White Mountain Hearth Empire Cast Iron Stove Vent-Free ( VFD_CC) Owner's manual

Brand: White Mountain Hearth

Model: Empire Cast Iron Stove Vent-Free ( VFD_CC)

Category: Fireplaces

Type: Owner's manual

This manual is also suitable for

INSTALLATION INSTRUCTIONS

AND OWNER'S MANUAL

CAST IRON UNVENTED

ROOM HEATER MODELS:

SMALL

VFD(10,20)CC(30,70)

(B,F,M)(N,P)-1

MEDIUM

VFD30CC(30,70)

(B,F,M,S,W)(N,P)-1

GAS-FIRED

WARNING

FIRE OR EXPLOSION HAZARD

Failure to follow safety warnings exactly

could result in serious injury, death or

property damage.

— Do not store or use gasoline or other





— WHAT TO DO IF YOU SMELL GAS

 

 



 

 





 



 





INSTALLER:



CONSUMER:

Retain this manual for future reference.

WARNING

If not installed, operated and maintained

in accordance with the manufacturer's

instructions, this product could expose you



which can cause death or serious illness.



air (oxygen) from the room in which it is in-



      

to page 7.

WATER VAPOR: A BY-PRODUCT OF

UNVENTED ROOM HEATERS

-

-

proximately one (1) ounce (30ml) of water for



hour. Refer to page 6.

-

market, permanently located, manufactured



codes.

This appliance is only for use with the type

of gas indicated on the rating plate. This ap-



gases.

Page 1

31208-17-0120Page 2

SECTION PAGE

IMPORTANT SAFETY INFORMATION .................................................................................................... 3

SAFETY INFORMATION FOR USERS OF PROPANE GAS................................................................... 4

INTRODUCTION ...................................................................................................................................... 5

SPECIFICATIONS .................................................................................................................................... 6

WATER VAPOR: A BY-PRODUCT OF UNVENTED ROOM HEATERS ............................................... 6-7

GAS SUPPLY ........................................................................................................................................... 8

CLEARANCES ......................................................................................................................................... 9

LOG IDENTIFICATION .......................................................................................................................... 10

LOG PLACEMENT ............................................................................................................................ 11-18

PLACEMENT OF GLOWING EMBERS (ROCK WOOL) ....................................................................... 19

OPERATION INSTRUCTIONS/FLAME APPEARANCE ........................................................................ 19

OPERATING GUIDELINES .................................................................................................................... 20

MILLIVOLT LIGHTING INSTRUCTIONS ............................................................................................... 21

10,000 BTU MILLIVOLT LIGHTING INSTRUCTIONS ........................................................................... 22

PILOT FLAME CHARACTERISTICS ................................................................................................ 23-24

MILLIVOLT WIRING .......................................................................................................................... 25-26

MILLIVOLT TROUBLESHOOTING ................................................................................................... 27-28

IP OPERATING INSTRUCTIONS .......................................................................................................... 29

IP WIRING .............................................................................................................................................. 30

IP LIGHTING INSTRUCTIONS .............................................................................................................. 31

IP TROUBLESHOOTING .................................................................................................................. 32-34

MAIN BURNER FLAME CHARACTERISTICS ...................................................................................... 35

MAINTENANCE ..................................................................................................................................... 36

PARTS LIST - VFD10CC(30,70) ............................................................................................................ 37

PARTS VIEW - VFD10CC(30,70) .......................................................................................................... 38

PARTS LIST - VFD20CC(30,70) ............................................................................................................ 39

PARTS VIEW - VFD20CC(30,70) .......................................................................................................... 40

PARTS LIST - VFD30CC(30,70) ............................................................................................................ 41

PARTS VIEW - VFD30CC(30,70) .......................................................................................................... 42

CASTING PARTS LIST - VFD(10,20,30)CC(30,70) ............................................................................... 43

CASTING PARTS VIEW - VFD(10,20,30)CC(30,70) ............................................................................. 44

MASTER PARTS DISTRIBUTOR LIST .................................................................................................. 45

HOW TO ORDER REPAIR PARTS ........................................................................................................ 45

