De Dietrich EcoNox EF 36 User manual

Brand: De Dietrich

Model: EcoNox EF 36

Category: Water heaters & boilers

Type: User manual

EASYLIFE

S U S T A I N A B L E C O M F O R T

Neovo

MW-8000039-3

User Guide

Oil/Gas-fired boiler

NeOvo EcoNox

EF 22

EF 29

Dear Customer,

Thank you very much for buying this appliance.

Please read through the manual carefully before using the product, and keep it in a safe place for later reference. In order to

ensure continued safe and efficient operation we recommend that the product is serviced regularly. Our service and customer

service organisation can assist with this.

We hope you enjoy years of problem-free operation with the product.

Contents

1 Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

1.1 General safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

1.2 Recommendations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

1.3 Liabilities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

1.3.1 Manufacturer's liability . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

1.3.2 Installer's liability . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

1.3.3 User's liability . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9

2 About this manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

2.1 Symbols used . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

2.1.1 Symbols used in the manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

2.1.2 Symbols used on the appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10

3 Technical specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

3.1 Homologations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

3.1.1 Certifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

3.1.2 Oil categories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11

3.2 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11

4 Description of the product . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

4.1 General description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13

4.2 Main components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

4.2.1 Boiler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

4.3 Description of the control panel B-Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

4.3.1 Description of the keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

4.3.2 Description of the display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13

4.4 Description of the control panel IniControl 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

4.4.1 Description of the keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

4.4.2 Description of the display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14

5 Utilisation with the control panel B-Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

5.1 Browsing in the menus . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

5.2 Start-up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

5.3 Shutdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

5.3.1 Switching off the heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

5.3.2 Stopping domestic hot water production . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

5.3.3 Shutting down the installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

5.4 Frost Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

6 Utilisation with the control panel IniControl 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

6.1 Browsing in the menus . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

6.2 Start-up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

6.2.1 Description of the PCBs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19

6.2.2 Selecting a PCB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

6.3 Shutdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

6.3.1 Switching off the heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

6.3.2 Stopping domestic hot water production . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

6.3.3 Shutting down the installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

6.4 Frost Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21

7 Control panel settings B-Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

7.1 List of parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

7.1.1 Information menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22

7.2 Setting the parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

7.2.1 Setting the heating water temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .22

7.2.2 Modifying the domestic hot water temperature setpoint . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

8 Control panel settings IniControl 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

8.1 List of parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

8.1.1 User Menu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

8.1.2 COUNTERS /TIME PROG / CLOCK menus . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26

8.2 Setting the parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

8.2.1 Modifying the User parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

Contents

7626252 - v03 - 25072017 EF 3

8.2.2 Setting the heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

8.2.3 Setting the domestic hot water temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29

8.2.4 Setting the timer programming . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29

8.2.5 Activating Manual Forcing for heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

8.2.6 Reading out measured values . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

9 Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

9.1 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

9.2 Maintenance instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

9.2.1 Check the hydraulic pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

9.2.2 Topping up the installation with water . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

9.3 Venting the installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35

10 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36

10.1 Error messages B-Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36

10.1.1 Error code display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36

10.1.2 Fault code display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36

10.2 Error messages IniControl 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36

10.2.1 Error messages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36

10.2.2 Accessing the error log . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36

11 Environmental . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

11.1 Disposal and Recycling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38

11.2 Energy savings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

12 Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

12.1 General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

12.2 Terms of warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

Contents

4 EF 7626252 - v03 - 25072017

1 Safety

1.1 General safety instructions

Danger

This appliance is not intended for use by persons

(including children) with reduced physical, senso

ry or mental capabilities, or lack of experience

and knowledge, unless they have been given su

pervision or instruction concerning use of the ap

pliance by a person responsible for their safety.

Children should be supervised to ensure that they

do not play with the appliance.

Danger of electric shock

Before any work, switch off the mains supply to

the boiler.

