Zebex Z-3190BT User manual

AdvancedHandheldHigh‐SpeedLaserScanner1



WirelessHandheldGunTypeScanner

i

USER’SMANUAL

RevisionHistory

Changestotheoriginalmanualarelistedbelow:

Version Date DescriptionofVersion

1.0 11/01/2012 Initialrelease

1.1 11/07/2013 Addedwirelessdongleinaccessories

1.2 08/06/2014 Removedwirelessdongle

1.3 06/23/2017 UpdatedHIDparingprocedures

1.4 2017/8/2 Newbatteryinformation

1.5 2018/6/20 RemovedCDasincludeditem

1.6 2018/12/20 Updatedintercharacterdelayset tings



WirelessHandheldGunTypeScanner

ii

USER’SMANUAL

ImportantNotice

Nowarrantyofanykindismadeinregardtothismaterial,including,butnotlimitedto,

impliedwarrantiesofmerchantabilityorfitnessforanyparticularpurpose.Wearenot

liableforanyerrorscontainedhereinnorforincidentalorconsequentialdamagesin

connectionwithfurnishing,performanceoruseofthismat

erial.Weshallbeunderno

liabilityinrespectofanydefectarisingfromfairwearandtear,willfuldamage,

negligence,abnormalworkingconditions,failuretofollowtheinstructionsandwarnings,

ormisuseoralterationorrepairoftheproductswithoutwrittenapproval.Nopartofthis

documentmaybereproduced,tra

nsmitted,storedinaretrievalsystem,transcribed,or

translatedintoanyhumanorcomputerorotherlanguageinanyformorbyanymeans

electronic,mechanical,magnetic,optical,chemical,biological,manualorotherwise,

exceptforbriefpassageswhichmaybequotedforpurposesofscholasticorliterary

review,withoutexpresswrittencon

sentandauthorization.Wereservetherighttomake

changesinproductdesignwithoutreservationandwithoutnotification.Thematerialin

thisguideisforinformationonlyandissubjecttochangewithoutnotice.Alltrademarks

mentionedherein,registeredorotherwise,arethepropertiesoftheirvarious,ill,

assortedowners.

GeneralHandlingPrecautions



Donotdisposethescannerinfire.

Donotputthescannerdirectlyinthesunorbyanyheatsource.

Donotuseorstorethescannerinaveryhumidplace.

Donotdropthescannerorallowittocollideviolentlywithotherobjects.

Donottakethescannera

partwithoutauthorization



GuidanceforPrinting



ThismanualisinA5size.Pleasedoublecheckyourprintersettingbeforeprintingitout.

Whenthebarcodesaretobeprintedoutforprogramming,theuseofahigh‐resolution

laserprinterisstronglysuggestedforthebestscanresult.



Copyright©2018.Allrightsreserved.



WirelessHandheldGunTypeScanner

iii

USER’SMANUAL



RadioNotice

Thisequipmentgeneratesusesandcanradiateradiofrequencyenergy.Ifnotinstalled

andusedinaccordancewiththeinstructionsinthismanual,itmaycauseinterferenceto

radiocommunications.Theequipmenthasbeentestedandfoundtocomplywiththe

limitsforaClassAcomputingdevicepursuanttoEN55022and47CFR,Pa

rt2andPart15

of the FCC rules.These specifications are designed  to provide reasonable protection

againstinterferencewhenoperatedinacommercialenvironment.



RadioandTelevisionInterference

Operation of this equipment in a residential area can cause interference to radio or

television reception.This can be determined by turning the equipment off and on.

Theuserisencouragedtotrytocorrecttheinterferencebyoneormoreofthefollowing

measures:

‐Reorientthereceivingantenna.

‐Relocatethede

vicewithrespecttothereceiver.

‐Movethedeviceawa yfromthereceiver.

‐ Plug the device into a different outlet so that the device and the receiver are on

differentbranchcircuits.

