Schumacher SL1404 Owner's manual

Page is loading ...

CONTENTS

IMPORTANT SAFETY INSTRUCTIONS .............................................................................. 5

PERSONAL SAFETY PRECAUTIONS ................................................................................ 5

ASSEMBLY INSTRUCTIONS ............................................................................................... 5

FEATURES ........................................................................................................................... 6

LCD SCREEN....................................................................................................................... 6

OPERATING INSTRUCTIONS ............................................................................................. 7

MAINTENANCE AND CARE ................................................................................................ 9

WARNINGS .......................................................................................................................... 9

TROUBLESHOOTING.......................................................................................................... 9

BEFORE RETURNING FOR REPAIRS ............................................................................. 10

SPECIFICATIONS .............................................................................................................. 10

REPLACEMENT PARTS ....................................................................................................10

DISPOSAL INFORMATION ................................................................................................ 11

LIMITED WARRANTY ........................................................................................................ 11

WARRANTY CARD ............................................................................................................ 27

CONTENIDOS

INSTRUCCIONES IMPORTANTES DE SEGURIDAD ....................................................... 12

PRECAUCIONES DE SEGURIDAD PERSONAL .............................................................. 12

INSTRUCCIONES DE MONTAJE ...................................................................................... 12

CARACTERÍSTICAS .......................................................................................................... 13

PANTALLA LCD .................................................................................................................. 13

INSTRUCCIONES DE OPERACIÓN ................................................................................. 14

MANTENIMIENTO Y CUIDADO ......................................................................................... 16

ADVERTENCIAS ................................................................................................................16

LOCALIZACIÓN Y SOLUCIÓN DE PROBLEMAS ............................................................. 16

ANTES DE DEVOLVER A REPARACIONES ..................................................................... 17

ESPECIFICACIONES......................................................................................................... 17

REPUESTOS ......................................................................................................................18

INFORMACIÓN DE ELIMINACIÓN .................................................................................... 18

GARANTÍA LIMITADA ........................................................................................................ 18

TARJETA DE GARANTÍA ................................................................................................... 27

Page is loading ...

• 5 •

1. IMPORTANT SAFETY INSTRUCTIONS

SAVE THESE INSTRUCTIONS.

1.1 SAVE THESE INSTRUCTIONS –

This manual contains important safety

and operating instructions.

1.2 This product is not intended for use by

children.

1.3 If someone else uses the unit, ensure

they are well informed on how to use it

safely, and have read and understood the

operating instructions.

1.4 Do not use near ammable fumes or

gases, such as in the bilge of a gasoline-

powered boat or near propane tanks.

1.5 Do not use in an enclosure containing

automotive-type lead-acid batteries.

1.6 Do not expose the unit to temperatures

over 113 °F (45 °C).

1.7 Do not operate the unit with damaged

cord or plug – replace the cord or plug

immediately.

1.8 Do not recharge the unit with a damaged

extension cord.

1.9 Do not operate the unit if it has received

a sharp blow, been dropped, or otherwise

damaged in any way; take it to a qualied

service person.

1.10 Do not disassemble the unit. If repair is

required, contact Customer Service for

assistance.

1.11 To reduce risk of electric shock, unplug

the unit from the outlet before attempting

any maintenance or cleaning. Turning off

controls will not reduce this risk.

1.12 The unit gets uncomfortably warm during

use and must have proper ventilation.

Ensure at least 3 in. (7.5 cm) air space is

maintained on all sides of the unit.

1.13 Do not set the unit on ammable materials,

such as carpeting, upholstery, paper,

cardboard, etc. During operation, keep unit

away from materials that can be affected

by high temperatures, such as blankets,

pillows and sleeping bags.

2. PERSONAL SAFETY PRECAUTIONS

WARNING!

RESTRICTIONS ON USE.

2.1 This unit may not be used with life

support devices or systems. Failure of

this device can reasonably be expected

to cause failure of that life support device

or system, or to affect the safety or

effectiveness of that device or system.

2.2 When working on electrical equipment,

always ensure someone is nearby to aid

you in case of an emergency.

