WAGNER 0529002 User guide

English

8 ¥8BHOFS4QSBZ5FDI"MM3JHIUT3FTFSWFE

Proper Spraying Technique

STOP

The room you are spraying must be

properly masked in order to prevent

overspray from covering woodwork,

oors or furnishings. Make sure you

have properly masked the room per the

instructions on the enclosed “Taping

Guide”.

*GTQSBZJOHXJUIBOBJSBTTJTUFETQSBZTZTUFNJTOFX

PSVOGBNJMJBSUPZPVJUJTBEWJTBCMFUPQSBDUJDFPOB

QJFDFPGTDSBQXPPEPSDBSECPBSECFGPSFCFHJOOJOH

POZPVSJOUFOEFEXPSLQJFDFBOEPSUFTUXJUIXBUFS

Surface Preparation

"MMPCKFDUTUPCFTQSBZFETIPVMECFUIPSPVHIMZ

DMFBOFECFGPSFTQSBZJOHNBUFSJBMPOUIFN"SFBT

OPUUPCFTQSBZFENBZJODFSUBJODBTFTOFFEUPCF

NBTLFEPSDPWFSFE

Spray Area Preparation

5IFTQSBZBSFBNVTUCFDMFBOBOEGSFFPGEVTUJO

PSEFSUPBWPJECMPXJOHEVTUPOUPZPVSGSFTIMZ

TQSBZFETVSGBDF

How to Spray Properly

STOP

It is important to keep your arm moving

whenever the gun is being triggered. If

you pause or linger in one spot too long,

too much material will be sprayed to the

surface.

STOP

Partially pulling the trigger will start

the turbine, but no material will spray

until the trigger is pulled fully. It is

recommended that the trigger rst be

pulled partially in order to start the

turbine before a spray pass is made.

 r 1PTJUJPOUIFTQSBZHVOQFSQFOEJDVMBSUPBOE

TJYPSNPSFJODIFTGSPNUIFTQSBZTVSGBDF

EFQFOEJOHVQPOUIFTQSBZQBUUFSOTJ[FEFTJSFE

8JUISFEVDFENBUFSJBMóPXBOEBJSQPXFSZPV

DBOHFUDMPTFSUPUIFTQSBZJOHTVSGBDF

 r 4QSBZQBSBMMFMUPUIFTVSGBDFXJUITNPPUIQBTTFT

BUBDPOTJTUFOUTQFFEBTJMMVTUSBUFECFMPX

%PJOHUIJTXJMMIFMQBWPJEJSSFHVMBSJUJFTJOUIF

ñOJTIJFSVOTBOETBHT

6 to 12 inches

Correct

Even coat throughout

Keep stroke smooth and at an even speed

 r "MXBZTBQQMZBUIJODPBUPGNBUFSJBMPOUIFñSTU

QBTTBOEBMMPXUPESZCFGPSFBQQMZJOHBTFDPOE

TMJHIUMZIFBWJFSDPBU

 r 8IFOTQSBZJOHMBSHFSTVSGBDFTPWFSMBQFBDI

TQSBZQBTTCZBUMFBTU5IJTXJMMFOTVSFGVMM

DPWFSBHF

 r 8IFOTQSBZJOHBMXBZTUSJHHFSUIFTQSBZHVO

BGUFSTQSBZQBTTIBTCFHVOBOESFMFBTFUSJHHFS

CFGPSFTUPQQJOHUIFQBTT"MXBZTLFFQUIF

HVOQPJOUFETRVBSFMZBUUIFTQSBZTVSGBDFBOE

PWFSMBQQBTTFTTMJHIUMZUPPCUBJOUIFNPTU

DPOTJTUFOUBOEQSPGFTTJPOBMñOJTIQPTTJCMF

Incorrect

Do not ex wrist while spraying.