If necessary the user may consult the manufacturer, and authorized dealer, or

experienced radio/television technician for additional sug

gestions.The user may find

the following booklet prepared by the Federal Communications Commission helpful:

“HowtoIdentifyandResolveRadio‐TVInterferenceProblems.”Thisbookletisavailable

from the U.S. Government Printing Office, Washington, DC 20402 U.S.A., Stock No.

004000003454.



LaserSafety

Thisequipmentgenerates,uses,andcanradiateradiofrequencyenergy.Ifnotinstalled

andusedinaccordancewiththeinstructionsinthismanual,itmaycauseinterferenceto

radiocommunications.Theequipmenthasbeentestedandfoundtocomplywiththe

limitsforaClassAcomputingdevicepursuanttoEN55022an

d47CFR,Part2andPart15

ofFCCRules.Thesespecificationsaredesignedtoprovidereasonableprotectionagainst

interferencewhenoperatedinacommercialenvironment.

RadiantEner gy:Thelaserscannerusesonelow‐powervisiblelaserdiodesoperatingat

650nminanopto‐mechanicalscannerresultinginlessthan3.9μWradiatedpoweras

observedthrougha7mmapertureandaveragedover10seconds.

Donotattempttoremovetheprotectivehousingofthescanner,asun

scannedlaserlight

withapeakoutputupto0.8mWwouldbeaccessibleinside.



WirelessHandheldGunTypeScanner

iv

USER’SMANUAL

LaserLightViewing:Thescanwindowistheonlyaperturethroughwhichlaserlightmay

beobservedfromthisproduct.Afailureofthescannerengine,whilethelaserdiode

continuestoemitalaserbeam,maycauseemissionlevelstoexceedthoseforsafe

operation.Thescannerhassafeguardstopr

eventthisoccurrence.If,however,a

stationarylaserbeamisemitted,thefailingscannershouldbedisconnectedfromits

powersourceimmediately.

Adjustments:Donotattemptanyadjustmentsoralterationofthisproduct.Donot

removetheprotectivehousingofthescanner.Therearenouser‐serviceablepartsinside.

Optical:Theuseofopticalinstrumentswiththisproductwillincreasetheeyehazard.

Opticalinstrumentsincludebinoculars,magnifyingglasses,andmicroscopesbutdonot

includenormaleyeglasseswornbytheuser.

CAUTION:Useofcontrolsoradjustmentsorperformanceofproceduresotherthanthose

specifiedhereinmayresultinhazardousradiationexposure.

ForCE‐Countries

ThisscannerisinconformitywithCEstandards.Pleasenotethatanapproved,CE‐marked

powersupplyunitshouldbeusedinordertomaintainCEconformance.



WirelessCommunication

 Wirelesstechnologyoperates100M/75Mwithcommunicationcradle. Maximumcommunication

rangemayvarydependingonobstacles(person,metal,wall,etc.)orelectromagneticenvironment.

 Thefollowingconditionsmayaffectthesensitivityofwirelesscommunication.

 Thereisanobstaclesuchasaperson,metal,orwallbetweenthisunitandwirelessde

vice.

 Adeviceusing2.4GHzfrequency,suchasawirelessLANdevice,cordlesstelephone,or

microwaveoven,isinusenearthisunit.

 BecausewirelessdevicesandwirelessLAN(IEEE802.11b/g)usethesamefrequency,microwave

interferencemayoccurandresultingincommunicationspeeddeterioration,noise,orinvalidconne

ction

ifthisunitisusednearawirelessLANdevice.Insuchacase,performthefollowing.

 Usethisunitatleast10m(about30ft)awayfromthewirelessLANdevice.

 Ifthisunitisusedwithin10m(about30ft)ofawi

relessLANdevice,turnoffthewirelessLAN

device.

 Installthisunitandwirelessdeviceasneartoeachotheraspossible.

 Microwavesemittingfromawirelessdevicemayaffecttheoperationofelectronicmedicaldevices.

Turnoffthisunitandotherwirelessdevicesinthefollowinglocations,asitmaycauseanaccident.