3. ASSEMBLY INSTRUCTIONS

3.1 Remove all cord wraps and uncoil the cables prior to using the unit.

• 6 •

4. FEATURES

13

14

15

16

1

2

3

4

5

6 7

8

9

10

11

12

1. 110V AC power outlets (2)

2. 1A USB port

3. 2A USB port

4. 2.4A USB port

5. AC adaptor input socket

6. ON/OFF power switch

7. LCD display

8. Solar charging input socket

9. 12V DC output ports

10. 12V DC cigarette lighter

output only port

11. AC output button

12. AC output LED indicator

13. Handle

14. Light button

15. Light

16. Cooling vents

5. LCD SCREEN

AC ADAPTOR

CHARGING

BATTERY

CAPACITY

INDICATOR

SOLAR

CHARGING

WARNING

POWER OUTPUT

INDICATOR

AC OUTPUT

CHARGING

INDICATOR

USB

OUTPUT

12V DC

OUTPUT

12V DC

CIGARETTE

LIGHTER

OUTPUT

• 7 •

6. OPERATING INSTRUCTIONS

IMPORTANT! Charge immediately after

purchase and when battery level is below

40%, to keep the internal battery fully

charged and prolong battery life. Do not

recharge unit for more than 12 hours.

POWERING ON

Press the ON/OFF power switch. The unit

will initialize, and all icons on the LCD

screen will activate. If normal function

is detected, the screen will return to its

normal display.

CHECKING THE LEVEL

OF THE INTERNAL BATTERY

The Battery Capacity Indicator on the

LCD display will show the battery’s charge

level in 20-percent increments. For best

performance, the battery capacity should

be 20% or greater.

CHARGING THE INTERNAL BATTERY

NOTE: Do not use the unit while charging

its internal battery.

AC adaptor

1. If the red AC Output LED is lit, press

the AC Output button to turn off before

charging.

2. Connect the provided AC charger to

the socket on the front of the unit. Plug

the charger’s power cord directly into

a live grounded 120V outlet. Charging

will start automatically, and the AC

Adaptor Charging icon will show on the

display.

3. While the unit is charging, the rotating

Charging indicator will show on

the display. When the internal battery

is fully charged, all ve bars of the

Battery Capacity indicator on the

display will show. Complete charging

will take approximately 5 hours.

4. When the unit is fully charged, unplug

the charger from the 120V outlet and

then from the unit.

Solar Charging

Solar charging can be accomplished by

plugging in a 30-36V solar panel (not

included) into the Solar Charging Input port.

The Solar Charging icon will show on

the display. For best results, face the panel

toward the sun, away from curtains and

windows. Charging by solar panel takes

approximately 10 hours (on a sunny day).

POWERING A 12V DC DEVICE

NOTE: Do not power a 12V device while

charging the internal battery.

12V DC Output

1. Make sure the device to be powered is

OFF before inserting the 12V DC plug

into one of the two 12V DC output ports.

2. Plug the 12V DC device into one of the

12V DC output ports and turn on the

12V DC device (if required). The

12V DC output icon and the rotating

Discharging indicator will show on the

display.

3. When nished, turn off the DC device

(if required) and unplug from the DC

output port.

4. Recharge the unit when the battery

level is below 40%.

12V DC Cigarette lighter plug

1. Make sure the device to be powered

is OFF before inserting the 12V DC

cigarette lighter plug into the 12V DC

cigarette lighter socket.

2. Plug the 12V DC device into the DC

cigarette lighter socket and turn on

the 12V DC device (if required). The

Cigarette Lighter Output icon and the

rotating

Discharging indicator will

show on the display.

3. When nished, turn off the DC device

(if required) and unplug from the DC

Cigarette Lighter socket.

4. Recharge the unit when the battery

level is below 40%.

USING THE USB PORTS

The USB ports provide 1A, 2A and 2.4A

at 5V DC.

1. Plug the device into one of the three

USB ports on the front panel.

2. Turn on the USB device, if necessary.

The USB Output icon and the

rotating Discharging indicator will

show on the display.

