Agri-Fab HA21362 User manual

Brand: Agri-Fab

Model: HA21362

Type: User manual

This manual is also suitable for

45-0464

PRINTED IN USA

the fastest way to purchase parts

www.speedepart.com

FORM NO. 41153 (02/25/09)

POLY DUMP CART

CHARIOT BASCULANT EN PLASTIQUE

CARRETILLA VOLCADORA DE PLÁSTICO

OWNERS MANUAL

NOTICE D’UTILISATION

MANUAL DEL USUARIO

CAUTION:

Read Rules for

Safe Operation

and Instructions

Carefully

Model No.

Modèle No.

Modelo No.

45-0464

ATTENTION:

Lire et suivre attentivement

les instructions et consignes

de sécurité de cette notice.

PRECAUCION:

Lea cuidadosamente

los Procedimientos e

Instrucciones para la

Operación Segura de la

Máquina.

• Safety

• Assembly

• Operation

• Maintenance

• Parts

• Seguridad

• Montaje

• Operación

• Mantenimiento

• PiezasdeRepuesto

• Sécurité

• Assemblage

• Fonctionnement

• Maintenance

• PiècesdeRechange

™

IMPORTANT!

Addgreasetowheelbearingsbeforeusingcart.

IMPORTANT!

Ajoutezdelagraissesurlesroulementsàbillesavantd’utiliserle

chariot.

¡IMPORTANTE!

Apliquegrasaaloscojinetesdelasruedasantesdeusarla

carretilla

SAFETY RULES

Remember,anypowerequipmentcancauseinjuryifoperatedimproperlyoriftheuserdoesnotunderstandhowto

operatetheequipment.Exercisecautionatalltimeswhenusingpowerequipment.

CARTON CONTENTS

LOOK FOR THIS SYMBOL TO POINT OUT

IMPORTANT SAFETY PRECAUTIONS.

IT MEANS — ATTENTION! BECOME

ALERT! YOUR SAFETY IS INVOLVED.

CAUTION: VEHICLE BRAKING AND

STABILITY MAY BE AFFECTED WITH

THE ADDITION OF AN ACCESSORY

OR AN ATTACHMENT. BE AWARE OF

CHANGING CONDITIONS ON SLOPES.

Readthisownersmanualbeforeattemptingtoassembleoroperatethecart.•

Readthevehicleownersmanualandknowhowtooperateyourtractorbeforeusingthecartattachment.•

Donotatanytimecarrypassengersinthiscart.Ithasnotbeendesignedtocarrypassengers.•

Neverallowchildrentooperatethetractororthecartattachment.•

Donotallowadultstooperatethetractororcartattachmentwithoutproperinstructions.•

Alwaysbeginwiththetransmissioninrst(low)andgraduallyincreasespeedasconditionspermit.•

Maximumtowingspeedis10m.p.h.•

Donottowthiscartonhighwaysorpublicthoroughfares.•

Towthecartatreducedspeedoverroughterrainandhillsidesornearcreeksandditchestopreventtippingoverand•

lossofcontrol.Donotdrivetooclosetoacreekorditch.

Vehiclebrakingandstabilitymaybeaffectedwiththeattachmentofthiscart.Donotllcarttomaximumweightcapacity•

withoutcheckingthecapabilityofthetowingvehicletosafelypullandstopwiththecartattached.

Beforeoperatingvehicleonanygrade(hill)refertosafetyrulesinthevehicleowner'smanualconcerningsafeoperation•

onslopes.Referalsototheslopeguideonpage13 ofthismanual.Beawareofchangingconditionsonslopes.Stayoff

steep slopes!

