Fluke Calibration 9144 User manual

9144
Fluke Calibration
Brand
Fluke Calibration
Model
9144
Category
Measuring, testing & control
Type
User manual

This manual is also suitable for

9142, 9143, 9144
Field Metrology Well
February 2013
© 2013 Fluke Corporation. All rights reserved. Specifications are subject to change without notice.
All product names are trademarks of their respective companies.
PN 3720986
User’s Guide
iii
Table of Contents
1 Before You Start .......................................................................1
1.1 Introduction ............................................................................................... 1
1.2 Unpacking ................................................................................................ 2
1.3 Symbols Used ........................................................................................... 3
1.4 Safety Information ..................................................................................... 4
1.4.1 Warnings .........................................................................................................5
1.4.2 Cautions ..........................................................................................................7
1.5 CE Comments ........................................................................................... 8
1.5.1 EMC Directive .................................................................................................8
1.5.2 Immunity Testing .............................................................................................8
1.5.3 Emission Testing ..............................................................................................9
1.5.4 Low Voltage Directive (Safety) ........................................................................9
1.6 Authorized Service Centers ...................................................................... 9
2 Specications and Environmental Conditions .................... 11
2.1 Specifications ......................................................................................... 11
2.2 Environmental Conditions ....................................................................... 13
3 Quick Start ..............................................................................15
3.1 Setup ....................................................................................................... 15
3.2 Parts and Controls .................................................................................. 16
3.2.1 Display Panel ................................................................................................17
3.2.2 Display ..........................................................................................................18
3.2.3 Power Panel ..................................................................................................20
3.2.4 -P Option Panel (-P models only) ..................................................................22
3.3 Languages .............................................................................................. 24
3.3.1 Language Selection ......................................................................................24
3.3.2 Reset to English Language ...........................................................................25
4 Menu Structure .......................................................................27
