Agri-Fab 45-0464 User manual

Agri-Fab
Brand
Agri-Fab
Model
45-0464
Type
User manual

This manual is also suitable for

PRINTED IN USA
the fastest way to purchase parts
www.speedepart.com
FORM NO. 41153 (02/25/09)
POLY DUMP CART
CHARIOT BASCULANT EN PLASTIQUE
CARRETILLA VOLCADORA DE PLÁSTICO
OWNERS MANUAL
NOTICE D’UTILISATION
MANUAL DEL USUARIO
CAUTION:
Read Rules for
Safe Operation
and Instructions
Carefully
Model No.
Modèle No.
Modelo No.
45-0464
ATTENTION:
Lire et suivre attentivement
les instructions et consignes
de sécurité de cette notice.
PRECAUCION:
Lea cuidadosamente
los Procedimientos e
Instrucciones para la
Operación Segura de la
Máquina.
• Safety
• Assembly
• Operation
• Maintenance
• Parts
• Seguridad
• Montaje
• Operación
• Mantenimiento
• PiezasdeRepuesto
• Sécurité
• Assemblage
• Fonctionnement
• Maintenance
• PiècesdeRechange
™
IMPORTANT!
Addgreasetowheelbearingsbeforeusingcart.
IMPORTANT!
Ajoutezdelagraissesurlesroulementsàbillesavantd’utiliserle
chariot.
¡IMPORTANTE!
Apliquegrasaaloscojinetesdelasruedasantesdeusarla
carretilla
2
SAFETY RULES
Remember,anypowerequipmentcancauseinjuryifoperatedimproperlyoriftheuserdoesnotunderstandhowto
operatetheequipment.Exercisecautionatalltimeswhenusingpowerequipment.
CARTON CONTENTS
LOOK FOR THIS SYMBOL TO POINT OUT
IMPORTANT SAFETY PRECAUTIONS.
IT MEANS — ATTENTION! BECOME
ALERT! YOUR SAFETY IS INVOLVED.
CAUTION: VEHICLE BRAKING AND
STABILITY MAY BE AFFECTED WITH
THE ADDITION OF AN ACCESSORY
OR AN ATTACHMENT. BE AWARE OF
CHANGING CONDITIONS ON SLOPES.
Readthisownersmanualbeforeattemptingtoassembleoroperatethecart.•
Readthevehicleownersmanualandknowhowtooperateyourtractorbeforeusingthecartattachment.•
Donotatanytimecarrypassengersinthiscart.Ithasnotbeendesignedtocarrypassengers.•
Neverallowchildrentooperatethetractororthecartattachment.•
Donotallowadultstooperatethetractororcartattachmentwithoutproperinstructions.•
Alwaysbeginwiththetransmissioninrst(low)andgraduallyincreasespeedasconditionspermit.•
Maximumtowingspeedis10m.p.h.•
Donottowthiscartonhighwaysorpublicthoroughfares.•
Towthecartatreducedspeedoverroughterrainandhillsidesornearcreeksandditchestopreventtippingoverand•
lossofcontrol.Donotdrivetooclosetoacreekorditch.
Vehiclebrakingandstabilitymaybeaffectedwiththeattachmentofthiscart.Donotllcarttomaximumweightcapacity•
withoutcheckingthecapabilityofthetowingvehicletosafelypullandstopwiththecartattached.
Beforeoperatingvehicleonanygrade(hill)refertosafetyrulesinthevehicleowner'smanualconcerningsafeoperation•
onslopes.Referalsototheslopeguideonpage13 ofthismanual.Beawareofchangingconditionsonslopes.Stayoff
steep slopes!
Followmaintenanceandlubricationinstructionsasoutlinedinthismanual.•
1
10
8
3
6
9
4
5
2
7
5
41008
41009
25106
25636
42159
24497
26584
24498
23014
26533
REF DESCRIPTION
1 Tailgate
2 Cart Bed