3. When nished, turn off the USB device

(if required) and unplug from the USB

port.

4. Recharge the unit when the battery

level is below 40%.

• 8 •

USING THE LIGHT

There are 5 lighting modes:

• High (100% power)

• Normal (50% power)

• Energy saving (25% power)

• Emergency ash

• SOS

Press once to turn the light ON or OFF.

Press twice quickly, to change to the

next mode.

USING THE AC POWER OUTLETS

The SL1404 is equipped with a 500W pure

sine wave inverter, which produces the

best power for all electronic devices and

appliances, without damage.

It is important to know the continuous

wattage of the device you plan to use with

the AC outlets. The unit must be used with

devices drawing 500 watts or less.

Devices such as fans or electric motors

require additional power to start (commonly

known as the “starting” or “peak” power).

The generator can supply a momentary

surge in wattage of as high as 2,500W

for less than 1/10 of a second; however

even devices rated less than the maximum

500 watts can exceed the inverter’s surge

capability and cause an automatic overload

shutdown.

Do not use the inverter with a product that

draws a higher wattage than the inverter

can provide, as this may cause erratic

operation.

CAUTION: Always run a test to establish

whether the inverter will operate a

particular piece of equipment or device.

In the event of a power overload (noted

with an audible alarm beeping every 3

seconds and a ashing Warning icon),

the inverter is designed to automatically

shut down. This safety feature prevents

damaging the inverter while testing devices

and equipment within the 500-watt range.

If powering more than one device, start one

device at a time to avoid a power surge and/

or inverter overload. The surge load of each

device should not exceed the inverter’s

Continuous Operation wattage rate.

You can use an extension cord from the

inverter to the device without signicantly

decreasing the power being generated by

the inverter. For best operating results, the

extension cord should be 16 AWG (1.31 mm

2

)

or larger and no longer than 50 feet.

WARNING! RISK OF ELECTRIC SHOCK.

Incorrect operation of your inverter may

result in damage and personal injury. The

inverter output is 110V AC and can shock

or electrocute the same as any ordinary

household AC wall outlet.

NOTE: The maximum continuous load

is 500 watts. Do not use the AC outlets with

a product that draws more than 500 watts,

as this may cause erratic operation.

CAUTION:

• Do not connect an AC power source to

the 110V AC outlets.

• Do not connect the unit’s AC power cord

to its 110V AC outlets.

NOTE: Do not power an AC device while

charging the internal battery.

1. Connect your AC-powered devices or

small household appliances to one or

more of the unit’s two AC outlets.

NOTE: Make sure the device to be

powered is OFF before inserting the plug

into the AC power outlet.

2. Press the AC Output button. The AC

Output icon will show on the display

and the green AC power LED lights,

to conrm that the unit is on and ready

to provide AC power. The rotating

Discharging indicator will also show on

the display.

NOTE: Extended operation of an AC device

may result in excessive battery drain.

3. Recharge the unit when the battery

level is below 40%.

ESTIMATED RUN-TIMES

APPLIANCE TYPE

ESTIMATED

RUN TIME

CHARGES

Projector 8 hours —

12V Heated blanket 15 hours —

12V Cooler 17 hours —

Mini refrigerator 23 hours

Drone 24 hours 145

Television 24 hours —

Fan 29 hours —

Router 60 hours —

Table lamp 65 hours —

Laptop 117 hours 17

LED lights 167 hours —

Go Pro 210 hours 140

Radio 245 hours —

Tablet 273 hours 22

Speaker 750 hours 63

Smartphone 843 hours 70

NOTE: Actual time may vary. Times are based

on the internal battery being fully charged.

• 9 •

7. MAINTENANCE AND CARE

7.1 Recharge the unit when the battery level

is below 40%.

7.2 Never completely discharge the internal

battery.

8. WARNINGS

WARNING

LCD DISPLAY TIME CAUSE

Alarm LED

3 short beeps every

2 seconds, lasting 30

seconds

AC LED

blinking

Low battery icon ashes

for 30 seconds.