 Whe

reinflammablegasispresent,inahospital,train,airplane,orapetrolstation

 Nearautomaticdoorsorafirealarm

 Thisunitsupportssecuritycapabilitiesthatcomplywiththewirelessstandardtoprovideasecure

connectionwhenthewirelesstechnologyisused,butse

curitymaynotbeenoughdependingonthe

setting.Becarefulwhencommunicatingusingwirelesstechnology.

 Wedonottakeanyresponsibilityfortheleakageofinformationduringwirelesscommunication.

 Connectionwithallwirelessdevicescannotbeguaranteed.



WirelessHandheldGunTypeScanner

v

USER’SMANUAL

 Adevicefeaturingwirelessfunctionisrequiredtoconformtothewirelessstandardspecifiedby

wirelessSIG,andbeauthenticated.

 Eveniftheconnecteddeviceconfo rmstotheabovementionedwirelessstandard,somedevices

maynotbeconnectedorworkcorrectly,dependingonthefeaturesorspecificationsofthe

device.

 Dependingonthedevicetobeconn

ected,itmayrequiresometimetostartcommunication.



Tipstohelpimproveyourwirelessnetwork



1.Positiontheaccesspoint(host/cradle)inarelativelyemptyspaceatcentrallocation.

Whenpossible,placetheaccesspointinacentrallocationonthehighground(1morabove).Ifyouraccess

pointisagainstanoutsidewall,thesignalwillbeweakontheothersideoftheroo

m.



2.Movetheaccesspoint(host/cradle)offthefloorandawayfromwallsandmetalobjects(suchasmetalfile

cabinets).Metalobjects,walls,andfloorswillinterferewithyourwirelesssignals.Thecloseryouraccess

pointistotheseobstructions,themoreseveretheinterference,andtheweakeryourconnectionwillbe.



3.Redu

cewirelessinterference.

Themostcommonwirelesst echnology,802.11g(wireless‐G),operatesatafrequencyof2.4gigahertz(GHz).

Manycordlessphones,microwaveovens,hospitalequipments,refrigerator,LED,andotherwireless

electronicsalsousethisfrequency.Ifyouusethesewirelessdevicesinyouroffice,yourdevicemi

ghtnotbe

ableto"hear"thesignalsoverthenoisecomingfromthem.

XBadhostplacement OGoodhostplacement

Atleast1m

XBadhostplacement OGoodhostplacement



WirelessHandheldGunTypeScanner

vi

USER’SMANUAL

Ifyournetworkuseswireless‐G,youcanquiet thenoisebyavoidingwirelessele ctronicstha t usethe2.4

GHzfrequency.Instead,lookforcordlessphonesandotherdevicesthatusethe5.8GHzor900megahertz

(MHz)frequencies.Because802.11n(wireless‐N)operatesatboth2.4GHzandthelessfreq

uentlyused5.0

GHzfrequency,youmayexperiencelessinterferenceonyournetworkifyouusethistechnology.



4.Updatethefirmwareordriverofyourwirelessdongle.

Ifyouareusingawirelessdongleorothersimilardevicestomaketheconnection,gettingthelatest

firmwareordriverupdatesmayimprovetheperformance.Visityourmanufacturer’swebsiteforthe

updates.



BatteryInformation

 UseonlyaZEBEXapprovedbatteries.

 Usinganyothertypeofbatteryandchargingequipmentmaydamagethe

deviceandinvalidatethewarranty.

 Storebatteriesathalfoffullchargeinadry,coolplace,removedfromthe

equipmenttopreventlossofcapacity,rustingofmetallicpartsan

d

electrolyteleakage.

 Whenbatteriesarestoredoversix(6)months,someirreversible

deteriorationinoverallbatteryqualitymayoccur.

 Whenstoringbatteriesforoverayear,thechargelevelshouldbeverifiedat

leastonceevery6monthsandchargedtohalfoffullcharge.

BattySafety

 Theareainwhichtheunitsarechargedshouldbeclearofdebrisand

combustiblematerialsorchemicals. Particularcareshouldbetakenwhere

thedeviceischargedinanon‐commercialenvironment.

 Followbatteryusage,storage,andchargingguidelinesfoundintheuser

guide.