4.1 Temp Setup Menu ................................................................................... 27
4.2 Prog Menu .............................................................................................. 28
4.2.1 Switch Test Parameters .................................................................................29
4.2.2 Switch Test Description .................................................................................29
4.3 System Menu .......................................................................................... 31
4.4 Input Setup (-P only) ............................................................................... 32
iv
5 Maintenance ...........................................................................33
5.1 Field Metrology Well Performance Analysis ........................................... 33
v
Tables
Table 1 Symbols used ........................................................................................ 3
Table 2 Base Unit Specifications ..................................................................... 11
Table 3 -P Option Specifications ..................................................................... 12
vi
Figures
Figure 1 Clamp-on ferrite installation ................................................................. 9
Figure 2 914X Field Metrology Well ................................................................. 16
Figure 3 Display panel and keys .................................................................... 18
Figure 4 914X display ...................................................................................... 19
Figure 5 9142 power panel .............................................................................. 21
Figure 6 9143 and 9144 power panel .............................................................. 21
Figure 7 -P option panel ................................................................................. 22
Figure 8 Probe connector wiring ..................................................................... 23
Figure 9 Jumper locations for 3-wire and 2-wire connections ......................... 24
Figure 10 Steps to language selection ............................................................ 25
Figure 11 Main Menu - Temp SetUp ................................................................ 27
Figure 12 Main Menu - Prog Menu .................................................................. 28
Figure 13 Auto and manual switch test operation example ............................ 30
Figure 14 Main Menu - System Menu .............................................................. 31
Figure 15 Main Menu - Input Setup ................................................................ 32
1
Before You Start
Introduction
1 Before You Start
1.1 Introduction
)LHOG0HWURORJ\:HOOVDQGDUHGHVLJQHGWREHUHOLDEOHVWDEOHKHDWVRXUFHV
WKDWFDQEHXVHGLQWKH¿HOGRUODERUDWRU\7KH\RIIHUDFFXUDF\SRUWDELOLW\DQGVSHHGIRUQHDUO\
HYHU\¿HOGFDOLEUDWLRQDSSOLFDWLRQ7KHLQVWUXPHQWVKDYHEHHQGHVLJQHGZLWKWKH¿HOGXVHULQ
PLQGDQGDUHHDV\WRXVHZKLOHPDLQWDLQLQJVWDELOLW\XQLIRUPLW\DQGDFFXUDF\FRPSDUDEOHWR
VRPHODERUDWRU\LQVWUXPHQWV
6SHFLDOEXLOWLQIHDWXUHVPDNH)LHOG0HWURORJ\:HOOVH[WUHPHO\DGDSWDEOH7KHH[FOXVLYH9ROW
DJH&RPSHQVDWLRQDOORZVWKHWHFKQLFLDQWRSOXJLQWRPDLQVSRZHUZLWKYROWDJHIURP9DFWR
9DFZLWKRXWGHJUDGDWLRQWRWKHLQVWUXPHQW7KH$PELHQW7HPSHUDWXUH&RPSHQVDWLRQ86