30 sec.

before

AC OFF

Economy mode. Pre-

alert for AC OFF.

3 short beeps every

2 seconds, lasting 30

seconds

N/A

Low battery icon ashes until

battery is charged above 10%.

30 sec.

before

DC OFF

Low battery capacity

mode.

Pre-alert for DC OFF.

Every 1 second N/A

Warning icon ashes until fault is removed.

Charging fault.

Every 2 seconds N/A DC output fault

Every 3 seconds N/A AC output fault

Every 4 seconds N/A Over temperature

3 short beeps every

3 seconds.

N/A Overload

9. TROUBLESHOOTING

PROBLEM CAUSE SOLUTION

Power-up failure Under-voltage protection

Abnormal load protection

Damaged unit

Recharge unit.

Remove loads and recharge unit.

Contact customer service.

Charger fault Unmatched charger

Damaged charger

Abnormal power supply or

connection

Use only the included charger.

Contact customer service for

replacement.

Reconnect the charger. If problem

persists, replace the charger.

Solar panel

charging fault

Over-current

Weak sunlight

Damaged solar panel

Abnormal wiring-harness

connection

Use only the recommended solar

panel.

Charge in a sunny place.

Replace the solar panel.

Reconnect the wiring-harness.

If problem persists, replace the

solar panel.

DC/AC output fault Battery under-voltage protection

Discharge over-current protection

Over-temperature protection

Damaged unit

Charge the unit.

Make sure loads are within allowed

range (total ≤500W).

Turn unit off, allow to cool down

and then restart.

Contact customer service.

• 10 •

PROBLEM CAUSE SOLUTION

Abnormal icon

display

Abnormal loads

Hardware fault

Damaged LCD screen

Remove loads.

Contact customer service.

LCD screen fault Damaged LCD screen Contact customer service.

10. BEFORE RETURNING FOR REPAIRS

If these solutions do not eliminate the problem,

or for more information about troubleshooting,

contact customer service for assistance:

[email protected]

www.batterychargers.com

or call 1-800-621-5485

For REPAIR OR RETURN, contact Customer Service at 1-800-621-5485. DO NOT

SHIP UNIT until you receive a RETURN MERCHANDISE AUTHORIZATION (RMA)

number from Customer Service at Schumacher Electric Corporation.

11. SPECIFICATIONS

Internal battery type .......................................................................................... Lithium-Ion

Capacity .............................................................................................750 Wh (25V, 30 Ah)

AC input .................................................................................................... 147W/29.4V, 5A

Solar input ...................................................................... 30-36V (Max. power up to 200W)

AC output ....................................................................................................2 x 110V/60 Hz

DC output .................................................................................................2 x 12V DC, 2.5A

Cigarette lighter output................................................................................1 x 12V DC, 5A

USB output..........................................................................................5V DC, 1A, 2A, 2.4A

Light ...............................................................................................................................1W

Operating Temperature ................................................................ 14˚–113˚F (-10 ˚– 45 ˚C)

Storage Temperature ...................................................................... 32˚–113˚F (0 ˚– 45 ˚C)

Dimensions (H x W x D)....................... 13.7˝ x 6.3˝ x 11.2˝ (349 mm x 6.3 mm x 285 mm)

Weight ...................................................................................................... 16.7 lbs. (7.6 kg)

12. REPLACEMENT PARTS

AC charger module ........................................................................................... 93026980Z

AC charger cable ..........................................................................................3899003972Z

• 11 •

13. DISPOSAL INFORMATION

Do not dispose of this product with other household waste. To prevent possible

harm to the environment or human health from uncontrolled waste disposal, and

to promote the sustainable reuse of material resources, recycle it responsibly. To

discard your used device, please use the return and collection systems or contact

the retailer where the product was purchased, for environmentally-safe recycling.

14. LIMITED WARRANTY

WARRANTY NOT VALID IN MEXICO.

SCHUMACHER ELECTRIC CORPORATION, 801 BUSINESS CENTER DRIVE,

MOUNT PROSPECT, IL 60056-2179, MAKES THIS LIMITED WARRANTY TO THE

ORIGINAL RETAIL PURCHASER OF THIS PRODUCT. THIS LIMITED WARRANTY

IS NOT TRANSFERABLE OR ASSIGNABLE.

