Marvel MLCP215-SS01A User manual

Brand: Marvel

Model: MLCP215-SS01A

Type: User manual

O W N E R S G U I D E

M A R V E L U N D E R C O U N T E R R E F R I G E R A T I O N

T H E O R I G I N A L R E F R I G E R A T I O N E X P E R T S S I N C E 1 8 9 2

F O R MO D E L # M L C P 2 1 5

NOTE

CAUTION

Important Safety Instructions

Warnings and safety instructions appearing in this guide

are not meant to cover all possible conditions and situa-

tions that may occur. Common sense, caution, and care

must be exercised when installing, maintaining, or operat-

ing this appliance.

Recognize Safety Symbols,

Words, and Labels.

CAUTION-Hazards or unsafe practices which could re-

sult in personal injury or property / product damage.

NOTE-Important information to help assure a problem

free installation and operation.

WARNING

WARNING - You can be killed or seriously injured

if you do not follow these instructions.

WARNING

State of California Proposition 65 Warning:

This product contains one or more chemicals known

to the State of California to cause cancer.

WARNING

State of California Proposition 65 Warning:

This product contains one or more chemicals known

to the State of California to cause birth defects or

other reproductive harm.

WARNING

WARNING - This unit contains R600a (Isobutane)

which is a ammable hydrocarbon. It is safe for regular

use. Do not use sharp objects to expedite defrosting.

Do not damage refrigerant circuit.

IMPORTANT SAFETY INSTRUCTIONS

TABLE OF CONTENTS

Tip: Click on any section below to jum

p directly there

Safety

Important Safety Instructions

Installation

Unpacking Your Appliance

Electrical

Installing The Water Supply

Service

Obtaining Service

Product Liability

Ordering Replacement Parts

System Diagnosis Guide

Warranty

NOTE

CAUTION

WARNING

WARNING - Dispose of the plastic bags which can

be a suocation hazard.

WARNING

WARNING - Help Prevent Tragedies

Child entrapment and suocation are not problems of

the past. Junked or abandoned refrigerators are still

dangerous - even if they sit out for "just a few hours".

If you are getting rid of your old refrigerator, please fol-

low the instructions below to help prevent accidents.

Before you throw away your old refrigerator or freezer:

• Take o the doors or remove the drawers.

• Leave the shelves in place so children may not

easily climb inside.

WARNING

EXCESSIVE WEIGHT HAZARD

Use two or more people to move product.

Failure to do so can result in personal injury.

Remove Interior Packaging

Your appliance has been packed for shipment with all parts

that could be damaged by movement securely fastened.

Remove internal packing materials and any tape holding in-

ternal components in place. The owners manual is shipped

inside the product in a plastic bag along with the warranty

registration card, and other accessory items.

Important

Keep your carton and packaging until your appliance has

been thoroughly inspected and found to be in good condi-

tion. If there is damage, the packaging will be needed as

proof of damage in transit. Afterwards please dispose of all

items responsibly.

Note to Customer

This merchandise was carefully packed and thoroughly

inspected before leaving our plant. Responsibility for its

safe delivery was assumed by the retailer upon acceptance

of the shipment. Claims for loss or damage sustained in

transit must be made to the retailer.

DO NOT RETURN DAMAGED MERCHANDISE TO THE

MANUFACTURER - FILE THE CLAIM WITH THE

RETAILER.

If the appliance was shipped, handled, or stored in other

than an upright position for any period of time, allow the ap-

pliance to sit upright for a period of at least 24 hours before

plugging in. This will assure oil returns to the compressor.

Plugging the appliance in immediately may cause damage

to internal parts.

UNPACKING YOUR APPLIANCE

Electrical Connection

A grounded 115 volt, 15 amp dedicated circuit is required.