Followmaintenanceandlubricationinstructionsasoutlinedinthismanual.•

41008

41009

25106

25636

42159

24497

26584

24498

23014

26533

REF DESCRIPTION

1 Tailgate

2 Cart Bed

3 WheelSupport

4 Axle

5 Wheel

REF DESCRIPTION

6 LatchStandBracket

7 HitchBracket

8 Tongue

9 LatchLockBracket

10 StepBracket

SHOWN FULL SIZE

NOT SHOWN FULL SIZE

11 12

x1 x2

x1x2

x11

x2x1x8

13 14 15

47407

43840

43001

43182

43661

HA21362

47810

46980

47189

43601

43343

43093

43014

44678

47408

23353

47622

REF DESCRIPTION

11 HexBolt,5/16-18x4"

12 HexBolt,5/16-18x1-1/4"

13 HexBolt,3/8-16x1"

14 HexBolt,5/16-18x3/4"

15 HexBolt,1/4-20x1"

16 NylockNut,3/8"

17 NylockNut,5/16"

18 SimsNut,5/16"

19 NylockNut,1/4"

REF DESCRIPTION

20 Washer,1"

21 HairCotterPin,3/32x2-5/16"

22 CotterPin,1/8x1-1/2"

23 HubCap

24 Spacer,1.03x.25x2.06"

25 ExtensionSpring

26 HitchPin,3/8x3"

27 Spring Puller Tool

ASSEMBLY INSTRUCTIONS

Attachthewheelsupport(3)tothemiddleofthecart1.

bed (2) using eight 5/16 x 1-1/4" hex bolts (12) and

5/16"nylocknuts(17).Tighten.

TOOLS REQUIRED FOR ASSEMBLY

(2) 9/16"Wrenches

(2) 1/2"Wrenches

(2) 7/16"Wrenches

(1) Pliers

(1) Grease Gun

FIGURE 1

5/16" NYLOCK NUT

5/16 X 1-1/4"

HEX BOLT

WHEEL

SUPPORT

Assemblethelatchstandbracket(6)tothecartbed2.

usingfour1/4x1"hexbolts(15)and1/4"nylocknuts

(19). Tighten.

FIGURE 2

1/4" NYLOCK

NUT

1/4 X 1"

HEX BOLT

LATCH STAND

BRACKET

Turn cart over and place tongue (8) on latch stand3.

bracket(6)andwheelsupport(3).

Slideaxlethroughwheelsupportandtongue.4.

FIGURE 3

AXLE

TONGUE

Assemble the step bracket (10) to the latch lock5.

bracket (9) usingtwo5/16 x 3/4" hex bolts (14) and

5/16"nylocknuts(17).Tighten.

FIGURE 4

5/16" NYLOCK NUT

LATCH LOCK

BRACKET

STEP BRACKET

5/16 X 3/4"

HEX BOLT

FIGURE 5

5/16" SIMS NUT

EXTENSION SPRING

SPRING PULLER TOOL

5/16" X 4" HEX BOLT

5/16" NYLOCK NUT

Slidethestepbracket(10)andlatchlockbracket(9)into6.

theslotinthetongue(8).

Securethestepbracket(10)andlatchlockbracket(9)to7.

thetongue(8)usinga5/16x4"hexbolt(11),a5/16"sims

nut(18)oneachsideofthebracketsanda5/16"nylocknut

(17).Donotovertightennylocknut,theboltmustpivot.

Attachtheshortendofextensionspring(25)totheholeat8.

thebottomofthelatchlockbracket(9).

Usethespring puller(27)tool to pullthelong end ofthe9.

extensionspring(25)downandattachittothetongue(8).

Assembleaspacer(24),a1"washer(20),awheel(5)10.

(valve stemfacing out), andthenanother 1" washer

(20)totheaxle(4).

Securewith a1/8x1-1/2"cotter pin(22),spreading11.

theendsofthecotterpinwithapairofpliersbending

theendsaroundtheaxle.

Presshubcap(23)ontowasheronoutsideofwheel.12.

Add grease13. towheelbearingsusingagreasegun.

Repeatforotherwheel.14.

FIGURE 6

SPACER

WHEEL

1/8 X 1-1/2"

COTTER PIN

1" WASHER

HUB CAP ADD GREASE

FIGURE 7

3/8 X 1"

HEX BOLT

3/8" NYLOCK NUT

HAIR COTTER PIN

HITCH PIN

HITCH

BRACKET

Slidehitchinto slot atend of tongue(8)and secure15.

witha3/8x1"hexbolt(13)and3/8"nylocknut(16).

