Reely 1851824 Operating instructions

Brand
Reely
Model
1851824
Category
Remote controlled toys
Type
Operating instructions
Page is loading ...
Page is loading ...
Installation
• Iftheintendtousetheproductasreplacementforanexistingspeedcontrol,checkrstthattheengineis
suitableforthespeedcontrol.Thenremovetheoldspeedcontrollerfromyourmodel.
• Nowinstallthespeedcontrollerunitintothemodelvehicle.Choosealocationwhichisasfaraspossible
fromthereceiver.Thecontrolunitshouldalsonotbedirectlynexttothemotor.
• Connectthetwocablesofthespeedcontrollerwiththemotorcables;payattentiontoanycolourcoding.
Thisensuresthatthemotorwillmoveforward/backwardasdenedbythespeedcontrol.
Ifyoulaterdiscoverthatthemotor’sdirectionofrotationofthemotoriswrong(dependingon
thedriveofthevehicle),eitherswapthetwomotorcablesoractivatethereversesettingonyour
transmitter.Themotorthenrotatesintheotherdirection.
• Useforexamplethedouble-sidedadhesivetapeenclosedtoattachthespeedcontrol.
• Installthespeedcontrol’son/offbuttonsothatitcanbeeasilyoperated.Useagaindouble-sidedtapeto
attachthebutton.
• Connectthethree-poleplugofthespeedcontrollertothecorrespondingchannelofthereceiver.
Makeabsolutelysureyouhavethecorrectreceiverconguration(checktheoperationinstruc-
tionsforthereceiverorthelabelonthereceiver).
Yellow/white/orangeconnectingline:Controlsignal
Redcable:Operatingvoltage/+
Brown/blackcable:GND/Minus/-
ThespeedcontrollerfeaturesBECelectronics;thereforeyoucan’tuseanybatteryorrecharge-
ablebatterywiththereceiver!Boththereceiverandthesteeringservoconnectedtoitwillbe
poweredwithvoltage/currentdirectlythroughthespeedcontroller,fromtherechargeabledrive
battery.
Ifinsteadofthespeedcontroller'sBECisusedaseparatereceiverpowersupply,themiddle
wireofthespeedcontroller'sthree-pinreceiverplughastobeinterrupted.
Failuretocomplywiththisindicationwilldestroythespeedcontroller!Thewarrantywillbevoid!
• Positionallcablessothattheycannotbecomeentangledinrotatingormovingpartsofthevehicle.Use
cabletiestoafxthem,forexample.
• Exampleofconnectingofthespeedcontroller(motor,servo,receiverandrechargeabledrivebatteryare
notsuppliedwiththespeedcontroller):
1 Speedcontroller
2 On/offswitch
3 Motor
4 Drivebattery
5 Steeringservo
6 Receiver
Operating instructions
Electronic crawler/boat speed controller
Item No. 1851824
Intended Use
Thespeedcontrollerisspecicallydesignedfortheinstallationincrawlersorinashipmodel.Itcanrunwith
aLiPodrivebattery(2-3cells,ratedvoltage7.4Vor11.1V)oraNiMH/NiCddrivebattery(5-9cells,
ratedvoltage6.0-10.8V).
Forsafetyandcompliancereasons,theproductmustnotbeconvertedormodiedinanyway.Ifyouusethe
productforotherpurposesthanthosedescribedabove,theproductmaybedamaged.Furthermore,improp-
erusecancauseriskssuchasshort-circuits,re,etc.Pleasereadtheoperatinginstructionscarefullyanddo
notdiscardthem.Pleaseincludetheseoperatinginstructionswhenyoupasstheproductontoathirdparty.
ThisproductcomplieswiththeapplicablenationalandEuropeanRegulations.Allnamesofcompaniesand
productsarethetrademarksoftherespectiveowners.Allrightsreserved.
Package contents
• Speedcontroller
• Double-sidedadhesivetape
• OperatingInstructions
Latest operating instructions
Downloadthelatestoperatinginstructionsviathelinkwww.conrad.com/downloadsorscantheQRcode
shownhere.Followtheinstructionsonthewebsite.
Explaining the symbols
Anexclamationmarkinatriangleindicatesimportantinstructionsintheseoperatinginstructions
whichabsolutelyhavetobeobserved.
Thearrowsymbolindicatesspecictipsandadviceonoperation.