This product is factory equipped with a power supply

cord that has a three-pronged, grounded plug. It must be

plugged into a mating grounding type receptacle in accor-

dance with the National Electrical Code and applicable lo-

cal codes and ordinances (see Figure 4). If the circuit does

not have a grounding type receptacle, it is the responsibility

and obligation of the customer to provide the proper power

supply. The third ground prong should not, under any cir-

cumstances, be cut or removed.

Figure 4

NOTE

Ground Fault Circuit Interrupters (GFCI) are prone to nui-

sance tripping which will cause the appliance to shut down.

GFCI’s are generally not used on circuits with power equip-

ment that must run unattended for long periods of time, un-

less required to meet local building codes and ordinances.

ELECTRICAL

Figure 2

Do not remove

ground prong

Figure 3

Electrical Shock Hazard

• Do not use an extension cord with this appliance.

They can be hazardous and can degrade product

performance.

• This appliance should not, under any circumstanc-

es, be installed to an un-grounded electrical supply.

• Do not remove the grounding prong from the power

cord. (See Figure 2).

• Do not use an adapter. (See Figure 3).

• Do not splash or spray water from a hose on the

appliance. Doing so may cause an electrical shock,

which may result in severe injury or death.

WARNING

INSTALLING THE WATER SUPPLY

Access

panel

Drain pipe, (not

provided)

Drain tubing, cut

to length and

install in the drain

»8"

(37.8 cm)

»16"

(17mm)

»4"

(3.2 cm)

»32"

(11.5 cm)

»2"

(54.6 cm)

Drain line coiled

and secured to

the back of the

unit

Uncoil the drain line, route

to an appropriate drain and

FXWWRWKHUHTXLUHGOHQJWK

Electrical Shock Hazard

Reasonable care and safe methods should be

practiced. Do NOT work with energized electrical

HTXLSPHQWLQDZHWDUHD5HDGDQGIROORZWKH

installation instructions listed in this manual.

WARNING

CAUTION

)DLOXUHWRXVHDQDGHTXDWHGUDLQDJHV\VWHPZLOOUHVXOWLQ

surrounding water damage and/or poor ice production.

CAUTION

Observe and follow all local building codes

when installing this ice machine and drain

lines.

Water

supply

inlet

Drain access in

bottom of unit

»32"

(10.4 cm)

Sanitary

trap

»4"(5.7 cm)

»8" (13 cm)

Drain Plumbing

<RXULFHPDFKLQHUHTXLUHVGUDLQSOXPELQJ7KHUHDUH

variations of ice machines in regards to the installation of

the drain plumbing, without a drain pump (gravity drain),

and with a drain pump.

Gravity Drain (no drain pump):

The ice machine is shipped with the drain line installed,

coiled and secured to the back of the cabinet as shown

below. It can be uncoiled, routed to an appropriate GUDLQ

DQGFXWWROHQJWKDVUHTXLUHG$GGLWLRQDOO\WKHUHLVWKH

provision of drain routing through the cut-out in the bottom

of the unit. A drain can be installed in this gray area with the

drain line cut to a short length and positioned into the drain,

or if the ice machine is to be built-in, the drain tube could

be URXWHGWKURXJKDKROHLQWKHIORRULQWKLVJUD\DUHDWRD

GUDLQbelow.

The gravity drain line must be routed no higher than 6"

FPRIIWKHÀRRUWRDVVXUHSURSHUGUDLQDJH

CAUTION

INSTALLING THE WATER SUPPLY

This drain pump is designed to be installed in Marvel ice

machines only and approved for use with water only.

CAUTION

Drain pump

vent tube.

Keep this

open to

assure air

ÀRZVIUHHO\

as water

enters

the pump

reservoir.

Drain line coiled and

secured to the back of the

cabinet. Uncoil, route to

an appropriate drain and

cut to length.

Optional Drain Pump.

An optional drain pump is available if you have purchased

an ice machine without one and do not have access to a

gravity drain. Installation instructions are provided with the

optional drain pump. Contact Marvel customer service at

616-754-5601 or your dealer for ordering.