Caution

Only genuine spare parts may be used.

Important

Only qualified professionals are permitted to in

stall the boiler, in accordance with prevailing local

and national regulations.

Important

Allow the space required to correctly install the

boiler. Refer to the Overall space needed for the

boiler section in the installation and service man

ual.

Warning

Do not touch the flue gas pipes. Depending on

the boiler settings, the temperature of the flue gas

pipes may exceed 60°C.

Warning

Do not touch the radiators for long periods. De

pending on the boiler settings, the temperature of

the radiators may exceed 60°C.

Warning

Take precautions with the domestic hot water.

Depending on the boiler settings, the domestic

hot water temperature may exceed 65°C.

Warning

Only qualified professionals are authorised to

work on the boiler and the heating system.

1 Safety

7626252 - v03 - 25072017 EF 5

Important

The installation must comply on all points with

prevailing regulations and directives, which gov

ern work and interventions in individual homes,

blocks of flats and other buildings.

Hydraulic safety

Important

Respect the minimum and maximum water inlet

pressure to ensure correct operation of the boiler:

refer to the chapter Technical Specifications.

Electrical safety

Caution

A disconnection method must be allowed in the

fixed pipes in accordance with the rules on instal

lation in force in the country.

Caution

If a power cord comes with the appliance and it

turns out to be damaged, it must be replaced by

the manufacturer, its after sales service or per

sons with similar qualifications in order to obviate

any danger.

Important

The installation must comply on all points with

prevailing regulations and directives, which gov

ern work and interventions in individual homes,

blocks of flats and other buildings.

Caution

The boiler must always be connected to the pro

tective earthing.

Earthing must comply with the prevailing instal

lation standards.

Earth the appliance before making any electrical

connections.

For the type and calibre of the protective equip

ment, refer to the chapter Electrical Connections

in the Installation and Service Manual.

Danger of electric shock

Only qualified professionals are permitted access

to the inside of the appliance, in accordance with

the prevailing electrical safety standard.

1 Safety

6 EF 7626252 - v03 - 25072017

Danger

If you smell flue gases:

1. Switch off the appliance.

2. Open the windows.

3. Evacuate the premises.

4. Contact a qualified professional.

Caution

Do not neglect to service the boiler. Contact a

qualified professional or take out a maintenance

contract for the obligatory annual servicing of the

boiler.

Failure to service the appliance voids the warran

ty.

Important

This manual can also be found on our internet

site.

1.2

Recommendations

Caution

The system must satisfy each point in the rules

(DTU, EN and others, etc.) that govern works and

interventions in individual homes, blocks of flats

or other buildings.

Note

Keep the boiler accessible at all times.

Caution

Install the boiler in a frost-free environment.

Note

Regularly check the presence of water and pres

sure in the heating installation.

Important

Never remove or cover labels and data plates af

fixed to the appliances. Labels and data plates

must be legible throughout the entire lifetime of

the appliance.

Immediately replace damaged or illegible instruc

tions and warning stickers.

Important

Remove the casing only to perform maintenance

and repair work. Put the casing back in place af

ter maintenance and repair work.

1 Safety

7626252 - v03 - 25072017 EF 7

Important

Insulate the pipes to reduce heat losses to a mini

mum.

Caution

Have the boiler and heating system drained by a

qualified professional if the home is left empty for

a long period of time and there is a chance of

frost.

1.3

Liabilities

1.3.1

Manufacturer's liability

Our products are manufactured in compliance with the

requirements of the various Directives applicable. They

are therefore delivered with the

marking and any

documents necessary. In the interests of the quality of

our products, we strive constantly to improve them. We

therefore reserve the right to modify the specifications

given in this document.

Our liability as manufacturer may not be invoked in the

following cases:

Failure to abide by the instructions on installing the

appliance.

Failure to abide by the instructions on using the appli

ance.

Faulty or insufficient maintenance of the appliance.

