Page 2
MW24-1100 MICROWAVE OVEN
General Information
1-2
#814888 - Revision A - May, 2009
INTRODUCTION
This Technical Service and Parts Manual has been compiled with information provided by the Sharp Electronics
Corporation. This manual provides the most recent technical service information for the model MW24-1100 which
will enable the service technician to troubleshoot and diagnose malfunctions, perform necessary repairs and return a
Wolf MW24-1100 Microwave Oven to proper operational condition.
The Service Technician should read the complete instructions contained in this Technical Service and Parts Manual
before initiating any repairs on a Wolf MW24-1100 appliance..
TECHNICAL ASSISTANCE
If you should have any questions regarding the appli-
ance and/or this manual, please contact:
Wolf Appliance, Inc.
ATTN: Service Department
P.O. Box 44988
Madison, WI 53744 - 4988
Customer Assistance
Phone #: (800) 222 - 7820
Facsimile #: (608) 441 - 5887
Technical Assistance
(For Technicians in Customer’s Homes Only)
Phone #: (800) 919 - 8324
Warranty Claims
Phone #: (800) 222 - 7820
Facsimile #: (608) 441 - 5886
Service Department e-mail Address:
Office Hours:
7:00 AM to 6:00 PM Central Time
Monday through Friday
IMPORTANT SAFETY INFORMATION
Below are Product Safety Labels used in this manual.
The "Signal Words" used are WARNING or CAUTION.
When reviewing this manual, please note these differ-
ent Product Safety Labels placed at the beginning of
certain sections of this manual. You must follow the
instructions given in the boxes of the Product Safety
Labels in order to avoid personal injury and/or product
damage.
The sample Product Safety Labels below illustrate the
precautions that should be taken when the signal word
is observed.
INDICATES THAT HAZARDOUS OR UNSAFE
PRACTICES COULD RESULT IN SEVERE PERSON-
AL INJURY OR DEATH!
Indicates that hazardous or unsafe practices could
result in minor personal injury, and/or product
damage, and/or property damage!
In addition, please pay attention to the signal word
“NOTE”, which highlights information that is especially
important for the topic being covered.
This manual is designed to be used by Authorized Service Personnel only. Wolf Appliance, Inc. assumes
no responsibility for any repairs made on Wolf appliance units by anyone other than Authorized Service
Technicians.
The information and images contained in this manual are the copyright property of Wolf appliance, Inc. Neither this
manual nor any information or images contained herein may be copied or used in whole or in part without the
express written consent of Wolf Appliance, Inc.©, all rights reserved.
Page 3
MW24-1100 MICROWAVE OVEN
General Information
1-4
#814888 - Revision A - May, 2009
Figure 1-1. Serial Number Tag Layout and Location
Serial Tag Location
Serial Tag Layout
CSA RATING - 117 V.A.C. 1.5 kW 60 Hz OUTPUT 1100 W 2450 MHz
UL RATING - 120 V.A.C. 1.5 kW 60 Hz OUTPUT 1100 W 2450 MHz
COMPLIES
WITH DHHS RADIATION PERFORMANCE STANDARDS 21CFR SUBCHAPTER J.
MADE IN U.S.A. from domestic and imported parts.
W
O
L
F
APPLIANCE
COMPANY , LLC Fitchburg,
Wisconsin
53719
SERIAL NO.
MANUFACTURED:
HOUSEHOLD MICROWAVE OVEN MODEL NO.
MW24-1100
FCC ID: APYDMR0146
12400000 JANUARY 2009
WOLF
R
C US
285B
WARRANTY INFORMATION
This page contains a summary of the 2 & 5 Year Warranty that is supplied with every Wolf product, followed by a
Non Residential Warranty summary and then notes about the warranties.
TWO & FIVE YEAR Warranty Summary
• Two year TOTAL PRODUCT warranty, parts and labor.
• Limited Parts Only Warranty for the 3rd through 5th year on the following parts: Transformer, Magnetron,
Capacitor, Rectifier, Electronic Control System, etc.
NOTE: This warranty only applies to products installed for normal residential use in the United States or Canada.
NON RESIDENTIAL Warranty Summary
• Two year TOTAL PRODUCT warranty, parts and labor.
NOTE: This warranty only applies to products installed in test kitchens, culinary and school kitchens, and other
installations which help promote Wolf Appliance products. Restaurant installations and other similar commercial
applications carry no warranty.