Safety Instructions
Please read the operating instructions carefully and pay particular attention to the safety
instructions. We do not assume liability for any injuries/material damages resulting from
failure to observe the safety instructions and the information in these operating instruc-
tions regarding the proper use of the product. Furthermore, in such cases, the warranty/
guarantee will be null and void.
• Theproductisnotatoyandshouldbekeptoutofthereachofchildren!
• Alwaysdisconnectthebatteryfromthespeedcontrollerifyoudonot useit. Ifthe speed
controllerisnotusedforshortperiods,itcanbedeactivatedviatheOn/Offswitch.
• Alwaysswitchonthetransmitterrstandbringitsoperatingleverforthemotorfunctiontothe
neutralposition(motoroff).Onlyafterthat,connectthespeedcontrollertothedrivebattery
andswitchiton.Whenswitchingoffproceedinthereverseorder.Beforeswitchingoffthe
transmitter,turnoffthespeedcontrollerand,ifnecessary,separateitfromthedrivebattery.
• ThespeedcontrollerworkswithaLiPooraNiMH-Akkubattery.Theadmissiblenumberof
cells,etc.canbefoundinthechapter"TechnicalData".
• Onlyoperatethespeedcontrollerwithabatterypack,butneverwithapoweradapter.
• Thespeedcontrollercanbecomeveryhotduringoperation.Riskofburns!
• Make sure that body parts or objects are kept away from rotating parts when handling
vehicles.Riskofinjury!
• Onlyconnectonesinglemotortothespeedcontrol.
• Thespeedcontrollerisnotsuitablefortheoperationofthree-portbrushlesselectricmotors.
• Keepthemaximalpossibledistancebetweenthereceiverandmotorwheninstallingtomutual
interferences.Donotinstallthereceiver’santennacableparalleltocurrent-carryingcables.
• Makesurecoolingofthespeedcontrollerissufcient,whenoperatingthemodel.Nevercover
thecoolingelementofthespeedcontroller!
• Avoidblockingthedrive.Thecurrentsarisingfromthiscoulddestroythespeedcontroller.Pay
attentiontoasmooth-running,regularlyserviceddrive-line.
• Checkvehicle,speedcontrollerandtheconnectedmotorondamagesinregularintervals.If
younoticeanydamage,donotanylongeroperatethevehicleorthespeedcontroller.
• Alwaysremovethebatteryfromthespeedcontrollerbeforerechargingthebattery.
• Handletheproductwithcare;itcanbedamagedbyimpacts,blowsorfallsevenfromalow
height.
• Do not leave the packaging material carelessly lying around, since it could become a
dangerousplaythingforchildren.
• Ifyouhavedoubtsabouthowtheproductshouldbeoperated,itssafetyorhowtoconnectit,
consultaqualiedtechnician.
• Maintenance, adjustment and repair work should only be carried out by an expert or a
specialisedworkshop.
• Ifyouhaveanyquestionsthatarenotansweredinthismanual,pleasecontactourtechnical
serviceoranotherspecialist.
Speed controller's Conguration
Thespeedcontrollerfeaturestwojumpers;throughthese
canbeconguredboththedrivingfunctionandthere-
chargeablebatterytype.
Jumper "MODE":
• "Crawler":Operatingmodeforcrawler;togglebetweenforwardandreverse.Ifthethrottleleveronthe
transmitterismovedfromforwardorreversetothecentre/neutralposition,thespeedcontrollerwillacti-
vatethemotorbrake.100%drivepowerisavailableforbothtraveldirections,forwardandreverse.
• "Boat":Operatingmodeforboatmodels;togglebetweenforwardandreverse.Ifthethrottleleveronthe
transmitterismovedfromforwardorreversetothecentre/neutralposition,thereisnothemotorbrake.
Only25%drivepowerisavailableforreversetravel.
"BATT" jumper:
Setherewhichrechargeabledrivebatteryisconnectedtothespeedcontroller.
• "Lipo"=2or3cellLiPorechargeabledrivebattery
• "NiMH"=5-9cellNiMH/NiCdrechargeabledrivebattery
Important!
IfyouareusingaLiPorechargeabledrivebatteryandsettingtherechargeablebatterytypeto
"NiMH",thentheretakesplaceadeepdischargeofthebattery,whichdestroysit.
Therefore,beforeyouconnectarechargeabledrivebatterytothespeedcontroller,alwaysmake
suretosetthecorrectrechargeablebatterytype.
IfyouarestillusingoldNiCddrivebatteries,setthejumper"BATT"on"NiMH".
Getting Started with the Speed Controller
Attention, be careful!
