Zebex Z-3051HS (U)(B) Specification

AdvancedHandheldHigh‐SpeedLaserScanner1



AdvancedHandheldHigh‐SpeedLaserScanner

i

USER’SMANUAL

RevisionHistory

Changestotheoriginalmanualarelistedbelow:

Version Date DescriptionofVersion

1.0 Jun.25,2010 Initialrelease

1.1 Sep.07,2010 Addconfigurationbarcodevalue.

AddsettingsofCode11,Standard2of5,Industrial2

of5,Telepen,Matrix2of5.



AdvancedHandheldHigh‐SpeedLaserScanner

ii

USER’SMANUAL

ImportantNotice

Nowarrantyofanykindismadeinregardtothismaterial,including,butnotlimitedto,

impliedwarrantiesofmerchantabilityorfitnessforanyparticularpurpose.Wearenot

liableforanyerrorscontainedhereinnorforincidentalorconsequentialdamagesin

connectionwithfurnishing,performanceoruseofthismat

erial.Weshallbeunderno

liabilityinrespectofanydefectarisingfromfairwearandtear,willfuldamage,

negligence,abnormalworkingconditions,failuretofollowtheinstructionsandwarnings,

ormisuseoralterationorrepairoftheproductswithoutwrittenapproval.Nopartofthis

documentmaybereproduced,tra

nsmitted,storedinaretrievalsystem,transcribed,or

translatedintoanyhumanorcomputerorotherlanguageinanyformorbyanymeans

electronic,mechanical,magnetic,optical,chemical,biological,manualorotherwise,

exceptforbriefpassageswhichmaybequotedforpurposesofscholasticorliterary

review,withoutexpresswrittencon

sentandauthorization.Wereservetherighttomake

changesinproductdesignwithoutreservationandwithoutnotification.Thematerialin

thisguideisforinformationonlyandissubjecttochangewithoutnotice.Alltrademarks

mentionedherein,registeredorotherwise,arethepropertiesoftheirvarious,ill,

assortedowners.

GeneralHandlingPrecautions



Donotdisposethescannerinfire.

Donotputthescannerdirectlyinthesunorbyanyheatsource.

Donotuseorstorethescannerinaveryhumidplace.

Donotdropthescannerorallowittocollideviolentlywithotherobjects.

Donottakethescannera

partwithoutauthorization



GuidanceforPrinting



ThismanualisinA5size.Pleasedoublecheckyourprintersettingbeforeprintingitout.

Whenthebarcodesaretobeprintedoutforprogramming,theuseofahigh‐resolution

laserprinterisstronglysuggestedforthebestscanresult.



Copyright©2010.Allrightsreserved.



AdvancedHandheldHigh‐SpeedLaserScanner

iii

USER’SMANUAL

LaserSafety



Thisequipmentgenerates,uses,andcanradiateradiofrequencyenergy.Ifnotinstalled

andusedinaccordancewiththeinstructionsinthismanual,itmaycauseinterferenceto

radiocommunications.Theequipmenthasbeentestedandfoundtocomplywiththe

limitsforaClassAcomputingdevicepursuanttoEN55022an

d47CFR,Part2andPart15

ofFCCRules.Thesespecificationsaredesignedtoprovidereasonableprotectionagainst

interferencewhenoperatedinacommercialenvironment.

RadiantEner gy:Thelaserscannerusesonelow‐powervisiblelaserdiodesoperatingat

650nminanopto‐mechanicalscannerresultinginle ssthan3.9μWradiatedpoweras

observedthrougha7mmapertureandaveragedover10seconds.

Donotattempttoremovetheprotectivehousingofthescanner,asun

scannedlaserlight

withapeakoutputupto0.8mWwouldbeaccessibleinside.

LaserLightViewing:Thescanwindowistheonlyaperturethroughwhichlaserlightmay

beobservedfromthisproduct.Afailureofthescannerengine,whilethelaserdiode

continuestoemitalaserbeam,maycauseemissionlevelstoexceedthoseforsafe

operation.Thescannerhassafeguardstopr

eventthisoccurrence.If,however,a

stationarylaserbeamisemitted,thefailingscannershouldbedisconnectedfromits

powersourceimmediately.

Adjustments:Donotattemptanyadjustmentsoralterationofthisproduct.Donot

removetheprotectivehousingofthescanner.Therearenouser‐serviceablepartsinside.