ACCESSORY SIDE SHELVES INSTALLATION INSTRUCTIONS ........................................................ 46

OPTIONAL STONE INLAY INSTALLATION INSTRUCTIONS ............................................................... 46

CIB4-1 OPTIONAL BLOWER INSTALLATION INSTRUCTIONS ..................................................... 47-48

CIB3-1 OPTIONAL BLOWER INSTALLATION INSTRUCTIONS ..................................................... 49-50

WARRANTY ........................................................................................................................................... 51

APPLIANCE SERVICE HISTORY ..................................................................................................... 52-53

QUICK REFERENCE GUIDE ........................................................................................................... 54-55

TABLE OF CONTENTS

31208-17-0120 Page 3

THIS IS A HEATING APPLIANCE

DO NOT OPERATE THIS APPLIANCE WITHOUT FRONT PANEL INSTALLED.

IMPORTANT SAFETY INFORMATION

DANGER: Indicates a hazardous situation which, if not avoided, will

result in death or serious injury.

WARNING: Indicates a hazardous situation which, if not avoided,

could result in death or serious injury.

CAUTION: Indicates a hazardous situation which, if not avoided,

could result in minor or moderate injury.

NOTICE: Addresses practices not related to personal injury.

 



 



 



 

         

ignition.

 

the same room with the appliance.

 

appliance.

           

fresheners, etc. ) while the log set is in operation. Air fresheners

produce a residue in the air similar to candles and may produce



 

set is in operation. Candles produce a residue in the air that









of soot produced and deposited.

  QUALIFIED SERVICE

PERSON. 







 

kept clean.

 



room heater and to replace any part of the control system and



 

 

operation.

      







off during initial operation of the appliance. This is a normal





 



      

installation or operation, can settle on surfaces outside the





         













        







WARNING: DO NOT operate this appliance unless all







Log set placement instructions for correct log and twig

positioning.

      

dealer as indicated in the How to Order Repair Parts section of

the appliance manual.

 





WARNING: Failure to keep the primary air opening(s) of the



WARNING



-

ous gas.

        

-





of instructions, refer to the National Fuel Gas Code, ANSI

     



    PILOT LIGHT SAFETY SYS-

TEM designed to turn off the heater if not enough fresh air



DO NOT TAMPER WITH PILOT LIGHT SAFETY SYSTEM!





control compartment clean.

CARBON MONOXIDE POISONING MAY LEAD TO DEATH.



        

     Get fresh air at



Some people — pregnant women, persons with heart or lung



         

than others.

The pilot light safety system senses the depletion of oxygen







In this type of application, a fan to circulate the structure air will









31208-17-0120Page 4

SOME POINTS TO REMEMBER

NO ODOR DETECTED - ODOR FADE

PROPANE GAS WARNING ODOR



That's your signal to go into immediate action!

-

sions. In its natural state, propane is odorless and colorless.

You may not know all the following safety precautions which









exactly what to do. If, after reading the following information,

you feel you still need more information, please contact your

gas supplier.

 

Do not do anything that could ignite the gas.



IMMEDIATELY.











         



not continue to smell gas, do not turn on the gas again. Do not



 Finally, 

       





Some people cannot smell well. Some people cannot smell the



can smell the odorant in propane.











The odorant in Propane Gas is colorless, and it can fade under

some circumstances. For example, if there is an underground











some of the odorant out of the gas, reducing its odor intensity.

Propane Gas may stratify in a closed area, and the odor intensity

could vary at different levels. Since it is heavier than air, there may



-

diately go into action as instructed earlier.

  Your local Pro-

pane Gas Dealer can give you a "Scratch and Sniff" pamphlet.





Propane Gas Dealer.

 





Gas prior to and while lighting pilot lights or performing service



 

that can cover up the Propane Gas odor. Do not try to light pilot



the conditions are such that you may not detect the odor if there



 











a time may develop internal rust which will cause odor fade. If

such conditions are suspected to exist, a periodic sniff test of



odor, call your Propane Gas Dealer. A periodic sniff test

of the Propane Gas is a good safety measure under any

condition.

 





when you do detect the odorized Propane Gas.