Schumacher Electric Corporation (the “Manufacturer”) warrants this Portable Power

Generator for one (1) year and the internal battery for ninety (90) days from the date of

purchase at retail against defective material or workmanship that may occur under normal

use and care. If your unit is not free from defective material or workmanship, Manufacturer’s

obligation under this warranty is solely to repair or replace your product, with a new or

reconditioned unit, at the option of the Manufacturer. It is the obligation of the purchaser

to forward the unit, along with proof of purchase and mailing charges prepaid to the

Manufacturer or its authorized representatives in order for repair or replacement to occur.

Manufacturer does not provide any warranty for any accessories used with this product

that are not manufactured by Schumacher Electric Corporation and approved for use

with this product. This Limited Warranty is void if the product is misused, subjected

to careless handling, repaired, or modied by anyone other than Manufacturer or if

this unit is resold through an unauthorized retailer. Manufacturer may void this Limited

Warranty if a “warranty may be void if removed” label is removed from the product.

Manufacturer makes no other warranties, including, but not limited to, express, implied or

statutory warranties, including without limitation, any implied warranty of merchantability

or implied warranty of tness for a particular purpose. Further, Manufacturer shall

not be liable for any incidental, special or consequential damage claims incurred by

purchasers, users or others associated with this product, including, but not limited to,

lost prots, revenues, anticipated sales, business opportunities, goodwill, business

interruption and any other injury or damage. Any and all such warranties, other than the

limited warranty included herein, are hereby expressly disclaimed and excluded. Some

states do not allow the exclusion or limitation of incidental or consequential damages or

length of implied warranty, so the above limitations or exclusions may not apply to you.

This warranty gives you specic legal rights and it is possible you may have other rights

which vary from this warranty.

THIS LIMITED WARRANTY IS THE ONLY EXPRESS LIMITED WARRANTY AND THE

MANUFACTURER NEITHER ASSUMES OR AUTHORIZES ANYONE TO ASSUME

OR MAKE ANY OTHER OBLIGATION TOWARDS THE PRODUCT OTHER THAN

THIS WARRANTY.

Schumacher

®

is a registered trademark

of Schumacher Electric Corporation.

Page is loading ...

• 13 •

4. CARACTERÍSTICAS

13

14

15

16

1

2

3

4

5

6 7

8

9

10

11

12

1. Tomas de CA de 110V (2)

2. Puerto USB de 1A

3. Puerto USB de 2A

4. Puerto USB de 2.4A

5. Receptáculo de entrada de

adaptador de CA

6. Interruptor de alimentación ON/OFF

7. Pantalla LCD

8. Receptáculo de entrada

para carga solar

9. Puertos de salida de 12V de CC

10. Puerto de salida único de CC para

encendedor de cigarrillos de 12V

11. Botón de salida de CA

12. Indicador LED de salida de CA

13. Manilla

14. Botón de luz

15. Luz

16. Ventilas de enfriamiento

5. PANTALLA LCD

INDICADOR

DE CAPACIDAD

DE BATERÍA

CARGA DE

ADAPTADOR

DE CA

CARGA

SOLAR

ADVERTENCIA

INDICADOR

DE POTENCIA

DE SALIDA

SALIDA

DE CA

INDICADOR

DE CARGA

SALIDA

USB

SALIDA DE

CC DE 12V

SALIDA DE

CC PARA

ENCENDEDOR

DE CIGARRILLOS

DE 12V

Page is loading ...

4. ATTRIBUTS

1. (2) Prises de courant 110 vc.a.

2. Port USB-1 A

3. Port USB-2 A

4. Port USB-2,4 A

5. Douille d’adaptateur d’entrée c.a.

6. Commutateur d’alimentation

MARCHE/ARRÊT

7. Afcheur ACL

8. Douille d’entrée de recharge

solaire

9. Ports de sortie 12 Vc.c.

10. Port unique de sortie allume-

cigare 12 Vc.c.

