Ford 1996 Escort Maintenance Guide

1

General Information

*

[BK00050( ALL)05/95]

thirty-two pica chart:0060629-D

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

2

Table of Contents

General Maintenance Information............... 3

What Maintenance Schedule Do You

Follow? ................................................................ 6

Normal Schedule............................................... 7

Severe Duty Schedule ................................... 27

Owner Maintenance Checks........................ 54

*

[BK00110( ALL)05/95]

twenty-two pica chart:0060691-A

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

3

Maintenance Schedule and

Record

*

[BK00125(BEF )05/93]

quarter page art:0060553-B

*

[BK00200( ALL)01/95] General Maintenance Information

*

[BK00300( ALL)01/95]

The required Scheduled Maintenance Services

listed in this booklet are considered essential to

the proper operation, safety and performance of

your Ford Motor Company vehicle. We

recommend that you also perform the Owner

Maintenance Checks listed. These services are

matters of day-to-day care that are also

important to the proper operation of your

vehicle. The recommended lubricants, fluids and

service parts conforming to Ford Specifications

are available from your dealer.

*

[BK00350( ALL)01/95]

This booklet gives you a place to record the

services that are performed on your vehicle so

that you can keep a record of when parts should

be checked or replaced. Give your Maintenance

Schedule and Record booklet to the dealer service

manager.

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

4

*

[BK00400( ALL)01/95]

Maintenance: An investment

*

[BK00500( ALL)01/95]

An investment which will pay dividends in the

form of improved reliability, durability, and

resale value.

*

[BK01300( ALL)01/95]

To assure the durability of your vehicle and its

emission control systems, it is necessary that

scheduled maintenance be performed at the

designated intervals.

*

[BK01400( ALL)05/95]

Ford strongly recommends the use of genuine

Ford replacement parts. If other than Ford or

Motorcraft parts or Ford authorized

remanufactured parts are used for maintenance

replacements or for the service of components

affecting emission control, such non-Ford parts

should be equivalent to genuine Ford Motor

Company parts in performance and durability. It

is the owner’s responsibility to determine the

equivalency of such parts. Please consult your

warranty booklet for complete warranty

information.

*

[BK01410( ALL)05/95]

No Cost PCV Valve Replacement

*

[BK01415(BEF )05/95]

THE PCV VALVE IS A CRITICAL EMISSION

COMPONENT. YOUR DEALER WILL

REPLACE THE VALVE AT NO COST AT

60,000 MILES/96,000 KILOMETERS (EXCEPT

CANADA AND CALIFORNIA VEHICLES).

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

5

*

[BK01435( ALL)06/94]

Wheel Lug Nuts

*

[BK01455( ALL)06/94]

Wheel lug nuts must be retightened to proper

torque specifications at 500 miles/800 km of

new vehicle operation (100 miles/160 km for

vehicles equipped for snowplowing). Proper

torque specifications are provided in your

Owner Guide. Also retighten to proper torque

specification at 500 miles/800 km after (1) any

wheel change or (2) any other time the wheel

lug nuts have been loosened.

*

[BK01462( ALL)01/95]

PRE-DELIVERY CHECK

*

[BK01464( ALL)01/95]

❑

Pre-Delivery Service Inspection Completed

*

[BK01466( ALL)08/93]

four pica chart:0060627-A

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

6

What Maintenance

Schedule Do You Follow?

*

[BK01701(BEF )02/95]

Normal

Schedule

*

[BK01801(BEF )01/95]

Follow the Normal Schedule for most normal

everyday driving conditions.

*

[BK01901(BEF )01/95]

Severe Duty

Schedule

*

[BK02001(BEF )01/95]

Follow the Severe Duty Schedule if your driving

habits FREQUENTLY include one or more of the

following conditions:

*

[BK02101(BEF )05/93]

❑

Towing a trailer or carrying a heavy load.

*

[BK02201(BEF )01/95]

❑

Operating in severe dust conditions.

*

[BK02301(BEF )01/95]

❑

Extensive idling, such as police, taxi or

door-to-door delivery service.

*

[BK02401(B F )05/93]

❑

Snowplowing

*

[BK02501(B F )05/93]

❑

Off-Road operation

*

[BK02600(BEF )01/95]

❑

Short trips of less than 10 miles (16 km)

when outside temperatures remain below 0˚F

(-18˚C).