Electrical Shock Hazard

Risk of electrical shock or personal injury could

occur due to moving components, if the machine

compartment access cover is removed before

unplugging the ice machine power cord.

WARNING

Reverse osmosis, (RO), water, softened water, and de-

ionized water are not recommended as they can adversely

DIIHFWWKHTXDOLW\DQGTXDQWLW\RIWKHLFH

Water

Supply

Line

Clamp and

Screw

Back view of

ice machine

NOTE

CAUTION

INSTALLING THE WATER SUPPLY

Compression

¿WWLQJ

Water

supply

line

Water supply

service loop

to shut off

valve

Water valve

inlet

Water Supply

Observe and follow all local building codes when installing

this appliance.

This ice machine must be connected to a potable cold

water supply line. delivering water pressure between a

minimum of 20 psi and a maximum of 120 psi.

Use

»4" copper tubing for your water supply which is

available at any local hardware or plumbing supply store.

Route the

»4" copper tubing to suit your installation being

sure not to kink the tubing. Purchase enough copper tubing

length to allow a coil to be formed behind the unit for a

"service loop" which will allow the appliance to be pulled

out from the installation for servicing or cleaning. Connect

the copper tubing to the "top side" of a cold water pipe to

prevent the ice-maker from plugging with sediment.

A shutoff valve is recommended on the water supply line to

ease servicing the appliance. NOTE: A SELF-PIERCING

TYPE VALVE IS NOT RECOMMENDED as they are prone

to clogging with sediment which will create pressure drop

reducing the water supply to the unit.

Connect the copper tubing water supply to the water valve

LQOHWZLWKDFRPSUHVVLRQQXWILWWLQJ

IMPORTANT: Secure the water supply line to the back of

the cabinet with the screw and strain relief clamp provided

in the corner of the back panel.

Make certain all connections are watertight after

installation. Form the tubing so that it will not vibrate

against the cabinet body or kink when your appliance is

moved in and out of position.

This ice machine is designed to make clear ice from the

majority of water sources on a daily basis. If your results

DUH XQVDWLVIDFWRU\ \RXU ZDWHU PD\ QHHG WR EH ILOWHUHG RU

treated. A water specialist can recommend proper water

treatment.

CAUTION

7RSUHYHQWZDWHUOHDNV

• 7KHZDWHUOLQH¿WWLQJLVWREHXVHGZLWKFRSSHUWXELQJ

only. Do not use with plastic tubing.

• 'RQRWXVHDQ\WKUHDGVHDOHUVRQWKLVZDWHUOLQH¿WWLQJ

INSTALLING THE WATER SUPPLY

Procedure for Testing Drain System

(both gravity and drain pump models)

Drain pump models have a safety feature that will interrupt power to the unit if a high-limit condition occurs to prevent

ÀRRGLQJ7KLVVDIHW\IHDWXUHFDQEHLQLWLDWHGE\DUHVWULFWLRQLQWKHGUDLQV\VWHPDQGZLOOFRQWLQXHXQWLOKLJKOLPLWFRQGLWLRQ

is corrected, at which time power will be restored to the unit. Power interruption can be detected when no icons are

visible in the display area of the user interface. Once power is returned, a startup chime will sound followed by a self-test,

and "OFF" should be visible in the display area.

Drain pump vent

tube. Keep this

open to assure

DLUÀRZVIUHHO\DV

water enters the

pump reservoir.