Placethemodelvehiclesothedrivewheels(incaseofboats,the propellers)do notmake
contactwiththegroundorotherobjects.Donottouchthedrivemechanism,donotblockit!Risk
ofinjury!
Ifthe trimming was adjusted on the transmitter,after switching onthespeedcontrollercan
directlydeterminethestartingofthemotor!
• Firstly,turnoffthespeedcontroller’son/offswitch(switchposition"OFF").Thencheckthesettingofjump-
ers,andcorrectitifnecessary.
• Turnonthetransmitterandcheckafterwardsthetransmitter’sbatterystatus.
• Inserttherechargeabledrivebatteryintothevehicleandconnectittothespeedcontrol.
Attention!
Youshouldpayattentiontothecorrectpolarityofthespeedcontroller'sconnectioncable:Red=
Plus(+)andBlack=Minus(-).Ifincorrectlyconnected,thespeedcontrollerandtherecharge-
abledrivebatterycanbedestroyed!Dangerofexplosion/burns!
• Movethetrimmingforsteeringanddrivingtothecentralpositionandcheckiftheoperatingleverforthe
drivefunctionisintheneutral/centralposition.
• Now,turnonthespeedcontroller(switchposition"ON").
• Thespeedcontrollernowstoresthepositionoftheneutralposition(donotmovethethrottleleveronthe
transmitterwhilestillinthecentral/neutralposition!).Themotorgeneratesdifferenttypesofbeeps(these
willbeproducedbytheactuationofthemotorbythespeedcontroller).Thespeedcontrollerisnowready
foruse.
1shortbeep=5-9cellNiMH/NiCdrechargeabledrivebattery
2shortbeeps=2cellLiPorechargeabledrivebattery
3shortbeeps=3cellLiPorechargeabledrivebattery
1longerbeep=self-testandcalibrationsuccessfully;thespeedcontrollerisreadyforoperation
Ifthespeedcontrollerdoesnotrecognisethetransmitter'sneutralposition,thennofunctionis
possible!Thiscanhappenwhenthetrimmingisadjustedonthetransmitterorwhenthedriving/
brakingfunction'soperatingleverisnotinthecentre/neutralposition.
Speed Controller Function Test
Themodel’smotor/drivemustnotrotatewhilethedriving/brakingfunction’soperatingleveronthetransmitter
isinthecentreposition(neutralposition).
Ifyoumovethedrivecontrollevertowardsforwardtravel(pulltothehandle),thevehicle(car/boatmodel)
shouldmoveforward.
Thenmovethecontrolleverfromtheforwarddrivepositiontothecentrepositionandwaitabit.Themotor
shouldstopnow.
Toreversethevehicle,movethedrivecontrollevertowardreversetravel(pushitawayfromthehandle).The
vehicle(car/boatmodel)shouldnowmovebackwards.
Ifthevehiclemovescontrarytothefunctiondescribedabove,switchoffthespeedcontroller
andswapthetwomotorcablesoractivatethereversesettingforthedrivingfunctiononthe
transmitter.
TheredLEDofthespeedcontrollerisoffintheneutralposition;theLEDasheswhendrivingforwards/
backwards.
In"Crawler"operatingmode,theLEDissteadylitif"fullthrottleforward/reverse"isselected.In"Boat"mode,
theLEDissteadylitonlyif"Fullthrottleforward"isselected.
Ending the Operation
• Bringthethrottle/brakelevertotheneutralpositionandletthevehiclerollout(ifnecessary,correctaccord-
inglythetransmitter'strimmingcontrol,sothatthemotorstops).
• Switchoffthecontrolunit.
• Alwaysdisconnecttherechargeabledrivebatteryfromthespeedcontroller.
• Onlynowdoyouturnoffthetransmitter.
Excess temperature protection
Whenthespeedcontrolleristoohot(>100°C),themotorwillturnoff.Insuchacase,theLEDwillsignalthis
withashing.Ifthespeedcontrollerscoolsunderabout+80°C,itisagainreadytobeused.
Fail-Safe Function
Thespeedcontrollerswitchesoffthemotorforsafetyreasons,iftherecomesnovalidsignalfromthere-
ceiver.Inthiscase,theredLEDwillashfast.Ifyourtransmitter/receiverfeaturesitsownfail-safefunction,
makesureyouareprogrammingitcorrectly!Checkthisfunctiontomakesureitwillworkcorrectlyinthe
eventofanerror.