Light coat Heavy coat Light coat

Note: 8IFOZPVRVJUTQSBZJOHGPSBOZMFOHUIPG

UJNFVOQMVHUIFTQSBZHVO

8IFOZPVSFTUBSUXJQFUIFOP[[MFXJUIBEBNQ

DMPUIUPSFNPWFBOZESJFEQBJOU

¡Å¦

English

¥8BHOFS4QSBZ5FDI"MM3JHIUT3FTFSWFE 9

Proper Spraying Technique

Pattern Examples

6TFUIFJNBHFTBOEHVJEFMJOFTCFMPXJOPSEFSUP

BTTJTUZPVJOBDIJFWJOHUIFEFTJSFETQSBZQBUUFSOGPS

ZPVSQSPKFDU5IFTFBSFNFBOUUPCFHFOFSBMTUBSUJOH

QPJOUTZPVNBZIBWFUPTMJHIUMZNPEJGZDFSUBJO

DPOUSPMTPOUIFTZTUFNJOPSEFSUPHFUUIFFYBDU

QFSGPSNBODFZPVOFFE

Large Surface Projects

(FOFSBMMZIJHINBUFSJBMóPXJTOFFEFEGPSTQSBZJOH

MBSHFTVSGBDFBSFBTTVDIBTXBMMTBOEEFDLT

 r 5IFBJSDBQQPTJUJPOXJMMEFUFSNJOFUIF

NPWFNFOUEJSFDUJPOPGUIFTQSBZHVO

Small Surface Projects

(FOFSBMMZMPXNBUFSJBMóPXJTOFFEFEGPSTQSBZJOH

TNBMMFSTVSGBDFBSFBTTVDIBTDPSOFSTMBUUJDFPS

TQJOEMFT

 r *GZPVGFFMUIFNBUFSJBMJTHPJOHPOUPPUIJO

JODSFBTFUIFNBUFSJBMóPX

 r *GZPVGFFMUIFNBUFSJBMJTHPJOHPOUPPUIJDL

EFDSFBTFUIFNBUFSJBMóPXFWFOGVSUIFSPSNPWF

UIFTQSBZHVOGVSUIFSBXBZGSPNUIFTVSGBDF

Note: *GBGUFSGPMMPXJOHUIFHVJEFMJOFTPO

UIFTFUXPQBHFTZPVBSFTUJMMOPUHFUUJOHUIF

TQSBZQFSGPSNBODFZPVOFFESFGFSUPUIF

A5SPVCMFTIPPUJOHTFDUJPOPOQBHF

#FTJEFTBEKVTUJOHUIFDPOUSPMTPUIFSGBDUPSTUIBU

TIPVMECFDPOTJEFSFEXIFOTQSBZJOH

 r Distance from the spray object -JGZPVBSFUPP

GBSGSPNUIFTQSBZJOHTVSGBDFUIFNBUFSJBMXJMM

HPPOUPPUIJOBOEWJDFWFSTB

 r Material thickness -JGUIFTQSBZQBUUFSOSVOT

BOEPSJTUPPTQMPUDIZUIFNBUFSJBMNBZOFFEUP

CFUIJOOFE

Note: 0OMZUIJOUIFNBUFSJBMJGBCTPMVUFMZ

OFDFTTBSZUPJNQSPWFTQSBZQFSGPSNBODF0QUJNBM

TQSBZQFSGPSNBODFTIPVMECFBDIFJWFETJNQMZCZ

BEKVTUJOHUIFWBSJPVTDPOUSPMTPOUIFVOJU

 r Spray gun movement -NPWJOHUIFHVOUPP

RVJDLMZXJMMDBVTFUIFTQSBZQBUUFSOUPCFUPP

UIJOBOEFYDFTTPWFSTQSBZ.PWJOHUIFHVOUPP

TMPXMZXJMMDBVTFUIFTQSBZQBUUFSOUPCFUPP

DPBSTFPSUIJDL

¡Å¦

English

10 ¥8BHOFS4QSBZ5FDI"MM3JHIUT3FTFSWFE

Cleanup

Flushing the unit

Before you begin:

8IFODMFBOJOHVTFUIFBQQSPQSJBUFDMFBOJOHTPMVUJPOXBSN

TPBQZXBUFSGPSMBUFYNBUFSJBMTNJOFSBMTQJSJUTGPSPJMCBTFE

NBUFSJBMT

IMPORTANT: Never clean air cap or air holes in the

nozzle with sharp metal objects. Do not use solvents or

lubricants containing silicone.

