Primera LX2000 Owner's manual



LX2000/LX1000VacuumTubeMaintenanceKitandInkPadReplacement 

TheLX2000hasavacuumsystemtocarryexcessinkoversprayintotheinksaturationpads.Depending

onhowoftentheprinterisused,someinkcanbuildupinsidethetubeopeningandeventuallyblockthe

vacuumtubeopening.InkPadscanalsobecomesaturatedovertimeandshouldbe

replaced.

TubeCleaningMaintenanceInterval:Performthismaintenanceevery10,000printsoratthefirstsign

ofanyinkbuildupontheinternalmechanism.Ifyoustarttoseea magentafogonanyoftheinternal

components,thismaintenanceshouldbedoneregardlessofhowmanyprintshave

beensenttothe

printer.

InkPadMaintenanceInterval:50,000prints

MaintenanceKitPartNumber:661380–Purchaseonwww.primera.com

Kitincludes:Inkpadtraywith2xsaturationpads,1xcleartubetocleanthevacuumtubeopening.

1. OpentheCover



2. LocatetheblackInkcapturebin.



3. Liftthelatch(1)andpullthecoverforward(2).







4. Lookforthetubeopeningbehindthesmallplasticbarrier.Youmayneedtouseaflashlightto

seetheopening.



5. Locatethecleartubeincludedwiththekit.Thetubeisjustsmallenoughtofitinsidethe

vacuumtube.Insertthetubeinto thevacuumtubeopening.Tip!Userubberglovesforthis

part.



6. Pushthetubeasfarasyoucanwhilestillholdingitwithyourfingers.



7. Removethetube.Itshouldbefullofblack

ink.Onecleaningisusuallyenough.

However,youmaywashthetubeandrepeat

thecleaningimmediately,savethetubefor

repeatuse

ordiscarditafteruse.



8. ReplacetheInkCaptureBinCover.



9. Finallyreplacetheinkpadsaturationtrayby

pushingdownonthereleasepinandpulling

thedrawerout.



Note:Thenewtrayhasonly2saturationpads

insteadof3.Thiswasdonetoprevent

blockageofdrainholesinsidethecapturebin.

Primera LX2000, LX1000/LX2000 Owner's manual

Related papers

Other documents