Undervoltage Detection
Belowaspecicvoltageoftherechargeablebattery,themotorpowerisreduced,respectivelythemotoris
turnedoff.Thisprotectstherechargeabledrivebatteryagainstaharmfuldeepdischarge.
Jumper in the "NiMH" position (rechargeable drive battery with 5 - 9 cell)
Thespeedcontrollerreducestheoutputpowerto50%ifitismeasuredarechargeablebatteryvoltageof
4.5V.Belowarechargeablebatteryvoltageof4.0V,themotoristurnedoff.
Jumper in the "Lipo" position (rechargeable drive battery with 2 cell)
Thespeedcontrollerreducestheoutputpowerto50%ifitismeasuredarechargeablebatteryvoltageof
6.5V.Belowarechargeablebatteryvoltageof6.0V,themotoristurnedoff.
Jumper in the "Lipo" position (rechargeable drive battery with 3 cell)
Thespeedcontrollerreducestheoutputpowerto50%ifitismeasuredarechargeablebatteryvoltageof
9.75V.Belowarechargeablebatteryvoltageof9.0V,themotoristurnedoff.
Important!
Iftheundervoltagedetectionhasdetectedanemptybattery(motorpowerhasbeenreduced
orthemotorhasbeenswitchedoff),thespeedcontrollerwillresetthesafetyfeaturewhenyou
movethethrottlelevertothecentre/neutralposition.Thedrivecanthenbereactivated(untilthe
safetyfeatureistriggeredagain).
This"reactivationfunction"ismeanttohelpyoutostilldrivetheshipmodelashore,forexample,
ifthebatteryisat.
Connection to the receiver
Connectthe three-poleplug ofthespeedcontrollerto thecorresponding channelofthe receiver.Make
absolutelysureyouhavethecorrectreceiverconguration(seeoperationinstructionsforthereceiveras
wellastheinscriptiononthereceiver).
Yellow/white/orangeconnectingline:Controlsignal
Redcable:Operatingvoltage/+
Brown/blackcable:GND/Minus/-
ThespeedcontrollerfeaturesaBEC.Thismeansthatthebatterysuppliesthereceiverdirectly
withpowerviathespeedcontroller.IftheBECisusedasthepowersupplyofthereceiverunit,
donotuseareceiverbattery!
Important!
IfaseparatereceiverpowersupplyisusedinsteadoftheintegratedBEC,theredwireinthe
middleof the speedcontroller'sthree-pin receiver plug hastobe interrupted and insulated.
Failuretocomplywiththisindicationwilldestroythespeedcontroller!Thewarrantywillbevoid!
Ending the Operation
Firstswitchoffthecontrolunit(bringswitchintothe"OFF"position).Disconnecttherechargeablebattery
packfromthespeedcontrol/receiver,loosentheplugconnectionaltogether.Onlynowdoyouturnoffthe
transmitter.
Disposal
Electronicdevicesarerecyclablematerialsanddonotbelonginthehouseholdwaste.Dispose
ofanunserviceableproductinaccordancewiththerelevantstatutoryregulations.
Technical Data
NumberofcellsNiMH 5-9
NumberofcellsLiPo 2-3
Continuouscurrent Forward40A,backward20A
Max.current(<1second) Forward180A,backward90A
BEC 6V/DC,2A
Lowvoltagecutout yes
Overtemperatureshutdown yes
Fail-safefunction yes
Motorlimitat2LiPocells
or5-6NiMHcells
Motortype540/550,≥12turns(or<30000rpmat7.2V)
Motorlimitat3LiPocells
or7-9NiMHcells
Motortype540/550,≥18turns(or<20000rpmat7.2V)
Plug-systemforreceiver JR
Dimensions(LxWxH) approx.46.5x34x28.5mm
Weightwithcable approx.70g
ThisisapublicationbyConradElectronicSE,Klaus-Conrad-Str.1,D-92240Hirschau(www.conrad.com).
Allrightsincludingtranslationreserved.Reproductionbyanymethod,e.g.photocopy,microlming,orthecapturein
electronicdataprocessingsystemsrequirethepriorwrittenapprovalbytheeditor.Reprinting,alsoinpart,isprohibited.
Thispublicationrepresentthetechnicalstatusatthetimeofprinting.
Copyright2018byConradElectronicSE.  *1851824_V1_1218_02_VTP_m_en
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8

Reely 1851824 Operating instructions

Brand
Reely
Model
1851824
Category
Remote controlled toys
Type
Operating instructions
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

in other languages

Related papers

Other documents