Optical:Theuseofopticalinstrumentswiththisproductwillincreasetheeyehazard.

Opticalinstrumentsincludebinoculars,magnifyingglasses,andmicroscopesbutdonot

includenormaleyeglasseswornbytheuser.

CAUTION:Useofcontrolsoradjustmentsorperformanceofproceduresotherthanthose

specifiedhereinmayresultinhazardousradiationexposure.

ForCE‐Countries

ThisscannerisinconformitywithCEstandards.Pleasenotethatanapproved,CE‐marked

powersupplyunitshouldbeusedinordertomaintainCEconformance.



AdvancedHandheldHigh‐SpeedLaserScanner

iv

USER’SMANUAL

TableofContents

ImportantNotice..................................................................................................................ii

Introduction .........................................................................................................................1

ScannerandAccessories..............................................................................................2

ConnectingtoaHost....................................................................................................3

DisconnectingtheCablefromtheScanner..................................................................4

HowtoScan .................................................................................................................5

ScanninginHandheldMode ................................................................................5

ScanninginStandMode.......................................................................................5

ScannerOutline....................................................................................................................6

AssemblingtheOptionalStand....................................................................................7

VisibleIndicators..........................................................................................................8

SoundIndicators ..........................................................................................................8

Troubleshooting...................................................................................................................9

ConfigurationModes .................................................................................................10

Barcodes.............................................................................................................10

SerialProgramming............................................................................................10

ProgrammingGuide...........................................................................................................11

ProgrammingOptions................................................................................................11

DefaultParameters....................................................................................................11

FactoryDefaultSetting ..............................................................................................12

ScannerOperation .............................................................................................12

InterfaceCommunication ..................................................................................12

Symbologies .......................................................................................................13

DataFormating ..................................................................................................14

ProgramProcedureUsingBarcodeManual .......................................................15

Parametersetting.......................................................................................................16

ScannerOperation .............................................................................................16

InterfaceConfiguration ......................................................................................26

TheSymbologies ................................................................................................34

DataEditing........................................................................................................58

Appendix1:USBVirtualCOMDriverInstallation ..............................................................63

Appendix2:BarcodeLengthSetting..................................................................................64

Appendix3:Multi‐BarcodeEditor .....................................................................................65

Appendix4:FullASCIICode39Table.................................................................................67



AdvancedHandheldHigh‐SpeedLaserScanner

1

USER’SMANUAL

Introduction

Thisscannerisanewlyreleasedhandheldsingle‐linelaserscannerwithacutting‐edge

scanengine.Itutilizestheomnidirectionaltechnologytotransf ormsevenlaserlines

intooneandperformsasuperbscanningspeedat500scanspersecond.Thebuilt‐in

hardwaredecodingtechnologyand32‐bitMPUguaranteesre

al‐timescanningand

accuracy,ensuringanunbeatablefirstreadsuccessrate.

Thescannercomeswithastandofsmallfootprinttosavecounterspace.ItsLEDand

beeperindicatescanningstatusandareprogrammabletocatertotheusers’own

preference.Itsreplaceablecommunicationcablefurtherincreasesitsconveniencean

d

flexibilityinuse.

Streamlinedandlight‐weighed,thishandydevicereadsmost1Dbarcodetypes,GS1

DataBarandPDF417.Itisthereliablebusinesstooltoenhanceworkefficiencyata

competitivecost,thebestsolutionforretail,officeorwarehouseenvironments.

KeyFeatures:

 Superbscanning ability

 Proprietaryh

ardwaredecodingtechnology

 AbletoreadGS1DataBarandPDF417

 Ruggedandergonomicformfactor

 Flexiblecommunications



AdvancedHandheldHigh‐SpeedLaserScanner

2

USER’SMANUAL

ScannerandAccessories

The high‐speedsinglelinelaserhandheldscannerpackagecontains:

1ea.

1ea.

‐Single‐linelaserhandheldscanner

‐Optionalscannerstand

(withstand)



(withoutstand)

1ea. Communicationcable

(Modeldependsoncustomerneeds.)



1ea. 5VPoweradapter

(OnlyforspecificRS‐232cablesasoptional

accessory.Modeldependsonelectrical

requirementsofyourgeographiclocation)



1ea.



CD‐ROMorhandbook

(Containingmanualandprogrammingguide)



Ifanycontentsaredamagedormissing,pleasecontactyourdealerimmediately.