1.3.2

Installer's liability

The installer is responsible for the installation and initial

commissioning of the appliance. The installer must ob

serve the following instructions:

Read and follow the instructions given in the manuals

provided with the appliance.

Install the appliance in compliance with prevailing leg

islation and standards.

Carry out initial commissioning and any checks neces

sary.

Explain the installation to the user.

If maintenance is necessary, warn the user of the obli

gation to check the appliance and keep it in good

working order.

Give all the instruction manuals to the user.

1 Safety

8 EF 7626252 - v03 - 25072017

1.3.3

User's liability

To guarantee optimum operation of the system, you

must abide by the following instructions:

Read and follow the instructions given in the manuals

provided with the appliance.

Call on a qualified professional to carry out installation

and initial commissioning.

Get your installer to explain your installation to you.

Have the required inspections and maintenance car

ried out by a qualified installer.

Keep the instruction manuals in good condition close

to the appliance.

1 Safety

7626252 - v03 - 25072017 EF 9

2 About this manual

2.1 Symbols used

2.1.1 Symbols used in the manual

This manual uses various danger levels to draw attention to special in

structions. We do this to improve user safety, to prevent problems and to

guarantee correct operation of the appliance.

Danger

Risk of dangerous situations that may result in serious personal

injury.

Danger of electric shock

Risk of electric shock.

Warning

Risk of dangerous situations that may result in minor personal in

jury.

Caution

Risk of material damage.

Important

Please note: important information.

See

Reference to other manuals or pages in this manual.

2.1.2 Symbols used on the appliance

1 Alternating current.

2 Protective earthing.

3 Before installing and commissioning the appliance, carefully read

the instruction manuals provided.

4 Dispose of used products through an appropriate recovery and re

cycling structure.

5 Caution: danger of electric shock, live parts. Disconnect the mains

power prior to carrying out any work.

6 Connect the appliance to the protective earthing.

Fig.1

1 2

MW-1000123-2

2 About this manual

10 EF 7626252 - v03 - 25072017

3 Technical specifications

3.1 Homologations

3.1.1 Certifications

The boiler complies with current standards.

CE identification number: 0085CQ0006

3.1.2 Oil categories

Tab.1

Type of oil that can be used Maximum viscosity

GNR

Non-road diesel with a maximum FAME content of 7 %

(1)

Note

To be used exclusively for a boiler fitted with a burner with a heater.

6 mm

/s at 20 °C

Standard fuel oil

6 mm

/s at 20 °C

Low-sulphur oil

6 mm

/s at 20 °C

Bio-oil B10

Mixture of low-sulphur oil (<50 mg/kg) plus 5.9 to 10.9% (in volume) of FAME

(1)

6 mm

/s at 20 °C

Bio-oil B5 (or Bio 5)

Mixture of low-sulphur oil (<50 mg/kg) plus 3 to 5.9% (in volume) of FAME

(1)

6 mm

/s at 20 °C

(1) Liquid petroleum products — Fatty Acid Methyl Esters used as heating fuel

3.2

Technical data

Important

Technical parameters obtained in association with the RDB 2.2

burner

Tab.2 Technical parameters for boiler space heaters

Product name EF 22 EF 29

Condensing boiler No No

Low-temperature boiler

(1)

Yes Yes

B1 boiler No No

Cogeneration space heater No No

Combination heater No No

Rated heat output

Prated

kW 22 30

Useful heat output at rated heat output and high tem

perature regime

(2)

kW 22.4 29.8

Useful heat output at 30% of rated heat output and low

temperature regime

(1)

kW 7.0 9.3

Seasonal space heating energy efficiency

% 86 86

Useful efficiency at rated heat output and high temper

ature regime

(2)

% 87.5 87.3

Useful efficiency at 30% of rated heat output and low

temperature regime

(1)