Special cleanup instructions for use with

flammable solvents (must have a flashpoint

above 100ºF (38ºC):

 r "MXBZTóVTITQSBZHVOPVUTJEF

 r "SFBNVTUCFGSFFPGóBNNBCMFWBQPST

 r $MFBOJOHBSFBNVTUCFXFMMWFOUJMBUFE

 r %POPUTVCNFSHFUVSCJOF

To Flush the Unit:

  6OQMVHUIFQPXFSDPSE-PPTFOUIFNBUFSJBMDPOUBJOFS

CZUVSOCVUEPOPUSFNPWFJU5IJTXJMMSFMJFWFBOZ

QSFTTVSFMFGUPWFSJOUIFTZTUFN

  1VMMUIFUSJHHFSTPUIBUUIFNBUFSJBMJOTJEFUIFTQSBZ

OP[[MFESBJOTCBDLJOUPUIFDPOUBJOFS

  6OTDSFXUIFDPOUBJOFSBOESFNPWF&NQUZBOZ

SFNBJOJOHNBUFSJBMCBDLJOUPUIFNBUFSJBMDPOUBJOFS

  1PVSBTNBMMBNPVOUPGUIFBQQSPQSJBUFDMFBOJOHTPMVUJPO

JOUPUIFDVQ8BUFSGVMM.JOFSBMTQJSJUTGVMM

  "UUBDIUIFDVQUPUIFOP[[MFBOEQMVHJOUIFTQSBZFS

  4QSBZUIFDMFBOJOHTPMVUJPOJOUPBTBGFBSFB

  8IJMFTQSBZJOHHFOUMZTIBLFUIFTQSBZHVO5IJTTMJHIU

BHJUBUJPOXJMMIFMQCSFBLVQTNBMMFSQBSUJDMFTPGTQSBZ

NBUFSJBM

  6OQMVHUIFQPXFSDPSE-PPTFOUIFNBUFSJBMDPOUBJOFS

CZUVSOCVUEPOPUSFNPWFJU5IJTXJMMSFMJFWFBOZ

QSFTTVSFMFGUPWFSJOUIFTZTUFN

  1VMMUIFUSJHHFSTPUIBUUIFNBUFSJBMJOTJEFUIFTQSBZ

OP[[MFESBJOTCBDLJOUPUIFDPOUBJOFS

IMPORTANT: If you cleaned the sprayer using mineral

spirits, repeat steps 1-6 using warm, soapy water.

Move on to “Cleanup - Cleaning the Nozzle”, next page.

1/2

PULL

Empty waste

container

¡Å¦

English

¥8BHOFS4QSBZ5FDI"MM3JHIUT3FTFSWFE 11

Cleanup (continued)

Cleaning the Gun

To Clean the Nozzle:

  .BLFTVSFQPXFSDPSEJTVOQMVHHFE1VTIUIFUBCCFMPX

UIFUSJHHFSUXJTUBOETFQBSBUFUIFTQSBZHVOGSPNUIF

UVSCJOF

  8JQFUIFFYUFSJPSPGUIFDVQBOEHVOVOUJMDMFBO

  3FNPWFUIFBEKVTUNFOUSJOHBDBSFGVMMZGSPNUIF

DPOOFDUJOHOVUC-PPTFOUIFDPOOFDUJOHOVU

  3FNPWFUIFQBSUTBTTIPXO$MFBOBMMQBSUTXJUIB

DMFBOJOHCSVTIBOEUIFBQQSPQSJBUFDMFBOJOHTPMVUJPO

  $MFBOUIFBJSWFOUDPOUIFTVDUJPOUVCFXJUIBTPGU

CSJTUMFEDMFBOJOHCSVTI

  $MFBOUIFSFBSPGUIFOP[[MFEXJUIUIFBQQSPQSJBUF

DMFBOJOHTPMVUJPO6TFBUIJOMBZFSPGQFUSPMFVNKFMMZUP

MVCSJDBUFUIF0SJOHF

  5PSFBTTFNCMFTFFUIFJOTUSVDUJPOTPOUIFOFYUQBHF

(d)