Assemblehitchpin(26)tohitchbracket(7)andtongue16.

(8)andsecurewithahaircotterpin(21).

OPERATION

CAUTION: Vehicle braking and stability may

be affected with the addition of an accessory

orattachment.Beawareofchangingconditions

on slopes.

DO NOT EXCEED 800 LB. CAPACITY OF CART

One cubic foot of dirt weighs approximately 80 lbs.

Themaximumtowingspeedforthiscartis10m.p.h.1.

Refertovehicleownersmanualforinstructionsonsafe2.

operation on slopes.

Useslopeguideprovidedonpage13ofthismanualto3.

determinewhetheraslopeangleistoosteepforsafe

operation.

Always test to make sure yourtractor has adequate4.

towing and braking capabilities whenever hauling a

substantial amount of weight in yourcart. Use extra

cautionwhenoperatingonslopes.

Forbesthandlingandtraction,distributetheweightof5.

theloadevenlyinthecart.

To dump material from the cart, remove the tailgate6.

from rear of cart and then step down on latch step

bracket.Afteremptying,pullthefrontofthebeddown

towardthecarttongueuntilthelatchsnapsintoplace.

Reinstall tailgate.

CAUTION:Toavoidpossibleinjury,besureno

oneisnearcartbeforereleasinglatch.

CAUTION: DO NOT inate tires beyond the

maximum recommended pressure printed on

side of tire.

MAINTENANCE

Checkforloosefastenersbeforeeachuse.1.

Checkforwornordamagedpartsbeforeeachuse.2.

Keeptireslledtorecommendedtirepressureprinted3.

onthetire.

Atthebeginningofeachseason,usingalightmachine4.

oil,lubricatethelatchandthelatchpivotbolt.

Pumpgreaseintogreasettingsonwheelsperiodically5.

(atleastonceeachseason).

STORAGE

Cleanthoroughlybeforestoring.1.

Removeanyrustfrompaintedsurfacesandcoatwith2.

touchuppaint.

Store in a dry area.3.

Page is loading ...

REPAIR PARTS FOR 45-0464 POLY DUMP CART

REF PART NO QTY DESCRIPTION

1 41009 1 Tailgate

2 41008 1 Cart Bed

3 25106 1 WheelSupport

4 25636 1 Axle

5 42159 2 Wheel

6 24497 1 LatchStandBracket

7 23014 1 HitchBracket

8 26584 1 Tongue

9 24498 1 LatchLockBracket

10 26533 1 StepBracket

11 47407 1 HexBolt,5/16-18x4"

12 43840 8 HexBolt,5/16-18x1-1/4"

13 43001 1 HexBolt,3/8-16x1"

14 43182 2 HexBolt,5/16-18x3/4"

REF PART NO QTY DESCRIPTION

15 43661 4 HexBolt,1/4-20x1"

16 HA21362 1 NylockNut,3/8"

17 47810 11 NylockNut,5/16"

18 46980 2 SimsNut,5/16"

19 47189 4 NylockNut,1/4"

20 43601 4 Washer,1"

21 43343 1 HairCotterPin,3/32x2-5/16"

22 43093 2 CotterPin,1/8x1-1/2"

23 43014 2 HubCap

24 44678 2 Spacer,1.03x.25x2.06"

25 47408 1 ExtensionSpring

26 23353 1 HitchPin,3/8x3"

27 47622 1 Spring Puller Tool

41153 1 Owners Manual

A POWER POLE

A CORNER OF A BUILDING

OR A FENCE POST

FOLD ALONG DOTTED LINE, REPRESENTING A 10 DEGREE SLOPE

SIGHT AND HOLD THIS LEVEL WITH A VERTICAL TREE

SLOPE GUIDE

(Keep this sheet in a safe place for future reference.)

Use this guide to determine if a slope is safe for the operation of your tractor and cart. Refer

also to the instructions in your vehicle owners manual.