AdvancedHandheldHigh‐SpeedLaserScanner

3

USER’SMANUAL

ConnectingtoaHost

1. Turnoffthehostsystem.

2. Connectthe10‐pinRJ45maleconnectorintothejackonthescanneruntila

“click”isheard.Ifthescannerispowereddirectlyfromthehostsupply,skipto

step5.

3. Ifnecessary,plugtheL‐shapedplugofthepowersupplyintothepowerja

ckon

thecable.

4. ConnectthepowersupplyintoanACoutlet.(DoublecheckthattheACinput

requirementofthepowersupplymatchestheACoutlet.)

5. Connectthecabletotheproperportonthehostsystem.

6. Turnonthehostsystem.

7. Ifthesca

nnerisproperlyinstalled,thered,green,blueLEDwillturnononceand

3power‐upbeepswillbeheard.

8. SetthescannertocommunicatewithyourparticularPOSterminalbyscanning

theappropriatebarcodes.Theprogrammingprocedurevariesondifferent

terminals.PleaserefertotheProgrammingse

ctionformoreinformation.

9. Verifythatthescannerissuccessfullyreadingbarcodesandtransmittingcorrect

informationtotheterminal.



AdvancedHandheldHigh‐SpeedLaserScanner

4

USER’SMANUAL

DisconnectingtheCablefromtheScanner

Thecommunicationcableisdesignedtobefield‐replaceable.Priortoremovingthe

cablefromthescanner,itishighlyadvisedtoturnoffthepowerofthehostsystem

anddisconnectthepowersupplyfromthecable.

1. Locatethesmallholeatthebottomofthescanner.

2. Useametallicpinandinsertintothehole.

3. Gentlypullthestrain‐reliefofthecableonceafaint“click”isheard.



AdvancedHandheldHigh‐SpeedLaserScanner

5

USER’SMANUAL

HowtoScan

Thescannercanbeoperatedintwodifferentmodes:“HandheldMode”and“Stand

Mode.”Thefollowingexplainshowthesecanbeachieved.

ScanninginHandheldMode

1. Whenthescannerisremovedfromthestand,theHandheldModeis

automaticallyactivated.

2. Pressthetriggerandaimatthebarcode.

3. Whendecodingissuccessful,thescannerbeepsandtheLEDindicateblue/green.

ScanninginStandMode

1. WhentheStandModeisactivated,theblueLEDwouldblinkasthescanneris

placedontheoptionalpresentationstand.

2. Presentabarcodeinthescanfield.

3. Thebarcodewouldbeautomaticallydecodedandtransmitted.



AdvancedHandheldHigh‐SpeedLaserScanner

6

USER’SMANUAL

ScannerOutline



BlueLED



RedLED



GreenLED



CableConnection



Trigger



PinHole



ExitWindow



BuzzerSoundHole



AdvancedHandheldHigh‐SpeedLaserScanner

7

USER’SMANUAL

AssemblingtheOptionalStand

Theoptionalself‐supportingstandistofacilitatetheusageofyourscanner.Itmoves

freelyandcanbeplacedanywhereoncountertops.Itcanbetiltedtoamaximumof

60degrees.

60°

Toattachthescannertotheoptionalstand,hookthescanneronthetwoholeslocated

atthefrontofthestand.



AdvancedHandheldHigh‐SpeedLaserScanner

8

USER’SMANUAL

VisibleIndicators

TherearethreeblueLEDindicatorbarsandtwogreen/redLEDindicatorsontopof

thescanner.Theseindicatetheoperationalstatusofthescanner.

LEDStatus LEDIndication

Blue,red,andgreen

LEDsareoff

*Thescannerisnotpowered.

*Whenthescannerisinstand‐bymode,thetriggerbuttonis

enabled.PresentabarcodetothescannerandtheredLEDwould

turnonwhenthelaseristurnedon.

Steadyblue,red,

andgreen

ThescannerisinBootloadMode(firmwareupgradestatus)

Steadyred

Whenthelaserisactive,theredLEDison. TheredLEDwouldremain

onuntilthelaserisdeactivated.

GreenandblueLED

flashonce

Abarcodehasbeensuccessfullydecoded.

Steadygreen

*Abarcodehasbeensuccessfullydecoded,buttheobjectisnot

removedfromthescanwindow.