3 WheelSupport
4 Axle
5 Wheel
REF DESCRIPTION
6 LatchStandBracket
7 HitchBracket
8 Tongue
9 LatchLockBracket
10 StepBracket
3
SHOWN FULL SIZE
NOT SHOWN FULL SIZE
11 12
x1
x1 x2
x1
x1
x1x2
x2
x4
x4
x1
x11
x2
x4
x2x1x8
20
21
23
25
24
26
27
13 14 15
16
17
18
22
19
47407
43840
43001
43182
43661
HA21362
47810
46980
47189
43601
43343
43093
43014
44678
47408
23353
47622
REF DESCRIPTION
11 HexBolt,5/16-18x4"
12 HexBolt,5/16-18x1-1/4"
13 HexBolt,3/8-16x1"
14 HexBolt,5/16-18x3/4"
15 HexBolt,1/4-20x1"
16 NylockNut,3/8"
17 NylockNut,5/16"
18 SimsNut,5/16"
19 NylockNut,1/4"
REF DESCRIPTION
20 Washer,1"
21 HairCotterPin,3/32x2-5/16"
22 CotterPin,1/8x1-1/2"
23 HubCap
24 Spacer,1.03x.25x2.06"
25 ExtensionSpring
26 HitchPin,3/8x3"
27 Spring Puller Tool
4
ASSEMBLY INSTRUCTIONS
Attachthewheelsupport(3)tothemiddleofthecart1.
bed (2) using eight 5/16 x 1-1/4" hex bolts (12) and
5/16"nylocknuts(17).Tighten.
TOOLS REQUIRED FOR ASSEMBLY
(2) 9/16"Wrenches
(2) 1/2"Wrenches
(2) 7/16"Wrenches
(1) Pliers
(1) Grease Gun
FIGURE 1
5/16" NYLOCK NUT
5/16 X 1-1/4"
HEX BOLT
WHEEL
SUPPORT
Assemblethelatchstandbracket(6)tothecartbed2.
usingfour1/4x1"hexbolts(15)and1/4"nylocknuts
(19). Tighten.
FIGURE 2
1/4" NYLOCK
NUT
1/4 X 1"
HEX BOLT
LATCH STAND
BRACKET
Turn cart over and place tongue (8) on latch stand3.
bracket(6)andwheelsupport(3).
Slideaxlethroughwheelsupportandtongue.4.
FIGURE 3
AXLE
TONGUE
Assemble the step bracket (10) to the latch lock5.
bracket (9) usingtwo5/16 x 3/4" hex bolts (14) and
5/16"nylocknuts(17).Tighten.
FIGURE 4
5/16" NYLOCK NUT
LATCH LOCK
BRACKET
STEP BRACKET
5/16 X 3/4"
HEX BOLT
FIGURE 5
5/16" SIMS NUT
EXTENSION SPRING
SPRING PULLER TOOL
5/16" X 4" HEX BOLT
5/16" NYLOCK NUT
Slidethestepbracket(10)andlatchlockbracket(9)into6.
theslotinthetongue(8).
Securethestepbracket(10)andlatchlockbracket(9)to7.
thetongue(8)usinga5/16x4"hexbolt(11),a5/16"sims
nut(18)oneachsideofthebracketsanda5/16"nylocknut
(17).Donotovertightennylocknut,theboltmustpivot.
Attachtheshortendofextensionspring(25)totheholeat8.
thebottomofthelatchlockbracket(9).
Usethespring puller(27)tool to pullthelong end ofthe9.
extensionspring(25)downandattachittothetongue(8).
5
Assembleaspacer(24),a1"washer(20),awheel(5)10.
(valve stemfacing out), andthenanother 1" washer
(20)totheaxle(4).
Securewith a1/8x1-1/2"cotter pin(22),spreading11.
theendsofthecotterpinwithapairofpliersbending
theendsaroundtheaxle.
Presshubcap(23)ontowasheronoutsideofwheel.12.
Add grease13. towheelbearingsusingagreasegun.
Repeatforotherwheel.14.
FIGURE 6
SPACER
WHEEL
1/8 X 1-1/2"
COTTER PIN
1" WASHER
HUB CAP ADD GREASE
FIGURE 7
3/8 X 1"
HEX BOLT
3/8" NYLOCK NUT
HAIR COTTER PIN
HITCH PIN
HITCH
BRACKET
Slidehitchinto slot atend of tongue(8)and secure15.
witha3/8x1"hexbolt(13)and3/8"nylocknut(16).
Assemblehitchpin(26)tohitchbracket(7)andtongue16.