% 91.2 90.6

3 Technical specifications

7626252 - v03 - 25072017 EF 11

Product name EF 22 EF 29

Auxiliary electricity consumption

Full load

elmax

kW 0.143 0.144

Part load

elmin

kW 0.050 0.050

Stand-by

kW 0.004 0.004

Other specifications

Standby heat loss

stby

kW 0.083 0.095

Ignition burner power consumption

ign

kW -- --

Annual energy consumption

GJ 74 100

Sound power level, indoors

dB - -

Emissions of nitrogen oxides NO

mg/kWh 116 116

(1) Low temperature means for condensing boilers 30°C, for low temperature boilers 37°C and for other heaters 50°C return temperature

(at heater inlet).

(2) High temperature regime means 60°C return temperature at heater inlet and 80°C feed temperature at heater outlet.

See

The back cover for contact details.

3 Technical specifications

12 EF 7626252 - v03 - 25072017

4 Description of the product

4.1 General description

The floor-standing oil boilers in the EF range have the following specifica

tions:

Heating only with possibility to produce domestic hot water by combining

them with a domestic hot water tank

High-efficiency heating

Low polluting emissions

Heating body in cast iron

Electronic control panel

Flue gas discharge via a chimney type connection

4.2

Main components

4.2.1 Boiler

Control panel

On/Off switch

Data plate

4.3 Description of the control panel B-Control

4.3.1 Description of the keys

Heating temperature setting button

Level access key: Information, Installer or Chimney Sweep

Manual reset key

Domestic hot water temperature setting button

4.3.2 Description of the display

Hour run meter

Malfunctions

Maintenance

Reset necessary

Burner status

Heating mode

Outside temperature sensor

Domestic hot water mode

Fig.2

MW-5000484-1

Fig.3

MW-5000031-3

Fig.4

MW-3000235-3

4 Description of the product

7626252 - v03 - 25072017 EF 13

4.4 Description of the control panel IniControl 2

4.4.1 Description of the keys

: back to the previous level without saving the modifications

made

: manual reset

: accessing the heating parameters

: lowering the value

: accessing the domestic hot water parameters

: raising the value

: MODE display

: accessing the menu selected or confirming the value modifi

cation

4.4.2

Description of the display

Burner Operation

Burner ON

Operating modes

Steady symbol: heating function enabled

Flashing symbol: heating production running

Steady symbol: domestic hot water function enabled

Flashing symbol: domestic hot water production running

Heating function disabled

Domestic hot water function disabled

Menu display

Information menu: displays the measured values and the statuses

of the appliance

User menu: provides access to the User level setting parameters

Installer menu: provides access to the Installer level setting param

eters

Manual Forcing menu: the appliance runs at the set point dis

played, the pumps operate and the three-way valves are not con

trolled.

Malfunction menu: the appliance has malfunctioned. This informa

tion is signalled by an error code and a flashing display.

Sub-Menu COUNTERS

TIME PROG sub-menu: Timer programming dedicated to heat

ing and domestic hot water production

Sub-Menu CLOCK

PCB selection menu: access to information on the additional PCBs

connected

Fig.5

MW-1000043-5

1 2 3 4

Fig.6

MW-1000085-4

Fig.7

MW-1000083-5

Fig.8

4 Description of the product

14 EF 7626252 - v03 - 25072017

Display of PCB names

The name of the PCB for which the parameters are displayed is

shown as 3 characters.

CU-OH04 central unit PCB for the boiler

SCB-04B additional PCB: 2

circuit

COUNTERS / TIME PROG / Sub-Menus CLOCK

COUNTERS sub-menu (CNT)

TIME PROG sub-menu: Timer programming dedicated to heat

ing and domestic hot water production (CIRC A, CIRC B, ECS)

Timer program for Monday

Timer program for Tuesday

Timer program for Wednesday

Timer program for Thursday

Timer program for Friday

Timer program for Saturday

Timer program for Sunday

CLOCK sub-menu (CLK)

Temperature sensors

Outside temperature sensor connected:

fixed symbol for WINTER mode,

flashing symbol for SUMMER mode.