*Thescannerisinprogrammingmode.

Steadyred/green

Thisindicatesthescannerhasamotororlaserfailure.Abeepis

heardwhenamotorfailureoccurs.Returnthe unitforrepair.

ConstantblueLED

flashes

Whilethescannerisonthestand,thelaserwouldturnon(alongwith

theredLED)whenabarcodeispresentedinthescanfield.The

barcodewouldbeautomaticallydecodedandtransmitted.

Alternateredand

greenLEDflashes

Thescannerdetectsapowerfailure.Pleasecheckwhetherthepower

isproperlyconnected.

SoundIndicators

Whenthescannerisinoperation,itprovidesaudiblefeedback.Thebeepsindicatethe

statusofthescanner.

Beep Indication

Onebeep Abarcodehasbeensuccessfullydecoded.

Threeconsequent

beeps

*Thescannerhaspassedtheself‐testandisoperatingproperly.

*Thescannerispoweredup.

Twoconsequent

beep

Thisindicatesthatthescannerisinprogrammingmode.



AdvancedHandheldHigh‐SpeedLaserScanner

9

USER’SMANUAL

Continuousbeep

tone

Thisisafailureindication.Returntheunitforrepair.

Troubleshooting

Problem PossibleCause Solution

Thescannerhasno

reaction;noLED,

beeps,orlaser

ThepowerisnotON

Refertothe“Connectingto

aHost”sectionofthe

manual

Thescanneris

functioningbutisnot

decoding.

*Thesymbologyofthe

barcodemightbedisabled.

*Thenumberofcharacters

ofthebarcodelabeldoes

notmatchtheinitial

setting.

*Enablethebarcodetype

fromtheprogramming

guide.

*Adjustthelabellength

settingofthebarcode

type.

Whenusingthe

keyboardwedge

interface,thedata

transmissionis

slowerthanusual.

Thesystemisnot

compatiblewiththe

internationalALTmethod.

Underproperties,selectthe

languagepropertythatis

suitableforyourkeyboard.

Abarcodeisreadbut

notacceptedbythe

hostdevice.

Eitherawronginterfaceis

selectedortheinterfaceis

incorrectlyset.

Checktheinterfacecable

usedandtheinterface

settings.

Alternatingredand

greenflashes

Thereisapowerfailurein

thisscanner.

Pleasecheckandseeifthe

powerisproperly

connected.

Steadyred/greenLED

Thereisalaserfailureinthe

scanner.

Immediatelypoweroffthe

scannerandreturntheunit

forrepair.

Charactersarebeing

dropped.

Thedelaytimeintheinter‐

characterneedstobe

increased.

Adjustthecharacterdelay

time.



AdvancedHandheldHigh‐SpeedLaserScanner

10

USER’SMANUAL

ConfigurationModes

Thisscannerhastwoprogrammingmodes.

Barcodes

Thisscannercanbeconfiguredbyscanningthebarcodeslocatedinthebelow

“ProgrammingGuide”section.Pleaserefertothisguideforinstructions.

SerialProgramming

Thismodegivesend‐userstheabilitytosendaseriesofcommandsusingtheserial

portofthehostsystem.Formoreinformation,pleasecontactyourdealer.



AdvancedHandheldHigh‐SpeedLaserScanner

11

USER’SMANUAL

ProgrammingGuide

Scanningaseriesofprogrammingbarcodelabelscanconfigurethescanners.This

allowsdecodingoptionsandinterfaceprotocolstobetailoredtoaspecificapplication.

Theconfigurationisstoredinnon‐volatilememoryandwillnotbelostbyremoving

powerfromthescanner.

Thescannermustbeproperlypoweredbeforeprogrammi

ng.ForRS‐232Ctype

scanners,anexternalpoweradaptermustbeusedtosupplyDCpowertothescanner.

IfakeyboardemulationtypescannerisusedwithanIBMPC/XT/AT,PS/2oranyfully

compatiblecomputers,powerwillbedrawnfromthekeyboardport.Noexternal

poweradapterisrequired.Ifkeybo

ardemulationtypescannerisusedwithanyother

nonIBMPCcompatiblecomputers,anexternalpoweradaptermaybeneeded.

Duringtheprogrammingmode,thelaserscannerwillacknowledgeagoodandvalid

readingwithashortbeep.Itwillgivelongbeepsforeitherani

nvalidorbadreading.