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

Normal Schedule 7

Normal Schedule

*

[BK29000(BEF )01/95]

NOTE: Items for Emission Control Service are

shown in this type and style.

*

[BK29100(BEF )02/91]

For items marked with number in parentheses

such as (1), see footnote at end of this section.

NOTE: Rear axle lube quantities must be

replaced every 100,000 miles

(160,000 km) or if the axle has been

submerged in water. Otherwise, the

lube should not be checked or changed

unless a leak is suspected or repair

required.

*

[BK29350(BEF )02/95]

Regular

Maintenance

Intervals

for the Normal

Schedule

*

[BK29400(BEF )01/95]

5,000 MILES (8,000 Kilometers)

*

[BK29500(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK29700(BEF )05/94]

❑

Rotate tires and adjust air pressure. (1)(2)

*

[BK29900(B F )08/94]

❑

Check clutch reservoir fluid level.

*

[BK30000(BEF )04/93]

❑

Inspect and lubricate automatic transmission

shift linkage.

*

[BK30150(BEF )04/94]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

8 Normal Schedule

*

[BK30200(BEF )05/93]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

*

[BK30225(BEF )05/94]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK30250(BEF )08/93]

four pica chart:0060627-A

*

[BK30300(BEF )01/95]

10,000 MILES (16,000 Kilometers)

*

[BK30400(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK30475(BEF )08/93]

four pica chart:0060627-A

*

[BK31100(BEF )01/95]

15,000 MILES (24,000 Kilometers)

*

[BK31200(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK31300(B )01/95]

❑

Inspect engine cooling system, hoses, and clamps;

and check coolant strength every 15,000 miles

(24,000 km) or 12 months.

*

[BK31400(BEF )05/94]

❑

Rotate tires and adjust air pressure. (1)(2)

*

[BK31700(B F )08/94]

❑

Check clutch reservoir fluid level.

*

[BK31800(B F )04/93]

❑

Lubricate transfer case shift lever pivot bolt

and control rod connecting pins (4x4).

*

[BK31900(BEF )04/93]

❑

Inspect and lubricate automatic transmission

shift linkage.

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

Normal Schedule 9

*

[BK32000(BEF )04/94]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK32200(BEF )04/94]

❑

Inspect disc brake system, lubricate caliper

slide rails.

*

[BK32300(BEF )04/94]

❑

Inspect drum brake systems, hoses and lines.

*

[BK32400(BEF )05/93]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

*

[BK32450(BEF )05/94]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK32650(BEF )04/94]

❑

Change fuel filter (Recommended but not

required for California Certified Vehicles).

*

[BK32675(BEF )04/93]

four pica chart:0060627-A

*

[BK32700(BEF )01/95]

20,000 MILES (32,000 Kilometers)

*

[BK32800(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK33050(BEF )04/93]

four pica chart:0060627-A

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

10 Normal Schedule

*

[BK33500(BEF )01/95]

25,000 MILES (40,000 Kilometers)

*

[BK33600(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK33700(BEF )05/94]

❑

Rotate tires and adjust air pressure. (1)(2)

*

[BK33900(B F )08/94]

❑

Check clutch reservoir fluid level.

*

[BK34000(BEF )04/93]

❑

Inspect and lubricate automatic transmission

shift linkage.

*

[BK34150(BEF )04/94]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK34200(BEF )05/93]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

*

[BK34225(BEF )05/94]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK34250(BEF )04/93]

four pica chart:0060627-A

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

Normal Schedule 11

*

[BK34300(BEF )01/95]

30,000 MILES (48,000 Kilometers)

*

[BK34400(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK34650(BEF )01/95]

❑

Inspect engine cooling system, hoses, and clamps;

and check coolant strength every 15,000 miles

(24,000 km) or 12 months.

*

[BK34700(BEF )03/94]

❑

Replace air cleaner filter every 30,000 miles

(48,000 km) or 30 months. If operating in dusty

conditions, consult your dealer and/or follow

severe duty maintenance schedule.

*

[BK34800(BEF )03/94]

❑

Replace crankcase emission air filter. If operating

in dusty conditions consult your dealer and/or

follow severe duty maintenance schedule. (4.9L,

5.0L man. trans., and 7.5L only.)