Other Information

Chimney Sweep Menu: forced operation in full load mode

Three-way valve connected

Three-way valve closed

Three-way valve open

Pump running

Fig.9

MW-1000670-1

Fig.10

MW-1000683-2

...CUO / H04...

Fig.11

MW-1000687-1

...SCB / 04- / B...

Fig.12

MW-1000575-2

Fig.13

MW-1001083-1

Fig.14

MW-5000038-4

4 Description of the product

7626252 - v03 - 25072017 EF 15

5 Utilisation with the control panel B-Control

5.1 Browsing in the menus

Press any key to turn on the backlight for the control panel screen.

Important

If no key is pressed within 3 minutes, the backlight will go out.

The key is used to access the various menus:

Tab.3 Menus available

Information menu

Chimney Sweep menu

Press the key to access the Information menu.

Press the key for 2 seconds to access the Chimney Sweep menu.

Keep pressing the key to scroll through the information.

Note

Thirty minutes after the key is pressed for the last time, the dis

play reverts to the main display.

5.2 Start-up

If the boiler was powered off:

1. Check that the heating system and the boiler are adequately primed

with water. Recommended pressure: 0.15 MPa (1.5 bar).

2. Check that the storage tank is filled with fuel.

3. Open the oil inlet valve.

4. Switch on the boiler.

A venting cycle is run automatically.

The display shows the operating status of the boiler, the heating flow tem

perature and any error codes.

5.3

Shutdown

5.3.1 Switching off the heating

1. Turn the setting button all the way to the left until is dis

played.

Note

The frost protection function continues to run

Fig.15

MW-1000668-1

Fig.16

MW-1000667-1

2’’

Fig.17

MW-1000668-1

Fig.18

MW-3000241-3

5 Utilisation with the control panel B-Control

16 EF 7626252 - v03 - 25072017

5.3.2 Stopping domestic hot water production

1. Turn the setting button all the way to the left until is dis

played.

Note

Frost protection continues to run on the domestic hot water tank.

The venting cycle is not tripped when domestic hot water produc

tion is shut down.

5.3.3 Shutting down the installation

It is recommended that the boiler is kept powered on to ensure frost pro

tection.

5.4

Frost Protection

Caution

The frost protection function does not work if the boiler is powered

off.

Caution

The integrated protection system only protects the boiler, not the

heating system.

Caution

Have the boiler and heating system drained by a qualified profes

sional if the home is left empty for a long period of time and there

is a chance of frost.

Important

To prevent the radiators and the installation from freezing in pla

ces where that risk exists (e.g. in a garage or an equipment room),

we recommend the connection of an outside temperature sensor

to the boiler.

If the temperature of the water in the boiler falls too much, the integrated

protection device switches itself on. This device functions as follows:

If the water temperature is lower than 7°C, the circulation pump starts

up.

If the water temperature is lower than 4°C, the boiler starts up.

If the water temperature is higher than 10°C, the boiler shuts down and

the circulation pump continues to run for a short time.

Fig.19

MW-3000242-3

5 Utilisation with the control panel B-Control

7626252 - v03 - 25072017 EF 17

6 Utilisation with the control panel IniControl 2

6.1 Browsing in the menus

Press any key to turn on the backlight for the control panel screen.

Important

If no key is pressed within 3 minutes, the backlight will go out.

Press the 2 right-hand keys together to access the different menus:

Tab.4 Menus available

Information menu

User menu

Installer menu

Manual Forcing menu

Malfunction menu

COUNTERS sub-menu

TIME PROG sub-menu

CLOCK sub-menu

PCB selection menu

Note

The icon is displayed only if an optional PCB has

been installed.

Note

The different menus are only accessible when the icons flash.

Press the key to:

access the next menu,

access the next sub-menu,

access the next parameter,

increase the value.