3DWHQWVDQGSURYLGHVWKHODUJHVWRSHUDWLQJUDQJHLQWKHLQGXVWU\&WR
&ZLWKWKHODUJHVWJXDUDQWHHGWHPSHUDWXUHUDQJH&WR&7KH*UDGLHQW7HPSHUD
WXUH&RPSHQVDWLRQ3DWHQW3HQGLQJNHHSVWKHD[LDOJUDGLHQWZLWKLQVSHFL¿FDWLRQRYHUWKHHQWLUH
WHPSHUDWXUHUDQJHRIWKHLQVWUXPHQWDQGRYHUWKHVSHFL¿HGJXDUDQWHHGRSHUDWLQJWHPSHUDWXUH
UDQJH7KHVHFRPELQHGIHDWXUHVDORQJZLWKWKHUXJJHGGHVLJQOLJKWZHLJKWDQGVPDOOVL]H
PDNHWKLVOLQHRILQVWUXPHQWVLGHDOIRU¿HOGDSSOLFDWLRQV
8QLTXH3DWHQW3HQGLQJVDIHW\IHDWXUHVPDNHWKHVHWKHVDIHVW¿HOGKHDWVRXUFHVDYDLODEOH7KH
XQLTXH$LU)ORZ'HVLJQ3DWHQW3HQGLQJNHHSVWKHSUREHKDQGOHFRROSURWHFWLQJGHOLFDWHLQ
VWUXPHQWVDQGWKHXVHU7KH%ORFN7HPSHUDWXUH,QGLFDWRU863DWHQWVKRZVWKHXVHU
ZKHQWKHZHOOWHPSHUDWXUHLVDERYH&OHWWLQJWKHXVHUNQRZZKHQLWLVVDIHWRUHPRYHWKH
LQVHUWRUPRYHWKHLQVWUXPHQW7KHLQGLFDWRUOLJKWLOOXPLQDWHVZKHQWKHLQVWUXPHQWLVHQHUJL]HG
DQGWKHZHOOLVDERYH&,IWKHLQVWUXPHQWLVUHPRYHGIURPPDLQVSRZHUWKHLQGLFDWRUOLJKW
ÀDVKHVXQWLOWKHZHOOKDVFRROHGWROHVVWKDQ&
7KHRSWLRQDO³3URFHVV´YHUVLRQ³;±3´FRPELQHVWKHKHDWVRXUFHZLWKDEXLOWLQUHDGRXW
HOLPLQDWLQJWKHQHHGIRUWKHWHFKQLFLDQWRWDNHWZRLQVWUXPHQWVWRWKH¿HOG7KHUHDGRXWLVSHU
IHFWIRUWUDQVPLWWHUORRSFRPSDULVRQFDOLEUDWLRQRUDVLPSOHFKHFNRIDWKHUPRFRXSOHVHQVRU
7KHUHLVQRQHHGWRFDUU\DGGLWLRQDOWRROVLQWRWKH¿HOGZLWKWKH³3URFHVV´RSWLRQRIDEXLOWLQ
UHDGRXWIRUUHVLVWDQFHYROWDJHDQGP$PHDVXUHPHQW9ORRSSRZHUDQGRQERDUGGRFXPHQ
WDWLRQ7KHFRQYHQLHQWVPDUWUHIHUHQFHFRQQHFWRUDXWRPDWLFDOO\WUDQVIHUVDQGVWRUHVWKHSUREH
FRHI¿FLHQWV
7KH)LHOG0HWURORJ\:HOOV¶FRQWUROOHUXVHVD357VHQVRUDQGWKHUPRHOHFWULFPRGXOHVRUKHDWHUV
WRDFKLHYHVWDEOHXQLIRUPWHPSHUDWXUHVWKURXJKRXWWKHEORFN
7KH/&'GLVSOD\FRQWLQXRXVO\VKRZVPDQ\XVHIXORSHUDWLQJSDUDPHWHUVLQFOXGLQJWKHEORFN
WHPSHUDWXUHWKHFXUUHQWVHWSRLQWEORFNVWDELOLW\DQGKHDWLQJDQGFRROLQJVWDWXV)RUWKH3UR
FHVVYHUVLRQWKHUHIHUHQFHWHPSHUDWXUHDQGVHFRQGDU\LQSXWW\SH887UHDGLQJVDUHGLVSOD\HG
7KHGLVSOD\FDQEHVHWWRVKRZWKHLQIRUPDWLRQLQRQHRIHLJKWGLIIHUHQWODQJXDJHV(QJOLVK
-DSDQHVH&KLQHVH*HUPDQ6SDQLVK)UHQFK5XVVLDQDQG,WDOLDQ
7KHLQVWUXPHQW¶VUXJJHGGHVLJQDQGVSHFLDOIHDWXUHVPDNHWKHPLGHDOIRUWKH¿HOGRUWKHODERUD
WRU\:LWKSURSHUXVHWKHLQVWUXPHQWSURYLGHVFRQWLQXHGDFFXUDWHFDOLEUDWLRQRIWHPSHUDWXUH
914X Field Metrology Wells
Unpacking
2
VHQVRUVDQGGHYLFHV%HIRUHXVHWKHXVHUVKRXOGEHIDPLOLDUZLWKWKHZDUQLQJVFDXWLRQVDQG
RSHUDWLQJSURFHGXUHVRIWKHFDOLEUDWRUDVGHVFULEHGLQWKH8VHUV*XLGH
1.2 Unpacking
8QSDFNWKHLQVWUXPHQWFDUHIXOO\DQGLQVSHFWLWIRUDQ\GDPDJHWKDWPD\KDYHRFFXUUHGGXULQJ
VKLSPHQW,IWKHUHLVVKLSSLQJGDPDJHQRWLI\WKHFDUULHULPPHGLDWHO\
9HULI\WKDWWKHIROORZLQJFRPSRQHQWVDUHSUHVHQW

● )LHOG0HWURORJ\:HOO
● ,16;,QVHUW; $%&'(RU)
● 3RZHU&RUG
● 56&DEOH
● 8VHU*XLGH
● 7HFKQLFDO0DQXDO&'
● 5HSRUWRI&DOLEUDWLRQDQGFDOLEUDWLRQODEHO
● SLQ',1&RQQHFWRU3PRGHORQO\
● 7HVW/HDG.LW3PRGHORQO\
● :HOO,QVXODWRU
● &ODPSRQIHUULWHV>3PRGHORQO\@
● 7RQJVLQVHUWUHPRYDOWRRO
● ,QWHUIDFHLW6RIWZDUHDQG8VHUV*XLGH

● )LHOG0HWURORJ\:HOO
● ,16;,QVHUW; $%&'(RU)
● 3RZHU&RUG
● 56&DEOH
● 8VHU*XLGH
● 7HFKQLFDO0DQXDO&'
● 5HSRUWRI&DOLEUDWLRQDQGFDOLEUDWLRQODEHO
● SLQ',1&RQQHFWRU3PRGHORQO\
● 7HVW/HDG.LW3PRGHORQO\
● &ODPSRQIHUULWHV>3PRGHORQO\@
● 7RQJVLQVHUWUHPRYDOWRRO
● ,QWHUIDFHLW6RIWZDUHDQG8VHUV*XLGH
3
Before You Start
Symbols Used

● )LHOG0HWURORJ\:HOO
● ,16;,QVHUW; $%&'(RU)
● 3RZHU&RUG
● 56&DEOH
● 8VHU*XLGH
● 7HFKQLFDO0DQXDO&'
● 5HSRUWRI&DOLEUDWLRQDQGFDOLEUDWLRQODEHO
● SLQ',1&RQQHFWRU3PRGHORQO\
● 7HVW/HDG.LW3PRGHORQO\
● &ODPSRQIHUULWHV>3PRGHORQO\@
● 7RQJVLQVHUWUHPRYDOWRRO
● ,QWHUIDFHLW6RIWZDUHDQG8VHUV*XLGH
,IDOOLWHPVDUHQRWSUHVHQWFRQWDFWDQ$XWKRUL]HG6HUYLFH&HQWHUVHH6HFWLRQ$XWKRUL]HG