/RFDWLRQRIYHQWWXEH

([DPSOHRIDQRSHQGUDLQ

Sanitary trap

hours

ICE

1 4 6 8

OFF CLEAN

DOOR

ECO

days

On/off Menu Light Delay timer Lock

7. $IWHUFKHFNLQJWKHDERYHUHTXLUHPHQWVUHSHDWVWHSDQGYHULI\WKHZDWHUGUDLQVFRPSOHWHO\ZLWKRXWSRZHU

LQWHUUXSWLRQ,ISUREOHPVSHUVLVWFDOODTXDOL¿HGVHUYLFHWHFKQLFLDQDQGRUSOXPEHU

Air gap

between

end of

drain line

and top of

water level

8VHULQWHUIDFHGLVSOD\GXULQJSRZHULQWHUUXSWLRQ 2QFHWKH

GUDLQOLQHLVSOXPEHGSHUIRUPWKHIROORZLQJ

1. Plug the ice machine into 115v power supply.

2. 3ODFHXQLWLQWKH¿QDOLQVWDOODWLRQORFDWLRQ

3. Turn the unit off via the user interface (display will indicate “OFF”). The drain pump will still be operational during off

mode if the unit has one.

4. 6ORZO\SRXUTWVRIZDWHULQWRWKHLFHVWRUDJHELQ$OOZDWHUVKRXOGGUDLQFRPSOHWHO\

5. If water drains fully and without power interruption, the drain system has been successfully tested and further

installation of the ice machine can be continued.

6. ,IWKHZDWHUGRHVQRWGUDLQRUDSRZHULQWHUUXSWRFFXUVFKHFNWKHIROORZLQJ

D 7KHUHDUHQRNLQNVRUUHVWULFWLRQVLQWKHGUDLQOLQH1RWH'UDLQOLQHQHHGVWREHFXWWRWKHUHTXLUHGOHQJWKDQGDQ\

excess tubing should be removed to prevent possible restrictions).

E 'UDLQOLQHZDVUXQDFFRUGLQJWRWKHJXLGHOLQHVIRUPD[LXPXPDOORZDEOHULVHDQGUXQDVVKRZQLQWKHWDEOHEHORZ

Rise Above Floor Level 8 ft. 9 ft. 10 ft.

Maxium Allowable Drain Line Length 20 ft. 15 ft. 10 ft.

c. Your drain line is plumbed into an open drain (Figure 13).

d. The vent tube on the back of the unit is open (Figure 14).

If Service is Required:

• If the product is within the rst year warranty period

please contact your dealer or call Marvel Customer

Service at 616.754.5601 for directions on how to obtain

warranty coverage in your area.

• If the product is outside the rst year warranty period,

Marvel Customer Service can provide recommenda-

tions of service centers in your area. A listing of autho-

rized service centers is also available at www.marvelre-

frigeration.com under the service and support section.

• In all correspondence regarding service, be sure to

give the service number, serial number, and proof of

purchase.

• Try to have information or description of nature of the

problem, how long the appliance has been running, the

room temperature, and any additional information that

may be helpful in quickly solving the problem.

• Table "B" is provided for recording pertinent information

regarding your product for future reference.

For Your Records

Date of Purchase

Dealer’s name

Dealer’s Address

Dealer’s City

Dealer’s State

Dealer’s Zip Code

Appliance Serial Number

Appliance Service Number

Date Warranty Card Sent (Must

be within 10 days of purchase).

Table B

OBTAINING SERVICE

Ordering Replacement Parts

 















  















































 

  

 m.

Ordering Replacement Parts

  















  













































  

 

m.

Ordering Replacement Parts

System Diagnosis Guide





 











  

 









 







 







 

 





 

 















 





 

 



    

 





System Diagnosis Guide











 

  

 









 

 





 









 











 

 













 

  

  



  



 

  



  



 

HOUSEHOLD PRODUCT WARRANTY

Marvel Refrigeration (Marvel) Limited Warranty

ONE YEAR LIMITED PARTS & LABOR WARRANTY

For one year from the date of original purchase, this warranty covers all parts and labor to repair or replace any part of the product that proves to

be defecve in materials or workmanship. For products installed and used for normal residenal use, material cosmec defects are included in this

warranty, with coverage limited to 60 days from the date of original purchase. All service provided by Marvel under the above warranty must be

performed by a Marvel factory authorized servicer, unless otherwise specied by Marvel. Service provided during normal business hours.

