Ford 1997 F-350 Maintenance Guide

1

General Information

*

[BK00050(FM)08/95]

thirty-two pica chart:0060629-D

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

2

Table of Contents

Maintenance Schedule and Record ............ 3

General Maintenance Information ............ 3

Normal Schedule ............................................ 8

Severe Duty Schedule ................................. 31

What Maintenance Schedule Do You

Follow? .............................................................. 6

Owner Maintenance Checks ...................... 62

*

[BK00110(FM)01/96]

ten pica chart:0060691-B

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

3

Maintenance Schedule and

Record

*

[BK00125(F )05/93]

quarter page art:0060553-B

*

[BK00200(FM)01/95] General Maintenance Information

*

[BK00300(FM)01/95]

The required Scheduled Maintenance Services

listed in this booklet are considered essential to

the proper operation, safety and performance of

your Ford Motor Company vehicle. We

recommend that you also perform the Owner

Maintenance Checks listed. These services are

matters of day-to-day care that are also

important to the proper operation of your

vehicle. The recommended lubricants, fluids and

service parts conforming to Ford Specifications

are available from your dealer.

*

[BK00350(FM)02/96]

This booklet gives you a place to record the

services that are performed on your vehicle so

that you can keep a record of when parts should

be checked or replaced. Give your Maintenance

Schedule booklet to the dealer service manager.

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

4

*

[BK00400(FM)01/95]

Maintenance: An investment

*

[BK00500(FM)01/95]

An investment which will pay dividends in the

form of improved reliability, durability, and

resale value.

*

[BK01300(FM)01/95]

To assure the durability of your vehicle and its

emission control systems, it is necessary that

scheduled maintenance be performed at the

designated intervals.

*

[BK01400(FM)01/96]

Ford strongly recommends the use of genuine

Ford replacement parts. If other than Ford or

Motorcraft parts or Ford authorized

remanufactured parts are used for maintenance

replacements or for the service of components

affecting emission control, such non-Ford parts

should be equivalent to genuine Ford Motor

Company parts in performance and durability. It

is the owner’s responsibility to determine the

equivalency of such parts. Please consult your

warranty booklet for complete warranty

information.

*

[BK01410(FM)05/95]

No Cost PCV Valve Replacement

*

[BK01415(F )05/95]

THE PCV VALVE IS A CRITICAL EMISSION

COMPONENT. YOUR DEALER WILL

REPLACE THE VALVE AT NO COST AT

60,000 MILES/96,000 KILOMETERS (EXCEPT

CANADA AND CALIFORNIA VEHICLES).

[BK01420(F )04/96]

FOR VEHICLES WITH 7.5L EFI ENGINES,

YOUR DEALER WILL REPLACE THE PCV

VALVE AT NO COST AT 60,000 MILES/96,000

KILOMETERS (EXCEPT CANADA VEHICLES).

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

5

*

[BK01435(FM)06/94]

Wheel Lug Nuts

[BK01455(FM)06/96]

Wheel lug nuts must be retightened to proper

torque specifications at 500 miles/800 km of

new vehicle operation (100 miles/160 km for

vehicles equipped for snowplowing). Proper

torque specifications are provided in your

Owner Guide. Also retighten to proper torque

specification at 500 miles/800 km after (1) any

wheel change or (2) any other time the wheel

lug nuts have been loosened.

*

[BK01462(FM)01/95]

PRE-DELIVERY CHECK

*

[BK01464(FM)01/95]

❑

Pre-Delivery Service Inspection Completed

*

[BK01466(FM)08/93]

four pica chart:0060627-A

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

6

What Maintenance

Schedule Do You Follow?

*

[BK01701(F )02/95]

Normal

Schedule

*

[BK01801(F )01/95]

Follow the Normal Schedule for most normal

everyday driving conditions.

*

[BK01901(F )01/95]

Severe Duty

Schedule

*

[BK02001(F )01/95]

Follow the Severe Duty Schedule if your driving

habits FREQUENTLY include one or more of the

following conditions:

*

[BK02101(F )05/93]

❑

Towing a trailer or carrying a heavy load.

*

[BK02201(F )04/96]

❑

Operating in severe dust conditions.

*

[BK02301(F )04/96]

❑

Extensive idling, such as police, taxi or

door-to-door delivery service.