6HUYLFH&HQWHUVRQSDJH
1.3 Symbols Used
7DEOHOLVWVWKH,QWHUQDWLRQDO(OHFWULFDO6\PEROV6RPHRUDOORIWKHVHV\PEROVPD\EHXVHGRQ
WKHLQVWUXPHQWRULQWKLVJXLGH
Table 1 Symbols used
Symbol Description
AC (Alternating Current)
AC-DC
Battery
Complies with European Union directives
DC
Double Insulated
914X Field Metrology Wells
Safety Information
4
Symbol Description
Electric Shock
Fuse
PE Ground
Hot Surface (Burn Hazard)
Read the User’s Guide (Important Information)
Off
On
Canadian Standards Association
C-TICK Australian EMC mark
The European Waste Electrical and Electronic Equipment (WEEE) Directive (2002/96/
EC) mark.
1.4 Safety Information
)LHOG0HWURORJ\:HOOVDUHGHVLJQHGLQDFFRUGDQFHZLWK,(&,(&DQG
&$1&6$1R8VHWKLVLQVWUXPHQWRQO\DVVSHFL¿HGLQWKLVPDQXDO2WKHU
ZLVHWKHSURWHFWLRQSURYLGHGE\WKHLQVWUXPHQWPD\EHLPSDLUHG5HIHUWRWKHVDIHW\LQIRUPD
WLRQLQWKH:DUQLQJVDQG&DXWLRQVVHFWLRQVEHORZ
7KHIROORZLQJGH¿QLWLRQVDSSO\WRWKHWHUPV³:DUQLQJ´DQG³&DXWLRQ´
● ³:DUQLQJ´LGHQWL¿HVFRQGLWLRQVDQGDFWLRQVWKDWPD\SRVHKD]DUGVWRWKHXVHU
● ³&DXWLRQ´LGHQWL¿HVFRQGLWLRQVDQGDFWLRQVWKDWPD\GDPDJHWKHLQVWUXPHQWEHLQJXVHG
5
Before You Start
Safety Information
1.4.1 Warnings
7RDYRLGSHUVRQDOLQMXU\IROORZWKHVHJXLGHOLQHV
*(1(5$/
'2127XVHWKLVLQVWUXPHQWLQHQYLURQPHQWVRWKHUWKDQWKRVHOLVWHGLQWKH8VHUV*XLGH
,QVSHFWWKHLQVWUXPHQWIRUGDPDJHEHIRUHHDFKXVH,QVSHFWWKHFDVH/RRNIRUFUDFNVRUPLVVLQJ
SODVWLF'2127XVHWKHLQVWUXPHQWLILWDSSHDUVGDPDJHGRURSHUDWHVDEQRUPDOO\
)ROORZDOOVDIHW\JXLGHOLQHVOLVWHGLQWKH8VHUV*XLGH
&DOLEUDWLRQHTXLSPHQWVKRXOGRQO\EHXVHGE\WUDLQHGSHUVRQQHO
,IWKLVHTXLSPHQWLVXVHGLQDPDQQHUQRWVSHFL¿HGE\WKHPDQXIDFWXUHUWKHSURWHFWLRQSURYLGHG
E\WKHHTXLSPHQWPD\EHLPSDLUHG
%HIRUHLQLWLDOXVHRUDIWHUWUDQVSRUWRUDIWHUVWRUDJHLQKXPLGRUVHPLKXPLGHQYLURQPHQWV
RUDQ\WLPHWKHLQVWUXPHQWKDVQRWEHHQHQHUJL]HGIRUPRUHWKDQGD\VWKHLQVWUXPHQWQHHGV
WREHHQHUJL]HGIRUD³GU\RXW´SHULRGRIKRXUVEHIRUHLWFDQEHDVVXPHGWRPHHWDOORIWKH
VDIHW\UHTXLUHPHQWVRIWKH,(&,IWKHSURGXFWLVZHWRUKDVEHHQLQDZHWHQYLURQPHQW
WDNHQHFHVVDU\PHDVXUHVWRUHPRYHPRLVWXUHSULRUWRDSSO\LQJSRZHUVXFKDVVWRUDJHLQDORZ
KXPLGLW\WHPSHUDWXUHFKDPEHURSHUDWLQJDW&IRUKRXUVRUPRUH
'2127XVHWKLVLQVWUXPHQWIRUDQ\DSSOLFDWLRQRWKHUWKDQFDOLEUDWLRQZRUN7KHLQVWUXPHQW
ZDVGHVLJQHGIRUWHPSHUDWXUHFDOLEUDWLRQ$Q\RWKHUXVHRIWKHLQVWUXPHQWPD\FDXVHXQNQRZQ
KD]DUGVWRWKHXVHU
'2127SODFHWKHLQVWUXPHQWXQGHUDFDELQHWRURWKHUVWUXFWXUH2YHUKHDGFOHDUDQFHLV
UHTXLUHG$OZD\VOHDYHHQRXJKFOHDUDQFHWRDOORZIRUVDIHDQGHDV\LQVHUWLRQDQGUHPRYDORI
SUREHV
8VHRIWKLVLQVWUXPHQWDW+,*+7(03(5$785(6IRUH[WHQGHGSHULRGVRIWLPHUHTXLUHV
FDXWLRQ
&RPSOHWHO\XQDWWHQGHGKLJKWHPSHUDWXUHRSHUDWLRQLVQRWUHFRPPHQGHGGXHWRVDIHW\KD]DUGV
WKDWFDQDULVH
7KLVLQVWUXPHQWLVLQWHQGHGIRULQGRRUXVHRQO\
)ROORZDOOVDIHW\SURFHGXUHVIRUWKHWHVWDQGFDOLEUDWLRQHTXLSPHQW\RXXVH
,IXVHGLQVSHFWWKHWHVWOHDGVIRUGDPDJHGLQVXODWLRQRUH[SRVHGPHWDO&KHFNIRUWHVWOHDG
FRQWLQXLW\5HSODFHGDPDJHGWHVWOHDGVDVQHFHVVDU\
'RQRWXVHWKHLQVWUXPHQWLILWRSHUDWHVDEQRUPDOO\3URWHFWLRQPD\EHLPSDLUHG:KHQLQ
GRXEWKDYHWKHLQVWUXPHQWVHUYLFHG
'RQRWDSSO\PRUHWKDQWKHUDWHGYROWDJHDVPDUNHGRQWKHLQVWUXPHQWEHWZHHQWHUPLQDOVRU
EHWZHHQDQ\WHUPLQDODQGHDUWKJURXQG
914X Field Metrology Wells
Safety Information
6
1HYHUWRXFKWKHSUREHVWRDYROWDJHVRXUFHZKHQWKHWHVWOHDGVDUHSOXJJHGLQWRWKHFXUUHQW
WHUPLQDOV
6HOHFWWKHSURSHUIXQFWLRQDQGUDQJHIRUHDFKPHDVXUHPHQW
'LVFRQQHFWWKHWHVWOHDGVEHIRUHFKDQJLQJWRDQRWKHUPHDVXUHRUVRXUFHIXQFWLRQ
'2127RSHUDWHWKH)LHOG0HWURORJ\:HOODURXQGH[SORVLYHJDVYDSRURUGXVW
'2127RSHUDWHLQVWUXPHQWDWRULHQWDWLRQVRWKHUWKDQXSULJKW7LOWLQJWKHLQVWUXPHQWRUOD\LQJ