 Improperbatteryusema

yresultinafire,explosion,orotherhazard.

 Tochargethedevicebattery,thebatteryandchargertemperaturemustbe

between0°C~+45°C

 Donotuseincompatiblebatteriesandchargers.Useofanincompatible

batteryorchargermaypresentariskoffire,explosion,leakage, orthe

ha

zard.

Avoidpossiblewirelessinterference



WirelessHandheldGunTypeScanner

vii

USER’SMANUAL

 Donotdisassembleoropen,crush,bendordeform,puncture,orshred.

 Severeimpactfromdroppinganybattery‐operateddeviceonahardsurface

couldcausethebatterytooverheat.

 Donotshortcircuitabatteryorallowmetallicorconductiveobjectsto

contactthebatteryterminals.

 Dono

tmodifyorremanufacture,attempttoinsertforeignobjectsintothe

battery,immerseorexposetowaterorotherliquids,orexposetofire,

explosion,orotherhazard.

 Donotlea veorstoretheequipmentinornearareasthatmightgetveryhot,

suchasinaparkedve

hicleorneararadiatororotherheatsource.Donot

placebatteryintoamicrowaveovenordryer.

 Batteryusagebychildrenshouldbesupervised.

 Pleasefollowlocalregulationstopromptlydisposeofusedre‐chargeable

batteries.

 Donotdisposeofbatteriesinfire.

 Seekme

dicaladviceimmediatelyifabatteryhasbeenswallowed.Inthe

eventofabatteryleak,donotallowtheliquidtocomeincontactwiththe

skinoreyes.Ifcontacthasbeenmade,washtheaff ecte dar eawithlarge

amountsofwaterandseekmedicaladvice.

 Donotshortth

ebatteryterminals.Thebatterycouldoverheat.

 Donotattempttosplitorpeeltheoutercasing.



BatteryMaintenance

Thesearerecommendationstoextendthelifeofthebatterypack:

 Whenchargingthebatteryforthefirsttime,chargeforatleast12hoursprior

touse.

 Removethebatteryifthedeviceisnotgoingtobeusedforalongtime.Ifthe

batteryisleftu

nusedformorethan3months,youneedtochargethe

batterybeforeuse.

 Ifthebatteryisnotinstalled,rechargethebatteryevery6monthstoprevent

damagetothebatterycells.

 Thebatterycapacityisreducedattemperatureextremes,highandlow.



WirelessHandheldGunTypeScanner

viii

USER’SMANUAL

TableofContents

ImportantNotice..................................................................................................................ii

GeneralHandlingPrecautions..............................................................................ii

GuidanceforPrinting ........................................................................................... ii

LaserSafety ......................................................................................................... iii

ForCE‐Countries.................................................................................................. iv

WirelessCommunication.................................................................................... iv

BatteryInformation............................................................................................. vi

BattySafety ......................................................................................................... vi

BatteryMaintenance ......................................................................................... vii

Introduction .........................................................................................................................1

ProductOverview ........................................................................................................2

Scanner ................................................................................................................2

Cradle ...................................................................................................................2

ScannerandAccessories..............................................................................................3

BatteryInstallation.......................................................................................................4

InstallingCableClip ......................................................................................................5

ConnectingtheCradle..................................................................................................6

ConnectingtheCradle..................................................................................................7

ChargingtheBattery ....................................................................................................8

PowerontheScanner..................................................................................................9

HowtoScan ...............................................................................................................10

RadioCommunicationHostType...............................................................................11

CradleHostMode ..............................................................................................11

SPPMaster/SPPSlaveMode ..............................................................................11

HIDMode ...........................................................................................................11

PagingtheScanner.....................................................................................................12

ScannerUSBonlinetoHost .......................................................................................12

USBOnlineMode ...............................................................................................12

VisibleIndicators ........................................................................................................13

Scanner ..............................................................................................................13

Cradle .................................................................................................................14

SoundIndicators ........................................................................................................14

ACK/NAKProtocolorFramePacking..........................................................................15

ScannertoRemoteApplication..................................................................................16