11. Bouton de sortie c.a.

12. Témoin DEL de sortie c.a.

13. Poignée

14. Bouton d’éclairage

15. Tête d’éclairage

16. Évents de refroidissement

13

14

15

16

1

2

3

4

5

6 7

8

9

10

11

12

5. ÉCRAN ACL

RECHARGE PAR

ADAPTATEUR C.A.

INDICATEUR

DE CAPACITÉ

DES PILES

RECHARGE

SOLAIRE

AVERTISSEMENT

INDICATEUR

DE PUISSANCE

DE SORTIE

SORTIE C.A.

INDICATEUR

DE RECHARGE

SORTIE

USB

SORTIE

12 VC.C.

SORTIE

ALLUME-CIGARE

12 VC.C.

• 20 •

Page is loading ...

• 27 •

1 YEAR LIMITED

WARRANTY PROGRAM

REGISTRATION

MODEL: _____________________DESCRIPTION: ________________________

This is the only express limited warranty, and the manufacturer neither assumes

nor authorizes anyone to assume or make any other obligation. There is no other

warranty, other than what is described in the product owner’s manual.

The warranty card should be submitted within 30 days of purchase. The customer

must keep the ORIGINAL receipt because it will be required for any warranty claims.

This warranty is not transferable. Send warranty card only.

DO NOT SEND UNIT TO THIS ADDRESS FOR REPAIR.

Mail this card to: Schumacher Electric Corporation

801 Business Center Drive

Mount Prospect, IL 60056-2179

Name ______________________________________________________________

Street Address _______________________________________________________

City ________________________________State _________ Zip Code _________

Phone _____________________Email ___________________________________

Store Name Where Purchased ___________________ Date of Purchase _________

Store Location ____________________ UPC Number ________________________

Serial Number ______________________________________ (SEE PRODUCT)

For faster warranty activation, go to www.batterychargers.com to register your product online.

PROGRAMA DE REGISTRO

DE 1-AÑO DE GARANTÍA

LIMITADA

MODELO: ____________________DESCRIPCIÓN: ________________________

Esta es la única garantía limitada expresa, y el productor no autoriza ni otorga

a alguien a realizar alguna otra obligación. No existe ninguna otra garantía

más que la descrita en el manual del dueño.

La tarjeta de garantía debe enviarse durante los primeros 30 días después de la

compra. El cliente debe mantener el recibo de compra ORIGINAL como

comprobante, el cual le otorga todo derecho a cualquier reclamo de garantía.

Esta garantía no es transferible. Envie tarjeta de garantía solamente.

NO ENVÍE LA UNIDAD A ESTA DIRECCIÓN PARA SU REPARACIÓN.

Enviar esta tarjeta a: Schumacher Electric Corporation

801 Business Center Drive

Mount Prospect, IL 60056-2179

Nombre ____________________________________________________________

Dirección ___________________________________________________________

Ciudad __________________________Estado ____________ C.P. _____________

Tel: ________________________ Correo electrónico _________________________

Nombre de la Tienda donde se Compró ____________ Fecha de compra _________

Localización de la Tienda ____________ Numero de Serie ____________________

Código de barras ___________________________ (CONSULTE EL PRODUCTO)

Para una activación más rápida, visite nuestra página de internet en www.batterychargers.com

¡AHORRE EN EL ENVÍO! ¡ACTIVE SU GARANTÍA EN LÍNEA-LA FORMA MAS RÁPIDA Y FÁCIL!

Visite nuestra página en www.batterychargers.com para registrar su producto en línea.

WARRANTY CARD / TARJETA DE GARANTÍA

SAVE ON POSTAGE! ACTIVATE YOUR WARRANTY ONLINE – THE QUICK AND EASY WAY!

Go to www.batterychargers.com to register your product online.

1. WARRANTY CARD

2. TARJETA DE GARANTÍA

Page is loading ...

Schumacher SL1404 Owner's manual

This manual is also suitable for

Schumacher SL1404 Owner's manual

in other languages

Related papers

Other documents