LWGRZQRQLWVVLGHGXULQJXVHFRXOGFUHDWHD¿UHKD]DUG
%851+$=$5'
7KHLQVWUXPHQWLVHTXLSSHGZLWKD%ORFN7HPSHUDWXUH,QGLFDWRUIURQWSDQHO/('+27LQGLFD
WRUHYHQZKHQWKHLQVWUXPHQWLVXQSOXJJHG:KHQWKHLQGLFDWRULVÀDVKLQJWKHLQVWUXPHQWLV
GLVFRQQHFWHGIURPPDLQVSRZHUDQGWKHWHPSHUDWXUHRIWKHEORFNLVDERYH&:KHQWKH
LQGLFDWRULVLOOXPLQDWHGDOZD\VRQWKHLQVWUXPHQWLVSRZHUHGDQGWKHEORFNWHPSHUDWXUHLV
DERYH&
'2127WXUQWKHLQVWUXPHQWXSVLGHGRZQZLWKWKHLQVHUWVLQSODFHWKHLQVHUWVZLOOIDOORXW
'2127RSHUDWHQHDUÀDPPDEOHPDWHULDOV
8VHRIWKLVLQVWUXPHQWDW+,*+7(03(5$785(6IRUH[WHQGHGSHULRGVRIWLPHUHTXLUHV
FDXWLRQ
'2127WRXFKWKHZHOODFFHVVVXUIDFHRIWKHLQVWUXPHQW
7KHEORFNYHQWPD\EHYHU\KRWGXHWRWKHIDQEORZLQJDFURVVWKHKHDWHUEORFNRIWKH
LQVWUXPHQW
7KHWHPSHUDWXUHRIWKHZHOODFFHVVLVWKHVDPHDVWKHDFWXDOGLVSOD\WHPSHUDWXUHHJLIWKH
LQVWUXPHQWLVVHWWR&DQGWKHGLVSOD\UHDGV&WKHZHOOLVDW&
3UREHVDQGLQVHUWVPD\EHKRWDQGVKRXOGRQO\EHLQVHUWHGDQGUHPRYHGIURPWKHLQVWUXPHQW
ZKHQWKHLQVWUXPHQWLQGLFDWHVWHPSHUDWXUHVOHVVWKDQ&
'2127WXUQRIIWKHLQVWUXPHQWDWWHPSHUDWXUHVKLJKHUWKDQ&7KLVFRXOGFUHDWHD
KD]DUGRXVVLWXDWLRQ6HOHFWDVHWSRLQWOHVVWKDQ&DQGDOORZWKHLQVWUXPHQWWRFRROEHIRUH
WXUQLQJLWRII
7KHKLJKWHPSHUDWXUHVSUHVHQWLQ)LHOG0HWURORJ\:HOOVGHVLJQHGIRURSHUDWLRQDW&DQG
KLJKHUPD\UHVXOWLQ¿UHVDQGVHYHUHEXUQVLIVDIHW\SUHFDXWLRQVDUHQRWREVHUYHG
(/(&75,&$/+$=$5'
7KHVHJXLGHOLQHVPXVWEHIROORZHGWRHQVXUHWKDWWKHVDIHW\PHFKDQLVPVLQWKLVLQVWUXPHQW
RSHUDWHSURSHUO\7KLVLQVWUXPHQWPXVWEHSOXJJHGLQWRDQ$&RQO\HOHFWULFRXWOHWDFFRUGLQJ
WR7DEOH6SHFL¿FDWLRQV7KHSRZHUFRUGRIWKHLQVWUXPHQWLVHTXLSSHGZLWKDWKUHHSURQJHG
JURXQGLQJSOXJIRU\RXUSURWHFWLRQDJDLQVWHOHFWULFDOVKRFNKD]DUGV,WPXVWEHSOXJJHGGLUHFWO\
LQWRDSURSHUO\JURXQGHGWKUHHSURQJUHFHSWDFOH7KHUHFHSWDFOHPXVWEHLQVWDOOHGLQDFFRUGDQFH
ZLWKORFDOFRGHVDQGRUGLQDQFHV&RQVXOWDTXDOL¿HGHOHFWULFLDQ'2127XVHDQH[WHQVLRQ
FRUGRUDGDSWHUSOXJ
7
Before You Start
Safety Information
,IVXSSOLHGZLWKXVHUDFFHVVLEOHIXVHVDOZD\VUHSODFHWKHIXVHZLWKRQHRIWKHVDPHUDWLQJYROW
DJHDQGW\SH
$OZD\VUHSODFHWKHSRZHUFRUGZLWKDQDSSURYHGFRUGRIWKHFRUUHFWUDWLQJDQGW\SH
+,*+92/7$*(LVXVHGLQWKHRSHUDWLRQRIWKLVHTXLSPHQW6(9(5(,1-85<RU'($7+
PD\UHVXOWLISHUVRQQHOIDLOWRREVHUYHVDIHW\SUHFDXWLRQV%HIRUHZRUNLQJLQVLGHWKHHTXLSPHQW
WXUQSRZHURIIDQGGLVFRQQHFWSRZHUFRUG
30RGHO2QO\
:KHQXVLQJWHVWOHDGVNHHS¿QJHUVEHKLQGWKH¿QJHUJXDUGVRQWKHWHVWOHDGV
'2127DSSO\PRUHWKDQWKHUDWHGYROWDJHDVPDUNHGRQWKHLQVWUXPHQWEHWZHHQWKHWHUPL
QDOVRUEHWZHHQDQ\WHUPLQDODQGHDUWKJURXQG9P$PD[DOOWHUPLQDOV
1HYHUWRXFKWKHSUREHWRDYROWDJHVRXUFHZKHQWKHWHVWOHDGVDUHSOXJJHGLQWRFXUUHQW
WHUPLQDOV
6HOHFWWKHSURSHUIXQFWLRQDQGUDQJHIRU\RXUPHDVXUHPHQW
,QVSHFWWKHWHVWOHDGVIRUGDPDJHGLQVXODWLRQRUH[SRVHGPHWDO&KHFNWHVWOHDGVFRQWLQXLW\
5HSODFHGDPDJHGWHVWOHDGVEHIRUH\RXXVHWKHFDOLEUDWRU
1.4.2 Cautions
7RDYRLGSRVVLEOHGDPDJHWRWKHLQVWUXPHQWIROORZWKHVHJXLGHOLQHV
'2127OHDYHWKHLQVHUWVLQWKHLQVWUXPHQWIRUSURORQJHGSHULRGV'XHWRWKHKLJKRSHUDWLQJ
WHPSHUDWXUHVRIWKHLQVWUXPHQWWKHLQVHUWVVKRXOGEHUHPRYHGDIWHUHDFKXVHDQGEXIIHGZLWKD
6FRWFK%ULWHSDGRUHPHU\FORWKVHH6HFWLRQ0DLQWHQDQFHRQSDJH
$OZD\VRSHUDWHWKLVLQVWUXPHQWDWURRPWHPSHUDWXUHEHWZHHQ)DQG)&WR&
$OORZVXI¿FLHQWDLUFLUFXODWLRQE\OHDYLQJDWOHDVWLQFKHVFPRIFOHDUDQFHDURXQGWKH
LQVWUXPHQW2YHUKHDGFOHDUDQFHRIPHWHUIWLVUHTXLUHG'2127SODFHLQVWUXPHQWXQGHU
DQ\VWUXFWXUH
&RPSRQHQWOLIHWLPHFDQEHVKRUWHQHGE\FRQWLQXRXVKLJKWHPSHUDWXUHRSHUDWLRQ
'2127DSSO\DQ\W\SHRIYROWDJHWRWKHGLVSOD\KROGWHUPLQDOV$SSO\LQJDYROWDJHWRWKH
WHUPLQDOVPD\FDXVHGDPDJHWRWKHFRQWUROOHU
'2127XVHÀXLGVWRFOHDQRXWWKHZHOO)OXLGVFRXOGOHDNLQWRHOHFWURQLFVDQGGDPDJHWKH
LQVWUXPHQW