Warranty Notes:
• All warranties begin at the time of the unit's initial installation.
• All Warranty and Service information collected by Wolf Appliance, Inc. is arranged and stored under the unit seri-
al number and/or the customer's name. It is requested that you have the model and serial number available
whenever contacting the factory or parts distributor.
• See Figures 1-1 for serial tag layout and location.
Page 4
General Information
MW24-1100 MICROWAVE OVEN
1-5
#814888 - Revision A - May, 2009
MODEL FEATURES
Listed below are some features of the Wolf microwave. (See Figure 1-3)
1. One Touch Door Open Button
2. Safety Door Latches (Two)
NOTE: The oven will not operate unless the door is securely closed.
3. Removable Turntable
Support
NOTE: Must be placed in
center of oven floor.
4. Removable Turntable
NOTES:
• Turntable will rotate
clockwise or counter-
clockwise. Turntable
should only be removed
for cleaning.
• 13-1/4 lbs. (6 kg.) is max-
imum weight limit for
turntable motor.
5. Oven Lamp
NOTE: Lamp operates when
oven is operating or door is
open.
6. Oven Door with See-
through Window
7. Ventilation Openings (Rear
of unit)
8. Touch Control Panel
NOTE: Also see Control
Panel Layout on this page.
9. Interactive Digital Display
NOTE: Maximum time dis-
play is 99 minutes, 99 sec-
onds.
10. Coupling (a.k.a. Turntable
Motor Shaft)
11. Waveguide Cover
NOTE: Do NOT remove.
12. Power Supply Cord (partial
shown)
13. Menu Label
1
6
5
4
2
10
11
12
9
7
8
3
13
Figure 1-3. Oven Front and Rear View
Figure 1-4. Auto-Touch Control Panel
The diagram at right (Fig. 1-4)
illustrates the layout of the
microwave Touch Control
Panel.
Interactive
Digital Display
Auto Sensor
Cooking Keys
Auto Meal / Beverage /
Recipe Cooking Keys
Power Level Key
Number Keys
Help Key
Timer/Clock Key
Stop/Clear Key
Keep Warm Key
Add Minute Key
Quick On/Start Key
Door Open Button
CONTROL PANEL LAYOUT
Page 5
Installation Information
MW24-1100 MICROWAVE OVEN
2-3
#814888 - Revision A - May, 2009
Built-In Wall Installation
The Wolf 24” microwave can be set into a built-in wall
installation with the use of a 30” trim kit, available from
a Wolf dealer or distributor.
The trim kit consists of a ductwork assembly, duct
mounting screws, a decorative trim assembly and trim
mounting screws. (See Figure 2-3)
The ductwork assembly is placed on the platform of the
rough-in opening and secured with screws. The
microwave oven is first plugged into the electrical
receptacle, then set on top of the ductwork assembly
with the feet of the oven sitting in detents on the rails.
The decorative trim is then attached to the wall around
the front of the microwave oven. (See Figure 2-4)
NOTE: Because of the decorative trim design, the
ductwork assembly and microwave oven need to be
positioned toward the right side of the rough-in opening.
For complete built-in installation instructions, refer to the
installation guide and the instructions that accompany
the trim kit.
Ductwork
Assembly
Decorative
Trim Assembly
Mounting
Screws
Figure 2-3. Trim Kit Components
E
B
C
A
A
=
1
6
-1
/2
" m
in
., 1
7
" m
a
x
.
B
=
2
7
-1
/4
" m
in
., 2
8
-1
/2
" m
a
x
.
C
=
2
1
" m
in
.
E
=
L
o
c
a
tio
n
o
f e
le
c
tric
a
l o
u
tle
t
is
n
o
t c
ritic
a
l, a
s
lo
n
g
a
s
it is
w
ith
in
re
a
c
h
o
f th
e
th
re
e
-fo
o
t p
o
w
e
r s
u
p
p
ly
c
o
rd
p
ro
v
id
e
d
o
n
th
e
a
p
p
lia
n
c
e
.
Frame = 18-9/16" H X 29-7/8" W
Figure 2-4. Rough-in Opening Dimensions and Trim Kit Installation
NOTE: Oven platform must be mini-
mum 1” thick to support 100 lbs. load.
If installed above Wolf wall oven, rail
between appliances must be minimum
1-1/4” thick.
-
1
-
2
-
3
-
4
-
5