 



container valve is left on, the container may draw in some air



new internal rusting could occur. If the valve is left open, then







empty.

SAFETY INFORMATION FOR USERS OF PROPANE GAS

31208-17-0120 Page 5





Preparation



when installed in accordance with this Installation Manual. Report



log placement. Do not install unit with damaged, incomplete, or

       

and follow these instructions carefully during installation to insure





    



 

 



       

Systems Inc.

 

 























Commonwealth of Massachusetts: 



of Massachusetts.



room heaters shall provide to each purchaser a copy of 527 CMR

30 upon sale of the unit. In the Commonwealth of Massachusetts,







local codes, with the National Fuel Gas Code, ANSI Z223.1/NFPA 54.*

*Available from the American National Standards Institute, Inc., 11

West 42nd St., New York, N.Y. 10036.

WARNING







poisoning.

Any alteration of the original design, installed other than shown

in these instructions or use with a type of gas not shown on



making the change.

Always consult your local Building Department regarding regulations,

codes or ordinances which apply to the installation of an unvented

room heater.

     

       

state or local codes.

Instructions to Installer

1. Installer must leave instruction manual with owner after

installation.

 

card supplied with unvented room heater.

3. Installer should show owner how to start and operate unvented

room heater.







these instructions.



the manufacturer.

Well Head Gas Installations

Some Natural Gas utilities use “well head” gas. This may affect



converted to use well head gas.

This appliance is only for use with the type of gas indicated on the



WARNING

        



NOTICE: 

shipping damage.

Attention: During initial use of ceramic log you will detect an

odor as the ceramic log is cured.

Any alteration of the original design, installed other than as

shown in these instructions or use with a type of gas not



and company making the change. Do not operate this appliance







Refer to Log Placement on pages 10 - 11 for correct log and

twig positioning.



indicated in the Parts Sections on pages 30 through 37.

WARNING

This unit is not for use with solid fuels.

Important





NOTICE:



the room in which the unit is installed.

Installation in Residential Garages







INTRODUCTION

31208-17-0120Page 6



heater produces approximately one ounce (30 ml) of water for every



        

(a room) rather than a primary heat source (an entire house). In most

supplemental heat applications, the water vapor does not create a



humidity atmosphere experienced during cold weather.

The following Steps will help insure that water vapor does not



1. Be sure the heater is sized properly for the application, including



 

help lower the water vapor content of the air.

3. Do not use an unvented room heater as the primary heat source

(an entire house).

WATER VAPOR: A BY-PRODUCT OF UNVENTED ROOM HEATERS

SPECIFICATIONS

Accessories

FRBC Battery Operated Remote Control

FRBTC Battery Operated Remote Control w/Thermostat

FRBTP 

FREC Electric Remote Control

FWS Wall Switch

TMV Millivolt Wall Thermostat - Reed Switch

TRW Remote Wall Thermostat

CIB4 Automatic Blower (VFD(10,20)CC Units)

CIB3 Automatic Blower (VFD30CC Units)

Stone Inlay Replaces Standard Grill Top (Medium Units Only)

CSI-8V Stone Inlay Venetian Gold

CSI-9A Stone Inlay 

CSI-10M Stone Inlay Patina Mocha

CSI-11G Stone Inlay Temple Gray

CSI-12A Stone Inlay American Beauty

Model VFD10CC

Input BTU/HR (KW/H) Maximum 10,000

Input BTU/HR (KW/H) Minimum 10,000

Height 24 1/8" (612.8 mm)

Width 21 1/2" (546.1 mm)

Depth 15 3/8" (390.5 mm)

Gas Inlet 3/8" (9.5 mm)

Air Shutter Setting (Natural) 1/16"

Air Shutter Setting (Propane) 1/4"

Model VFD20CC

Input BTU/HR (KW/H) Maximum (Propane)

20,000

Input BTU/HR (KW/H) Minimum (Propane)

16,000

Input BTU/HR (KW/H) Maximum (Natu-

ral)

20,000

Input BTU/HR (KW/H) Minimum (Natu-

ral)

14,500

Height 24 1/8" (612.8 mm)