*

[BK02401(F )05/93]

❑

Snowplowing

*

[BK02501(F )05/93]

❑

Off-Road operation

*

[BK02600(F )04/96]

❑

Short trips of less than 10 miles (16 km)

when outside temperatures remain below 0˚F

(-18˚C).

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

7

[BK02700(F )04/96]

NOTE: Idling the engine for extended periods

will accumulate more hours of use on

your vehicle than is actually indicated

by the mileage odometer.

Consequently, the odometer reading

can be often misleading when

determining the right time to change

your engine oil and filter.

[BK02800(F )04/96]

NOTE: If you are using your Ford vehicle in a

manner which allows it to remain

stationary while the engine is running

for long periods (door to door delivery,

taxi, police, power/utility company

trucks, or similar duty), then Ford

recommends you increase the

frequency of oil and filter changes to

an interval equivalent to 200 ENGINE

HOURS of use. Since most vehicles are

not equipped with hourmeters, it may

be necessary for you to approximate

your idle time and plan oil/filter

changes accordingly.

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

8 Normal Schedule

Normal Schedule

*

[BK29000(F )09/95]

NOTE: Items for Emission Control Service are shown

in this type and style.

*

[BK29100(F )07/95]

For items marked with number in parentheses

such as (1), see footnote at end of this section.

*

[BK29200(F )05/96]

NOTE: Rear axle lube quantities must be

replaced every 100,000 miles

(160,000 km) or if the axle has been

submerged in water. Otherwise, the

lube should not be checked or changed

unless a leak is suspected or repair

required.

*

[BK29350(F )06/95]

Regular

Maintenance

Intervals

for the Normal

Schedule

*

[BK29400(F )01/95]

5,000 MILES (8,000 Kilometers)

*

[BK29500(F )11/95]

❑

Change engine oil and replace oil filter.

[BK29700(F )04/96]

❑

Rotate tires and adjust air pressure. (1)(2)

[BK29800(F )04/96]

❑

Check and lubricate clutch release lever (7.5L

and 7.3L DIT Diesel).

[BK29900(F )09/95]

❑

Check clutch reservoir fluid level.

*

[BK30000(F )09/95]

❑

Inspect and lubricate automatic transmission

shift linkage.

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

Normal Schedule 9

*

[BK30150(F )06/95]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK30200(F )06/95]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

*

[BK30225(F )09/95]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK30250(F )08/93]

four pica chart:0060627-A

*

[BK30300(F )01/95]

10,000 MILES (16,000 Kilometers)

*

[BK30400(F )11/95]

❑

Change engine oil and replace oil filter.

*

[BK30475(F )08/93]

four pica chart:0060627-A

*

[BK31100(F )01/95]

15,000 MILES (24,000 Kilometers)

*

[BK31200(F )11/95]

❑

Change engine oil and replace oil filter.

*

[BK31300(F )07/95]

❑

Inspect engine cooling system, hoses, and clamps;

and check coolant strength every 15,000 miles

(24,000 km) or 12 months.

[BK31325(F )04/96]

❑

For 7.3L DIT Diesel Engines, add 8-10 ounces of

FW-15 to the engine coolant every 15,000 miles

(24,000 km).

[BK31400(F )04/96]

❑

Rotate tires and adjust air pressure. (1)(2)

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

10 Normal Schedule

[BK31700(F )09/95]

❑

Check clutch reservoir fluid level.

*

[BK31800(F )06/95]

❑

Lubricate transfer case shift lever pivot bolt

and control rod connecting pins (4x4).

*

[BK31900(F )09/95]

❑

Inspect and lubricate automatic transmission

shift linkage.

*

[BK32000(F )06/95]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK32200(F )04/94]

❑

Inspect disc brake system, lubricate caliper

slide rails.

*

[BK32300(F )04/94]

❑

Inspect drum brake systems, hoses and lines.

*

[BK32400(F )06/95]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

*

[BK32450(F )09/95]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

[BK32500(F )04/96]

❑

Inspect parking brake fluid level (F-Super

Duty).

[BK32550(F )04/96]

❑

Replace fuel filter every 15,000 miles

(24,000 km) or when the filter restriction

lamp is illuminated (7.3L DIT Diesel only).

[BK32600(F )04/96]

❑

Check spring U-bolt torque (F-Super Duty).

[BK32650(F )04/96]

❑

Change fuel filter (Recommended but not

required for California Certified Vehicles).