*

[BK34850(BEF )01/95]

❑

Change automatic transmission fluid.

*

[BK34851(BEF )03/94]

NOTE: Except C6 and E4OD transmissions.

*

[BK35400(B F )04/93]

❑

Lubricate transfer case shift lever pivot bolt

and control rod connecting pins (4x4).

*

[BK35800(BEF )04/94]

❑

Inspect disc brake system, lubricate caliper

slide rails.

*

[BK35900(BEF )04/94]

❑

Inspect drum brake systems, hoses and lines.

*

[BK36000(BEF )05/94]

❑

Inspect and lubricate front wheel bearings.

*

[BK36500(BEF )04/93]

❑

Inspect parking brake system for damage and

operation.

*

[BK36700(BEF )05/93]

❑

Lubricate throttle kickdown or TV lever ball

studs.

*

[BK36800(B F )04/93]

❑

Lubricate front axle R.H. axle shaft slip yoke

(4x4).

*

[BK36900(B F )04/93]

❑

Inspect and lubricate spindle needle bearings

(4x4).

*

[BK37000(B F )04/93]

❑

Inspect and lubricate hub locks (4x4).

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

12 Normal Schedule

*

[BK37250(BEF )04/94]

❑

Change fuel filter (Recommended but not

required for California Certified Vehicles).

*

[BK37275(BEF )04/93]

four pica chart:0060627-A

*

[BK37300(BEF )01/95]

35,000 MILES (56,000 Kilometers)

*

[BK37400(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK37550(BEF )05/94]

❑

Rotate tires and adjust air pressure. (1)(2)

*

[BK37700(B F )08/94]

❑

Check clutch reservoir fluid level.

*

[BK37800(BEF )04/93]

❑

Inspect and lubricate automatic transmission

shift linkage.

*

[BK37950(BEF )04/94]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK38000(BEF )05/93]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

*

[BK38025(BEF )05/94]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK38050(BEF )04/93]

four pica chart:0060627-A

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

Normal Schedule 13

*

[BK38100(BEF )01/95]

40,000 MILES (64,000 Kilometers)

*

[BK38200(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK38300(BEF )04/93]

four pica chart:0060627-A

*

[BK38900(BEF )01/95]

45,000 MILES (72,000 Kilometers)

*

[BK39000(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK39100(BEF )01/95]

❑

Inspect engine cooling system, hoses, and clamps;

and check coolant strength every 15,000 miles

(24,000 km) or 12 months.

*

[BK39200(BEF )05/94]

❑

Rotate tires and adjust air pressure. (1)(2)

*

[BK39500(B F )08/94]

❑

Check clutch reservoir fluid level.

*

[BK39600(B F )04/93]

❑

Lubricate transfer case shift lever pivot bolt

and control rod connecting pins (4x4).

*

[BK39700(BEF )04/93]

❑

Inspect and lubricate automatic transmission

shift linkage.

*

[BK39825(BEF )04/94]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK39850(BEF )04/94]

❑

Change fuel filter (Recommended but not

required for California Certified Vehicles).

*

[BK40000(BEF )04/94]

❑

Inspect disc brake system, lubricate caliper

slide rails.

*

[BK40100(BEF )04/94]

❑

Inspect drum brake systems, hoses and lines.

*

[BK40200(BEF )05/93]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

14 Normal Schedule

*

[BK40250(BEF )05/94]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK40450(BEF )04/93]

four pica chart:0060627-A

*

[BK40500(BEF )01/95]

50,000 MILES (80,000 Kilometers)

*

[BK40600(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK40700(BEF )06/94]

❑

Change engine coolant initially at 50,000 miles

(80,000 km) or 48 months. Thereafter, change

engine coolant every 30,000 miles (48,000 km) or

36 months (Gasoline engines only).

*

[BK40900(BEF )04/93]

four pica chart:0060627-A

*

[BK41300(BEF )01/95]

55,000 MILES (88,000 Kilometers)

*

[BK41400(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK41500(BEF )05/94]

❑

Rotate tires and adjust air pressure. (1)(2)

*

[BK41800(BEF )04/93]

❑

Inspect and lubricate automatic transmission

shift linkage.