Width 21 1/2" (546.1 mm)

Depth 15 3/8" (390.5 mm)

Gas Inlet 3/8" (9.5 mm)

Air Shutter Setting (Natural) 1/8"

Air Shutter Setting (Propane) 3/8"

Model VFD30CC

Input BTU/HR (KW/H) Maximum

(Propane)

25,000

Input BTU/HR (KW/H) Minimum

(Propane)

21,000

Input BTU/HR (KW/H) Maximum (Natural)

25,000

Input BTU/HR (KW/H) Minimum (Natural)

17,500

Height 27 3/4" (704.9 mm)

Width 28 1/16" (712.8 mm)

Depth 17 1/8" (435.0 mm)

Gas Inlet 3/8" (9.5 mm)

Air Shutter Setting (Natural) 1/16"

Air Shutter Setting (Propane) 7/16"

Accessories

Model Description



VFD(10,20)CC VFD30CC

CSK-B

Side Shelf



X X

CSK-F

Side Shelf



X X

CSK-M

Side Shelf

Porcelain Mahogany

X X

CSK-S

Side Shelf

Porcelain Sand

CSK-W

Side Shelf

Matte Pewter

31208-17-0120 Page 7



       











which supply heated air to areas outside the space must draw return

air from outside the space through tightly sealed return air ducts. A

-











of all appliances in the space.

The following example is for determining the volume of a typical





The maximum input of the VFD30 is 25,000 Btu per hour. Based

minimum







measure the length, width and height of the area. Example: The

area measures 16 feet in length, 10 feet in width and 8 feet in







PROVISIONS FOR ADEQUATE COMBUSTION & VENTILATION AIR

WARNING





-





Unusually Tight Construction





unusually tight construction, you must provide additional fresh air.

      

where:

a. Walls and ceilings exposed to the outside atmosphere have

a continuous water vapor retarder with a rating of one perm



      

and doors, and

          







other openings.

-





31208-17-0120Page 8





Recommended Gas Pipe Diameter

Pipe

Length

Schedule 40 Pipe

Inside Diameter



Outside Diameter

Natural Propane Natural Propane

0-10 feet

0-3 meters

1/2”

12.7 mm

3/8”

9.5 mm

1/2”

12.7 mm

3/8”

9.5 mm

10-40 feet

4-12 meters

1/2”

12.7 mm

1/2”

12.7 mm

5/8”

15.9 mm

1/2”

12.7 mm

40-100 feet

13-30 meters

1/2”

12.7 mm

1/2”

12.7 mm

3/4”

19 mm

1/2”

12.7 mm

100-150 feet

31-46 meters

3/4”

19 mm

1/2”

12.7 mm

7/8”

22.2 mm

3/4”

19 mm

NOTICE:



NOTICE: Since some municipalities have additional local codes, it



Installing a New Main Gas Shut-Off

Each appliance should have its own manual gas shut-off.





contact your local authorized installer for installation or relocation.







 

















inlet. This should consist of a vertical length of pipe tee connected



and foreign particles may collect.

The use of the following gas connectors is recommended:

 

and Fittings

 

Than All-Metal Construction







GAS SUPPLY

Figure 1

Pressure Testing of the Gas Supply System

 





to the appliance.

         

disconnected from the gas supply piping system during any

pressure testing of that system at test pressures in excess of



          



any pressure testing of the gas supply piping system at test



WARNING







Checking Manifold Pressure

Natural Gas will have a manifold pressure of approximately



minimum input at the pressure regulator outlet with the inlet pressure



for the purpose of input adjustment to a maximum of 10.5" w.c.



Propane Gas will have a manifold pressure approximately



minimum input at the pressure regulator outlet with the inlet pressure to





NOTICE: 

pressure test point, therefore it is not necessary to provide a 1/8"

test point up stream of the control.

A test gauge connection is located downstream of the gas appliance

pressure regulator for measuring gas pressure. The connection is

a 1/8 inch (3 mm) N.P.T. plugged tapping.