(8)andsecurewithahaircotterpin(21).
OPERATION
CAUTION: Vehicle braking and stability may
be affected with the addition of an accessory
orattachment.Beawareofchangingconditions
on slopes.
DO NOT EXCEED 800 LB. CAPACITY OF CART
One cubic foot of dirt weighs approximately 80 lbs.
Themaximumtowingspeedforthiscartis10m.p.h.1.
Refertovehicleownersmanualforinstructionsonsafe2.
operation on slopes.
Useslopeguideprovidedonpage13ofthismanualto3.
determinewhetheraslopeangleistoosteepforsafe
operation.
Always test to make sure yourtractor has adequate4.
towing and braking capabilities whenever hauling a
substantial amount of weight in yourcart. Use extra
cautionwhenoperatingonslopes.
Forbesthandlingandtraction,distributetheweightof5.
theloadevenlyinthecart.
To dump material from the cart, remove the tailgate6.
from rear of cart and then step down on latch step
bracket.Afteremptying,pullthefrontofthebeddown
towardthecarttongueuntilthelatchsnapsintoplace.
Reinstall tailgate.
CAUTION:Toavoidpossibleinjury,besureno
oneisnearcartbeforereleasinglatch.
CAUTION: DO NOT inate tires beyond the
maximum recommended pressure printed on
side of tire.
MAINTENANCE
Checkforloosefastenersbeforeeachuse.1.
Checkforwornordamagedpartsbeforeeachuse.2.
Keeptireslledtorecommendedtirepressureprinted3.
onthetire.
Atthebeginningofeachseason,usingalightmachine4.
oil,lubricatethelatchandthelatchpivotbolt.
Pumpgreaseintogreasettingsonwheelsperiodically5.
(atleastonceeachseason).
STORAGE
Cleanthoroughlybeforestoring.1.
Removeanyrustfrompaintedsurfacesandcoatwith2.
touchuppaint.
Store in a dry area.3.
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
12
REPAIR PARTS FOR 45-0464 POLY DUMP CART
REF PART NO QTY DESCRIPTION
1 41009 1 Tailgate
2 41008 1 Cart Bed
3 25106 1 WheelSupport
4 25636 1 Axle
5 42159 2 Wheel
6 24497 1 LatchStandBracket
7 23014 1 HitchBracket
8 26584 1 Tongue
9 24498 1 LatchLockBracket
10 26533 1 StepBracket
11 47407 1 HexBolt,5/16-18x4"
12 43840 8 HexBolt,5/16-18x1-1/4"
13 43001 1 HexBolt,3/8-16x1"
14 43182 2 HexBolt,5/16-18x3/4"
REF PART NO QTY DESCRIPTION
15 43661 4 HexBolt,1/4-20x1"
16 HA21362 1 NylockNut,3/8"
17 47810 11 NylockNut,5/16"
18 46980 2 SimsNut,5/16"
19 47189 4 NylockNut,1/4"
20 43601 4 Washer,1"
21 43343 1 HairCotterPin,3/32x2-5/16"
22 43093 2 CotterPin,1/8x1-1/2"
23 43014 2 HubCap
24 44678 2 Spacer,1.03x.25x2.06"
25 47408 1 ExtensionSpring
26 23353 1 HitchPin,3/8x3"
27 47622 1 Spring Puller Tool
41153 1 Owners Manual
9
12
23
10
25
8
7
2
27
11
1
3
4
5
5
6
26
21
22
20
23
22
20
24
20
20
24
17
18
18
14
17
17
15
13
16
19
13
A POWER POLE
A CORNER OF A BUILDING
OR A FENCE POST
FOLD ALONG DOTTED LINE, REPRESENTING A 10 DEGREE SLOPE
SIGHT AND HOLD THIS LEVEL WITH A VERTICAL TREE
SLOPE GUIDE
(Keep this sheet in a safe place for future reference.)