Pin‐outConfiguration.................................................................................................18

CablePin‐out..............................................................................................................19

ProgrammingGuide ...........................................................................................................20

ConnectingtoaHost..................................................................................................24

CradleHostMode ..............................................................................................25

WirelessMode ...................................................................................................26

DataTransnitMethod ........................................................................................33

SystemFunctionSettings ...........................................................................................36

DataEditing........................................................................................................85

Appendix1:USBVirtualCOMDriverInstallation ..............................................93

Appendix2:BarcodeLengthSetting ..................................................................94



WirelessHandheldGunTypeScanner

1

USER’SMANUAL

Introduction

ThisscannerisaguntyperuggedwirelessCCD/Laserbarcodescannerwithastateof

theartscanengine.Featuringasuperbscanningspeedandabletowithstand1.5

meterdrop,itisidealformanufacturingandlogisticsectors.

Thecradle,adongle,ordeviceswithwirelesstechnologycanbethehos

tofthis

scanner.Allscanneddataareinstantlytransferredtotheconnectedhostina100‐

meterconnectionrangeinopenspaceor75‐meterrangeinindoorenvironments(the

actualcommunicationrangemayvaryduetodifferentindoorplacement).Thisfeature

eliminateshazardouscablesandcreatesasaferwo

rkenvironment.

Eitherscanninginthehandheldorhands‐freemode,thisscanneralwaysoffersahigh‐

accuracyandreliablescanningability.Thisscannerwouldbeyourtrustedtool

scanningpartner.



KeyFeatures:

 Superbscanning ability

 Proprietaryhardwaredecodingtechnology

 100Mlong‐rangewirelessconnection

 Ruggedan

dergonomicformfactor

 Flexiblecommunications



WirelessHandheldGunTypeScanner

2

USER’SMANUAL

MetalCharging

Contact s

ProductOverview



Scanner



Cradle



Function

Trigger/LED

indicator

Charging

Contact s

Host

Connector

DCPower

Connector

LEDIndicator

Buzzer

Trigger

CableConnector

ExitWindow

StrapHole

Bluetooth

AddressLabel



WirelessHandheldGunTypeScanner

3

USER’SMANUAL

ScannerandAccessories

The scannerpackagecontains: 

Wirelessscannerwithbattery/

Scannercradle(optional)



(withcradle)



(withoutcradle)

Li‐ionbatterypack



Communicationcableforcradle

(optional)



MiniUSBBtominiUSBAcable



5VUSBPoweradapter



Cableclip



Ifanycontentsaredamagedormissing,pleasecontactyourdealerimmediately.



WirelessHandheldGunTypeScanner

4

USER’SMANUAL

BatteryInstallation

InstallingBatteries

Therechargeablebatteriesarepackedindividuallyforshippingsafety.

Pleasefollowthestepsbelowtoinstallthebatteries.



Always use the rechargeable batteries provided by the manufacturer to

avoidany non‐compatibledangerorvoidthewarranty .



1. Unscrewthecapfromthebatterycompartmentatthebottomofthes

cannerand

insertthebattery.



2. Makesuretheredtagonthebatteryistuggedinandnotblockingthecable

connectorandclosethecap.



3. Tightenthescrewonthecaptosecurethebattery.



WirelessHandheldGunTypeScanner

5

USER’SMANUAL

InstallingCableClip

CableclipisusedtoholdtheminiUSBcableinUSBOnlineMode.Withthecableclip,you

caneasilytransformyourwirelessscannerintoawiredone.



AttachingCableClip



1. Insertthecablecliptothestrapholeasshown.



2. Gen tlyturnthecableclipcounter‐clockwiseandpushthecableclipalltheway

throughthestraphole.



3. Attachthebottompartofthecablecliptothescannerhandle.



4. InserttheUSBcableasillustratedbelow.



WirelessHandheldGunTypeScanner

6

USER’SMANUAL



RemovingCableClip



1. Detachthecablefromtheclipanddetachthebottompartofthecableclipfrom

thescannerhandle.