(e)

(c)

(a)

(b)

4 53

* Nozzle seal

5IFOP[[MFTFBMNBZCFDPNF

TUVDLJOTJEFUIFJ4QSBZPS%FUBJM

'JOJTIOP[[MFXIFOUIFOP[[MF

JTSFNPWFE*GUIJTPDDVSTNBLF

TVSFUPQVMMJUPVU

*UJTJNQPSUBOUUIBUUIFOP[[MF

TFBMJOTJEFUIFOP[[MFCFSF

JOTUBMMFEQSPQFSMZ.BLFTVSFUIF

DVQTJEFPGUIFTFBMUIFTJEFXJUI

UIFHSPPWFJTGBDJOHPVUUPXBSET

UIFGSPOUPGUIFOP[[MF*NQSPQFS

JOTUBMMBUJPOXJMMDBVTFMFBLBHFBOE

EBNBHFUPUIFUVSCJOF

Groove

¡Å¦

English

12 ¥8BHOFS4QSBZ5FDI"MM3JHIUT3FTFSWFE

Reassembly

To Reassemble:

  *OTUBMMUIFOP[[MFTFBM(1)XJUIUIFHSPPWFBTMPUGBDJOH

UPXBSEUIFOP[[MFBXBZGSPNUIFGSPOUFOEBTTFNCMZ

  *OTFSUUIFOP[[MF(2).BLFTVSFUPBMJHOUIFHSPPWFC

BOEOPUDIDBOEBMJHOUIFOP[[MFPQFOJOHXJUIUIF

OFFEMF

  1VUUIFBJSTDSFFOEJOUIFBJSDBQF1VUCPUI

(3)

POUIF

OP[[MF

(2)

BOETFDVSFXJUIUIFDPOOFDUJOHOVU

(4)



Note: 5IJTTUFQJTFBTJFSJGUIFTQSBZHVOJTGBDJOHVQ

  4OBQUIFBEKVTUNFOUSJOH

(5)

JOUPUIFDPOOFDUJOHOVU

(4)



FOBCMJOHUIFBEKVTUNFOUMFWFSGPOUIFQFHHUPCF

QPTJUJPOFEJOUIFBJSDBQ

Note:.BLFTVSFUIBUUIFUXPSFDFTTFTPOUIFBEKVTUNFOU

SJOHBSFFOHBHFEJOUIFBJSDBQUBCT

  3FBTTFNCMFUIFTQSBZHVO

Note: .BLFTVSFUIFBJSWBMWFUVCFJTGSFFPGQBJOU*GOPU

DMFBOUIFBJSWBMWFUVCFCZGPMMPXJOHUIFJOTUSVDUJPOTPO

UIFOFYUQBHF*GDMFBONBLFTVSFJUJTBUUBDIFETFDVSFMZBU

CPUIFOETTFFJOTFU

(b)

(c)

(a)

(g)

(f)

* Nozzle seal - DO NOT LOSE

*UJTJNQPSUBOUUIBUUIFOP[[MFTFBM

JOTJEFUIFOP[[MFCFSFJOTUBMMFE

QSPQFSMZ.BLFTVSFUIFDVQTJEFPGUIF

TFBMUIFTJEFXJUIUIFHSPPWFJTGBDJOH

PVUUPXBSETUIFGSPOUPGUIFOP[[MF

*NQSPQFSJOTUBMMBUJPOXJMMDBVTFMFBLBHF

BOEEBNBHFUPUIFUVSCJOF

Groove

(d)

(e)

3 4

¡Å¦

WAGNER 0529002 User guide

Related papers

Other documents