16776
USE THIS MANUAL FOR YOUR EXTENDED STATESMAN.
Call Us First!
DO NOT RETURN TO STORE.
For immediate help with assembly or product information
call our toll free number:
1-800-577-9663
or email:
Our staff is ready to provide assistance
April through October M-F 8:00 AM to 6:00 PM EST
Saturday 8:30 AM to 4:30 PM EST
November through March M - F 8:00 AM to 5:00 PM EST
STOP!
STOP!
(This page intentionally left blank.)
BEFORE YOU BEGIN
IMPORTANT!
READ INSTRUCTIONS THOROUGHLY PRIOR TO BEGINNING ASSEMBLY.
- CUSTOMER SERVICE -
Call: 1-800-577-9663 email: [email protected]
before building.
Contact our Customer Service Team if engineered drawings are needed to pull local permits.
To ensure proper assembly you must build your shed on a level surface. Recommended methods and materials to level your
shed are listed on page 12.
Inventory all parts listed on pages 5 - 9. Contact our Customer Service Team if any parts are missing or damaged.
CLASSIC STATESMAN GABLE 12' x 12' (304,8 x 365,8 cm)
ASSEMBLY MANUAL
16776 06-04-2013
A BACKYARD PRODUCTS COMPANY
KEEP THIS MANUAL FOR FUTURE REFERENCE
BUILDING SIZE ACTUAL FLOOR SIZE
12' x 12' (365,8 x 365,8 cm) 12' x 12' (365,8 x 365,8 cm)
BASE MODEL
12' x 16' (365,8 x 487,7 cm) 12' x 16' (365,8 x 487,7 cm)
ADD ONE 12' x 4'
12' x 20' (365,8 x 609,6 cm) 12' x 20' (365,8 x 609,6 cm)
12' x 24' (365,8 x 731,6 cm) 12' x 24' (365,8 x 731,6 cm)
ADD ONE 12' x 8'
ADD ONE 12' x 4' AND ONE 12' x 8'
2
TOOLS
Safety! Always use approved safety glasses during assembly.
Optional
HELPFUL REMINDER SYMBOLS
Look for these symbols for helpful reminders throughout this manual.
ORIENT LUMBER AND TRIM FOR BEST APPEARANCE
= Helpful assembly hint.
= Mark part with pencil.
= Beginning of steps for assembly or installation.
= Level
❑ Gloves
Framing lumber is graded for structural strength and not appearance. Exterior trim is graded for one good side.
Always install the material leaving the best edge and best surface visible. Please remember that these blemishes in no way
negatively affect the strength or integrity of our product. (See Fig. A, B, C.)
A
❑ Safety Glasses
❑ Tape Measure
❑ Paint Tools
❑ Ladder
❑ Caulk Gun
❑ Hammer
❑ Level
BEGIN
❑ Pencil
❑ Phillips
Screwdriver
❑
❑
❑
❑ #2 Philips Drive Bit
❑
Nail Pouch
❑ Chalk Line
❑ Nail Gun
❑ Tin Snips
(for drip edge)
❑
or
❑ Utility Knife
❑ Shingle Blades
C
❑ WoodGlue
❑ Sawsall
3
FOUNDATION OR FLOOR MATERIALS
ADDITIONAL MATERIALS
REINFORCED WOOD FLOOR FRAME (OPTIONAL)
(shown below as shaded). Below is a list of additional materials (not included):
x4
x36
12x16'
x5
x30
12x20'
x6
x36
12x24'
x3
x18
12x12'
4
ADDITIONAL MATERIALS
COMPLETING YOUR SHED
You will need these additional materials:
OPTIONAL MATERIALS
Use 100% acrylic latex exterior paint.
For shingles.
Use 100% acrylic latex exterior paint.
Use acrylic latex exterior caulk that is paintable.
7
2½
2
12x12'
10
3
3
12x16'
12x12'
12x16' 12x20' 12x24'
(2) coats recommended.
60'
184'
¼
70'
245'
¼
80' 90'
306' 365'
½ ¾
x1
x1
x2
x2
x4
x6
FLOOR PANELS (Not Included)
12x20'
12x24'
12x12'
12x16'
(1,6 x 121,9 x121,9 cm)
x1
(1,6 x 121,9 x121,9 cm)
x1
(1,6 x 121,9 x121,9 cm)
x2
x7
x8
12x20'
12
3
4
12x24'
13
4
5
5
PARTS IDENTIFICATION AND SIZES
is stamped on some parts.
