2. BARRON
  3. RWE Series LED Glass Refractor Wallpack

BARRON RWE Series LED Glass Refractor Wallpack Installation guide

  • Hello! I've reviewed the installation instructions for the BARRON RWE Series light fixture. This document provides step-by-step guidance for installation using J-Box or conduit mount options. It also includes safety precautions, electrical wiring instructions, and some troubleshooting advice. I am ready to answer any questions you may have about this product.
  • What should be done before servicing the equipment?
    Who should perform the installation and servicing?
    What should be ensured about the electrical wiring?
    What should you do after mounting?
IMPORTANT SAFEGUARDS
READ AND FOLLOW ALL SAFETY INSTRUCTIONS.
When using electrical equipment, basic safety precautions should always be followed including the following:
• DISCONNECT AC POWER SUPPLY BEFORE SERVICING.
• Installation and servicing of this equipment should be performed by qualified service personnel only.
• Ensure that the electrical wiring conforms to the National Electrical Code NEC® and local regulations
if applicable.
• Do not mount near gas or electrical heaters.
• Equipment should be mounted in locations and at heights where it will not be readily subjected to tampering
by unauthorized personnel.
• The use of accessory equipment not recommended by the manufacturer may cause an unsafe condition.
• Any modification or use of non-original components will void the warranty and product liability.
• Do not use this equipment for other than intended use.
SAVE THESE INSTRUCTIONS!
Technical SupportŶŶWHFKQLFDOVXSSRUW#EDUURQOWJFRP
RWE Series
Installation Instructions
5(9  ZZZEDUURQOWJFRP
J-Box Installation
5HPRYHWKHVFUHZVIURPWKHVLGHRIWKH
IL[WXUHDQGVHWDVLGH)LJ
6ZLQJRSHQWKHIL[WXUHGLVFRQQHFWWKHZLUH
KDUQHVVDQGUHPRYHWKHIURQWFRYHU)LJ
8QVFUHZDQGUHPRYHWKHSOXJIURPWKHIL[WXUH
EDVH)LJ
Fig. 3
'ULOOKROHVLQWKHIL[WXUHEDVHZLWKWKHVDPH
KROHSDWWHUQDVWKH-ER[)LJ
Fig. 4
Fig. 1 Fig. 2
$WWDFKWKHJDVNHWSDGWRWKHEDFNVLGHRIWKH
IL[WXUHEDVH)LJ
Fig. 5
)HHGWKHORDGZLUHVWKURXJKWKHFHQWHUKROHLQ
WKHIL[WXUHEDVH)LJ
Fig. 6
RWE Series
Installation Instructions
5(9  ZZZEDUURQOWJFRP
J-Box Installation, Continued
6HFXUHWKHIL[WXUHEDVHWR-ER[XVLQJVFUHZV
SURYLGHGE\RWKHUV)LJ
5HIHUWRWKHZLULQJGLDJUDPIRUZLULQJ
FRQQHFWLRQV8VHZLUHQXWVSURYLGHGE\
RWKHUVIRUFRQQHFWLRQV)LJ
5HDWWDFKWKHIL[WXUHFRYHUE\VOLGLQJWKHFRYHU
over the pins in the fixture base. Reconnect
WKHZLUHKDUQHVV)LJ
Fig. 9
7LJKWHQWKHVFUHZVWRVHFXUHWKHIL[WXUH
FRYHUWRWKHEDVH)LJ
Fig. 10
Fig. 7 Fig. 8
IMPORTANT: Weatherproof your outdoor installation. Be sure to seal all holes in the enclosure, such as the mounting,
conduit, plugs, sensors, and photocontrols with silicone sealant.
RWE Series
Installation Instructions
5(9  ZZZEDUURQOWJFRP
Wall Mount with Conduit Installation
5HPRYHWKHVFUHZVIURPWKHVLGHRIWKH
IL[WXUHDQGVHWDVLGH)LJ
8QVFUHZDQGUHPRYHDQ\RQHRIWKHIRXU
VLGHSOXJV$WWDFKWKHJDVNHWSDGWRWKH
EDFNVLGHRIWKHIL[WXUHEDVH)LJ
Fig. 13
6HFXUHWKHIL[WXUHEDVHWRZDOOXVLQJ
appropriate hardware for the mounting
DSSOLFDWLRQSURYLGHGE\RWKHUV)LJ
Fig. 14
Fig. 11
$WWDFKFRQGXLWWRWKHIL[WXUHEDVH5HIHUWRWKH
wiring diagram for electrical connections. Use
ZLUHQXWVSURYLGHGE\RWKHUVIRU
FRQQHFWLRQV)LJ
Fig. 15
5HDWWDFKWKHIL[WXUHFRYHUE\VOLGLQJWKHFRYHU
over the pins in the fixture base. Reconnect
WKHZLUHKDUQHVV)LJ
Fig. 16
6ZLQJRSHQWKHIL[WXUHGLVFRQQHFWWKHZLUH
KDUQHVVDQGUHPRYHWKHIURQWFRYHU)LJ
Fig. 12
RWE Series
Installation Instructions
5(9  ZZZEDUURQOWJFRP
IMPORTANT: Weatherproof your outdoor installation. Be sure to seal all holes in the enclosure, such as the mounting,
conduit, plugs, sensors, and photocontrols with silicone sealant.
Electrical Connections
0DNHHOHFWULFDOFRQQHFWLRQVSHUWiring Diagram)LJ
D&RQQHFWWKHOLQHIL[WXUHOHDGWRWKHEODFNVXSSO\OHDG
b. Connect the common fixture lead to the white supply lead.
c. Connect the ground lead from the service to the ground lead
coming from the driver plate.
Troubleshooting
If the unit does not turn “ON”:
&KHFNLQFRPLQJYROWDJHWRWKH/('GULYHU2QWKH6ZLWFK8QVZLWFKOLQHLWPXVWEHDPLQLPXPRI9$&DQGQR
JUHDWHUWKDQ9$&
$UHDOO/('VRQWKHOLJKWHQJLQH³2))´",IVRWKH/('GULYHUPD\EHGHIHFWLYH8VLQJDYROWPHWHUFKHFNWRVHHLIWKH
voltage is present at the output of the power supply. If low or no voltage is found, replace the power supply.
,IDQ\LQGLYLGXDO/('VDUH³2))´WKH/('OLJKWHQJLQHPD\EHGHIHFWLYH3OHDVHKDYHWKHVHULDOQXPEHURIIWKHOLJKW
engine available when you contact technical support.
Fig. 18 – Wiring Diagram
%ODFN/LQH
White Neutral
*UHHQ<HOORZ*UHHQ*URXQG
Wall Mount with Conduit Installation, Continued
7LJKWHQWKHVFUHZVWRVHFXUHWKHIL[WXUHFRYHU
WRWKHEDVH)LJ
Fig. 17
RWE Series
Installation Instructions
5(9  ZZZEDUURQOWJFRP
/