*

[BK32675(F )04/93]

four pica chart:0060627-A

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

Normal Schedule 11

*

[BK32700(F )01/95]

20,000 MILES (32,000 Kilometers)

*

[BK32800(F )11/95]

❑

Change engine oil and replace oil filter.

[BK33000(F )04/96]

❑

Check and lubricate clutch release lever (7.5L

and 7.3L DIT Diesel).

*

[BK33050(F )04/93]

four pica chart:0060627-A

*

[BK33500(F )01/95]

25,000 MILES (40,000 Kilometers)

*

[BK33600(F )11/95]

❑

Change engine oil and replace oil filter.

[BK33700(F )04/96]

❑

Rotate tires and adjust air pressure. (1)(2)

[BK33900(F )09/95]

❑

Check clutch reservoir fluid level.

*

[BK34000(F )09/95]

❑

Inspect and lubricate automatic transmission

shift linkage.

*

[BK34150(F )06/95]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK34200(F )06/95]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

*

[BK34225(F )09/95]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK34250(F )04/93]

four pica chart:0060627-A

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

12 Normal Schedule

*

[BK34300(F )01/95]

30,000 MILES (48,000 Kilometers)

*

[BK34400(F )11/95]

❑

Change engine oil and replace oil filter.

*

[BK34650(F )07/95]

❑

Inspect engine cooling system, hoses, and clamps;

and check coolant strength every 15,000 miles

(24,000 km) or 12 months.

[BK34655(F )04/96]

❑

For 7.3L DIT Diesel Engines, add 8-10 ounces of

FW-15 to the engine coolant every 15,000 miles

(24,000 km).

[BK34700(F )04/96]

❑

Replace air cleaner filter every 30,000 miles

(48,000 km) or 30 months. If operating in dusty

conditions, consult your dealer and/or follow

severe duty maintenance schedule.

[BK34750(F )04/96]

❑

Replace the air cleaner filter when the restriction

gauge is in the red zone (7.3L DIT Diesel only).

[BK34800(F )04/96]

❑

Replace crankcase emission air filter. If operating

in dusty conditions consult your dealer and/or

follow severe duty maintenance schedule. (7.5L

only.)

*

[BK35400(F )06/95]

❑

Lubricate transfer case shift lever pivot bolt

and control rod connecting pins (4x4).

*

[BK35800(F )04/94]

❑

Inspect disc brake system, lubricate caliper

slide rails.

*

[BK35900(F )04/94]

❑

Inspect drum brake systems, hoses and lines.

*

[BK36000(F )05/94]

❑

Inspect and lubricate front wheel bearings.

*

[BK36500(F )08/95]

❑

Inspect parking brake system for damage and

operation.

[BK36600(F )04/96]

❑

Inspect parking brake fluid level (F-Super

Duty).

*

[BK36700(F )09/95]

❑

Lubricate throttle kickdown or TV lever ball

studs.

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

Normal Schedule 13

*

[BK36800(F )06/95]

❑

Lubricate front axle R.H. axle shaft slip yoke

(4x4).

*

[BK36900(F )06/95]

❑

Inspect and lubricate spindle needle bearings

(4x4).

*

[BK37000(F )06/95]

❑

Inspect and lubricate hub locks (4x4).

[BK37200(F )04/96]

❑

Check spring U-bolt torque (F-Super Duty).

[BK37225(F )04/96]

❑

Replace fuel filter every 15,000 miles

(24,000 km) or when the filter restriction

lamp is illuminated (7.3L DIT Diesel only).

[BK37250(F )04/96]

❑

Change fuel filter (Recommended but not

required for California Certified Vehicles).

*

[BK37275(F )04/93]

four pica chart:0060627-A

*

[BK37300(F )01/95]

35,000 MILES (56,000 Kilometers)

*

[BK37400(F )11/95]

❑

Change engine oil and replace oil filter.

[BK37550(F )04/96]

❑

Rotate tires and adjust air pressure. (1)(2)

[BK37600(F )04/96]

❑

Check and lubricate clutch release lever (7.5L

and 7.3L DIT Diesel).

[BK37700(F )09/95]

❑

Check clutch reservoir fluid level.

*

[BK37800(F )09/95]

❑

Inspect and lubricate automatic transmission

shift linkage.

