLL)NDICATOR7INDOWWITH.UT 

#OLLAR.UTFOR7INDOW 

2ED0LASTIC,ID 

"OB+EY 

REPLACEMENT PARTS LIST

Plastic Tabs

to be Cut Off

Flush with this Surface

Plastic Tab (2)

Flat Rubber Washer

(moved back to

expose plastic tabs)

Latch Angle

Mounting Box

4063-83

4063-181

BobKey Slot

Angle Brackets

4112-79

305-127

4112-19

4063-48

Drawer Stops

24-17

Mounting

Screws (4)

FIGURE 1

FIGURE 2

Bobrick B-4063 Installation guide

Related papers

Other documents