Leviton SD1J5-54M Installation guide

WARNINGS AND CAUTIONS:

s "ALLASTINSTALLATIONANDREPLACEMENTSHOULDONLYBEPERFORMEDBYQUALIlEDPERSONNEL

s 0OWERTOBALLASTANDlXTUREMUSTBEDISCONNECTEDATALLTIMES

s "ALLASTANDlXTUREMUSTBEGROUNDED

s

&AILURETOMOUNTANDWIREBALLASTANDlXTUREINCONFORMANCEWITHTHE.ATIONAL%LECTRIC#ODEAPPLICABLE3TATEOR-UNICIPALCODESAND

SPECIlC5,3AFETYSTANDARDSFORTHEINTENDEDWORKINGENVIRONMENTMAYCAUSESERIOUSPERSONALINJURYDEATHANDORPROPERTYDAMAGE

NOTES:

s -AXIMUMDISTANCEBETWEENBALLASTANDTHELAMPSOCKETSISSEVENFEET

s -AXIMUMDEVICESPERBUSCONTROLLER

s 3ECTOR@3ECTOR.ETBALLASTSCANONLYBEUSEDWITHCOMPATIBLE,EVITON3ECTOR.ETEQUIPMENT

s 6BALLASTSCANBEUSEDWITHANYCONTROLLERDESIGNEDTOSINKTHECONTROLSIGNALFROMTHE6BALLASTS

s &OLLOWLAMPMANUFACTURERRECOMMENDATIONSFORINITIALLAMPBURNINPERIOD

s )NSTALLNEWLAMPSWITHNEWBALLASTINSTALLATION

s 3OCKETSMUSTBEINSTALLEDPERPENDICULARTOLAMPENDS

s 7IRELENGTHBETWEENSOCKETANDBALLASTSHALLBEKEPTASSHORTASPOSSIBLE

s DO NOTCOILWIREINSIDEOFlXTURECAVITY

s 5SEhTESTMODEvTOCONlRMNETWORKWIRING

s )SOLATEWIRINGPROBLEMSBYSEGMENTINGNETWORKUNTILTHEPROBLEMISFOUND

s -AXIMUMLONGESTRUNFROM0OWER3UPPLYTOLASTDEVICEIS2UNLENGTHSGREATERTHANALLOWEDONLYWHENPOWER

SUPPLYISINTHEMIDDLEOFTHERUNANDALLSEGMENTSARELESSTHAN

SYSTEM TESTING:

"ALLASTCANBETESTEDBYPOWERINGUPTHELIGHTlXTUREWITHOUTTHECONTROLWIRINGCONNECTED 4HISWILLRESULTINTHELAMPSGOINGTOFULL

INTENSITY)FlXTURESDONOTGOTOFULLBRIGHTNESSCHECKWIRING3ECTOR.ETCOMMUNICATIONSBETWEENTHEBALLASTANDTHEBUSCONTROLLER

POWERSUPPLYCANBETESTEDBYINITIATINGTHEhTESTvMODEONTHE3ECTORBUSCONTROLLER2EFERENCEBUSCONTROLLERDOCUMENTATIONFOR

ADDITIONALINFORMATIONONTHISFEATURE

INSTALLATION STEPS:

1. %NSUREpower is OFFONALLCIRCUITSYOUWILLBEWORKINGWITH

2. 2EMOVELAMPSlXTURECOVERETCASNECESSARYTOEXPOSEBALLASTCOMPARTMENT

3. 2EMOVEEXISTINGBALLAST

4. )NSTALLNEWRAPIDSTARTSOCKETSANDWIRINGIFNECESSARY)FUSING EXISTINGSOCKETSINSPECTSOCKETSANDWIRINGTOENSURETHEYAREOF

THECORRECTTYPEANDTHEYARENOTDAMAGED)FDAMAGEDREPLACESOCKETSANDORWIRING

5. %XAMINETHEBALLASTANDCONlRMTHATTHELAMPSYOUINTENDTOUSEINTHElXTUREARELISTEDASSUPPORTEDLAMPSBYTHEBALLAST

4HISINFORMATIONCANBEFOUNDONTHEBALLASTLABEL

6. )NSTALL3ECTORBALLASTINlXTURE%NSUREMAXIMUMCONTACTBETWEENlXTUREHOUSINGANDBALLASTBASEFORHEATDISSIPATION

7. &OLLOWINGWIRINGDIAGRAMONBALLASTCONNECTBALLASTTOLAMPS

8. #ONNECTCONTROLNETWORKTOBALLAST3ECTOR.ETNETWORKWIRINGISTOPOLOGYANDPOLARITYINDEPENDENT2EFERENCE,EVITONS3ECTOR

h.ETWORK$EVICE)NSTALLATIONvGUIDEANDh3ECTOR3YSTEM$ESIGNAND#OMMISSIONING'UIDEv FORADDITIONALINFORMATION

9. #ONNECTINPUTPOWERTOBALLAST%NSURETHATHOTNEUTRALANDGROUNDWIRESARECONNECTED

10. 2EINSTALLBALLASTCOMPARTMENTCOVER

11. 2EPEATPROCESSASREQUIRED

SOCKETS:

