1
INSTALLATION INSTRUCTIONS
T210025 V2.00 JUNE 2018 - ZIP FL064, FL104
TECHNICAL SUPPORT TEL: 0345 6 005 005 EMAIL: SERVICE@ZIPINDUSTRIES .CO.UK
WWW.ZIPWATER.CO.UK
ZIP
INLINE FILTERS
INSTALLATION INSTRUCTIONS
For commercial use
MODEL:
FL104, FL064
2
INSTALLATION INSTRUCTIONS
T210025 V2.00 JUNE 2018 - ZIP FL064, FL104
TECHNICAL SUPPORT TEL: 0345 6 005 005 EMAIL: SERVICE@ZIPINDUSTRIES .CO.UK
WWW.ZIPWATER.CO.UK
INSTALLATION INSTRUCTIONS
Safety information
WARNINGS
• This product must be installed in accordance with local regulations and these installation instructions.
• Installation, commissioning and maintenance must only be carried out by a competent installer who will then be
responsible for adhering to all relevant standards and regulations.
• An approved check valve or other (no less effective) back ow device must be tted between the supply and lter.
• The filter must not be modified in any way.
• In case of leaks isolate the water supply. Repairs must only be carried out by Zip or an authorised Zip service engineer.
• Incoming water temperature must not exceed 23°C.
• Only to be used with a Wholesome (cat 1) water supply.
• If the lter interferes with any earth bonding then a bonding strap should be tted according to current IEE regulations.
!
!
!
CAUTIONS
• Optimum operation is ensured at a water flow pressure of 0.5-8.6 bar. Do not subject the filter to water hammer or
excessive pressure.
• The filter must only be used when correctly installed and in perfect working order.
• Flush the water supply pipes thoroughly prior to installation.
• Zip cannot be held liable for any damages caused by failure to observe these instructions.
• Filter performance is dependent upon age and site water conditions.
Technical specications
• The filters are designed to reduce tastes and odours (including chlorine / chlorine by-products), THM’s, PAH’s,
pesticides such as Simazine, Atrazine, Lindane, Dieldrin and inhibit the precipitation of scale deposits.
• WRAS approved.
• Flow rate 2 - 3l / min.
• Temp. range 1 – 23
o
C.
• Water flow pressure of 0.5-8.6 bar.
• Capacity FL064 3000l nominal, FL104 6000l nominal.
• 15mm compression ttings.
Description
• A range of in-line lters, containing granular activated carbon and scale inhibitor.
Construction
• Filter casing polypropylene.
• Internal grilles polypropylene.
• Reticulated foam polyurethane.
• Particulate filters polyester.
• Media infill granular activated carbon / polyphosphate.
3
INSTALLATION INSTRUCTIONS
T210025 V2.00 JUNE 2018 - ZIP FL064, FL104
TECHNICAL SUPPORT TEL: 0345 6 005 005 EMAIL: SERVICE@ZIPINDUSTRIES .CO.UK
WWW.ZIPWATER.CO.UK
INSTALLATION INSTRUCTIONS
FL064
FL104
275mm
165mm
Existing Pipework
Existing Pipework
Remove 275mm of existing pipework to feed in lter
Remove 165mm of existing pipework to feed in lter
ø54
ø54
FL064
FL104
275mm
165mm
Existing Pipework
Existing Pipework
Remove 275mm of existing pipework to feed in lter
Remove 165mm of existing pipework to feed in lter
ø54
ø54
Preparation (if tting to existing pipework)
Installation
• Fit the lter in the incoming mains cold water supply line to the appliance.
• Turn off the incoming cold mains water supply.
• Note the ow direction on the lter (marked with an arrow).
• Connect supply line to the inlet side of the lter.
• Tighten rmly, using two spanners (do not over tighten).
• Turn on the water supply.
• Flush 18 litres of water through the lter (use a length of hose on the outlet of lter and drain to waste).
• Turn off water supply.
• Connect lter outlet.
• Tighten rmly using two spanners.
• Turn on water supply.
• Check for leaks and tighten ttings if leaks occur.
Dimensions
FL064 215mm x Ø50mm (max).
FL104 315mm x Ø50mm (max).
4
INSTALLATION INSTRUCTIONS
T210025 V2.00 JUNE 2018 - ZIP FL064, FL104
TECHNICAL SUPPORT TEL: 0345 6 005 005 EMAIL: SERVICE@ZIPINDUSTRIES .CO.UK
WWW.ZIPWATER.CO.UK
Zip Water UK
14 Bertie Ward Way, Dereham, Norfolk NR19 1TE
0345 6 005 005 [email protected]
www.zipwater.co.uk
-
1
-
2
-
3
-
4
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Zip HydroChill HC03 User manual
-
-
-
Zip InLine Instantaneous Hot Water heater 3kW User manual
-
-
-
-
-
Zip VARIPOINT II Series User manual
-
Other documents
-
B-Tech BT7823 Installation guide
-
REGATRON TC.ACS Device Manual
-
PRO-LAB PE111 Installation guide
-
PRO-LAB PE111 User manual
-
Ritron RLR-465NX User manual
-
LG GU285 User manual
-
LG U250 User manual
-
Motorola TIMEPORT 280 User manual
-
-
Delta Children MySize Bookshelf Assembly Instructions