*

[BK41950(BEF )04/94]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK42000(BEF )05/93]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

Normal Schedule 15

*

[BK42025(BEF )05/94]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK42050(BEF )04/93]

four pica chart:0060627-A

*

[BK42100(BEF )01/95]

60,000 MILES (96,000 Kilometers)

*

[BK42200(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK42250(BEF )01/95]

❑

Inspect engine cooling system, hoses, and clamps;

and check coolant strength every 15,000 miles

(24,000 km) or 12 months.

*

[BK42300(BEF )04/95]

❑

Replace spark plugs (Gasoline engines only).

*

[BK42500(BEF )03/94]

❑

Replace air cleaner filter every 30,000 miles

(48,000 km) or 30 months. If operating in dusty

conditions, consult your dealer and/or follow

severe duty maintenance schedule.

*

[BK42600(BEF )03/94]

❑

Replace crankcase emission air filter. If operating

in dusty conditions consult your dealer and/or

follow severe duty maintenance schedule. (4.9L,

5.0L man. trans., and 7.5L only.)

*

[BK42700(BEF )05/94]

❑

Replace PCV valve. (3)

*

[BK42900(BEF )06/94]

❑

Check thermactor hoses and clamps.

(Recommended, not required.)

*

[BK43100(BEF )05/93]

❑

Inspect accessory drive belt condition.

*

[BK43600(B F )04/93]

❑

Lubricate transfer case shift lever pivot bolt

and control rod connecting pins (4x4).

*

[BK43625(BEF )01/95]

❑

Change automatic transmission fluid.

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

16 Normal Schedule

*

[BK43626(BEF )03/94]

NOTE: Except C6 and E4OD transmissions.

*

[BK43850(BEF )04/94]

❑

Change fuel filter (Recommended but not

required for California Certified Vehicles).

*

[BK44000(BEF )04/94]

❑

Inspect disc brake system, lubricate caliper

slide rails.

*

[BK44100(BEF )04/94]

❑

Inspect drum brake systems, hoses and lines.

*

[BK44200(BEF )05/94]

❑

Inspect and lubricate front wheel bearings.

*

[BK44700(BEF )04/93]

❑

Inspect parking brake system for damage and

operation.

*

[BK44900(BEF )05/93]

❑

Lubricate throttle kickdown or TV lever ball

studs.

*

[BK45000(B F )04/93]

❑

Inspect and lubricate spindle needle bearings

(4x4).

*

[BK45100(B F )04/93]

❑

Inspect and lubricate hub locks (4x4).

*

[BK45200(B F )04/93]

❑

Change transfer case oil (4x4).

*

[BK45250(B F )04/93]

❑

Lubricate front axle R.H. axle shaft slip yoke

(4x4).

*

[BK45300(B F )04/93]

❑

Change manual transmission oil.

*

[BK45450(BEF )04/93]

four pica chart:0060627-A

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

Normal Schedule 17

*

[BK45500(BEF )01/95]

65,000 MILES (104,000 Kilometers)

*

[BK45600(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK45625(BEF )05/94]

❑

Rotate tires and adjust air pressure. (1)(2)

*

[BK45635(BEF )04/94]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK45655(BEF )05/93]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

*

[BK45660(BEF )05/94]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK45665(BEF )04/93]

❑

Inspect and lubricate automatic transmission

shift linkage.

*

[BK45675(B F )08/94]

❑

Check clutch reservoir fluid level.

*

[BK45690(BEF )07/93]

four pica chart:0060627-A

*

[BK45700(BEF )01/95]

70,000 MILES (112,000 Kilometers)

*

[BK45800(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK45850(BEF )04/93]

four pica chart:0060627-A

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

18 Normal Schedule

*

[BK45900(BEF )01/95]

75,000 MILES (120,000 Kilometers)

*

[BK46000(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK46005(BEF )01/95]

❑

Inspect engine cooling system, hoses, and clamps;

and check coolant strength every 15,000 miles

(24,000 km) or 12 months.

*

[BK46007(BEF )05/94]

❑

Rotate tires and adjust air pressure. (1)(2)

*

[BK46010(BEF )04/94]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK46030(BEF )05/93]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

*

[BK46035(BEF )05/94]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK46040(BEF )04/94]

❑

Inspect disc brake system, lubricate caliper

slide rails.