Press the key to:

access the previous menu,

access the previous sub-menu,

access the previous parameter

decrease the value.

Press the confirmation key to confirm:

a menu,

a sub-menu,

a parameter,

a value.

When the temperature is displayed, briefly pressing the back key

will

return to the time display.

6.2

Start-up

If the boiler was powered off:

1. Check that the heating system and the boiler are adequately primed

with water. Recommended pressure: 0.15 MPa (1.5 bar).

2. Check that the storage tank is filled with fuel.

3. Open the oil inlet valve.

4. Switch on the boiler.

A venting cycle is run automatically.

Fig.20

MW-2000369-1

Fig.21

MW-1000576-1

Fig.22

MW-2000370-1

Fig.23

MW-2000371-1

6 Utilisation with the control panel IniControl 2

18 EF 7626252 - v03 - 25072017

The display shows the operating status of the boiler, the heating flow tem

perature and any error codes.

6.2.1 Description of the PCBs

When commissioning the boiler, the PCB displayed is the CU-OH04.

The primary circuit is managed by the CU-OH04 central unit PCB. The

name of the PCB is displayed on the screen: .

See

Boiler instructions for setting the boiler parameters

Only the installer can access the parameters and settings for each PCB.

In order to control an installation that has an additional circuit, it will be

necessary to install the SCB-04 PCB. The name of the PCB is displayed

on the screen: .

Note

Given that numerous settings can be made on the 2 PCBs, de

pending on the circuit concerned, the name of the PCB will be rep

resented by in the rest of the manual.

6.2.2

Selecting a PCB

1. Access the menus by pressing the two keys on the right simultane

ously.

2. Access the PCB selection menu (only when several PCBs are

present).

Important

The PCB selection menu is available only when the icon flash

es.

3. Scroll through the names of the connected additional PCBs by

pressing the

or keys.

The names of the installed PCBs will be displayed in sequence.

4. Confirm the required PCB by pressing the key.

Note

The flow temperature for the selected PCB is displayed by default,

as well as the status of the pump(s) and the status of the valve

connected to the selected PCB.

5. Go back to the main display by pressing the

key.

For more information, see

Modifying the User parameters, page 28

COUNTERS /TIME PROG / CLOCK menus, page 26

User Menu, page 24

Fig.24

MW-1001085-1

...CU- /-OH /-04...

Fig.25

Management of a second

circuit

MW-1001084-1

...SCb /-04 /-B...

Fig.26

MW-2000369-1

Fig.27

MW-5000137-2

6 Utilisation with the control panel IniControl 2

7626252 - v03 - 25072017 EF 19

6.3 Shutdown

6.3.1 Switching off the heating

Note

Heating mode can be managed via the TIME PROG sub-menu

dedicated to timer programming.

1. Go to stop mode by pressing the key.

2. Select the heating mode by pressing the key.

3. Confirm by pressing the key.

4. Select the heating shut-down pressing the key.

The screen displays: .

The frost protection function continues to run.

The heating has been shut down.

Note

Press the key to restart the appliance: the screen will

display .

Confirm by pressing the key.

6. Go back to the main display by pressing the

key.

Note

The display disappears after a few seconds of inactivity.

6.3.2 Stopping domestic hot water production

Note

Domestic hot water production can be managed via the TIME

PROG sub-menu dedicated to timer programming.

1. Go to stop mode by pressing the key.

Fig.28

MW-5000027-4

Fig.29

MW-5000133-3

Fig.30

MW-5000134-3

Fig.31

MW-5000135-3

6 Utilisation with the control panel IniControl 2

20 EF 7626252 - v03 - 25072017

Page is loading ...

De Dietrich EcoNox EF 36 User manual

Brand: De Dietrich

Model: EcoNox EF 36

Category: Water heaters & boilers

Type: User manual

Download PDF

report

De Dietrich EcoNox EF 36 User manual

De Dietrich EcoNox EF 36 User manual

Related papers

Other documents