Secure Remote Controller

SKYCATCH Secure Remote Controller User manual

  • Hello! I've reviewed the user manual for the Skycatch Battery, Secure Controller and Explore2 aircraft. I understand the instructions for battery installation, pairing, and heating, as well as the remote controller operations. I am also familiar with RTK, expansion ports and protection rating of the device. Feel free to ask me any questions you may have about this equipment.
  • How do I turn on the battery?
    How can I heat the battery manually?
    What does the battery level indicator show when battery is turned off?
    How can I use Custom Network RTK?
    What is the IP rating of the Aircraft?
Installing the Batteries
1. TheperformanceoftheFlightBatteryissignificantlyreducedwhenflyinginlowtemperature
environments(temperaturesbelow5℃).Ensurethatthebatteryisfullychargedandthecellvoltage is
at4.4Vbeforeeachflight.
2. Endtheflightassoonasthe appdisplaysthe“LowBatteryLevelWarning”inlowtemperature
environments.Youwillstillbeabletocontroltheaircraft’smovementwhenthiswarningistriggered.
3. Inextremelycoldweather,thebatterytemperaturemaynotbehighenoughevenafterwarmingup.In
Pairing Batteries
Beforerstuse,itisrecommendedtomark2batteriesasapairandcontinueusingthemasapair(charge
anddischargethemtogether)tomaximizeservicelifeandensureightperformance.Iftwobatteries
withasignicantdierenceinbatterylifeareinstalledandpoweredon,apromptwillpopupintheapp
torecommendthatyoureplacethebatteriestoapairwithsimilarperformance.
Turning On / O
Thebatterycanonlybeturnedonandoffafteritisinstalledonthe
aircraft.
TurningOn:PressthePowerbuttononce,thenpressagainandholdfor3
secondstoturnon.ThePowerLEDwillturngreenandtheBatteryLevel
Indicatorswilldisplaythecurrentbatterylevel.
TurningO:PressthePowerbuttononce,thenpressagainandholdfor
3secondstoturno.ThePowerLEDandtheBatteryLevelIndicatorswill
beo.
Replacing the Batteries When Turned On
Ifthebatteryneedstobereplacedimmediatelyafterlanding,youcanreplaceitwithoutturningoff
theaircraft.Replacewithonefullychargedbattery,andwaitfor3seconds,andthenreplaceanother
battery.
Heating the Battery
ManualHeating:IftheFlightBatteryisnotinstalledintotheaircraft,pressandholdthebatterylevel
buttononthebatteryforfoursecondstoinitiatetheself-heating,keepingthebatteriesatatemperature
between 61° F (16° C) and 68° F (20° C), which is the ideal range of operating temperature, for
approximately30minutes.Pressandholdthebatterylevelbuttonfortwosecondstostopheating.
AutoHeating:Insert the batteries into the aircraftandpoweriton.Ifalowbatterytemperatureis
detected,thebatterywillautomaticallyheatupto maintain atemperaturebetween 61° F (16° C)and
68°F(20°C).
LowTemperatureNotice:
34
Confidential
Do not publish
thesecases,insulatethebatteryasrequired.
4. Toensureoptimalperformanceofthebattery,keepthebatterytemperatureabove16℃.
5. Inlowtemperatureenvironments,itwilltakealongertimeforthebatteriestowarmup.Itis
recommendedtokeepthebatterywarmbeforeusetoreducethewarm-uptime.
Checking Battery Levels
Whenthebatteryisturnedo,presstheBatteryLevelbuttononceandtheBatteryLevelIndicatorswill
displaythecurrentbatterylevel.
Low
High
BatteryLevel Indicatorsdisplayhowmuchpowerremains.When the batteryisturnedo,pressthe
PowerbuttononceandtheBatteryLevelIndicatorswilldisplaythecurrentbatterylevel.Seebelowfor
details.
TheBatteryLevelIndicatorswillalsoshowthecurrentbatterylevelduringdischarging.The
indicatorsaredenedbelow.
:LEDison.   :LEDiso.   :LEDisashing.
Battery Level
LED1 LED2 LED3 LED4 Battery Level
88%~100%
75%~88%
63%~75%
50%~63%
38%~50%
25%~38%
13%~25%
0%~13%
35
Confidential
Do not publish
RTK
Introduction
Theaircrafthasabuilt-inRTK,whichcanwithstandmagneticinterferencefrommetalstructures,
ensuringstableflight.
Enable / Disable RTK
Ensurethatthe“AircraftRTK”isenabledandRTKservicetypeiscorrectlysetbeforeeachuse.
Using the Custom Network RTK
Youcanmount a Dongle to the remotecontrollerorusetheapptoconnecttoaWi-Fi,and enable
InternetnetworktousetheCustomNetworkRTK. Custom Network RTKcanbeusedtoreplacethe
RTKbasestation.ConnecttheCustomNetworkRTKaccountto thedesignatedNtripservertosend
andreceivedierentialdata.KeeptheremotecontrollerturnedonandtheInternetnetworkconnected.