CAUTION: DO NOT OPERATE YOUR TRACTOR AND CART ON A SLOPE

IN EXCESS OF 10 DEGREES. BE SURE OF YOUR TRACTOR'S TOWING

AND BRAKING CAPABILITIES BEFORE OPERATING ON A SLOPE.

AVOID ANY SUDDEN TURNS OR MANEUVERS WHILE ON A SLOPE.

UN POTEAU ÉLECTRIQUE

LE COIN DE TOUT ÉDIFICE

UN PIQUET DE CLÔTURE

PLIEZ SELON LES POINTILLÉS, REPRÉSENTANT UNE PENTE DE 10 DEGRÉS

PLACEZ CETTE FEUILLE À NIVEAU CONTRE UN ARBRE DROIT

GUIDE DE CALCUL D’UNE PENTE

(Conservez cette feuille en lieu sûr pour référence future.)

.euqromer al ed te ruetcart ertov ed noitasilitu’l ruop eriatirucés tse etnep enu is renimretéd ed nﬁa ediug ec zesilitU

Voir également les instructions incluses dans votre manuel d’utilisation du tracteur.

ATTENTION: NE PAS UTILISER LE TRACTEUR ET LA REMORQUE SUR

UNE PENTE INCLINÉE À PLUS DE 10 DEGRÉS. VÉRIFIEZ LA TRAC

TION ET LE FREINAGE DE VOTRE TRACTEUR AVANT DE CONDUIRE

SUR UNE PENTE. ÉVITEZ TOUTE MANOEUVRE BRUSQUE LORSQUE

VOUS CONDUISEZ SUR UNE PENTE.

UN POSTE DE CORRIENTE ELECTRICA O TELEFONO

UNA ESQUINA DE UN EDIFICIO

O UN POSTE DE UNA CERCA

DOBLE LA HOJA A LO LARGO DE LA LINEA PUNTEADA,

LA CUAL REPRESENTA UNA PENDIENTE DE 10 GRADOS

ALINEE LA LINEA VERTICAL DEL EXTREMO IZQUIERDO

DEL GRAFICO CON UN OBJETO VERTICAL EN EL CAMPO, POR EJEMPLO

GUIA DE PENDIENTES

(Mantenga esta guía en un lugar seguro para referencia futura.)

Use esta guía para determinar si la operación de tractor y carrito es segura en una pendiente.

Consulte también las instrucciones en el Manual del Usuario de su vehículo.

PRECAUCION: NO OPERE EL TRACTOR REMOLCANDO EL CARRO

EN UNA PENDIENTE DE MAS DE 10°. VERIFIQUE LA CAPACIDAD

DE SU TRACTOR PARA REMOLCAR Y FRENAR ADECUADAMENTE

ANTES DE OPERAR EN UNA PENDIENTE. EVITE GIROS O

MANIOBRAS BRUSCAS CUANDO OPERA EN UNA PENDIENTE.

the fastest way to purchase parts

www.speedepart.com

REPAIR PARTS

Agri-Fab,Inc.

809SouthHamilton

Sullivan,IL.61951

217-728-8388

www.agri-fab.com

Thisdocument(ormanual)isprotectedundertheU.S.CopyrightLawsandthecopyrightlawsofforeigncountries,

pursuanttotheUniversalCopyrightConventionandtheBerneconvention.Nopartofthisdocumentmaybereproduced

ortransmittedinanyformorbyanmeans,electronicormechanical,includingphotocopyingorrecording,orbyany

informationstorageorretrievalsystem,withouttheexpresswrittenpermissionofAgri-Fab,Inc.Unauthorizedusesand/or

reproductionsofthismanualwillsubjectsuchunauthorizedusertocivilandcriminalpenaltiesasprovidedbytheUnited

StatesCopyrightLaws.

Agri-Fab HA21362 User manual

Brand: Agri-Fab

Model: HA21362

Type: User manual

This manual is also suitable for

45-0464

Download PDF

report

in other languages

français: Agri-Fab HA21362 Manuel utilisateur
español: Agri-Fab HA21362 Manual de usuario

Agri-Fab HA21362 User manual

This manual is also suitable for

Agri-Fab HA21362 User manual

in other languages

Related papers

Other documents