*

[BK37950(F )06/95]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK38000(F )06/95]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

14 Normal Schedule

*

[BK38025(F )09/95]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK38050(F )04/93]

four pica chart:0060627-A

*

[BK38100(F )01/95]

40,000 MILES (64,000 Kilometers)

*

[BK38200(F )11/95]

❑

Change engine oil and replace oil filter.

*

[BK38300(F )04/93]

four pica chart:0060627-A

*

[BK38900(F )01/95]

45,000 MILES (72,000 Kilometers)

*

[BK39000(F )11/95]

❑

Change engine oil and replace oil filter.

*

[BK39100(F )07/95]

❑

Inspect engine cooling system, hoses, and clamps;

and check coolant strength every 15,000 miles

(24,000 km) or 12 months.

[BK39150(F )04/96]

❑

For 7.3L DIT Diesel Engines, add 8-10 ounces of

FW-15 to the engine coolant every 15,000 miles

(24,000 km).

[BK39200(F )04/96]

❑

Rotate tires and adjust air pressure. (1)(2)

[BK39500(F )09/95]

❑

Check clutch reservoir fluid level.

*

[BK39600(F )06/95]

❑

Lubricate transfer case shift lever pivot bolt

and control rod connecting pins (4x4).

*

[BK39700(F )09/95]

❑

Inspect and lubricate automatic transmission

shift linkage.

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

Normal Schedule 15

*

[BK39825(F )06/95]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

[BK39850(F )04/96]

❑

Change fuel filter (Recommended but not

required for California Certified Vehicles).

[BK39875(F )04/96]

❑

Replace fuel filter every 15,000 miles

(24,000 km) or when the filter restriction

lamp is illuminated (7.3L DIT Diesel only).

*

[BK40000(F )04/94]

❑

Inspect disc brake system, lubricate caliper

slide rails.

*

[BK40100(F )04/94]

❑

Inspect drum brake systems, hoses and lines.

*

[BK40200(F )06/95]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

*

[BK40250(F )09/95]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

[BK40300(F )04/96]

❑

Inspect parking brake fluid level (F-Super

Duty).

[BK40400(F )04/96]

❑

Check spring U-bolt torque (F-Super Duty).

*

[BK40450(F )04/93]

four pica chart:0060627-A

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

16 Normal Schedule

*

[BK40500(F )01/95]

50,000 MILES (80,000 Kilometers)

*

[BK40600(F )11/95]

❑

Change engine oil and replace oil filter.

*

[BK40700(F )06/94]

❑

Change engine coolant initially at 50,000 miles

(80,000 km) or 48 months. Thereafter, change

engine coolant every 30,000 miles (48,000 km) or

36 months (Gasoline engines only).

[BK40750(F )04/96]

❑

For 7.3L DIT Diesel, add four (4) pints of FW-15

each time engine coolant is changed.

[BK40800(F )04/96]

❑

Check and lubricate clutch release lever (7.5L

and 7.3L DIT Diesel).

*

[BK40900(F )04/93]

four pica chart:0060627-A

*

[BK41300(F )01/95]

55,000 MILES (88,000 Kilometers)

*

[BK41400(F )11/95]

❑

Change engine oil and replace oil filter.

[BK41500(F )04/96]

❑

Rotate tires and adjust air pressure. (1)(2)

*

[BK41800(F )09/95]

❑

Inspect and lubricate automatic transmission

shift linkage.

*

[BK41950(F )06/95]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK42000(F )06/95]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

Normal Schedule 17

*

[BK42025(F )09/95]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK42050(F )04/93]

four pica chart:0060627-A

*

[BK42100(F )06/95]

60,000 MILES (96,000 Kilometers)

*

[BK42200(F )11/95]

❑

Change engine oil and replace oil filter.

*

[BK42250(F )07/95]

❑

Inspect engine cooling system, hoses, and clamps;

and check coolant strength every 15,000 miles

(24,000 km) or 12 months.

[BK42300(F )04/96]

❑

Replace spark plugs (Gasoline engines only).

[BK42500(F )04/96]

❑

Replace air cleaner filter every 30,000 miles

(48,000 km) or 30 months. If operating in dusty

conditions, consult your dealer and/or follow

severe duty maintenance schedule.

[BK42550(F )04/96]

❑

Replace the air cleaner filter when the restriction

gauge is in the red zone (7.3L DIT Diesel only).