s USE ‘RAPID START’ SOCKETS ONLY@)NSTANT3TARTORSHUNTEDSOCKETSARENOTSUPPORTEDFOR

USEWITH,EVITONDIMMINGBALLASTS

s 2APIDSTARTSOCKETSHAVETWOWIRESCOMINGOUTOFEACHSOCKETONEGOINGTOEACHPINOFTHELAMP

CORRECT WRONGWRONG WRONG WRONG

T8 BALLASTS

-AXDISTANCE

LAMPTOGROUND

PLANE

vv

MM

-AXDISTANCE

SOCKETTOBALLAST



M

T5 BALLASTS

-AXDISTANCE

LAMPTOGROUND

PLANE

vv

MM

-AXDISTANCE

SOCKETTOBALLAST



M

TROUBLESHOOTING:

1. )FCONTROLWIRINGIS3ECTOR.ETTEMPORARILYDISCONNECT3ECTORWIRINGANDCYCLEPOWERTOFORCEBALLASTTOFULL)FWIRINGIS6THE

BALLASTWILLGOTOFULLWHENTHEREISNOCONNECTIONANDWILLGOTOMINIMUMWHENTHEWIRESARE SHORTEDTOGETHER

2. )NSPECTSOCKETORIENTATIONTOLAMPMUSTBEPERPENDICULAR

3. #ONlRMWIRESAREFULLYINSERTEDINTOSOCKETSANDBALLAST

4. 2EPLACELAMPS

Ballast Installation Instructions

534ECHNICAL3UPPORT

INSTALLATION

ENGLISH

0+#

SECTORNET BALLAST ADDRESS:

0ARTOFTHECOMMISSIONINGPROCESSFOR3ECTOR.ETSYSTEMSREQUIRESTHEKNOWLEDGEOFTHEBALLASTRELAYgHARDgADDRESS4HEHARDADDRESS

OFEACHRELAYISPROVIDEDONAPARTLABELAFlXEDTOTHEBALLASTHOUSING4HESELABELSHAVEAPARTICULARPURPOSEANDINTENDEDPROCESS

FORUSAGE/NEOFTHELABELPARTSISTOREMAINONTHEBALLASTRELAY4HESECONDLABELPARTISTOREMAINONTHElXTUREEITHERONTHEWIRING

COMPARTMENTOREXTERNALLYVISIBLE4HETHIRDPARTOFTHELABELISTOBEAFlXEDTOTHELIGHTINGELECTRICALPLANSFORUSEBY,EVITON&IELD

3ERVICE0ERSONNELDURINGTHECOMMISSIONPHASETHENTURNEDOVERTOTHEOWNERASPARTOFTHEASBUILTDOCUMENTPACKAGE

4HEPROCESSFORLABELUSAGEISASFOLLOWS



7HENTHEBALLASTISINSTALLEDINTHElXTUREORTHERELAYIS

AFlXEDTOTHElXTUREOFTHELABELSSHOULDBEREMOVED

FROMTHERELAYATTHEPERFORATIONLINETHENTHELABEL

BACKINGREMOVEDFROMONLYOFTHELABELSANDTHELABEL

AFlXEDTOTHElXTUREINACONSPICUOUSLOCATION#OMMONLY

LABELSAREAFlXEDTOWIRINGCOMPARTMENTORVISIBLEEDGEOF

lXTUREINTHEROOM

Leave first label

on ballast or relay

Place remaining

two labels on fixture

Fig. 1

2. 7HENTHElXTUREISINSTALLEDATTHELOCATIONTHELASTLABEL

SHOULDBETORNOFFATTHEPERFORATIONLINETHELABELBACKING

REMOVEDANDTHELABELAFlXEDTOTHELIGHTINGELECTRICAL

PLANSFORUSEBY,EVITON&IELD3ERVICE0ERSONNELDURINGTHE

COMMISSIONPHASETHENTURNEDOVERTOTHEOWNERASPART

OFTHEASBUILTDOCUMENTPACKAGE)NTHEEVENTTHATBUILDING

PLANSARENOTAVAILABLEDOCUMENTADDRESSINTHECHARTS

PROVIDEDON,EVITONDRAWINGSORMAKEYOUROWN)TISCRITICAL

TOKNOWTHEADDRESSOFEACHBALLASTINEVERYROOM

Third label is affixed

to electrical plans

Fig. 2

Leave second

label on fixture

WEB VERSION

SECTORNET SYSTEM COMPONENTS

SectorNet Network

SectorNet Network SectorNet Wiring Min 18 AWG

Sector Ballast

Occupancy

Sensor

5 Button

Switch

Sector Relay

Max. Longest Run - 1000'