1. Makesuretheremotecontrollerandtheaircraftarelinked,andtheappisconnectedtotheInternet
network.
2. GotoCameraViewintheapp> >RTK,selecttheRTKservicetypeas“CustomNetworkRTK”,
llintheNtrip’shost,port,account,password,mountpoint,andthentap to set by followingthe
instructions.
3. WaittoconnecttotheNtripserver.IntheRTKSettingspage,thestatusoftheaircraft’spositioningin
thestatustablewillshow“FIX”toindicatethattheaircrafthasobtainedandusedthedierentialdata
fromthemobilestation.
36
Confidential
Do not publish
ADS-B Sensor
Airplanes and helicopters with an ADS-B transceiver will actively broadcast flight information
includinglocation,flightpath,speed,andaltitude.ADS_B sensorreceivesthisbyADS-Btransceivers
via an on-board receiver or internet connection. UAVs installed ADS-B sensorcan obtain the
position, orientationandvelocityinformationfrom the mannedairplanebuilt-inADS-B transmitter
(1090 ES and UAT standard supported), calculate the collision risk level real time and display the
warningtouser.Thesystemwillanalyzethepotentialriskofcollisionbycomparingthelocationofan
airplaneorahelicopter,displayingtimelywarningstopilotsviatheDJIPilotapp.
ADS-B sensorprovidesuserswithinformationaboutnearbyairplanesandhelicopterstoensureflight
safety.Thesystemdoesn’tactivelycontrolthedronetoavoidincomingairplanesorhelicopters.Always
fly your aircraft within a visual line of sight and be cautious at all times. Lower your altitude when
youreceivewarnings.PleasebeawarethatADS-B sensor hasthefollowinglimitations:
1. ItcanonlyreceivemessagessentbyairplanesandhelicoptersinstalledwithanADS-Boutdevice
andinaccordancewith1090ES(RTCADO-260)orUAT(RTCADo-282)standards.Skycatch
devices willnotreceiverelatedbroadcastmessagesordisplaywarningsforairplanesorhelicopters
without ADS-BoutsorwithmalfunctioningADS-Bouts.
2. IfthereisanobstacleorsteelstructurebetweenairplanesorhelicoptersandSkycatchaircraft,the
system won’tbeabletoreceiveADS-Bmessagessentbyairplanesorhelicoptersordisplay
warnings. Keenlyobserveyoursurroundingsandflywithcaution.
3. WarningsmaybesentwithdelaywhentheADS-B sensor isinterferedbythesurrounding.
Keenly observeyoursurroundingsandflywithcaution.
4. Warningsarenotsentwhentheaircraftisunabletodetermineitslocation.
5. ItcannotreceiveADS-Bmessagessentbyairplanesorhelicoptersordisplaywarningswhen
disabledormisconfigured.
On the precondition that connection between the aircraft and the pilot remote controller is stable,
whenthesystemconfirmsthepossibilityofacollision,itwilldisplayaseriesofwarningsbasedonthe
distancebetween droneandairplanesorhelicopters.Werecommendedthattheoperatordescend
altitudeimmediatelyafterthefirstwarningtoavoidacollision,choosinganotherflightpathwhere
necessary.
WarningEscalation:
Therst(or"lowest")levelwarningoccurswhenthemannedaircraftisdetected.Alldetectedaircraftwill
bedisplayedintheapp(upto10aircraftatatime).Pleasepayattentiontoensureightsafety.
Thesecond(or“middle”)levelwarningoccurstwokilometersawayfromthemannedaircraft.
Pleasepayattentiontoavoidanyhazards.
Thethird(or“highest”)levelwarningoccursonekilometerawayfromthemannedaircraft.Pleaseavoid
themannedaircraftimmediately.
37
Confidential
Do not publish
IP45 Protection Rating
Understablelaboratoryconditions,theExplore2achievesanIP45protectionratingbyIEC60529
standardswhenequippedwithFlightBatteries.However,thisprotectionratingisnot
permanentandmayreduceovertimeafterlong-termuse.
DONOTywhentheamountofrainfallexceeds100mm/24h.
DONOTfoldtheframearmsintherain.
Makesurethebatteryports,batterycompartmentports,batterysurfaces,andbatterycompartment
surfacesaredrybeforeinsertingthebatteries.
Makesurethebatteryportsandbatterysurfacesarefreefromanyliquidbeforechargingthebatteries.
Beforepackingtheaircraftintothecarryingcase,ensurethat it is freefromanyliquidbywipingit
carefully.
Productwarrantydoesnotcoverwaterdamage.
TheaircraftdoesnotachieveIP45protectionratinginthefollowingcircumstances:
Foldedframearms.
YouusebatteriesotherthanFlightBatteries.
Thecoverfortheportsarenotattachedcorrectly.
Thewaterproongtopshellplugisnotrmlyattachedtothetopshell.
Theaircraftisbrokenduetovariousreasons,suchasbrokenaircraftshell,failureofthewaterproof
adhesive, etc.