1HYHULQWURGXFHDQ\IRUHLJQPDWHULDOLQWRWKHSUREHKROHRIWKHLQVHUW)OXLGVHWFFDQOHDNLQWR
WKHLQVWUXPHQWFDXVLQJGDPDJH
8QOHVVUHFDOLEUDWLQJWKHLQVWUXPHQW'2127FKDQJHWKHYDOXHVRIWKHFDOLEUDWLRQFRQVWDQWV
IURPWKHIDFWRU\VHWYDOXHV7KHFRUUHFWVHWWLQJRIWKHVHSDUDPHWHUVLVLPSRUWDQWWRWKHVDIHW\
DQGSURSHURSHUDWLRQRIWKHFDOLEUDWRU
914X Field Metrology Wells
CE Comments
8
'2127DOORZWKHSUREHVKHDWKRULQVHUWVWRGURSLQWRWKHZHOO7KLVW\SHRIDFWLRQFDQFDXVHD
VKRFNWRWKHVHQVRUDQGDIIHFWWKHFDOLEUDWLRQ
7KHLQVWUXPHQWDQGDQ\WKHUPRPHWHUSUREHVXVHGZLWKLWDUHVHQVLWLYHLQVWUXPHQWVWKDWFDQEH
HDVLO\GDPDJHG$OZD\VKDQGOHWKHVHGHYLFHVZLWKFDUH'2127DOORZWKHPWREHGURSSHG
VWUXFNVWUHVVHGRURYHUKHDWHG
'2127RSHUDWHWKLVLQVWUXPHQWLQDQH[FHVVLYHO\ZHWRLO\GXVW\RUGLUW\HQYLURQPHQW$O
ZD\VNHHSWKHZHOODQGLQVHUWVFOHDQDQGFOHDURIIRUHLJQPDWHULDO
7KH)LHOG0HWURORJ\:HOOLVDSUHFLVLRQLQVWUXPHQW$OWKRXJKLWKDVEHHQGHVLJQHGIRURSWLPXP
GXUDELOLW\DQGWURXEOHIUHHRSHUDWLRQLWPXVWEHKDQGOHGZLWKFDUH$OZD\VFDUU\WKHLQVWUXPHQW
LQDQXSULJKWSRVLWLRQWRSUHYHQWWKHLQVHUWVIURPGURSSLQJRXW7KHFRQYHQLHQWKDQGOHDOORZV
IRUKDQGFDUU\LQJWKHLQVWUXPHQW
,IDPDLQVVXSSO\SRZHUÀXFWXDWLRQRFFXUVLPPHGLDWHO\WXUQRIIWKHLQVWUXPHQW3RZHUEXPSV
IURPEURZQRXWVFRXOGGDPDJHWKHLQVWUXPHQW:DLWXQWLOWKHSRZHUKDVVWDELOL]HGEHIRUHUH
HQHUJL]LQJWKHLQVWUXPHQW
7KHSUREHDQGWKHEORFNPD\H[SDQGDWGLIIHUHQWUDWHV$OORZIRUSUREHH[SDQVLRQLQVLGHWKH
ZHOODVWKHEORFNKHDWV2WKHUZLVHWKHSUREHPD\EHFRPHVWXFNLQWKHZHOO
0RVWSUREHVKDYHKDQGOHWHPSHUDWXUHOLPLWV,IWKHSUREHKDQGOHOLPLWVDUHH[FHHGHGWKHSUREH
PD\EHSHUPDQHQWO\GDPDJHG'XHWRDXQLTXH$LU)ORZ'HVLJQ3DWHQW3HQGLQJ)LHOG0H
WURORJ\:HOOVSURWHFWWKHSUREHKDQGOHWHPSHUDWXUHDQGSURYLGHDVDIHUWHPSHUDWXUHKDQGOHIRU
WKHXVHU
1.5 CE Comments
1.5.1 EMC Directive
+DUW6FLHQWL¿F¶VHTXLSPHQWKDVEHHQWHVWHGWRPHHWWKH(XURSHDQ(OHFWURPDJQHWLF&RPSDWLELOL
W\'LUHFWLYH(0&'LUHFWLYH((&7KH'HFODUDWLRQRI&RQIRUPLW\IRU\RXULQVWUXPHQW
OLVWVWKHVSHFL¿FVWDQGDUGVWRZKLFKWKHLQVWUXPHQWZDVWHVWHG
7KHLQVWUXPHQWZDVGHVLJQHGVSHFL¿FDOO\DVDWHVWDQGPHDVXULQJGHYLFH&RPSOLDQFHWRWKH
(0&GLUHFWLYHLVWKURXJK,(&(OHFWULFDOHTXLSPHQWIRUPHDVXUHPHQWFRQWURODQG
ODERUDWRU\XVH
$VQRWHGLQWKH,(&WKHLQVWUXPHQWFDQKDYHYDU\LQJFRQ¿JXUDWLRQV7KHLQVWUXPHQW
ZDVWHVWHGLQDW\SLFDOFRQ¿JXUDWLRQZLWKVKLHOGHG56FDEOHV
1.5.2 Immunity Testing
8VLQJ&ODPS2Q)HUULWHV
)RUWKH±3PRGHORQO\FODPSRQIHUULWHVDUHSURYLGHGIRUXVHLQLPSURYLQJLWVHOHFWURPDJQHWLF
(0LPPXQLW\LQHQYLURQPHQWVRIH[FHVVLYH(0LQWHUIHUHQFH'XULQJ(0&WHVWLQJZHIRXQG
WKDWIHUULWHVFODPSHGDURXQGSUREHFDEOHVIRUWKH5HIHUHQFH357WKH35757'LQSXWDQGWKH
WKHUPRFRXSOH7&LQSXWUHGXFHGWKHULVNWKH(0LQWHUIHUHQFHDIIHFWVPHDVXUHPHQWV7KHUHIRUH
9
Before You Start
Authorized Service Centers
ZHUHFRPPHQGWKDWWKHFODPSRQIHUULWHVSURYLGHGEHXVHGRQWKHFDEOHVRISUREHVDWWDFKHG
WRWKHUHDGRXWHVSHFLDOO\LIWKHSURGXFWLVXVHGQHDUVRXUFHVRI(0LQWHUIHUHQFHVXFKDVKHDY\
LQGXVWULDOHTXLSPHQW
7RDWWDFKDIHUULWHWRDSUREHFDEOHPDNHDORRSLQWKHFDEOHQHDUWKHFRQQHFWRUDQGFODPSWKH
IHUULWHDURXQGKDOIRIWKHORRSDVVKRZQLQWKHGLDJUDP7KHIHUULWHFDQEHHDVLO\VQDSSHGRSHQ
DQGPRYHGWRDQHZSUREHZKHQQHHGHG
clamp-on ferrite
connector
probe
Figure 1 Clamp-on ferrite installation
1.5.3 Emission Testing
7KHLQVWUXPHQWIXO¿OOVWKHOLPLWUHTXLUHPHQWVIRU&ODVV$HTXLSPHQW7KHLQVWUXPHQWZDVQRW
GHVLJQHGWREHXVHGLQGRPHVWLFHVWDEOLVKPHQWV
1.5.4 Low Voltage Directive (Safety)
,QRUGHUWRFRPSO\ZLWKWKH(XURSHDQ/RZ9ROWDJH'LUHFWLYH(&+DUW6FLHQWL¿F
HTXLSPHQWKDVEHHQGHVLJQHGWRPHHWWKH(1DQGWKH(1VWDQGDUGV
1.6 Authorized Service Centers
3OHDVHFRQWDFWRQHRIWKHIROORZLQJ$XWKRUL]HG6HUYLFH&HQWHUVWRFRRUGLQDWHVHUYLFHRQ\RXU
+DUWSURGXFW
)OXNH&RUSRUDWLRQ
+DUW6FLHQWL¿F'LYLVLRQ