AREA 1

Sector Relay

Dimmer

Sector Relay

Non-Dim

Device Signage

0-10V

Control

& Power

Load 0-10V

Dimming

Ballasts

2 Button

Switch

2 Button

Switch

Remote

5 Button

Switch

Occupancy

Sensor

Occupancy

Sensor

Occupancy

Sensor

Photocell Photocell

Photocell

Occupancy

Sensor

2 Button

Switch

5 Button

Switch

Occupancy

Sensor

Power Supply

Bus Controller

Terminate each end of the

LumaCAN network by

pushing blue button

Wiring may follow

any topology;

daisy chain, star,

home run etc.

or "T" at any

point in the

network. SectorNet

Network is also

polarity free!

Up to 8 areas

per Bus

Controller

64 SectorNet

devices per

Bus Controller

Max distance

between Bus

Controller &

last device on

line is 1000'

(304 meters)

Max 32 input

devices (Switch,

Photocell or

Occupancy

Sensor

Up to 250 devices

are supported on

each LumaCAN

subnet. A Bus

Controller counts

as (1) device

Max 256mA

per Power

Supply

LumaCAN NetworkLumaCAN Network

Power Supply

Bus Controller

To other Bus

Controllers

Sector Ballast

Line

Voltage

Line

Voltage

Line

Voltage

Line

Voltage

Line

Voltage

Sector Ballast

Line

Voltage

Sector Ballast

Line

Voltage

Sector Ballast

Line

Voltage

Line

Voltage

Line

Voltage

AREA 2

AREA 3 AREA 4

AREA 5 AREA 6

AREA 1

AREAS 2 - 7

AREA 8

0+#

Leviton Manufacturing - Lighting Management Systems

374ETON4UALATIN/2

4ECHNICAL3UPPORT#USTOMER3ERVICE

LIMITED 5 YEAR WARRANTY AND EXCLUSIONS

,EVITON WARRANTS TO THE ORIGINAL CONSUMER PURCHASER AND NOT FOR THE BENElT OF ANYONE ELSE THAT THIS PRODUCT AT THE TIME OF ITS SALE BY ,EVITON IS FREE OF DEFECTS IN MATERIALS AND WORKMANSHIP UNDER NORMAL AND PROPER USE FOR lVE YEARS FROM THE PURCHASE DATE ,EVITONS ONLY OBLIGATION IS TO CORRECT SUCH DEFECTS BY REPAIR OR REPLACEMENT AT ITS OPTION IF WITHIN SUCH lVE YEAR PERIOD

THE PRODUCT IS RETURNED PREPAID WITH PROOF OF PURCHASE DATE AND A DESCRIPTION OF THE PROBLEM TO Leviton Mfg. Co., Inc. 201 North Service Road, Melville, N.Y. 11747 4HIS WARRANTY EXCLUDES AND THERE IS DISCLAIMED LIABILITY FOR LABOR FOR REMOVAL OF THIS PRODUCT OR REINSTALLATION 4HIS WARRANTY IS VOID IF THIS PRODUCT IS INSTALLED IMPROPERLY OR IN AN IMPROPER ENVIRONMENT OVERLOADED

MISUSED OPENED ABUSED OR ALTEREDIN ANY MANNER OR IS NOT USED UNDER NORMAL OPERATING CONDITIONS OR NOT IN ACCORDANCE WITH ANY LABELS OR INSTRUCTIONS There are no other or implied warranties of any kind, including merchantability and ﬁtness for a particular purpose BUT IF ANY IMPLIED WARRANTY IS REQUIRED BY THE APPLICABLE JURISDICTION THE DURATION OF ANY SUCH IMPLIED WARRANTY INCLUDING MERCHANTABILITY AND

lTNESS FORAPARTICULARPURPOSE IS LIMITED TO lVE YEARSLeviton is not liable for incidental, indirect, special, or consequential damages, including without limitation, damage to, or loss of use of, any equipment, lost sales or proﬁts or delay or failure to perform this warranty obligation4HE REMEDIES PROVIDED HEREIN ARE THE EXCLUSIVEREMEDIES UNDERTHIS WARRANTY WHETHER BASEDON CONTRACT TORT OR OTHERWISE

Ú,EVITON-FG#O)NC

WEB VERSION