TWO YEAR LIMITED PARTS & LABOR WARRANTY (MARVEL PROFESSIONAL PRODUCTS)

For two years from the date of original purchase, this warranty covers all parts and labor to repair or replace any part of the product that proves to

be defecve in materials or workmanship. For products installed and used for normal residenal use, material cosmec defects are included in this

warranty, with coverage limited to 60 days from the date of original purchase. All service provided by Marvel under the above warranty must be

performed by a Marvel factory authorized servicer, unless otherwise specied by Marvel. Service provided during normal business hours.

AVAILABLE THIRD YEAR LIMITED WARRANTY (MARVEL PROFESSIONAL PRODUCTS)

For designated Marvel Professional product, Marvel oers a one year extension of the two year warranty coverage from the date of purchase, free

of charge. To take advantage of this third year warranty, you must register your product with Marvel within 60 days from the date of purchase at

marvelrefrigeraon.com and provide proof of purchase.

LIMITED FIVE YEAR SEALED SYSTEM WARRANTY

For ve years from the date of original purchase, Marvel will repair or replace the following parts, labor not included, that prove to be defecve in

materials or workmanship: compressor, condenser, evaporator, drier, and all connecng tubing. All service provided by Marvel under the above war-

ranty must be performed by a Marvel factory authorized servicer, unless otherwise specied by Marvel. Service provided during normal business

hours.

WARRANTY TERMS

These warranes apply only to products installed in any one of the y states of the United States, the District of Columbia, or the ten provinces of

Canada. The warranes do not cover any parts or labor to correct any defect caused by negligence, accident or improper use, maintenance, instal-

laon, service, repair, acts of God, re, ood or other natural disasters. The product must be installed, operated, and maintained in accordance with

the Marvel User Guide.

The remedies described above for each warranty are the only ones that Marvel will provide, either under these warranes or under any warranty

arising by operaon of law. Marvel will not be responsible for any consequenal or incidental damages arising from the breach of these warranes

or any other warranty, whether express, implied, or statutory. Some states do not allow the exclusion or limitaon of incidental or consequenal

damages, so the above limitaon or exclusion may not apply to you. These warranes give you specic legal rights, and you may also have other

rights which vary from state to state.

Any warranty that may be implied in connecon with your purchase or use of the product, including any warranty of merchantability or any war-

ranty t for a parcular purpose is limited to the duraon of these warranes, and only extends to ve years in duraon for the parts described

in the secon related to the ve year limited warranty above. Some states do not allow limitaons on how long an implied warranty lasts, so the

above limitaons may not apply to you.

• The warranes only apply to the original purchaser and are non-transferable.

• These warranes cover products installed and used for normal residenal use only.

• The warranes apply to units operated outside only if designed for outdoor use by model and serial number.

• Replacement water lters, light bulbs, and other consumable parts are not covered by these warranes.

• The start of Marvel’s obligaon is limited to four years aer the shipment date from Marvel.

• In-home instrucon on how to use your product is not covered by these warranes.

• Food, beverage, and medicine loss are not covered by these warranes.

• If the product is located in an area where Marvel factory authorized service is not available, you may be responsible for a trip charge or

you may be required to bring the product to a Marvel factory authorized service locaon at your own cost and expense.

• Units purchased aer use as oor displays, and/or cered recondioned units, are covered by the limited one year warranty only and no

coverage is provided for cosmec defects.

• Signal issues related to Wi-Fi connecvity are not covered by these warranes.

For parts and service assistance, or to nd Marvel factory authorized service near you, contact Marvel Refrigeraon:

MarvelRefrigeraon.com • techsupport@MarvelRefrigeraon.com • +616.754.5601

1260 E. Van Deinse St., Greenville, MI 48838

Marvel MLCP215-SS01A User manual

Marvel MLCP215-SS01A User manual

Marvel MLCP215-SS01A User manual

Related papers

Other documents