(8WDK9DOOH\'ULYH
$PHULFDQ)RUN87
86$
3KRQH
7HOHID[
(PDLOVXSSRUW#KDUWVFLHQWL¿FFRP
914X Field Metrology Wells
Authorized Service Centers
10
)OXNH1HGHUODQG%9
&XVWRPHU6XSSRUW6HUYLFHV
6FLHQFH3DUN(LQGKRYHQ
(&6RQ
1(7+(5/$1'6
3KRQH
7HOHID[
(PDLO6HUYLFH'HVN#ÀXNHQO
)OXNH,QW¶O&RUSRUDWLRQ
6HUYLFH&HQWHU,QVWULPSH[
5RRP6FLWHFN7RZHU
-LDQJXRPHQZDL'DMLH
&KDR<DQJ'LVWULFW
%HLMLQJ35&
&+,1$
3KRQH
7HOHID[
(PDLO[LQJ\HKDQ#ÀXNHFRPFQ
)OXNH6RXWK(DVW$VLD3WH/WG
)OXNH$6($15HJLRQDO2I¿FH
6HUYLFH&HQWHU
$OH[DQGUD7HUUDFH
7KH&RPWHFK/REE\'

6,1*$325(
3KRQH
7HOHID[
(PDLODQWKRQ\QJ#ÀXNHFRP
:KHQFRQWDFWLQJD6HUYLFH&HQWHUVIRUVXSSRUWSOHDVHKDYHWKHIROORZLQJLQIRUPDWLRQ
DYDLODEOH
● 0RGHO1XPEHU
● 6HULDO1XPEHU
● 9ROWDJH
● &RPSOHWHGHVFULSWLRQRIWKHSUREOHP
11
Specications and Environmental Conditions
Specications
2 Specications and Environmental Conditions
2.1 Specications
Table 2 Base Unit Specifications
Base Unit Specifications
9142 9143 9144
Temperature Range at
23°C
–25°C to 150°C
(-13°F to 302°F)
33°C to 350°C
(91°F to 662°F)
50°C to 660°C
(122°F to 1220°F)
Display Accuracy ±0.2°C Full Range ±0.2°C Full Range ±0.35°C at 50°C
±0.35°C at 420°C
±0.5°C at 660°C
Stability ±0.01°C Full Range ±0.02 °C at 33°C
±0.02 °C at 200°C
±0.03°C at 350°C
±0.03°C at 50°C
±0.05°C at 420°C
±0.05°C at 660°C
Axial Uniformity at 40
mm (1.6 in)
±0.05°C Full Range ±0.04°C at 33°C
±0.1°C at 200°C
±0.2°C at 350°C
±0.05°C at 50°C
±0.35°C at 420°C
±0.5°C at 660°C
Axial Uniformity at 60
mm (2.4 in)
±0.07°C Full Range ±0.04°C at 33°C
±0.2°C at 200°C
±0.25°C at 350°C
±0.1°C at 50°C
±0.6°C at 420°C
±0.8°C at 660°C
Radial Uniformity ±0.01°C Full Range ±0.01°C at 33°C
±0.015°C at 200°C
±0.02°C at 350°C
±0.02°C at 50°C
±0.05°C at 420°C
±0.1°C at 660°C
Loading Effect (with
a 6.35 mm reference
probe and three 6.35
mm probes)
±0.006°C Full Range ±0.015°C Full Range ±0.015°C at 50°C
±0.025°C at 420°C
±0.035°C at 660°C
Loading Effect (versus
display with 6.35 mm
probes)
±0.08°C Full Range ±0.2°C Full Range ±0.1°C at 50°C
±0.2°C at 420°C
±0.2°C at 660°C
Hysteresis 0.025°C 0.03°C 0.1°C
Operating Conditions 0°C to 50°C, 0% to 90% RH (non-condensing)
Environmental
conditions for all
specications except
temperature range
13°C to 33°C
Immersion (Well)
Depth
150 mm (5.9 in)
Insert OD 30 mm (1.18 in) 25.3 mm (1.00 in) 24.4 mm (0.96 in)
Heating Time 16 min: 23°C to 140°C
23 min: 23°C to 150°C
25 min: –25°C to 150°C
5 min: 33°C to 350°C 15 min: 50°C to 660°C
Cooling Time 15 min: 23°C to –25°C
25 min: 150°C to –23°C
32 min: 350°C to 33°C
14 min: 350°C to 100°C
35 min: 660°C to 50°C
25 min: 660°C to 100°C
Resolution 0.01°
Display LCD,°C or°F user-selectable
Key Pad Arrows, Menu, Enter, Exit, 4 soft keys
Size (H x W x D) 290 mm x 185 mm x 295 mm (11.4 x 7.3 x 11.6 in)
914X Field Metrology Wells
Specications
12
Base Unit Specifications
9142 9143 9144
Weight 8.16 kg (18 lbs) 7.3 kg (16 lbs) 7.7 kg (17 lbs)
Power Requirements 100 V to 115 V (±10%)
50/60 Hz, 575 W
230 V (±10%) 50/60 Hz,
575 W
100 V to 115 V (±10%), 50/60 Hz, 1400 W
230 V (±10%), 50/60 Hz, 1800 W
System Fuse Ratings 115 V: 6.3 A T 250 V
230 V: 3.15 A T 250 V
15 A 250 V Thermal Circuit Breakers
4–20 mA Fuse (-P
model only)
50 mA F 250V
Computer Interface RS-232 and 9930 Interface-it control software included
Safety EN 61010-1:2001, CAN/CSA C22.2 No. 61010.1-04
Table 3 -P Option Specifications
-P Specifications
Built-in Reference Thermometer Readout
Accuracy