1" x 4".................3/4" x 3-1/2" (1,9 x 8,9 cm)
2" x 4"..............1-1/2" x 3-1/2" (3,8 x 8,9 cm)
2" x 3"..............1-1/2" x 2-1/2" (3,8 x 6,3 cm)
1" x 3".................3/4" x 2-1/2" (3,8 x 6,3 cm)
RS
RS
DOOR RAFTERSTRIM WALL
x12
GABLE 12' X 12' PARTS LIST
x1
12x12'
x5
x5
SP
x2
AS
x6
x1
AM
x2
x23
x6
x4
TP
x2
TP
x2
x14
x2
x2
x4
x4
,1 x 10,2 x 101,6 cm)
x2
,1 x 10,2 x 46 cm)
x4
AF
x1
OO
x2
x2
x2
x2
x1
x1
(1,9 cm)
6
WALL PANEL & DOORS PARTS LIST
x2 x9
x1
x1
x1x1
(1 x 121,9 x 213,4 cm)
(1 x 60,7 x 213,4 cm)
GABLE PANELS
x2 x1 x1 x2
(1 x 59,9 x 121,9 cm)
(1 x 59,9 x 121,9 cm)
121,9 cm)
121,9 cm)
ROOF PANELS
x2 x2x2 x2
(92,7 x 121,9 cm)
(121,6 x 121,9 cm)
LOFT PARTS LIST
121,9 cm) cm)
121,9 cm) cm)
x1
x2
x1
x2
x1 x1
SP
PT
TP
7
x2
x4
x12
x12
x1
x11
x2
Other HARDWARE (Not Actual Size)
FASTENER/HARDWARE BAG (Shown Actual Size)
x1
x2
x2
x4
(30,5 x 30,5 cm)
x1
SHELVING PARTS LIST
(5,1 x 7,6 x 25,4 cm)
(2,5 x 10,2 x 243,9 cm)
(1 x 7,6 x 32 cm)
(2,5 x 10,2 x 243,9 cm)
Shelf panels
x14 x2
x14 x2
x2 x2
AC
NAIL BOXES (Shown Actual Size)
12x12'
12x12'
12x16'
12x16'
12x20'
12x20'
12x24'
12x24'
110
4
6
83
62
23
74
110
5
7
91
88
23
74
110
5
7
110
6
8
99
94
23
74
107
105
23
74
PARTS IDENTIFICATION AND SIZES
RAFTERSTRIMWALL PANELSROOF PANELS WALL
GABLE 12' x 4' EXTENDER KIT PARTS LIST
1" x 4".................3/4" x 3-1/2" (1,9 x 8,9 cm)
2" x 4"..............1-1/2" x 3-1/2" (3,8 x 8,9 cm)
2" x 3"..............1-1/2" x 2-1/2" (3,8 x 6,3 cm)
1" x 3".................3/4" x 2-1/2" (3,8 x 6,3 cm)
12x4'
stamped on some parts.
RS
RS
x4
x2
SP
x4
x4
x1
TP
x4
x2
x2
(1 x 121,9 x 213,4 cm)
x2x2
(1,1 x 92,7 x 121,6 cm)
(1,1 x 121,6 x 121,9 cm)
9
PARTS IDENTIFICATION AND SIZES
RAFTERSTRIMWALL PANELSROOF PANELS WALL
GABLE 12' x 8' EXTENDER KIT PARTS LIST
1" x 4".................3/4" x 3-1/2" (1,9 x 8,9 cm)
2" x 4"..............1-1/2" x 3-1/2" (3,8 x 8,9 cm)
2" x 3"..............1-1/2" x 2-1/2" (3,8 x 6,3 cm)
1" x 3".................3/4" x 2-1/2" (3,8 x 6,3 cm)
12x8'
stamped on some parts.
RS
RS
x2
x8
x8
x8
TP
x8
x4
(1 x 121,9x 213,4 cm)
x2 x2
(1,1 x 121,9 x 243,9 cm)
(1,1 x 92,71 x 243,9 cm)
INSTRUCTION MANUAL LAYOUT
10
IF ALL TABS ARE DISPLAYED, FOLLOW ALL INSTRUCTIONS
REGARDLESS OF MODEL SIZE.
TABS ARE DISPLAYED AT THE OUTSIDE EGDE OF INSTRUCTION
PAGES TO IDENTIFY MODEL SIZE.
GABLE 12' x 12'
GABLE 12' x 12'
GABLE 12' x 12' :
R
O
O D
R
O O D
GABLE 12' x 16'
GABLE 12' x 16'
GABLE 12' x 16' :
R
O
OD
GABLE 12' x 20'
GABLE 12' x 20'
GABLE 12' x 20' :
ROOD
GABLE 12' x 24' :
RO
O
D
11
A
B
C
4"
(10,2 cm)
3-1/2"
(8,9 cm)
D
D
CONCRETE FOUNDATION
If you choose to install your kit on a concrete slab refer to the diagram below.