[BK42600(F )04/96]

❑

Replace crankcase emission air filter. If operating

in dusty conditions consult your dealer and/or

follow severe duty maintenance schedule. (7.5L

only.)

*

[BK42700(F )05/94]

❑

Replace PCV valve. (3)

[BK42900(F )04/96]

❑

Check thermactor hoses and clamps.

(Recommended, not required.)

*

[BK43600(F )06/95]

❑

Lubricate transfer case shift lever pivot bolt

and control rod connecting pins (4x4).

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

18 Normal Schedule

[BK43700(F )04/96]

❑

Replace fuel filter every 15,000 miles

(24,000 km) or when the filter restriction

lamp is illuminated (7.3L DIT Diesel only).

[BK43850(F )04/96]

❑

Change fuel filter (Recommended but not

required for California Certified Vehicles).

*

[BK44000(F )04/94]

❑

Inspect disc brake system, lubricate caliper

slide rails.

*

[BK44100(F )04/94]

❑

Inspect drum brake systems, hoses and lines.

*

[BK44200(F )05/94]

❑

Inspect and lubricate front wheel bearings.

*

[BK44700(F )08/95]

❑

Inspect parking brake system for damage and

operation.

[BK44800(F )04/96]

❑

Inspect parking brake fluid level (F-Super

Duty).

*

[BK44900(F )09/95]

❑

Lubricate throttle kickdown or TV lever ball

studs.

*

[BK45000(F )06/95]

❑

Inspect and lubricate spindle needle bearings

(4x4).

*

[BK45100(F )06/95]

❑

Inspect and lubricate hub locks (4x4).

*

[BK45200(F )04/93]

❑

Change transfer case oil (4x4).

*

[BK45250(F )06/95]

❑

Lubricate front axle R.H. axle shaft slip yoke

(4x4).

*

[BK45300(F )08/95]

❑

Change manual transmission oil.

[BK45400(F )04/96]

❑

Check spring U-bolt torque (F-Super Duty).

*

[BK45450(F )04/93]

four pica chart:0060627-A

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

Normal Schedule 19

*

[BK45500(F )01/95]

65,000 MILES (104,000 Kilometers)

*

[BK45600(F )11/95]

❑

Change engine oil and replace oil filter.

[BK45610(F )04/96]

❑

For 7.3L DIT Diesel Engines, add 8-10 ounces of

FW-15 to the engine coolant every 15,000 miles

(24,000 km).

[BK45625(F )04/96]

❑

Rotate tires and adjust air pressure. (1)(2)

*

[BK45635(F )06/95]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK45655(F )06/95]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

*

[BK45660(F )09/95]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK45665(F )09/95]

❑

Inspect and lubricate automatic transmission

shift linkage.

[BK45675(F )09/95]

❑

Check clutch reservoir fluid level.

[BK45685(F )04/96]

❑

Check and lubricate clutch release lever (7.5L

and 7.3L DIT Diesel).

*

[BK45690(F )07/93]

four pica chart:0060627-A

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

20 Normal Schedule

*

[BK45700(F )01/95]

70,000 MILES (112,000 Kilometers)

*

[BK45800(F )11/95]

❑

Change engine oil and replace oil filter.

*

[BK45850(F )04/93]

four pica chart:0060627-A

*

[BK45900(F )01/95]

75,000 MILES (120,000 Kilometers)

*

[BK46000(F )11/95]

❑

Change engine oil and replace oil filter.

*

[BK46005(F )07/95]

❑

Inspect engine cooling system, hoses, and clamps;

and check coolant strength every 15,000 miles

(24,000 km) or 12 months.

[BK46007(F )04/96]

❑

Rotate tires and adjust air pressure. (1)(2)

*

[BK46010(F )06/95]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK46030(F )06/95]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

*

[BK46035(F )09/95]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK46040(F )04/94]

❑

Inspect disc brake system, lubricate caliper

slide rails.

*

[BK46055(F )04/94]

❑

Inspect drum brake systems, hoses and lines.

[BK46065(F )04/96]

❑

Change fuel filter (Recommended but not

required for California Certified Vehicles).

File:18ltbkf.ex

Update:Tue May 28 08:56:09 1996

Page is loading ...

Ford 1997 F-350 Maintenance Guide

This manual is also suitable for

Ford 1997 F-350 Maintenance Guide

Related papers

Other documents