(4-Wire Reference Probe)†
± 0.013 °C at -25 °C
± 0.015 °C at 0 °C
± 0.020 °C at 50 °C
± 0.025 °C at 150 °C
± 0.030 °C at 200 °C
± 0.040 °C at 350 °C
± 0.050 °C at 420 °C
± 0.070 °C at 660 °C
Reference Resistance Range 0 ohms to 400 ohms
Reference Resistance Accuracy‡ 0 ohms to 42 ohms: ±0.0025 ohms
42 ohms to 400 ohms: ±60 ppm of reading
Reference Characterizations ITS-90, CVD, IEC-751, Resistance
Reference Measurement Capability 4-wire
Reference Probe Connection 6 Pin Din with Infocon Technology
Built-in RTD Thermometer Readout Accuracy NI-120: ± 0.015 °C at 0 °C
PT-100 (385): ± 0.02 °C at 0 °C
PT-100 (3926): ± 0.02 °C at 0 °C
PT-100 (JIS): ± 0.02 °C at 0 °C
RTD Resistance Range 0 ohms to 400 ohms
Resistance Accuracy‡0 ohms to 25 ohms: ±0.002 ohms
25 ohms to 400 ohms: ±80 ppm of reading
RTD Characterizations PT-100 (385),(JIS),(3926), NI-120, Resistance
RTD Measurement Capability 2-,3-,4-wire RTD w\ Jumpers only
RTD Connection 4 terminal input
13
Specications and Environmental Conditions
Environmental Conditions
-P Specifications
Built-in TC Thermometer Readout Accuracy Type J: ± 0.7 °C at 660 °C
Type K: ± 0.8 °C at 660 °C
Type T: ± 0.8 °C at 400 °C
Type E: ± 0.7 °C at 660 °C
Type R: ± 1.4 °C at 660 °C
Type S: ± 1.5 °C at 660 °C
Type M: ± 0.6 °C at 660 °C
Type L: ± 0.7 °C at 660 °C
Type U: ± 0.75 °C at 600 °C
Type N: ± 0.9 °C at 660 °C
Type C: ± 1.1 °C at 660 °C
TC Millivolt Range –10 mV to 75 mV
Voltage Accuracy 0.025% of reading +0.01mV
Internal Cold Junction Compensation Accuracy ± 0.35 °C (ambient of 13°C to 33°C)
TC Connection Small connectors
Built-in mA Readout Accuracy 0.02% of reading + 0.002 mA
mA Range Cal 4-22 mA, Spec 4-24 mA
mA Connection 2 terminal input
Loop Power Function 24 VDC loop power
Built-in Electronics Temperature Coefficient
(0 °C to 13 °C, 33 °C to 50 °C)
± 0.005 % of range per °C
†The temperature range may be limited by the reference probe connected to the readout. The Built-
In Reference Accuracy does not include the sensor probe accuracy. It does not include the probe
uncertainty or probe characterization errors.
‡Measurement accuracy specications apply within the operating range and assume 4-wires for PRTs.
With 3-wire RTDs add 0.05 ohms to the measurement accuracy plus the maximum possible difference
between the resistances of the lead wires.
2.2 Environmental Conditions
$OWKRXJKWKHLQVWUXPHQWKDVEHHQGHVLJQHGIRURSWLPXPGXUDELOLW\DQGWURXEOHIUHHRSHUDWLRQ
LWPXVWEHKDQGOHGZLWKFDUH7KHLQVWUXPHQWVKRXOGQRWEHRSHUDWHGLQDQH[FHVVLYHO\GXVW\RU
GLUW\HQYLURQPHQW0DLQWHQDQFHDQGFOHDQLQJUHFRPPHQGDWLRQVFDQEHIRXQGLQWKH0DLQWH
QDQFHVHFWLRQ7KHLQVWUXPHQWRSHUDWHVVDIHO\XQGHUWKHIROORZLQJHQYLURQPHQWDOFRQGLWLRQV
● DPELHQWWHPSHUDWXUHUDQJH&)
● DPELHQWUHODWLYHKXPLGLW\WRQRQFRQGHQVLQJ
● PDLQVYROWDJHZLWKLQRIQRPLQDO
● YLEUDWLRQVLQWKHFDOLEUDWLRQHQYLURQPHQWVKRXOGEHPLQLPL]HG
● DOWLWXGHOHVVWKDQPHWHUV
● LQGRRUXVHRQO\
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24
  • Page 25 25
  • Page 26 26
  • Page 27 27
  • Page 28 28
  • Page 29 29
  • Page 30 30
  • Page 31 31
  • Page 32 32
  • Page 33 33
  • Page 34 34
  • Page 35 35
  • Page 36 36
  • Page 37 37
  • Page 38 38
  • Page 39 39
  • Page 40 40

Fluke Calibration 9144 User manual

9144
Fluke Calibration
Brand
Fluke Calibration
Model
9144
Category
Measuring, testing & control
Type
User manual
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Other documents