ProgrammingOptions

Programmableoptionsaredividedintofourgroups.Thefirstgroupincludesthe

optionsthatshowthegeneralbehaviorofthelaserscanner.Thesecondgroupgoverns

theoperationofdifferentinterfaces,RS‐232serialports,keyboard,andUSB.Thethird

groupsetsthedecodingparametersforeachbarcodesymbology.Thelastgr

oupis

aboutmoreadvanceddataformatting.



DefaultParameters

Thistablegivesthedefaultsettingsofalltheprogrammableparameters.Thedefault

settingswillberestoredwheneverthelaserscannerisinprogrammingmodeandthe

"Reset"programminglabelisscanned.



AdvancedHandheldHigh‐SpeedLaserScanner

12

USER’SMANUAL

FactoryDefaultSetting

ScannerOperation

Parameter Default

Samecodedelay 500msec

Beepingfrequency Medium

Beepingduration 50msec

LED/Beepbeforedatatransmission On

Triggermode(handheldmode) Enable

Standmode Enable

Headerandtrailer None

Intermessagedelay None

Intercharacterdelay None



InterfaceCommunication

Parameter Default

RS‐232Interface

Baudrate 9600

Parity none

DataBits 8

StopBit 1

RTS/CTS off

Terminator <CR><LF>

KeyboardWedgeInterface

TerminalType PC/AT

Keyboard USkeyboard

Terminator Enter

USBInterfac e

Terminatortype Enter

Codemode Scancode

Keyboard USkeyboard

WandEmulation

Wandemulationspeed Normal

Dataoutput Black=high



AdvancedHandheldHigh‐SpeedLaserScanner

13

USER’SMANUAL

 Symbologies

Parameter Default

DecoderSelection

EAN/UPC Enable

Code39 Enable

Code32 Disable

Codabar Disable

ITF2of5 Enable

MSI Disable

ChinesePostCode Disable

Code93 Enable

Code128 Enable

EAN‐128 Disable

Telepen Disable

Code11 Disable

Standard2of5 Disable

Industrial2of5 Disable

Matrix2of5 Disable

GS1DataBar Disable

PDF417 Disable

CodeIdentifiers

Identifiercodeasfactorystandard Disable

IdentifiercodeasAIMstandard Disable

Code39identifiercode M

ITF2of5identifiercode I

Chinesepostcodeidentifiercode H

UPC‐Aidentifiercode A

UPC‐Eidentifiercode E

EAN‐13identifiercode F

EAN‐8identifiercode FF

Codabaridentifiercode N

Code128identifiercode K

Code93identifiercode L

MSIidentifiercode P

Code11identifiercodeO

Standard2of5identifiercodeS

Industrial2of5identifiercode D

Matrix2of5identifiercodeG

GS1DataBaridentifiercodeRS



AdvancedHandheldHigh‐SpeedLaserScanner

14

USER’SMANUAL

GS1DataBarLimitedidentifiercodeRL

GS1DataBarExpandedidentifiercode RX

PDF417identifiercodeX

BarcodeLength

maximum 32

Codabar

Code11

Standard2of5

Industrial2of5

Matrix2of5

minimum 6

maximum 62

Code39

Code93

Code128

minimum 3

maximum 16

ChinesePostCode

minimum 10

maximum 32

MSI

ITF2of5

minimum 4

maximum 14GS1DataBar

GS1DataBarLimited

minimum 14

maximum 48

GS1DataBarExpanded

minimum 6



DataFormating

Code MessageFormat

EAN‐13 D1D2D3D4D5D6D7D8D9D10D11D12D13

EAN‐8 D1D2D3D4D5D6D7D8

UPC‐A D1D2D3D4D5D6D7D8D9D10D11D12

UPC‐E D1D2D3D4D5D6D7D8

Code128 D1‐Dx(default3~62)

EAN‐128 C1D1‐Dx(default3~62)

Code39 D1‐Dx(default3~62)

Codabar D1‐Dx(default6~32)

ITF2of5 D1‐Dx(default6~32)

ChinesePostCode D1‐Dx(default8~32)

Code93 D1‐Dx(default3~32)

MSI D1‐Dx(default6~32)



Page is loading ...

Zebex Z-3051HS (U)(B), Z-3051HS (K)(B), Z-3151HS (K)(B), Z-3151HS (U)(B) Specification

Related papers

Other documents