*

[BK46055(BEF )04/94]

❑

Inspect drum brake systems, hoses and lines.

*

[BK46065(BEF )04/94]

❑

Change fuel filter (Recommended but not

required for California Certified Vehicles).

*

[BK46075(BEF )04/93]

❑

Inspect and lubricate automatic transmission

shift linkage.

*

[BK46080(B F )08/94]

❑

Check clutch reservoir fluid level.

*

[BK46085(B F )04/93]

❑

Lubricate transfer case shift lever pivot bolt

and control rod connecting pins (4x4).

*

[BK46097(BEF )04/93]

four pica chart:0060627-A

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

Normal Schedule 19

*

[BK46100(BEF )01/95]

80,000 MILES (128,000 Kilometers)

*

[BK46200(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK46225(BEF )06/94]

❑

Change coolant every 30,000 miles (48,000 km) or

36 months.

*

[BK46280(BEF )04/93]

four pica chart:0060627-A

*

[BK46300(BEF )01/95]

85,000 MILES (136,000 Kilometers)

*

[BK46400(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK46405(BEF )05/94]

❑

Rotate tires and adjust air pressure. (1)(2)

*

[BK46410(BEF )04/94]

❑

Lubricate steering linkage suspension,

driveshaft U-joint if equipped with grease

fittings and lubricate slip yoke (if equipped).

*

[BK46430(BEF )05/93]

❑

Inspect exhaust system for leaks, damage or

loose parts. Remove any foreign material

trapped by exhaust system shielding.

*

[BK46435(BEF )05/94]

NOTE: It is normal for a certain amount of

moisture and staining to be present

around the muffler seams. The

presence of soot, light surface rust or

moisture does not indicate a faulty

muffler.

*

[BK46440(BEF )04/93]

❑

Inspect and lubricate automatic transmission

shift linkage.

*

[BK46451(B F )08/94]

❑

Check clutch reservoir fluid level.

*

[BK46475(BEF )04/93]

four pica chart:0060627-A

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

20 Normal Schedule

*

[BK46500(BEF )01/95]

90,000 MILES (144,000 Kilometers)

*

[BK46600(BEF )01/95]

❑

Change engine oil and replace oil filter.

*

[BK46850(BEF )01/95]

❑

Inspect engine cooling system, hoses, and clamps;

and check coolant strength every 15,000 miles

(24,000 km) or 12 months.

*

[BK46900(BEF )03/94]

❑

Replace air cleaner filter every 30,000 miles

(48,000 km) or 30 months. If operating in dusty

conditions, consult your dealer and/or follow

severe duty maintenance schedule.

*

[BK47000(BEF )03/94]

❑

Replace crankcase emission air filter. If operating

in dusty conditions consult your dealer and/or

follow severe duty maintenance schedule. (4.9L,

5.0L man. trans., and 7.5L only.)

*

[BK47015(BEF )05/93]

❑

Inspect accessory drive belt condition.

*

[BK47025(BEF )04/94]

❑

Change fuel filter (Recommended but not

required for California Certified Vehicles).

*

[BK47030(BEF )04/93]

❑

Inspect parking brake system for damage and

operation.

*

[BK47035(BEF )04/94]

❑

Inspect disc brake system, lubricate caliper

slide rails.

*

[BK47040(BEF )04/94]

❑

Inspect drum brake systems, hoses and lines.

*

[BK47045(BEF )05/94]

❑

Inspect and lubricate front wheel bearings.

*

[BK47051(BEF )05/93]

❑

Lubricate throttle kickdown or TV lever ball

studs.

*

[BK47055(B F )04/93]

❑

Inspect and lubricate hub locks (4x4).

*

[BK47060(B F )04/93]

❑

Inspect and lubricate spindle needle bearings

(4x4).

*

[BK47065(B F )04/93]

❑

Lubricate transfer case shift lever pivot bolt

and control rod connecting pins (4x4).

*

[BK47067(BEF )01/95]

❑

Change automatic transmission fluid.

File:ltbkb.ex

Update:Fri Jun 16 11:12:59 1995

Page is loading ...

Ford 1996 Escort Maintenance Guide

This manual is also suitable for

Ford 1996 Escort Maintenance Guide

Related papers

Other documents