Use this guide to determine if a slope is safe for the operation of your tractor and cart. Refer
also to the instructions in your vehicle owners manual.
CAUTION: DO NOT OPERATE YOUR TRACTOR AND CART ON A SLOPE
IN EXCESS OF 10 DEGREES. BE SURE OF YOUR TRACTOR'S TOWING
AND BRAKING CAPABILITIES BEFORE OPERATING ON A SLOPE.
AVOID ANY SUDDEN TURNS OR MANEUVERS WHILE ON A SLOPE.
14
UN POTEAU ÉLECTRIQUE
LE COIN DE TOUT ÉDIFICE
UN PIQUET DE CLÔTURE
PLIEZ SELON LES POINTILLÉS, REPRÉSENTANT UNE PENTE DE 10 DEGRÉS
PLACEZ CETTE FEUILLE À NIVEAU CONTRE UN ARBRE DROIT
GUIDE DE CALCUL D’UNE PENTE
(Conservez cette feuille en lieu sûr pour référence future.)
.euqromer al ed te ruetcart ertov ed noitasilitu’l ruop eriatirucés tse etnep enu is renimretéd ed nfia ediug ec zesilitU
Voir également les instructions incluses dans votre manuel d’utilisation du tracteur.
-
ATTENTION: NE PAS UTILISER LE TRACTEUR ET LA REMORQUE SUR
UNE PENTE INCLINÉE À PLUS DE 10 DEGRÉS. VÉRIFIEZ LA TRAC
TION ET LE FREINAGE DE VOTRE TRACTEUR AVANT DE CONDUIRE
SUR UNE PENTE. ÉVITEZ TOUTE MANOEUVRE BRUSQUE LORSQUE
VOUS CONDUISEZ SUR UNE PENTE.
15
UN POSTE DE CORRIENTE ELECTRICA O TELEFONO
UNA ESQUINA DE UN EDIFICIO
O UN POSTE DE UNA CERCA
DOBLE LA HOJA A LO LARGO DE LA LINEA PUNTEADA,
LA CUAL REPRESENTA UNA PENDIENTE DE 10 GRADOS
ALINEE LA LINEA VERTICAL DEL EXTREMO IZQUIERDO
DEL GRAFICO CON UN OBJETO VERTICAL EN EL CAMPO, POR EJEMPLO
GUIA DE PENDIENTES
(Mantenga esta guía en un lugar seguro para referencia futura.)
Use esta guía para determinar si la operación de tractor y carrito es segura en una pendiente.
Consulte también las instrucciones en el Manual del Usuario de su vehículo.
PRECAUCION: NO OPERE EL TRACTOR REMOLCANDO EL CARRO
EN UNA PENDIENTE DE MAS DE 10°. VERIFIQUE LA CAPACIDAD
DE SU TRACTOR PARA REMOLCAR Y FRENAR ADECUADAMENTE
ANTES DE OPERAR EN UNA PENDIENTE. EVITE GIROS O
MANIOBRAS BRUSCAS CUANDO OPERA EN UNA PENDIENTE.
©2009Agri-Fab,Inc.
the fastest way to purchase parts
www.speedepart.com
REPAIR PARTS
Agri-Fab,Inc.
809SouthHamilton
Sullivan,IL.61951
217-728-8388
www.agri-fab.com
Thisdocument(ormanual)isprotectedundertheU.S.CopyrightLawsandthecopyrightlawsofforeigncountries,
pursuanttotheUniversalCopyrightConventionandtheBerneconvention.Nopartofthisdocumentmaybereproduced
ortransmittedinanyformorbyanmeans,electronicormechanical,includingphotocopyingorrecording,orbyany
informationstorageorretrievalsystem,withouttheexpresswrittenpermissionofAgri-Fab,Inc.Unauthorizedusesand/or
reproductionsofthismanualwillsubjectsuchunauthorizedusertocivilandcriminalpenaltiesasprovidedbytheUnited
StatesCopyrightLaws.
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16

Agri-Fab 45-0464 User manual

Agri-Fab
Brand
Agri-Fab
Model
45-0464
Type
User manual
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

in other languages

Related papers

Other documents