Attach the sill plates on the foundaton as shown, and continue on to page 12.
.
Treated Sill Plate
Caulk between
sill plate and
concrete.
A
C
x4
Caulk
x1
x2
x2
Caulk
x1
A
C
x2
x2
x1
Caulk
x2
A
C
x2
x2
x2
Caulk
x3
A
C
12
and 4x4 touch.
and under seams.
OPTIONAL WOOD FRAME FLOOR LEVELING OPTIONS
Leveling materials are not included in this kit.
PREFERRED METHOD - 4x4 TREATED RUNNERS (Typical for 12' x 12' Kit)
shingles in direct contact with ground.
x3
x3
x6
x6
Always support frame seams.
Asphalt Shingles
12' x 12'
12' x 16'
12' x 20'
12' x 24'
x60
x78
x96
x144
Fasteners for Frame to 4"x 4".
DOOR
12"
12"
Measurements to
centers of 4x4's.
Gravel
Gravel
4x4 Runner
Shingle
Shingle
Maximum between leveling
material locations.
2x4 Treated Lumber
Level
GABLE 12' x 12'
DOOR
1313
LEVEL AND SQUARE FLOOR FRAME
!
4x4 touch.
LEVELING & SQUARING A 12 x 12' FLOOR FRAME (Not Included)
Measurements to
centers of 4x4's.
5
BEGIN
2
3
4
1
measurement will be approximately .
at ends of each runner. At the opposite end of the frame, secure the frame to 4x4 runners with one
.
runners .
secure at
ends with
one fastener.
Fig. A
12"
60"
60"
12"
and under seams.
at ends with
one fastener.
GABLE 12' x 16'
1414
DOOR
LEVELING & SQUARING A 12 x 16' FLOOR FRAME (Not Included)
BEGIN
2
3
4
1
.
fastener at ends of each runner. At the opposite end of the frame, secure the frame to 4x4 runners
.
runners .
5
LEVEL AND SQUARE FLOOR FRAME
!
Fig. A
Measurements to
centers of 4x4's.
240"
240"
and 4x4 touch.
and under seams.
at ends with
one fastener.
at ends with one
fastener.
60"
60"
12"
12"
GABLE 12' x 20'
DOOR
1515
LEVELING & SQUARING A 12 x 20' FLOOR FRAME (Not Included)
Fig. A
and under seams.
Measurements to
centers of 4x4's.
BEGIN
2
3
4
1
.
fastener at ends of each runner. At the opposite end of the frame, secure the frame to 4x4 runners
.
runners .
5
LEVEL AND SQUARE FLOOR FRAME
!
and 4x4 touch.
at ends with
one fastener.
with one fastener.
60"
60"
12"
12"
DOOR
16
LEVELING & SQUARING A 12 x 24' FLOOR FRAME (Not Included)
Fig. A
and under seams.
Measurements to
centers of 4x4's.
322"
322"
BEGIN
2
3
4
1
.
fastener at ends of each runner. At the opposite end of the frame, secure the frame to 4x4 runners
.
runners .
5
LEVEL AND SQUARE FLOOR FRAME
!
and 4x4 touch.
at ends with
one fastener.
with one fastener.
60"
60"
12"
12"
GABLE 12' x 12' GABLE 12' x 16' GABLE 12' x 20'
17
IMPORTANT!
to avoid over-handling of the walls.
NOTE:
GABLE 12' x 12' GABLE 12' x 16' GABLE 12' x 20'
BACK WALL FRAME
x7
x2
x2
R
O O D
x32
SP
TP
(61 cm)
(61 cm)
(61 cm)
(121,9 cm)
(199,4 cm)
SP
TP
SP
TP
(121,9 cm)
1
BEGIN
Use two .
2
(121,9 cm)
(2)
Nails
(4)
Nails
(4)
Nails
(2)
Nails
Fig. A
Fig. A
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Heartland 192807 User manual
-
Heartland 80644 Assembly Manual
-
-
Backyard Products Heartland CLASSIC GENTRY GABLE 12' x 12' Installation guide
-
-
-
-
-
-
Other documents
-
Abba Patio APSSD814GW Installation guide
-
Handy Home Products 60757-8 User manual
-
-
-
-
-
-
-
Dietrich Metal Framing 182131 Installation guide
-
YardLine 16549 Owner's manual