31208-17-0120 Page 9

Clearances

When facing the front of the appliance the following minimum



Top of appliance (ceiling) 36 inches

Rear Wall 2 inches

Side Wall 6 inches

Heater Corners (45° angle) to Wall 4 inches

Floor 0 inches







Installation on Rugs and Tile





raised up on a platform to enhance its visual impact. The continu-





CLEARANCES

Figure 2

Figure 3

Figure 4

31208-17-0120Page 10

Log

Description



Front View Top View

VFD(10,20)CC VFD30CC

Log A 29553 29546

Log B 29554 29547

Log C 29555 29548

Log D 29556 29549

Log E 29558 29551

Log F 29557 29550

LOG IDENTIFICATION

NOTE: Middle Top Log (F)

31208-17-0120 Page 11

LOG PLACEMENT

CAUTION



-



WARNING

Failure to position the parts in accordance with this diagram

         

heater may result in property damage or personal injury.

NOTE:   -

ages, see pages 12-18.

Figure 6 - Log Placement

Figure 5 - Burner

Figure 7 - Completed Log Placement

31208-17-0120Page 12

1. Place Log A

LOG PLACEMENT

TOP VIEW

FRONT VIEW

31208-17-0120 Page 13

2. Place Log B

LOG PLACEMENT

TOP VIEW

FRONT VIEW

31208-17-0120Page 14

3. Place Log C

LOG PLACEMENT

TOP VIEW

FRONT VIEW

31208-17-0120 Page 15

4. Place Log D onto the left pin on Log A. The end of Log D will rest on Log C

LOG PLACEMENT

TOP VIEW

FRONT VIEW

31208-17-0120Page 16

5. Place Log E on the right pin on Log A. The end of Log E Log C

LOG PLACEMENT

TOP VIEW

FRONT VIEW

31208-17-0120 Page 17

6. This step is optional for 10,000 BTU units. Place Log FLog BLog C.



LOG PLACEMENT

TOP VIEW

FRONT VIEW

31208-17-0120Page 18

 

LOG PLACEMENT

TOP VIEW

FRONT VIEW

31208-17-0120 Page 19







   













           



not



from Empire Comfort Systems, Inc. Application of excess loose

       

the heater.

WARNING



to reapplication.

NOTICE          





Replacement Loose Material





 31104

 15998

 PE-20-1









NOTICE:

up and down.

         



























is a normal and temporary occurrence.



      

windows or doors to allow odors to dissipate. Any odors remaining

          

continued use.



OPERATION INSTRUCTIONS/FLAME APPEARANCE

Figure 8

31208-17-0120Page 20

Standing Pilot Operation

1. Follow the SAFETY and LIGHTING INSTRUCTIONS for standing



to the appliance.

CAUTION









 







thermostat.

Figure 9

NOTICE: The gas control valve allows you to increase or decrease









3. When the heating season is over, turn the REMOTE/OFF/ON

switch to "OFF" and the control valve to "OFF". The system,



Maximum and Minimum Input



a maximum input of 25,000 Btuh to a minimum input of 17,500







the log set.

Before operating this heater, please review the safety warnings





1. Know what type of ignition system this model has (standing

       

instructions.

            

turn gas off to the heater and call a service person or your gas

utility.

CAUTION



on or near the appliance.

WARNING





       



3. Tampering is DANGEROUS and voids all warranties. Any



approved component.

Initial Lighting

Upon completing the gas line or turning the gas valve "ON" after it





for the lines to purge themselves of this air. Once the purging is

complete, the appliance will light and operate satisfactorily.



if the gas valve is not turned to "OFF."

OPERATING GUIDELINES

Page is loading ...

White Mountain Hearth Empire Cast Iron Stove Vent-Free ( VFD_CC) Owner's manual

Brand: White Mountain Hearth

Model: Empire Cast Iron Stove Vent-Free ( VFD_CC)

Category: Fireplaces

Type: Owner's manual

This manual is also suitable for

Download PDF

report

White Mountain Hearth Empire Cast Iron Stove Vent-Free ( VFD_CC) Owner's manual

This manual is also suitable for

White Mountain Hearth Empire Cast Iron Stove Vent-Free ( VFD_CC) Owner's manual

Related papers

Other documents