Expansion Ports
TheExplore2 offersseveralSDK expansionportson the top and bottomof the aircraft.These
expansionportsenabledeveloperstoexploremorepossibilitiesandfunctionswiththeaircraft.
Bottom viewTop view
Explore2supportsthreepayload SDKportsandoneonboard SDKport.Theexternal
powersupplycapacityof the payload SDKport is17.0 V / 13.6 V4 A. The external power
supplycapacityofonboard SDKportis24V4A.ThesefourSDKportsincorporateapower
limitof180W.
38
Confidential
Do not publish
Remote Controller
This section describes the features of the
remote controller that includes aircraft
and remote controller operations.
39
Confidential
Do not publish
Remote Controller
Profile
TheSkycatch Secure Controller(hereinafterreferredtoasSecure Controller”)features
radiotechnology,capableofcontrollingaircraftthatsupportsthistechnology,andprovidingaliveHDview
fromtheaircraft'scamera.Itcantransmitimagedataatdistancesofupto9.32mi(15km)andcomeswith
anumberofaircraftandgimbalcontrolsaswellassomecustomizablebuttons.*
Thebuilt-in 5.5-inch highbrightness1000cd/m²screenhas a resolutionof1920×1080pixels,featuring
anAndroidsystemwithmultiplefunctionssuchasBluetoothandGNSS.InadditiontosupportingWi-Fi
connectivity,itisalsocompatiblewithothermobiledevicesformoreflexibleusage.TheSecure Controller
hasamaximumworkingtimeof2.5hourswiththebuilt-inbattery.WhenusingtheRCBattery,the
maximumworkingtimecanbeextendedto4.5hours.**
*The Secure Controller canreach maximumtransmissiondistance (FCC) inanunobstructed areawithno
electromagneticinterferenceatanaltitudeofabout400feet(120meters).Theactualmaximumtransmission
distancemaybelessthanthedistancementionedaboveduetointerferenceintheoperatingenvironment,and
theactualvaluewilluctuateaccordingtothestrengthofinterference.
** Maximumoperatingtimeisestimatedinalabenvironmentatroomtemperature,forreferenceonly.Whenthe
Secure Controllerispoweringotherdevices,theruntimewillbereduced.
Compliance Standards: Theremotecontrolleriscompliantwithlocallawsandregulations.
Stick Mode: ControlscanbesettoMode1,Mode2,ortoacustommode.
DoNOToperatemorethanthreeaircraftswithinthesamearea(roughlythesizeofasoccer
eld)topreventtransmissioninterference.
Preparing the Remote Controller
Charging
Charging the Remote Controller
Whenturnedoff(usingthestandardUSBchargeratroomtemperature),ittakesapproximately2
hoursand15minutestofullychargetheSecure Controller.
PowerOutlet
(100-240V) USBCharger USB-CCable
PleaseusetheofficialUSBChargertochargetheSecure Controller.Whenastandard
USBChargerisnotavailable,itisrecommendedtouseanFCC/CEcertifiedUSBpower
adapterrated12V/2A.
Pleaserechargethebatteryatleasteverythreemonthstopreventoverdischarging-the
batterywilldepletewhenstoredforanextendedperiod.
40
Confidential
Do not publish
External Battery
1. ConnecttheCharging Stationtoapoweroutlet(100-120Vac,50-60Hz/220-240Vac,50-60Hz).
2. PressthePowerButtononcetoturnontheCharging Station.
3. InsertthebatteriesintotheBatteryPortstostartcharging.TheCharging Stationwillchargethe
battery withthehighestremainingbatterypowerfirst.
Power Outlet
2
1
3
Mounting the RC Battery
1Pressandholdthebatteryreleasebutton.
2InserttheBatteryintothebatterycompartment.Makesurethebottomofthebatteryis
alignedtothemarkinglineinthecompartment.
3Pushthebatterytothebottom.
ToremovetheBattery,pressandholdthebatteryreleasebutton,thenpushthebattery
upward.
Mounting the 4G Dongle and SIM Card
Onlyuseaapproveddongle.
ThedongleandSIMcardenabletheSecure Controllertoaccess4Gnetwork.Makesure
todeploythesecorrectly,otherwise,networkaccesswillnotbeavailable.
ThedongleandSIMcardareexcluded.
41
Confidential
Do not publish
Removethedonglecompartmentcover.
InsertthedongleintotheUSBportwiththeSIM cardinsertedintothe
dongle.
Reattachthecoverrmly.
Adjusting the Antennas
Lifttheantennasandadjustthem.ThestrengthoftheSecure Controller
signalisaffectedbythepositionoftheantennas.Whenthe
anglebetweentheantennasandthebackoftheSecure Controlleris
80° or 180°, the connection between the Secure Controller and
aircraftcanreachitsoptimalperformance.
Installing Other Mobile Devices
Forothermobiledevices(e.g.iPhones,iPads),theScreenMountingBracketandanappropriateUSB
cablearerequired.
Mounting the Screen Mounting Bracket
42
Confidential
Do not publish
/