2. Unhooktheleftpartofthecableclipfromthestrapholethenturnitclockwise.

Whileinturningmotion,pushthecableclipallthewaythrough.



3. Removethecableclipfromthestraphole.



WirelessHandheldGunTypeScanner

7

USER’SMANUAL

ConnectingtheCradle

Thecradlehostfeatureswirelesstechnologyandisdesignedtosupportradio

communicationtothescanner.Itcanbeusedforbothbatterychargingandradio

communication.



1. Take the desirable interface cable and insert the RJ‐45 connector on the

bottom of the cradle. You will hear a clear and short “

click” sound; then

connecttheotherendtothehost.

2. ConnecttheincludedUSBcabletominiUSBportatthebottomofthecradle

andconnectotherendtoUSBpoweradaptor.

3. ConnecttheUSBpoweradaptorintoACoutlet.TheLEDindicatoronthe

cradleshouldf

lashblueuntilitmadeconnectionwiththescanner.



 WhenusingKeyboardwedgeandUSBinterfaceforcradle

communication,itisnotnecessarytohaveanexternalpoweradapterif

hosthassufficientpower.Buttheseinterfacesneedexternalpower

adapterwhenchargingbatteries.

 TheminiUSBportonthebottomofthecradleshouldonlybeconnected

usingtheUS

Bpoweradaptor.PleasedonotconnecttheUSBcabletoa

PChostforchargingwhenusingthecradle.



MiniUSBBto

USBpower

adaptoronly

Communication

cable



WirelessHandheldGunTypeScanner

8

USER’SMANUAL

ChargingtheBattery

Thescannerofferstwodifferentwaystochargethebattery:USBCableorCradle.

Tochargethebatteryusingthecra dle:



1. Connectthecradle.PleaseseeConnectingth

eCradlesectionformoredetails.

2. Placethescanneronthecra dle.Youwillhearashortbeepsoundfromthe

scannerindicatingscannerisincontactwiththecradle.

3. ThebatterybeginschargingwhenthescannerLEDindicatorstartsflashing

green.

LEDturnssteadygreenwhenchargingiscomplete.



Approx.chargingtime:4.5hours

TochargethebatteryusingtheUSBcable:



TherearetwomethodtochargescannerviaUSBcable.

 HostUSBPower

 Poweradapt or

1. ConnecttheminiUSBconnectordirectlytothescanner.

2. ConnecttheotherendoftheUSBconnectortothehosttobegincharging.

YoucanalsoconnecttheUSBcabletoanou

tletusingthepoweradapterto

chargethebattery.

3. ThebatterybeginschargingwhenthescannerLEDindicatorstartsflashing

green.

LEDturnssteadygreenwhenchargingiscomplete.



WirelessHandheldGunTypeScanner

9

USER’SMANUAL



Approx.chargingtime:5~6hours



 Thescannerwillpoweronautomaticallywhencharging.

 Batteriesshippedmaynotbefullchargedandshouldbefully

chargedformaximumchargecapacity.

 Recommendedchargingenvironmentistemperaturein0°C~35°C(32°

F~95°F).



PowerontheScanner

1. Ensurethebatteryisfullycharged.Pleaserefertotheprevioussectionto

chargethebattery.

2. Pressandholdthetriggerfor1seconduntilalongbeepsoundisheardto

turnonthescanner.



WirelessHandheldGunTypeScanner

10

USER’SMANUAL

HowtoScan

Therearetwowaystoscanwiththisdevice.

 Handheldscanning

 Presentationscanning

Handheldscanning



1. Poweronthescanner.

2. Pressthetriggerandaimatthebarcodeasillustrated.

3. Whendecodingissuccessful,thescannerbeepsandtheLEDindicatesblue.







PresentationScanning



1. Putthescannerintothecradleforpresentationscanning.

2. Movethebarcodelabelapproachthescannerscanningzone.

3. Whendecodingissuccessful,thescannerbeepsandtheLEDindicatesblue.



Page is loading ...

Zebex Z-3190BT, Z-3191BT User manual

Related papers

Other documents